What 416 owners told NHTSA about the 2019 Kia Sorento Plug-in Hybrid

Multiple lights on dash same time. Auto Hold, Fwd Collision, Adaptive Cruise and ABS. Code said ABS Module faulty. Multiple Safety System affected and rendered useless.

NHTSA ODI 11742753

Warning lights for ABS, Traction Control, and Forward Collision-Avoidance (FCA) appear simultaneously. The FCA system may fail to engage or display warnings. Causes: The issues are frequently tied to a faulty ABS module, malfunctioning wheel speed sensors (often the rear), or corroded connectors. Unsafe to drive. Also paint is just peeling off the car in huge chunks all the way down to the metal for no reason.

NHTSA ODI 11713193

I get an error message on all the forward collision and lane departure system. A mechanic has looked at this and they cannot determine the issue. They say maybe the front cameras are acting up but the car has never been in a accident that would impact the cameras. In addition the drivers mirror will not reset from the reverse setting to drive mode. When driving it needs to be manually adjusted each time in order to see.

NHTSA ODI 11690362

Upon starting my vehicle after going to the grocery store, the ABS, ESC, Check Forward Collision-Avoidance Assist System, and Auto Hold warning lights illuminated. The cruise control was then inadvertently deactivated. When vehicle is started the Check Forward Collision error comes on. After a few months when entering the freeway and accelerating I received an error regarding unknown engine issue. Took vehicle to Kia dealership and was who diagnosed that the hydraulic electronic control unit (HECU) needed to be replaced. Manufacturer being notified, vehicle not repaired at dealer due to cost.

NHTSA ODI 11667820

The forward collision system warning system the warning that it's not working stays on for a couple of days then goes off but then it comes back on. My other problem is the Pearl White paint is peeling off the hood and roof of my Sorento. Kia said not their problem because it has 80,000 miles. I have read thousands of complaints about this problem. There seems to be a problem with the paint they are using.

NHTSA ODI 11634853

Master warning, forward collision avoidance assist, lane keeping assist, and high beam assist warning lights on. Message boards mention similar problems and there have been front and rear camera recalls for Telluride and other models of Kia, but not for Sorento. Similar problem occurred a few months ago when car died while going at highway speeds. This resolved after cleaning radar cover, cameras and sensors, but are not resolving current problem. Lane assist and departure are not working. We have not taken it to dealer yet. Our 2019 Sorento has not been included in recalls for this specific problem.

NHTSA ODI 11632284

Multifunction front camera unit part number 95740-c6560. Warning lights come on every day. They continue to alert while driving causing issues with attention to the road. The high beams will not work unless the lights are set to on instead of auto. Vehicle was taken to a Kia dealership, and they diagnosed a complete failure on the part. This part operates several of the safety functions of the vehicle. There have been several people who have had this issue.

NHTSA ODI 11625948

Vehicle has LKA FCA and HBA error lights on. Dealer inspection found Active DTC C180508 LKAS Can-Signal error. C160649 ECU Software Error. CAN Line inspection found incorrect Can-Signal from Multifunction Camera.

NHTSA ODI 11618508

Possible components/systems with issues: Engine, Suspension, Electrical, Emergency Parking Brake and Auto Hold, Back-Up Camera, Parking Collison Warning, et al Been trying to get my vehicle issues resolved. I have not been able to enjoy nor use my vehicle. I've had numerous repeat service appointments. I feel unsafe using the vehicle. Issues have almost caused accidents. It is now at the dealership and I've been in a loaner vehicle almost 3 months. 1. Suspension problems: I had to drive at reduced speeds and avoid highway usage. Poor driveability and rough handling. Felt like tires would pop off. 2. Oil consumption: Poor performance, reduced power and fuel economy. Check engine light came on. Dealership said I had no oil, history codes, and code for injector misfire. They cleared the codes, told me to come back if codes come back. Had me to do oil consumption tests every 1,000 miles which showed low oil levels. I had to restrict usage of my vehicle for the testing. They ultimately said someone did not properly do the testing and there was never an issue with oil consumption. I believe there was an issue. Check engine light keeps coming on. 3. Back-up camera was replaced for recall. New camera had issues causing inverted images, distorted views, and malfunctions with parking and blind spot sensors. Could not use camera. Took back to dealership multiple times, they checked and said they fixed it but it was not. 4. Emergency Parking Brake and Auto Hold Malfunction: Dashboard indicator for Auto hold malfunction and messages for activation/deactivation of emergency brake/Parking. Vehicle would stop abruptly while driving without notice. Almost caused several accidents. Auto hold would not function as designed so vehicle would keep moving when it was activated, however, the vehicle is not supposed to move when it is activated. Had to pull over, turn vehicle off and back on. Sometime it cleared, sometimes it didn't. Dealership could not replicate so had me record

NHTSA ODI 11615304

infotainment screens failed while driving. As a result call failed and this makes hands free phone usage unavailable. Kia case manager emailed directly due to open case regarding ongoing electical issues causing accident earlier in year. Kia unable to provide rental/transportation due to "covid" and "shortages". Appointment was missed 10/30/2021 due to unavailable transportation and issues potentially taking weeks to diagnose at dealership. Kia did not arrange/approve transportation as promised. Kia had vehicle 3/3/2022 to 3/30/2022

NHTSA ODI 11598734

Days prior to routine scheduled maintenance, several warning lights came on. There was a display of Front Collision Warning. Service department could not replicate the warning lights. Days later, the warning and lights came on more frequently. Took car into dealership and they confirmed a problem. Service department replaced: BR001 HECU 26238 C and 58910-C9600 Hydraulic Unit Assy. As I understand this motor is the main component in having the anti-lock braking system functioning normally. The service department told me to keep the receipt, since it wasn't under warranty, in the event there was a product recall. My concern: Even though there were warning lights the warning wasn't significant enough to indicate that there was a potential safety hazard with a malfunctioning brake system. I submit this in the event there are other incidents of this nature that could possibly warrant a recall.

NHTSA ODI 11580622

Check forwarded collision was on and it has disabled my traction control and abs light was on kia had me make an appointment 3 weeks out. Was leaving for work and it was rainy I was doing 30 in a 40 and I tried stopping to slow down because there was a car in front of me stopped at a yeld so I tired to stop harder but back of car stating sliding our so I had to quickly make a move to get to the lane next to me and there is no one over there and I went over a curb and resulting in totalling my car

NHTSA ODI 11577468

Screen turned off and then lights on dash started flashing. ABS, power steering, blind spot warning, tire monitoring failed. Battery light was flashing. Parking break light came on. Loss of power. Now it will not turn on

NHTSA ODI 11518533

While driving with cruise control enabled, the cruise control suddenly disengaged and became inoperative, and the following warning lights (icons) and warning messages displayed on dashboard: > “Check Forward Collision-Avoidance Assist System” warning message > Master warning mode light > ABS warning light > Forward collision assist warning light > Electronic stability control indicator light, and > Auto Hold indicator light. Vehicle continued to operate normally except for those error warnings; cruise control remained disengaged and inoperative. After pulling off the roadway, turning the vehicle off and restarting engine, vehicle operated normally, cruise control could be re-enabled normally, but eventually the same warning lights and warning messages displayed on dashboard and cruise control again disengaged and remained inoperative. This happened multiple times over a number of days. This error happens randomly, at various speeds, but only after cruise control has been engaged. After pulling off the roadway, I took pictures of the dashboard showing these error messages and warning icons to show dealership at appointment that has been scheduled later this week. (These photos are attached to this report.)

NHTSA ODI 11508243

I purchased my Kia Sorento in 2020. It was a used 2019 with 7,000 miles. I immediately noticed that it would squeak rather loud and bounce high when driving over very small humps on the roads. Being that I'm no mechanical savvy, I assumed this was normal for SUV's because I've driven sedans all my life. Anyways, I was informed of the issue when going to a tire repair shop asking why my back tires sounds so harsh when driving. I was told that there are waves in my tires due to the shocks. and that the shocks has had to have issues for a while to now change the formation of the tires. I have now read several Kia forums and there are lots of Kia Sorento owners who have suspension issues close or the same as mine. Another issue is the automatic emergency brake. I was unaware of this feature until one day having to make a sudden stop and the vehicle stopped and shut off on its own almost causing me to be hit in the rear. This event was very traumatizing. I googled this feature and thought that I had turned it off but I realize that I can't make it go away and it is a very dangerous feature to have. My vehicle does not have as much driving experience as I do and I am capable of controlling my vehicle to avoid an accident if I need to without the assistance of a computer which has almost caused nearly fatal accidents by immediate stops or shutting off the vehicle causing me to not be able to control the vehicle myself. Another defect is the powered trunk. Whether I open it from the button near the steering wheel or the button on the rear gate, the trunk will immediately close on its own after opening; sometimes closing down on the top of the head of my children or myself. I selected to disable the "smart" feature but it does not stop it. The last defect is electrical. I have replaced the same internal light near the rear view mirror, and it continues to go out. This is an indication of an electrical issue and with my Kia only having 54,000 miles, further action is needed.

NHTSA ODI 11483030

when vehicle is started and put in drive, you go about 5-10 feet and the FORWARD COLLISION AVOIDANCE ASSIST, warning lights come on dash. Bright orange triangle with a exclamation mark,& 2 orange cars crashing symbol,& middle display says FORWARD COLLISION AVOIDANCE ASSIST(FCA)SYSTEM DISABLED. RADAD BLOCKED. And the warning lights remain on. I have taken to KIA East in Louisville, they say my vehicle is fine, no problems. My advisor even told me that they popped off the plastic bumper and removed the radar and cleaned it.(I was told that if they did that the radar would have to be recalibrated--and it was not). When I left the dealership the warning lights came on and I took it back in and they still tell me they worked on it and its fine. called Kia Consumer, they tell me to video and get it back in the shop that if its throwing codes there is no problem. I told her I don't feel comfortable trying to drive and video my dash board, but did have a passenger help with this task. Lights come on every time you start it and proceed forward. I also reported how sluggish on take off and how it does not want to speed up and almost get hit if you pullout in traffic and then how it lunges forward and the accelerates very hard. I feel this is a very unsafe vehicle and they are giving me the run around Kia Consumer telling me to take it to other kia dealerships for service that are miles away from me. the documentation from the dealership just says can't duplicate and no real written explanation of what was done to my vehicle. it took 3 months to get my vehicle even checked at the dealership. i even took my vehicle to a local body shop to make sure it had not been hit and it had not. Please help me get this taken care of.

NHTSA ODI 11481957

Whenever I am stopped at a stoplight and in the close vicinity of a vehicle powered by electricity (specifically Tesla) or dual powered vehicles, the front warning lights start acting up. First going to (green) warning, then to (yellow) warning, and sometimes all the way to (red) warning. This happens even when the stopped vehicle is in the lane next to me and is parallel to me. The whole time all vehicles are stopped and waiting for the traffic to start moving. In my opinion this is very dangerous. Hopefully this is not affecting any of the other computer functions. This has been going on for at least 5 months. Consumer stated it only started about 6 months ago and really is only the late model Tesla an Prius models that cause the crash sensors to go off.

NHTSA ODI 11451771

TL* THE CONTACT OWNS A 2019 KIA SORENTO. WHILE DRIVING APPROXIMATELY 60 MPH, THE FORWARD COLLISION WARNING MESSAGE SUDDENLY DISPLAYED. MOMENTS LATER, THE VEHICLE ABRUPTLY STOPPED WITHOUT ANY OTHER VEHICLES IN THE VICINITY. AFTER TURNING THE VEHICLE OFF AND RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO VAN SYCKLE KIA (729 HOGAN RD, BANGOR, ME), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. LATER, WHILE DRIVING APPROXIMATELY 40 MPH, THE 'BLIND SIDE COLLISION' MESSAGE DISPLAYED AND SUDDENLY ACTIVATED, WHICH ABRUPTLY STOPPED THE VEHICLE WITHOUT ANY OTHER VEHICLES AROUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED CASE NUMBER: 13352019. THE FAILURE MILEAGE WAS 5,000.

NHTSA ODI 11267605