What 34 owners told NHTSA about the 2019 Volvo XC60 T8 Plug-in Hybrid

After I parked my car, the driver’s seat back tilted forward towards the steering wheel and could not be repositioned either manually or electronically. I could barely squeeze in and certainly could not drive the car with the seat in that position. The car needed to be towed to the dealer and Volvo replaced all related components, which were under warranty. If this had occurred while I was driving, the situation would have been extremely dangerous. There were no prior warnings of the seat back failure.

NHTSA ODI 11442178

The contact owns a 2019 Volvo XC60 equipped with Pirelli tires, Tire line: Scorpion Zero, Tire size: 235/55/R19, DOT number: XB08V824219. The contact stated that while the vehicle was parked, the passenger side rear tire experienced a blowout. The contact's child was nearby when the tire exploded but did not sustain any injuries. The dealer was made aware of the failure and was sending a tow truck to tow the vehicle. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11432966

WHILE I WAS DRIVING IN A BUSY MULTILANE CITY TRAFFIC SITUATION, THE CAR'S CENTER CONSOLE WENT COMPLETELY BLANK AND THE TURN SIGNALS, HAZARD LIGHTS, AND VOLVO ON CALL WERE NOT FUNCTIONING PROPERLY. I AM NOT SURE WHAT ELSE WAS AFFECTED. THIS CONTINUED FOR A FULL 1-2 MINUTES, UNLIKE TIMES BEFORE WHEN THE SYSTEM HAS DONE THE SAME THING BUT QUICKLY RE-BOOTED. THE SAFETY OF OTHERS AND MYSELF WAS COMPROMISED, AS I NEEDED TO CHANGE LANES TO GET ONTO THE INTERSTATE. I COULD NOT TELL IF MY SIGNALS WERE FUNCTIONING BECAUSE THE SIGNALS WERE NOT MAKING A CLICKING SOUND AND THE FLASHING SIGNAL INDICATOR LIGHTS WERE COMPLETELY NONFUNCTIONAL. I TRIED THE HAZARD LIGHTS AS WELL, WHICH DID NOT FUNCTION. I PRESSED THE VOLVO ON CALL BUTTON, BUT NOTHING HAPPENED. WHEN I TOOK THE CAR TO THE DEALERSHIP, THE SERVICE MANAGER STATED THAT A "SOFTWARE UPDATE" WAS PERFORMED TO FIX THE PROBLEM, AND WHEN I QUESTIONED HOW I WAS TO KNOW IF THIS WOULD BE A PROBLEM IN THE FUTURE, I WAS TOLD THAT I "WOULDN'T KNOW UNLESS THERE WAS A PROBLEM" AND THEY CLAIMED TO KNOW NOTHING ABOUT WHETHER THE INCIDENT WOULD BE REPORTED TO THE NHTSA. I FEEL UNSAFE DRIVING THIS CAR NOW, WHICH IS IRONIC CONSIDERING THAT I BOUGHT A VOLVO FOR ITS PURPORTED SAFETY.

NHTSA ODI 11413363

SINCE PURCHASING IN MAY 2019, MY BRAKE PADS WERE REPLACED ONCE AND MY ROTORS NOW THREE TIMES. I HAVE LESS THAN 20,000MI ON MY VOLVO. THE REASON IS BECAUSE OF PULSATIONS WHEN I APPLY THE BRAKES AND IT CAN BE FELT IN THE STEERING WHEEL, AT TIMES. MY DEALER HAS BEEN STELLAR IN ADDRESSING MY CONCERNS EACH TIME I HAVE HAD TO HAVE IT SERVICED. I HAVE SEEN ON VARIOUS BLOGS AND CONSUMER SITES THAT THIS IS A RATHER COMMON OCCURRENCE. I BELIEVE THE ROTORS EITHER ARE NOT EQUIPPED FOR THIS VEHICLE OR THE QUALITY OF THE ROTORS ARE SUBPAR. IF A REMEDY OR RECALL IS NOT SUBSTANTIATED, THE OWNERS SHOULD BE ASSURED BRAKES AND ROTORS WILL BE COVERED BY VOLVO, INDEFINITELY.

NHTSA ODI 11386345

WAS DRIVING ON HIGHWAY. I LET GO OF THE GAS PEDAL BUT THE CAR STILL UNCONTROLLABLY ACCELERATES! GAS PEDAL IS STUCK. HITTING THE BREAKS SLOWS THE CAR A BIT. THIS WENT ON FOR ABOUT 10 SECONDS AND FINALLY AND LUCKILY THE "R-DESIGN" GAS PEDAL COVER FELL OFF AND I WAS ABLE TO STOP ACCELERATING. INTENDED TO DRIVE AT 65 MPH BUT THE CAR ITSELF ACCELERATED TO UP TO 80 MPH MOMENTARILY.

NHTSA ODI 11348520

TL* THE CONTACT OWNS A 2019 VOLVO XC60 HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH THE VEHICLE AHEAD SUDDENLY STOPPED AND THE AUTOMATIC EMERGENCY BRAKING SYSTEM DID NOT ACTIVATE CAUSING THE VEHICLE TO CRASH INTO A SECOND VEHICLE. NO INJURIES WERE REPORTED. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER FINDLAY VOLVO (5385 W SAHARA AVE, LAS VEGAS, NV) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 7,000.

NHTSA ODI 11330582

VEHICLE WAS IN THE HOLD POSITION, AS I WAS COMPLETING A TRANSACTION AT MY PNC BANK DRIVE UP. UPON LEAVING MY FOOT TORCHED THE ACCELERATOR LIGHTLY.SUDDENLY THE CAR STARTED TO ACCELERATE AT A VERY HIGH SPEED. I BRAKED BUT COULD NOT STOP. YOU COULD HEAR THE ENGINE REVVING. I CHOOSE TO HIT A LARGE TREE RATHER THAN ENTER A MAIN ROAD.THE CAR WAST TOTALED.

NHTSA ODI 11298948

IN A STATIONARY POSITION, TAILGATE DOES NOT FULLY LATCH WHEN BUTTON PRESSED TO CLOSE IT. HAVE TO MANUALLY PUSH TAILGATE DOWN FOR IT TO FULLY LATCH. DEALERSHIP WAS UNABLE TO FIX THE PROBLEM. PROBLEM HAS BEEN PRESENT SINCE PURCHASE.

NHTSA ODI 11292373

SAFETY ISSUE THE AUTO-HOLD BRAKE FUNCTION MALFUNCTIONED. I AM USING THIS FEATURE A LOT. WHEN ENTERING A PAID PARKING GARAGE THE CAR STOPPED CORRECTLY BEFORE THE GATE . BUT WHEN OPENING THE DOOR AND UNBUCKLING THE DRIVER'S BELT THE SYSTEM MALFUNCTIONED- INSTEAD OF ENTERING AUTO PARKING MODE AND BE STOPPED IF MOVED FORWARD FAST, BREAKING THE PARKING GATE COMPLETELY, DAMAGING CITY'S PROPERTY, BREAKING MY MIRROR AND GETTING DENTS ON THE HOOD, DRIVER'S DOOR AND B-PILLAR TRIM PANEL. ALSO MY LEFT ANKLE HAD A BIG BRUISE AND LUMP AFTER THAT, BUT LUCKILY WAS NOT BROKEN . THIS CASE WAS REPORTED TO POLICE. THE VEHICLE WAS STOPPED. PARKING GARAGE ENTRANCE

NHTSA ODI 11223132