What 119 owners told NHTSA about the 2020 Ford Ranger

December 2024 experienced loss of power, was able to have a Certified Ford maintenance facility look at it, but found nothing, codes cleared. Codes presented were Hill Start Assist Warning, pre-collision Assist Warning, power train malfunction/reduced power. Drove the vehicle 3 hours in below zero temp. The next day after the vehicle sat in freezing temps, drove approximately 5 miles on snow covered roads when experienced loss of power. Went from 55 miles an hour to less than 10 MPH in about 200 feet. No traffic behind me, drove the remainder of the distance (another 5 miles) at 5-10 mph. Had to have the vehicle tow to a dealership where I was informed that there is a service bulletin on the throttle body. They ended up dumping approximately 2 cups of water from the throttle body. Ford replaced the throttle body at no charge. I called Ford Customer service to share my concern. The fact that the vehicle speed fell off so quickly was what prompted me to call.

NHTSA ODI 11598823

At about 40,000 miles truck started jumping and hesitating under 30mph and has now gotten worse and jumping and hesitating at 65mph had it in the shop 3 times and they can't find the problem they came up with driveshaft and pinion flange. It came from Detroit and I believe it is a problem with the transmission.

NHTSA ODI 11598360

1.) Ford motor company (ford) is recalling certain 2020 ranger and f-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 expedition vehicles equipped with a 'police' package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver. 2.) Ford motor company (ford) is recalling certain 2020 ford f-150, f-250, f-350, f-450, f-550, explorer, mustang, transit, expedition, escape, ranger and edge, and lincoln nautilus and corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 111, 'rear visibility.' 3.)Ford motor company (ford) is recalling certain 2020-2021 ranger super cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 225, 'child restraint anchorage system.' 4.) Ford motor company (ford) is recalling certain 2022-2023 bronco, 2023 super duty f-250, and 2019-2023 ranger vehicles. The tire and loading information (tread) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 110, 'tire selection and rims.' NHTSA# FOR REPORTING 21V811000 21V765000 20V575000 20V197000

NHTSA ODI 11592935

When driving between 40 & 45 miles per hour truck start jerking and skipping also burning lots more fuel.

NHTSA ODI 11592574

The contact owns a 2020 Ford Ranger. The contact stated that on several occasions while driving between 40-45 MPH, the vehicle began jerking and the transmission was skipping. Additionally, the vehicle lost power and was consuming an excessive amount of fuel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,900.

NHTSA ODI 11592578

The contact owns a 2020 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal knocking sound. The vehicle was taken to a dealer and was diagnosed with transmission failure. The vehicle was repaired but the sound persisted. The vehicle was taken to the dealer again and diagnosed with transmission failure again. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11589693

The contact owns a 2020 Ford Ranger. The contact stated that while driving at unknown speeds, the front camera fault service required and pre-collision assist not available, messages were displayed. There was an abnormal chiming sound detected. The safety features were disabled. The vehicle was taken to the local dealer, who informed the contact to clean the camera. The dealer used an ODB scanner but retrieved no codes and informed the contact to schedule a service appointment. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that there were no open recalls on the VIN. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 21,000.

NHTSA ODI 11586502

The contact owns a 2020 Ford Ranger. The contact stated while attempting to accelerate from a complete stop, the vehicle failed to respond. The contact shifted into neutral(N), and then shifted back into drive(D). The contact stated that the vehicle responded, then jerked forward and backward. The contact stated that the failure recurred several times while driving from a complete stop; however, on the latest failure, the vehicle failed to respond and stalled. The vehicle was pushed to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 109,000.

NHTSA ODI 11586429

The contact owns a 2020 Ford Ranger. The contact stated that while parking and removing the seat belt, the belt retracted quickly wrapping around their child's neck. The contact was able to stop the vehicle and release the child; however, the seat belt still failed to retract properly. No injuries were reported. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

NHTSA ODI 11586126

The contact owns a 2020 Ford Ranger. The contact stated while starting the vehicle, a message indicating that the computer system needed to be updated was displayed. The contact stated that the failure recurred while driving 35 MPH. The vehicle was taken to the dealer, where the contact was informed that the computer system could not be updated, and the dealer determined that the Accessory Protocol Interface Module (APIM) had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact was awaiting a call from the manufacturer. The failure mileage was approximately 13,000.

NHTSA ODI 11584992

The Transmission in this truck has problems the 10 speed shifts hard on down shifts and slips on up shifts. This should have a recall to be addressed

NHTSA ODI 11584303

Rear seat latch does not work resulting in seat collapsing forward when braking and would also collapse in an accident. Seat belts and child car seat would not be functional. Appears to be a common problem based on our research on the Internet. Salinas Ford dealership rep stated repairs are not covered because it is not a seat belt. This vehicle only has 2,758 miles, even though it is a 2020.

NHTSA ODI 11573596

The contact owns a 2020 Ford Ranger. The contact stated while driving 30 MPH, the contact became aware that the interior lighting failed to turn off, resulting in the battery becoming drained. A short time later, the contact stated that the center display failed to display the correct information, after which the vehicle lost electrical power. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the audio control module (ACM). The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 14,000.

NHTSA ODI 11572162

The contact owns a 2020 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle surged unintendedly. Additionally, the engine was misfiring. The vehicle was taken to the dealer where it was diagnosed with water leaking into cylinder #1. The contact was informed that the cylinder needed to dry out. The contact was also informed that an engine cover needed to be installed. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 38,000.

NHTSA ODI 11572231

Presently, my mileage is approximately 42770. It has started to exhibit vibration throughout the cab. It wasn't as prevalent during the cold and would only last about 30 seconds, after warm up, and around 70 mph. Now that it has gotten warmer, it is happening after warm up at all speeds. I haven't take it to the dealership yet, but have read reports of the problem with the same model year.

NHTSA ODI 11569621

I just purchased a vehicle from Autex Mazda of Keene. (1/2/24) A 2020 Ford Ranger with 36K miles and extended warranty. When driving on the highway at 60MPH my steering wheel started shimming very bad as I was passing a school bus that I felt I might of hit because it startled me and never felt a steering wheel shimmy so bad like that. Called dealer and they balanced the tires and leaving to return home the shimmy was back almost out of the lot. Are there any recalls on this issue and my backup camera is barely visible. I feel I was taking advantage of knowing there was a problem with this vehicle. I'll be calling Ford Service next but wanted to know about recalls and to report this before someone gets killed because of the issue.

NHTSA ODI 11565694

Transmission has difficulty moving through gears- powertrain failure noted via alert system x2 when vehicle stopped abruptly while driving. "Powertrain Malfunction/Reduced Power". Fortunately no one injured. 60k miles on the vehicle and Ford reporting need a 6k new transmission.

NHTSA ODI 11565800

The contact owns a 2020 Ford Ranger. The contact stated while driving at various speeds, the driver’s side headlight intermittently failed to operate as needed. There was no warning light illuminated. The vehicle was taken to a dealer and the contact was informed that a defective wiring harness had caused the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.

NHTSA ODI 11565849

Vehicle has 11000 miles on it When stopping brakes are soft and pedal can go lower than gas pedal. Have talked to other drivers w same problem w ford rangers. It will b $150 expense Ford dealer says abs bleed procedure will correct. To me this is a safety issue as my foot could I have the gas pedal when braking

NHTSA ODI 11564662

Vehicle has hard jerking when increasing speeds. Vehicle takes several seconds to gain power from being stopped at red light and shifts very hard. Sometimes feels like gear slips into neutral and loses power after accelerating slowing. Takes several seconds to recognize being in reverse and jerks hard when it gets going. Started at around 37,000 miles and getting worse at 45,000. Been told several times it's normal, but it very obviously is not and feels very unstable and unsafe.

NHTSA ODI 11564316

Problem shifting,jerky motion or no response at all with the transmission had to pull over almost was rear ended because of no response.

NHTSA ODI 11563392

The 10 speed automatic transmission has a problem. Yes the problem was verified by the Dealer. Yes the Dealer has had the car 3 separate times and worked on the issue. The transmission when starting out from a stop will fall on its face with no power to move from the stop. 2-4 seconds and then it takes off. When pulling out into traffic this condition is very unsafe and could cause an accident. Now it is starting to do it as traveling at speed and light acceleration it will hesitate before it goes. This is an intermittent problem not doing it all the time .

NHTSA ODI 11562626

Vehicle has 51,532 miles and a blend door actuator needs to be replaced - inconsistent air flow coming in. The desired air wanted whether it be hot or cold, is being diverted incorrectly, so we are not getting a consistent temperature out of the A/C system. This item was recalled previously In the 2019 Ford Ranger.

NHTSA ODI 11560748

At one point, the heat/ac would blow air but would not heat or cool. This was about a month and a half ago., There was an electrical burning smell, and at that point the system would not heat or cool. The burning smell has since subsided. I took the truck to Santa Maria Ford to have it looked at and have my oil changed. I was told that it would cost 3500.00 to repair the issue. I looked the issue up and I found that the 2019 Ford Ranger had been recalled for this exacted issue. I felt that it was just a matter of time before the 2020 Ford Ranger would be recalled for this item. I decided to I should submit this form to be on the safe side.

NHTSA ODI 11559859

The contact owns a 2020 Ford Ranger. The contact stated that the vehicle had experienced various transmission failures which included the transmission slamming into gear while shifting from park to drive. Also, while driving at various highway speeds, the message "Power Train Malfunction, Reduce Speed" was displayed. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 85,000.

NHTSA ODI 11558264