What 869 owners told NHTSA about the 2019 Toyota RAV4 Plug-in Hybrid

WHILE FEELING THE GAS, AT ALMOST EMTPY, I DIDN,'T WENT ABOVE THE 10 GALLONS. THIS REQUIERED ME TO GO MULTIPLE TIMES TO THE GAS STATION TO FILL IO THE GASTANK. MOREOVER, THE GAS RANGE HAS DECREASED FROM ALMOST 500 MILES TO LESS THAN 380 MILES IN RANGE FROM 2 MONTHS AGO TILL NOW. THE MILAGE OF THE VEHICLE IS LESS AROUND 2,800 MILES. VEHICLE WAS BOUGHT IN AUGUST OF 2019

NHTSA ODI 11312168

WHEN FUELING THE VEHICLE, THE AUTO SHUTOFF AT THE GAS PUMP SHUTS OFF BEFORE THE FUEL TANK IS COMPLETELY FILLED. OCCURS AT MULTIPLE GAS STATIONS REGARDLESS OF THE AMOUNT OF FUEL REMAINING IN THE TANK.

NHTSA ODI 11311891

TL* THE CONTACT OWNS A 2019 TOYOTA RAV4 HYBRID. THE CONTACT STATED THAT THE FUEL GAUGE WAS INOPERABLE. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THE FUEL GAUGE FAILED TO REGISTER THE CORRECT AMOUNT OF FUEL. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300.

NHTSA ODI 11311573

WHEN FUELING, THE TANK WILL NOT COMPLETELY FILL. IF YOU ATTEMPT TO CONTINUE TO FILL VERY SLOWLY THE TANK OVER FILLS AND YOU HAVE PROBLEMS WITH THE VAPOR RECOVERY SYSTEM.

NHTSA ODI 11311696

FUEL TANK WILL NOT FILL CORRECTLY. IF I OVER FILL IT AFFECTS THE VAPOR RECOVERY SYSTEM OF THE RA 4 HYBRID. HAVE TO BE EXTREMELY CAREFUL NOT TO RUN OUT OR GASOLINE.

NHTSA ODI 11311699

1ST INCIDENT: SITTING AT STOP LIGHT FOR A FEW MINS AS NORMAL. WHEN TIME TO ACCELERATE, THE VEHICLE STARTED LURCHING FORWARD IN A HARD JERKING MOTION. 2ND INCIDENT: SLOWER TRAFFIC. WHEN DRIVING IN SLOWER TRAFFIC OR AT SLOWER SPEEDS, ~20-35MPH THE VEHICLE WILL START LURCHING JERKING FORWARD. TOOK BACK TO DEALERSHIP FOR INSPECTION, THERE WERE NO ISSUES FOUND. DEALERSHIP RESET INTERNAL COMPUTER, STATING THAT "VEHICLE IS OPERATING NORMALLY". NEITHER HAS ISSUE HAS YET TO CAUSE AN ACCIDENT WITH ANY OTHER DRIVERS AT THIS TIME. I DO TRAVEL WITH DOGS WHO ARE HARNESSED AND SEAT-BELTED IN THE BACKSEAT, THEY WOULD HAVE BEEN THROWN TO FLOOR OF CAR IF NOT SEAT-BELTED. FOR MYSELF, I GET TOSSED FORWARD SEVERAL INCHES AND HEAD THROWN FORWARD. WHEN DRIVING IN SLOWER TRAFFIC AND/OR STOP AND GO TRAFFIC, THE CAR LURCHING/HARD JERKING FORWARD WILL EVENTUALLY CAUSE AN ACCIDENT. ALL INCIDENTS HAVE HAPPEN ON DRY CITY STREETS. I WOULD ASSUME DURING THESE INCIDENTS OF THE JERKING FORWARD THAT THE BREAK LIGHTS DO NOT ALERT REAR DRIVERS THAT THE CAR IS IN A STOP/GO MOTION.

NHTSA ODI 11311751

THE VEHICLE WILL NOT ACCEPT MORE THAN 10 GALLONS OF FUEL AND MILEAGE RANGE IS SIGNIFICANTLY LOWER THAN EXPECTED/ADVERTISED ON A 14.5 CAPACITY TANK

NHTSA ODI 11310531

WHEN THE FUEL GAUGE INDICATES THAT THE TANK IS NEARLY EMPTY, MY VEHICLE WILL ONLY ACCEPT ABOUT 10 GALLONS OF FUEL UNTIL PUMP SHUT-OFF. AS A RESULT MY VEHICLE FAILS TO MEET TOYOTA MILEAGE RANGE SPECIFICATIONS OF 580 MILES AND ONLY MAKES ABOUT 400 MILES. MOREOVER, IF TRYING TO FILL UP WITH 15 GALLONS OF FUEL AND GOING BEYOND PUMP SHUT-OFF THERE IS A RISK OF OVERFILL AND FIRE HAZARD. KOONS DEALERSHIP REFUSES TO ACKNOWLEDGE THE DEFECT WHICH SHOULD BE COVERED BY WARRANTY.

NHTSA ODI 11310449

THE VEHICLE'S LISTED FUEL TANK CAPACITY IS 14.5 GALLONS. I HAVE NEVER BEEN ABLE TO ADD MORE THAN 9.5 GALLONS EVEN THOUGH THE FUEL GARAGE WAS REGISTERING EMPTY AND THE COMPUTER WAS SHOWING 14 MILES TO EMPTY. TOYOTA AND THE DEALERSHIPS KNEW OF THIS PROBLEM IN THE SUMMER OF 2019 YET CONTINUED TO SELL THIS VEHICLE WITHOUT INFORMING CUSTOMERS OF THE ISSUE. THIS PROBLEM NEEDS TO BE ADDRESSED.

NHTSA ODI 11310159

UNABLE TO FILL GAS TANK WITH 14.5 GALLONS EVEN WHEN EMPTY. MAXIMUM AMOUNT OF GAS THAT CAN BE FILLED IS APPROXIMATELY 10 GALLONS EVEN WITH LOW FUEL LIGHT ON. COMMON ISSUE MENTIONED ON NUMEROUS ONLINE RESOURCES.

NHTSA ODI 11310162

PURCHASED 2019 RAV4 HYBRID 4/2019. ON WINDING ROADS USING LOW BEAMS, LIT UP DISTANCE IS ABRUPTLY AND SEVERELY SHORTENED AS THE ROADWAY DIPS AND TURNS. THESE HEADLIGHTS ARE UNSAFE, IN MY OPINION. SANTA CRUZ,CA HAS MANY SUCH ROADS, INCL. HWY. 17, AND USING HIGH BEAMS IS NOT ALWAYS AN OPTION. IT WAS UNNERVING DRIVING THIS VEHICLE THE FIRST NIGHT THAT I OWNED IT, AND STILL IS.

NHTSA ODI 11310172

I HAVE A 2019 TOYOTA RAV4 XSE HYBRID. I BOUGHT IT BRAND NEW WITH ROUGHLY 300 MILES ON IT AND SINCE THEN HAVE PUT ON AN ADDITIONAL 5700. I BOUGHT IT IN NOVEMBER AND IT IS NOW FEBRUARY. I WAS INFORMED AND RESEARCHED TOLD ME THAT THE FUEL TANK WAS 14.5 GALLONS. YET, EVERY TIME I GO TO FILL UP THE TANK ONCE THE LIGHT HAS CAME ON, I CAN ONLY GET ROUGHLY 8.5-9 GALLONS OF FUEL IN AND THEN THE PUMPS SHUT OFF. I HAVE FILLED UP MORE THAN 15 TIMES AND EVERY SINGLE TIME AT NUMEROUS DIFFERENT PUMPS, THIS SAME THING HAPPENS. I AM ABLE TO SQUEEZE IN ROUGHLY ANOTHER 2-3 GALLONS BUT I HAVE NEVER SEEN ANYWHERE CLOSE TO 13 GALLONS LET ALONE THE ADVERTISED 14.5. WE ARE SUPPOSED TO GET A MAX OF 580 MILES PER TANK AND THE AVERAGE I GET WITH THIS LESS AMOUNT OF GAS I CAN PUT IN IS ROUGHLY 410-430.

NHTSA ODI 11310183

OUR NEW IN AUGUST OF 19 HYBRID RAV4 HAS THE FUEL PROBLEM THAT IT APPEARS THOUSANDS OF OTHERS DO. IT HAS A 14.5 GALLON TANK, BUT THE SYSTEM WON'T ALLOW YOU TO FILL THE TANK. AT EVERY GAS STATION, THE PUMP IS INITIALLY SHUT OFF WITH MANY GALLONS LEFT TO GO TO FILL THE TANK. THIS LEADS TO A SITUATION WHERE YOU HAVE TRICKLE FILL TO GET IT CLOSE TO FULL. TRICKLE A LITTLE IN, THE VAPOR SYSTEM SHUTS IT OFF---AND DO THAT AGAIN AND AGAIN AND AGAIN UNTIL YOU FEEL YOU ARE CLOSE TO FULL. IT'S EASY TO OVERFILL AND EASY TO SPILL GAS ONTO THE GROUND WHILE DOING SO. WE STARTED AN OPEN CASE ON THIS WITH TOYOTA WITHIN A FEW MONTHS OF NEW LAST FALL, AND TO DATE THEY STILL HAVE NO FIX FOR THE ISSUE. IT APPEARS SIMILAR TO A BLADDER PROBLEM THEY HAD WITH PRIUS GAS TANKS SOME YEARS AGO, BUT THEY REFUSE TO DISCUSS WHAT THEY ARE DOING TO FIX IT.

NHTSA ODI 11310005

ON LIGHT ACCELERATION FROM AN INTERSECTION AND/OR MILD CRUISING SPEED IN ECO MODE, THERE IS AN OFTEN VIOLENT LURCH FROM STOP OR SURGING AT CRUISING SPEEDS. WITH TRACTION CONTROL SWITCHED OFF, THE PROBLEM IS LESSENED, BUT TRACTION CONTROL BY DEFAULT TURNS BACK ON IN <ONE MINUTE. WE HAVE BEEN TOLD BY BOTH MARIETTA AND WORLD TOYOTA THAT THIS IS A KNOWN PROBLEM, LIKELY RELATED TO DRIVE-BY-WIRE, AND THAT TOYOTA HAS NO PLANS TO ADDRESS THE ISSUE UNTIL SOMETHING HAPPENS TO JUSTIFY THE FINANCIAL BURDEN OF A "FIX". WE LIVE IN ATLANTA, WHERE TRAFFIC IS INTENSE AND RELIABILITY IS KEY. THIS IS OUR 14TH TOYOTA AND FIRST PROBLEM THAT HAS BEEN IGNORED. THE SERVICE DEPARTMENT DOES NOT KNOW HOW TO FIX THE PROBLEM WITHOUT GUIDANCE FROM TOYOTA CORPORATE. WE ARE MARKEDLY LIMITING OUR USE OF THE VEHICLE (3K MILES IN 7+ MONTHS) DUE TO RISK OF COLLISION. THE PROBLEM BEGAN AFTER WE HAD DRIVEN THE CAR FOR ONE MONTH.

NHTSA ODI 11309593

RAV4 HAS ONLY 500O MILES ON ODOMETER. HAVE BEEN GETTING A SQUEALING SOUND FROM THE BRAKES WHEN BRAKE PEDAL IS DEPRESSED. BRAKING ABILITY IS NOT DIMINISHED, JUST A PERSISTENT SPEAK. SEEMS TO BE MORE PRONOUNCED AT FIRST MORNING BRAKING. AFTER ABOUT 5-10 MINUTES IT WILL GO AWAY FOR THE DAY.

NHTSA ODI 11309648

I CAN NOT FILL UP MY GAS TANK IT SHUTS OFF AT ABOUT 12 GALLONS

NHTSA ODI 11309705

UNABLE TO FILL 14.5 GALLONS AS ADVERTISED.MAX FILL IS 11 GALLONS. BROUGHT IT TO THE DEALER AND THEY CONTINUE SAYING THE CAR IS FINE AND THAT THERE'S A "RESERVE FUEL" WE CAN'T SEE. THEY ARE UNWILLING TO FIX THIS ISSUE

NHTSA ODI 11309456

MY 2019 RAV4 HYBRID HAS A TOYOTA ADVERTISED FUEL TANK CAPACITY OF 14.5 GALLONS. TILL DATE, VIRTUALLY ALL MY FUEL STOPS HAVE RESULTED IN NO MORE THAN 11 GALLONS OF FUEL. I WOULD LIKE TO RAISE THIS MATTER TO NHTSA AND URGE NHTSA TO INVESTIGATE MATTER FURTHER. THE BIGGEST QUESTION I HAVE IS IF THERE IS A LAW OR SAFETY RULE THAT TOYOTA MUST FOLLOW SURROUNDING THIS ISSUE? MY CONCERN IS THAT IF ANY RESIDUAL FUEL (WHICH IN THIS CASE IS GREATER THAN 3 GALLONS), MAY CAUSE SAFETY HAZARDS FOR DRIVERS AND THIS ISSUE NEEDS TO BE FIXED.

NHTSA ODI 11309479

THE VEHICLE HAS AN ENGINE KNOCK/RATTLE NOISE AT COLD START UP.

NHTSA ODI 11309474

THIS VEHICLE IS A HYBRID. THE GAS TANK IS SUPPOSED 14.5 GALLONS. THE GAS GUAGE NEVER SHOWS AS FULL. THE VEHICLE SHOWED 103 MILES TO EMPTY SO I FILLED IT UP. I COULD ONLY ADD 7.414 GALLONS OF GAS BEFORE THE PUMP STOPPED ON THE 2ND ATTEMPT. IT CLICKED OFF JUST A LITTLE OVER 7 GALLONS. I PULLED THE NOZZLE OUT OF THE TANK A LITTLE AND WAS ABLE TO GET ABOUT0.4 GALLONS ADDITIONAL IN THE TANK BEFORE IT CUT OFF AGAIN. THE GAS GUAGE STILL SHOWED AS A COUPLE OF LINES BEFORE BEING FILLED YET I COULD GET NO MORE GAS IN THE TANK. ALSO, IT ONLY SHOWED MY VEHICLE RANGE AS 419 MILES. AT 40+ MPG AND A 14.5 GALLON TANK, IT SHOULD SHOW OVER 580 MILES TO EMPTY. THERE IS DEFINETELY AN ISSUE WITH THIS GAS TANK. I HAVE ATTACHED PICTURES OF THE BEFORE FILL UP, AFTER FILL UP AND THE GAS RECEIPT SHOWING THE AMOUNT OF GAS I COULD GET IT THE TANK WITHOUT RISKING AN OVERFLOW. I REALLY HAVE NO WAY OF KNOWING HOW MUCH GAS IS IN THE TANK OR HOW FAR I CAN EXPECT TO DRIVE BEFORE RUNNING OUT OF GAS. I HAVE MORE INSTANCES OF THIS, ALL SHOWING THE SAME PROBLEM.

NHTSA ODI 11309483

MY 2019 TORTOLA RAV4 XLE WITH 6401 MILES ON IT HAS BEEN EXPERIENCING PROBLEMS WITH STALLING SINCE I FIRST GOT IT IN AUGUST. I NOTICE IT ESPECIALLY WHEN I DON'T MAKE COMPLETE STOPS. IT WILL STALL AND YANK THE CAR FORWARD. IT IS ANNOYING AND EMBARRASSING THAT MY NEW CAR DOES NOT DRIVE SMOOTH. I WILL BE TAKING IT TO A TOYOTA DEALERSHIPS TO GET EVALUATED.

NHTSA ODI 11309396

AFTER ENTERING AN ADDRESS, I DECEIDED NOT TO GO THERE. THE GPS CANNOT BE READDRESSED OR DELETED WITH A SIMPLE COMAND. IT IS MOST DISTRACTING TO HEAR THE REPETITION OF THE PREVIOUS ADDRESS WHILE DRIVING. NO ONE PERSON AT THE DEALERSHIP COULD GIVE INSTRUCTIONS TO DELETE THE GPS, EXCEPT TO TURN IT OFF.

NHTSA ODI 11309109

UNABLE TO FILL FUEL TANK TO CAPACITY. WHEN FUELING SHUTS OFF AT ABOUT 7 TO 8 GALLONS.

NHTSA ODI 11309126

FUEL TANK IS DEFECTIVE. DOES'T ACCEPT A FULL TANK OF GAS. 3/4 AT MOST BEFORE PUMP SHUTS OFF. NOT GETTING MILES PER TANK/EFFICIENCY THAT WAS ADVERTISED. FILED A CASE WITH TOYOTA AND DEALER BUT NO FIX AVAILABLE. PROBLEM STARTED AS SOON AS I DROVE IT OFF THE LOT IN MAY 2019.

NHTSA ODI 11309194

WHEN FILLING THE GAS TANK, THE PUMP WILL STOP BEFORE THE GAS TANK IS FULL, USUALLY 2-3 GALLONS SHORT OF BEING FULL. THIS HAPPENS EVERY TIME I TRY TO FILL THE TANK SINCE I BOUGHT THE CAR IN MAY, 2019. THIS RESULTS IN MORE FREQUENT STOPS AT THE GAS STATION OR MAKING EFFORTS TO TRY TO TOP OFF THE GAS TANK BY TRYING TO SLOW DOWN THE GAS BEING PUMPED IN. WITH A VERY SLOW RATE, THE GAS PUMP MAY NOT SHUT OFF THEN LEADING TO FUEL SPILLAGE.

NHTSA ODI 11309239