What 185 owners told NHTSA about the 2019 Volkswagen Tiguan Ltd

Me and my family were driving to Los Angeles on a freeway. All of a sudden the car showed a warning saying something like "Limited to 4,000 RPM", and we felt strong vibration under the hood. We decided to pull over at a first available gas station. While turning into the gas station, the car refused to go and refused to start, making a loud clicking sounds. We had to tow the car to the nearest VW dealership (Galpin VW). Later they informed us that they have to replace fuel injectors and harness and it will cost us approximately $2,600. After paying the amount, I found that VW issued a recall/bulletin for this very problem - VWP-23-03 for my model year (VW Tiguan 2019). I contacted VW but they refused to honor the warranty claiming that the warranty does not apply to my VIN. It seem obvious to me that this is the same exact problem as described in the bulletin VWP-23-03. I feel like VW has made a mistake by not applying this bulletin to my VIN number (and probably others) and is endangering motorists that would otherwise get this serious issue fixed during regular maintenance.

NHTSA ODI 11608359

Starter system of the car, due to excess heat on days when the car is parked outside, it gives warning of starter system and the ignition turns off by itself

NHTSA ODI 11607648

On [XXX] my sunroof spontaneously shattered while my husband and I were driving down a country road in New Hampshire. There were only pine trees on either side of the road, and nothing dropped on the roof to shatter the glass. The glass rained down on me and the pop noise was very alarming. The only thing we can surmise is that the glass shattered due to temperature differential whereby the hot outside air, since it was an August day, and the cold air conditioning inside the car stressed the glass. However, we have never had this happen before in any car. We were grateful the glass did not fall into our eyes but this could have had a very different outcome. We became concerned for people in climates like Arizona or Florida who may experience this danger, especially when driving on the highway. Regardless, the sunroof glass should be able to withstand the heat of the outdoors and the Volkswagen air-conditioning system. We concluded that this had to be a defect in the glass used, and we feel compelled to write and report this incident. We were put at risk by shattered glass raining down on the front seats, and the dealer was unresponsive and said the sunroof shattering spontaneously was not typical. It has not been inspected yet, and police have not been involved as there was no accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11607158

I was driving on a hot day and all of the instrument panel, air conditioning, all controllers, like signaling, windshield wipers, radio and all electronic gear turned off. Without the equipment and tools available, I could not change lanes or come to a stop safely. It would be difficult for me to say if other systems were affected. I was luckily not going very fast at the time and was able to navigate to the shoulder and stop my car without incident but it was a very stressful situation that I had never experienced in a vehicle before that time. Yes, my vehicle is available for inspection. This happened for the first time today so I have not tried to reproduce the issue. However, many others have complained about it on forums. Here is one of many examples: [XXX] A car's electronic systems should not completely turn off because of changes in the weather. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11604399

Around 8 times now if my vehicle senses something in the front it will abruptly brake very hard. There doesn’t have to be anything in the view, simply pulling out of a gas station it will do, and it’s almost caused a collision, as it takes a few seconds to be able to disable, manually. This is extremely dangerous, and is going to eventually hurt someone seriously. It is imperative that something be done concerning this issue before innocent people get hurt as a result of a faulty braking sensor. Please take this complaint seriously as it has on multiple occasions almost caused a collision. Thank you!

NHTSA ODI 11603893

It’s happened twice in extreme heat; the first time I was driving not even 3 minutes after starting the car. All of a sudden there was a screen on the dash that popped up and said “ignition off, please stop the car safely”. The car was still able to drive but nothing else was working- gas gauge, speedometer, a/c, radio, etc. The second time happened when I had just started the car. Let it run for about 2-5 minutes and then the dash said “check starter system”. Is still fully capable of reversing, driving but just nothing else electrical working.

NHTSA ODI 11601630

Since 03/2023, I have experienced several false applications of the automatic emergency braking system. One particular incident involved the vehicle going 75mph on the freeway when the braking system has been applied. Other times have been between 20-40mph on city roads. I have reported this to the local dealer, they have the logs of my car doing this however they will not release them to me. Volkswagen has offered a warranty extension on this issue, however that's not a solution. I work in automotive repair, this is a software programming issue. Volkswagen has no fix. This car is going to kill me or someone else. Please review all the other similar complaints with this year, make and model.

NHTSA ODI 11601489

My car dash and all electrical components are shutting off WHILE I’m driving! All needles go to 0, radio shuts off, AC/HEATER, turn signals, brake lights, headlights, ect. The engine seems to run for a moment and then shuts off. Once the car is pulled over to the side of the road (if I make it!) and turn the car completely off and try to start it again, it won’t turn on immediately. I’ve had to sit for 5 -10 minutes on the side of the freeway multiple times on my way home from work as the car would continue to shut down on me. It’s absolutely terrifying. Luckily I wasn’t driving at night and was visible in the daylight and LUCKILY I didn’t have my children in the car with me when this has happened.

NHTSA ODI 11600097

Moldy smell in car. Wet seatbelt back passenger and carpet on floor. When seatbelt pulled out, wet and moldy smelling. Sunroof cloth has water stains from what appears to be a leak even though sunroof is closed. Car smells like mold and I am concerned to be breathing it. I am in remission from Pulmonary Sarcoidosis and any environmental irritants put me at risk significantly of relapse and I could get a fungal infection. I need this addressed as I do not want to be at risk, nor do I want anyone else jeopardized. MOLD SPORES are DANGEROUS. I called VW and they told me it was part of a recall but my car does not qualify because of my mileage. I have 124K miles. This is a serious problem, and VW is not willing to help me. This is a manufacturer defect and I want it addressed and fixed by VW.

NHTSA ODI 11597487

While driving the car a message appears " check starter system" and the car stops. This happened after about a quarter mile away of driving after starting the car. This has happened twice on really hot days. The first time it happened the car started back up normally, the second time (today) it did the same shut off three times before I had it towed. I am going to call the Volkswagen dealership tomorrow morning about this. I read online that the 2019 Jetta was recalled for what sounds like the same exact issue.

NHTSA ODI 11594680

VW has only issued an ignition failure recall for 2019 - 2021 Jetta's. I just purchased a 2019 VW Tiguan and because the recall does not extend to this model the repair to replace the ignition switch due to a failure that is identical to the Jetta is being refused. It is absolutely a safety risk and needs to be extended to include other car models of the same year. I was on my way to a mechanic when I lost all power to the car, the dash lights went out, and the check starter system error message popped up. It was 89 degrees here with overcast and was actually a lower temperature day when two days prior it was 100. CarMax specifically is only willing to replace the starter/alternator because there is no recall notice for the Tiguan. I am trying to get them to fully repair the car to a safer standard, but there is no guarantee without an actual recall for this model.

NHTSA ODI 11593759

The automatic emergency braking(AEB) on the vehicle is too sensitive or goes off for no reason. On multiple occasions I the AEB system goes off when exiting parking lots onto busy streets. On one occasion the driver behind me had to suddenly stop to avoid rear ending my car. On a separate occasion the system when off while turning right onto a busy street. The right turn could have been performed safely but the system went off leaving my car in the middle of the road while cars were headed my way which could have cause my car to be t-bones if the drivers were speeding or not paying attention. My wife and kids were in the car with me. The system causes you to to come to a complete stop and unable to disengage the brake for 5-10 seconds. There have been other incidents where luckily the streets were not so busy.

NHTSA ODI 11590694

I was driving down a completely clear road, not a single car or turn in sight. When suddenly my cars front collision warning comes on the screen and brakes my car for me. There was no advance warning, just hard braking.

NHTSA ODI 11588779

The emergency braking system caused a rear accident . Leaving at fault " unable to control vehicles ", listed by State Farm, resulting in a personal injury claim with no injuries for $475,000.00 all parties including Volkswagen will be sued . The vehicle has caused loss of employment and a lawsuit on top of that I'm still paying a $586.00 Car note and $686.00 car insurance just for me to drive now . I'm mad asf !!!!

NHTSA ODI 11583569

I have a 2019 VW Tiguan with 2.0 liter turbo 4 cylinder and auto trans. I am experiencing frequent delayed acceleration from standing start in duration of 2 - 6 seconds. This BW is equipped with Drive By Wire technology which means an electrical wire with a solenoid at each ends sends a signal to motor to rev up. If that signal is not perfect the car suffers from a delay in acceleration from stopped position. I have reported this twice to NHTSA since Aug 2019 when car was newly purchased. Within first week I experienced a “delayed acceleration” from stop and under 1800-2000 rpm’s and under 25mph so this is NOT turbo lag as service manager first suggested. This always occurs from a dead stop pulling into traffic whether left, right or straight away driving. The delay occurs about half the time 5 out of 10. Fortunately for me the six second delay event occurred in church parking lot. During these episodes the engine remains at idle with the accel pedal fully depressed to floor, and at end of the event motor races and car takes off. To repeat there is NOT a mechanical linkage for accel pedal to motor, with “Drive By Wire” technology. There are literally thousand of reports online about these failures and a cottage industry has sprung up to decrease these “delays” (Roar Pedal etc) but they are ineffective. I believe this “drive by wire technology “ is a means that an auto mfg attempts to meet EPA city CAFE fuel requirements. I have requested VE replace one or both solenoids but they refuse until they can replicate the issue and BE corporate isn’t listening and a new 2023 Tiguan I test drive for comparison suffered same issue but less frequent in short 30 minute drive. It is up to you to investigate and require auto manufacturers to correct this major problem in public confidence in auto mfgs and regulatory organizations tasked with protecting the public.

NHTSA ODI 11574971

The system says ignition switched off. Please check the starter system. Then, all electrical system is turned off. It seems the same problem with 2019 VW jetta

NHTSA ODI 11573250

The car automatically and inadvertently engages the parking brake while driving, as in approaching an intersection or in heavy traffic on highway. This obviously puts occupants and others at significant risk, as the driver cannot accelerate to avoid a potential collision, the car could be hit from behind, or the car could fishtail if the roads are snowy. It is wintertime and our roads are snowy, so we drive the car as little as possible. This first occurrence was more than one year ago. This initial warning in the car display is "Driver Door Contact Switch" error, particularly during cold weather, which precedes a cascade of other electronic alerts and activities described elsewhere, such as errors messages and sounds, and automatic engagement of the parking brake while driving. Some VW models have a recall for this exact problem, indicating that airbag deployment may also be affected: [XXX] This technical tip for many additional VW models indicates that the proper service procedure (error U019900) is to replace the door wiring harness: [XXX] The recall should be widened to include the models affected as indicated in this Technical Tip!! Our local VW dealer (which sold and services the car) claimed not to know anything about this common problem. At our first appt, they replaced the car battery. Prior to our second appointment (each requires ~4 weeks lead time), they said that they would not replace the wiring harness unless the error code occurred while the car was in their possession, despite multiple OBD error codes as cited in the technical tip above. The dealer ultimately agreed to replace the part only after (1) I sent a copy of the class action lawsuit; (2) I sent a copy of the relevant VW Technical Tip; AND (3) I said that I would pay for the repair (despite being covered under warranty). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11565749

Warning sign with message, ‘Only exit vehicle in P position. Please service vehicle.’ displays. Other vw cars recalled for this ‘same issue’ but not Tiguan. Please let them recall and fix the problem.

NHTSA ODI 11565175

I am writing a complaint in reference to Safety Code Recall : 42J5 April 10, 2019. I bought my vehicle at Shearer VW in South Burlington VT on June 1, 2019. When I bought my vehicle I wasn't informed of any Recalls. I took my vehicle to Montpelier Volkswagen to get an oil change on Dec. 22, 2023 and was informed that I had a broken rear axle coil spring and bushings that needed to be replaced . I was given an estimate and appointment for Jan. 12, 2024. In talking with my local mechanic to try to get an earlier repair (both him and Montpelier VW tell me that my car is a safety hazard with these problems.) my local mechanic found this safety recall and advised me to see if my vehicle was ever checked for defects. My vehicle year, make and model are listed in this recall. I have talked to VW Customer Care and Shearer VW where I bought my car and neither can answer my questions. Shearer VW did not know such a recall ever existed. My questions are: Where was my vehicle when this recall came out? Was my car on the list for repair because of the problem stated in the recall 42J5? Was my car checked for this safety recall? If it was checked, did parts get replaced or not? I think this was a serious recall and for VW to have no knowledge of this recall really bothers me. How can I get questions answered? My coil spring has broken and it does make me wonder if it had anything to do with a defect in materials or problems in the spring production process? Maybe not but I want answers. I have owned many vehicles and never had coil springs and bushings go like this . I do have 82,00 miles on my car now but other vehicles lasted through 100,000 miles + without any problems with this. I have now spoken to numerous individuals who have had the same kind of issues with their VW's. VW is offering me nothing but a big bill for repairs. And I am driving a very UNSAFE vehicle. Can you please help me get answers ? I think all VW dealerships should know about recall

NHTSA ODI 11563246

Take blind spot indicator is not working.Not warning of another car in our blind spot posses a safety risk to us and other drivers on the road with us.The dealer, Garvey Volkswagon Queensbury NY 12804, confirmed our complaint. Our car has not been inspected by anyone other than the dealer. The problem first appeared in April 2023 without any warning. I contacted Volkswagon of America and they said they would not pay for the repair. I have a statement from the dealer and Volkswagen of America.

NHTSA ODI 11559856

Road trip from VA to NJ approx 700 mi. Mid-trip, stopped for fuel and oil check. Thereafter, engine started to run rough. Check engine MIL on. Could not find any problem. Back on road. Received a low engine oil warning. Checked engine, oil all over back of engine compartment. Shut down engine and towed to nearest VW dealer. Found engine dipstick not completely seated. I checked and measured force needed to completely seat dipstick, at 30 lbs. Dipstick insert sleeve is plastic. Dipstick can be inserted to bottom w/o seating. Any leakage of vacuum from this engine causes extreme performance problems. Oil spewing in engine compartment is a significant fire hazard.

NHTSA ODI 11558472

The read window defroster was not working well. A few days ago, when I turned on the defroster and drove for about 10 minutes, all of a sudden, the rear window made an explosion sound, and windows cracked like a spiderweb. I stopped the car and got out the car and shut the door, the cracked window shattered in pieces. It seems like the heating element overheated as the crack propagated from where the electicla wired were attached.

NHTSA ODI 11552773

In September 2022, we began to hear clunking sounds from the front left, especially when turning. We took the vehicle to the VW dealer and were told that there is a known issue with the steering and they will order the part. At this point, the vehicle was still under warranty. For several months, we continued to ask the dealer for an update on the part and were told that it was back-ordered but to continue driving the vehicle, as it was safe to do so. We continued to drive the vehicle as our daily driver. We also informed the VW dealer that the clunking was becoming louder and more prevalent. They continued to tell us the vehicle was safe and the part was back-ordered, with no estimate of when it would be back in stock. We asked about the part every time the vehicle was at the dealer, and called periodically to check in, almost every month until August 2023. At no point did VW reach out to us. Fast forward to September 2023. We took the vehicle to a local mechanic for a routine oil change, and asked that they evaluate the steering. This mechanic told us to stop driving the vehicle immediately as the vehicle could lose steering at any time. I immediately called the dealer and was told again that the vehicle was safe to drive. When I informed the dealer that I had in writing to stop driving the vehicle immediately, they offered us a loaner. The dealer stated there is still no estimated time of delivery for the needed part, and also stated that 800+ vehicles are waiting on the same part. I assume not all these vehicles have been parked & that most remain on the road, unaware that they may lose their steering.

NHTSA ODI 11552183

The contact owns a 2019 Volkswagen Tiguan. The contact stated that the vehicle experienced rough starts. Additionally, the vehicle drove rough and there was an oil odor present while driving. Upon inspection, it was discovered that there was no oil on the dip stick. The vehicle was taken to the local dealer who diagnosed that the turbo was faulty and needed to be replaced. The turbo was replaced but the failure persisted. The contact stated that the vehicle was experiencing excessive oil consumption. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 35,000.

NHTSA ODI 11550752

Vehicle was purchased from Volkswagen Marin Dealership As Certified Pre-owned 2019 model year Tiguan SE 4motion Turbo Color Red on August 24, 2021 and has 18,664 mileage already upon delivery. We have received a recall letter for the water pump & made an appointment to the Dealership& brought the car there In VW Sunnyvale, Ca.. According to the service advisor (Tanya) that the recall we are acquiring is not in their database, but oil change service performed on 27,450 mileage (estimated) during that scheduled appointment for water pump service recall letter received. My wife paid for oil change service charges and fees total amount paid in cash for $450.00 - Now there are issues coming out while driving (1) frequently low tire pressure Front R-side (2) airbag icon shows (3) steering wheel steers to the right while driving; (4) the Volkswagen net-software was not activated nor provided.(5) the 4 alloy wheels has like a mirror scratch all over the design of the wheels This are the issues came out in the vehicle that we've purchased and owned possession... Please advise, hoping to get this into your attention and safety concerns is our main priority. Submitted by MR&MRS [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11545531