What 541 owners told NHTSA about the 2019 Volkswagen Jetta Hev

When weather is warm and interior heats up car will shut off by itself and a message saying "Ignition switch off, safely stop the vehicle," followed by "Starter system faulty, please service vehicle" appears. Vehicle must cool down before it runs normally.

NHTSA ODI 11593771

VW Jetta should be included in the ignition switch recall. Problem started last year August on a trip out of state. After a day sitting in the hot parking lot on drive back car reported ignition switch failure and all electronics shut off and eventually the car shut off and wouldn't restart until the interior of the car cooled off. Once inside of car cooled down car was drivable again. Contacted dealer they stated they had not serviced another Jetta with this problem yet. They adivised to continue driving and see if problem occurs again. All winter (living in cold climate) it was no problem. In March as things warmed up problem occurred multiple times. Multiple occasions the car shut off in the middle of the road luckily no accidents occurred. Had car serviced at VW dealer, they were able to replicate problem and talked with VW field rep. who said to change the ignition switch. Since replacing the ignition switch my car has not had any issues anymore. I contacted VW Care and asked to add my car to the recall or reimburse my repair cost ($ 320) They refuse and insist that my car does not have the same problem as the recalled 2019/2020 models. I was fortunate that nobody hit me from behind when my car decided to shut off in the middle of a 55 mile an hour road. since the warning lights won't work when this problem occurs. This is a very serious problem and the remedy was to replace the ignition switch. I have the email conversation between the VW CARE rep as well as a copy of my repair bill. The last email I received from VW care states that my car is not part of the recall, that they can not add it to the recall and even though it presents with the exact same problem nothing can be done about it. Please let me know if you need any additional information Sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11592978

The contact owns a 2019 Volkswagen Jetta. The contact stated while driving approximately 25 MPH, the vehicle made an abnormal beeping sound. The message "Faulty Ignition Starter" was displayed, and the vehicle shut off. The contact was able to pull to the side of the road. The contact was able to restart the vehicle after several attempts and continued driving; however, the failure recurred while driving. The contact stated that the failure had recurred several times while driving. The vehicle was towed to the dealer, where it was diagnosed that the ignition switch had failed and needed to be replaced. The contact related the failure to NHTSA Campaign Number: 23V604000 (Electrical System); however, the dealer and the manufacturer informed the contact that the vehicle could not be repaired under the recall because the VIN was not included. The vehicle was not repaired. The failure mileage was approximately 83,000.

NHTSA ODI 11592803

The incident occurred twice the first time the car stopped in the intersection and a notice came up with ignition failure; start vehicle engine: have vehicle serviced. All the electrical systems shut down except for the radio. No lights, monitor, turn signals, everything shut off except the engine kept running. I changed all the spark plugs but that did not solve the problem. When it gets really hot here in Vegas the cars ignition just fails. They have recalled 47,000 of these 2019 Jetta's for this problem but not mine. They want me to dish out money for something that is obviously their problem.

NHTSA ODI 11588967

Check engine light is on. When it’s checked it says a fuel emissions leak. Code is cleared and then turns back on a month later.

NHTSA ODI 11585481

The contact owns a 2019 Volkswagen Jetta. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the contact smelled a strong gasoline odor inside the vehicle. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

NHTSA ODI 11585277

I know there is a Shift Lever Micro Switch Recall for the Volkswagen Jetta up to the year 2018. My car is the 2019 model and I am getting the error message for this issue. Can the recall be expanded to include the 2019 model? For now, I am setting my parking brake to keep my car from possibly rolling when I park.

NHTSA ODI 11584650

The steering lock has miraculously failed and several other individuals have made this complaint. VW advised this is a known issue but has not issued a recall to have this fixed. Instead, we are forced to pay thousands to fix their mistake when it came to manufacturing

NHTSA ODI 11584364

The contact owns a 2019 Volkswagen Jetta. The contact stated while driving 35 – 45 MPH, the instrument cluster went blank, and the “Safety System Failure - Stop Vehicle” message was displayed. The contact stated that the A/C, radio, and hazard lights became inoperable. The contact pulled over and stopped the vehicle. After five minutes, the vehicle was restarted. The vehicle was taken to the local dealer, where it was diagnosed that the ignition switch had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V604000 (Electrical System). The manufacturer was informed about the failure. The failure mileage was approximately 72,413.

NHTSA ODI 11583982

Rear coil spring broke while driving about 50 mph in a straight line. A loud bang was heard in the rear of the car. This was confirmed by the dealer during an oil change. I see that this was a recall for other 2019 VW Jetta models.

NHTSA ODI 11583770

-It is not pumping gas correctly, it started out as while I pump gas it will stop frequently. I brought it to the mechanic and they replaced the evap system canister & now (while pumping) it stops even more frequently than before. Now I can only pump about 3/4 full & when I get to "full" it overflows. -I believe it is a safety concern because it is the fuel tank system. -It is available for inspection. -The problem hasn't been reproduced, it has been confirmed that 2019 VW Jetta GLI, 2019 VW Golf Sportwagen's, as well as some Audi's have been recalled for this problem. Has been confirmed that this is how it starts out. -No, there were not any indicators or symptoms prior to the problem beginning. It first started at the end of January of 2024.

NHTSA ODI 11583688

The car is making a weird sound when I break. It sounds like liquid is moving around and another sound. The central caution off in my car and the airbags too

NHTSA ODI 11583416

VEHICLE SHUTS DOWN WHILE DRIVING. ALL ELECTRICAL TURNS OFF, DASHBOARD GOES DARK CODE READS STARTER SYSTEM FAULTY, IGNITION SWITCHED OFF, PLEASE SERVICE VEHICLE

NHTSA ODI 11582990

See attached document for complaint

NHTSA ODI 11581996

The contact owns a 2019 Volkswagen Jetta. The contact stated that while attempting to park the vehicle in a handicapped parking space, the vehicle failed to stop despite the contact's foot firmly depressed on the brake pedal. As the vehicle continued to move forward with the contact's foot depressed to the floorboard, the vehicle drove over the parking barrier, knocked over the handicapped post, and entered the sidewalk. The vehicle eventually decelerated and the contact managed to shift the vehicle into reverse(R) and regain control of the vehicle. The contact was uncertain if any warning lights appeared on the instrument panel during the failure. Despite the property damage and emotional distress suffered by both the contact and the passenger, no injuries were reported and no immediate medical attention was needed. A police report was not filed and the air bags did not deploy as a result of the failure. The incident was reported to the store manager. The contact was able to drive the vehicle back home without incident. The manufacturer nor the dealer had been notified of the failure. The vehicle had yet to be diagnosed or serviced. The failure mileage was approximately 66,000.

NHTSA ODI 11577941

Exhaust cam phaser cover bolt backed out. It hit the engine casing which caused the exhaust cam phaser to misfunction.disfunction. The car has not been checked by a dealer but is available for inspection.

NHTSA ODI 11578161

1. Was rear ended on [XXX]. The air bag in my vw jetta 2019 did not deploy. The car is currently at the Ritchey Automotive 5320 I-55 North in Jackson, MS... It is available for inspection upon request. 2. No. 3. No. The car was sent to the collision center for rear bumper repair and cosmetics. 4. No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11574620

refueling problems - early stopping of gas station fuel nozzles - then the fuel would spillback on me during the refueling at the gas station 4/10/2023 - early stopping of gas station fuel nozzles - remove and replace leak detection pump - evaporative emissions system and leak detection pump 7/27/2023 - continued early stopping then fuel spillback (very dangerous situation) during refueling - remove and replace gas tank - problems have not returned

NHTSA ODI 11574152

My son, [XXX] , bought a 2019 Jetta on [XXX] from Westside VW in St. Louis Park, MN. It was marked as a Certified vehicle. On [XXX] the clutch started slipping. Later that day it gave out completely, and had to be towed to Westside. After service looked, they said that the clutch was burned out, and that this is a “wear and tear” item like tires so that he was on the hook for the entire cost of repairs, $3,433.16. When we pushed harder, they indicated that the clutch had actually been replaced just before [XXX] bought the car, when it had 43,111 miles. It failed at 52,829 miles. He has been driving manual transmission vehicles for around 15 years. I first handed down a 2000 Passat 5-speed that I bought new, and he drove that until it fell apart with around 150,000 miles and the original transmission. Later he bought a 2015 Toyota Corolla with a manual transmission, and drove that for over 80,000 miles until it was totaled in 2023. The point is that he is an experienced driver of manual transmissions. Westside claimed that he caused the clutch to wear out in less than six months and 9,718 miles. Clearly there is a problem with the vehicle if it needs two completely-new clutches in that period of time and low mileage. We are very disappointed and dissatisfied with both Volkswagen quality and Westside VW for not standing by their product. [XXX] is terrified that, despite his most cautious driving, the clutch will again fail in six months or so. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11573387

Starter system faulty message. Car shuts off when it gets warm. Shut down while driving on interstate.

NHTSA ODI 11570077

The contact owns a 2019 Volkswagen Jetta. The contact stated that while her husband was driving approximately 30–40 MPH, the vehicle stalled. The instrument cluster was blank. The contact received notification of NHTSA Campaign Number: 23V604000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ODI 11569330

The contact owns a 2019 Volkswagen Jetta. The contact received notification of NHTSA Campaign Number: 23V604000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11567286

when getting into the car the ignition switch failed to start 8 times. This happens every time I enter the vehicle where I live which is a cold climate. The recall is suspected only to affect the car in hotter climates but my car has been affected in the cold. It stalled while I was driving as well and I was able to turn the car back on. On the screen, it said failed transmission. This recall has been mailed to me 5 months ago and is still not yet fixed. I have been paying for my car on time monthly and am struggling to drive my car to the ignition switch failing. The car stalling did not hurt me and luckily no one was behind me. volkswagen has recognized the issue and sent out a recall in the mail but It's taking so long to fix and was not supposed to stall like this. the warning light was that there was failed transmission. my car has been inspected by Fitzgerald and they are unable to do anything about it because there is no remedy for the issue at the moment.

NHTSA ODI 11566961

There has been a recall out on my vehicle for the past 6 months. Previous to this recall being announced by Volkswagen I had issues with my vehicle starting, the dealership determined it was the ignition switch and replaced it out of my pocket. Since this recall being out I have noticed the same issue starting to come back. I have been in person to my local dealership and spoken to many managers as well as waited HOURS trying to contact VW Corporate. I have exhausted all ends and ultimately VW has put me into a position where my vehicle is no a reliable car to drive on day to day life having responsibilities. They have stated that I can have the current issue fixed (the recall) but it will be replaced with the same part and come out of my pocket as well as saying that I will run into this issue again until VW Corporate has come out with a solution and so far it has taken 6 months. I have waited patiently, as we all know, as time goes on the issue is progressing. My local dealership keeps trying to get me to trade in my vehicle but I should not have to take more money out of my pocket when this is a RECALL to begin with.

NHTSA ODI 11565822

Manufacture hasn’t come up with repairs my car turns off complete while driving. I haven’t been able to drive it because I’m scared of being or cause an accident please help

NHTSA ODI 11565867