What 202 owners told NHTSA about the 2019 Kia Optima

Original owner, received in mail that this vehicle was recalled for engine issues. Provided a lifetime warranty for engine. Noticed my vehicle began consuming oil more than normal. I constantly have to put oil in the car 2-3/ week. The shops say it doesn’t need an oil change the oil is burning fast. Never notice any leaks bit my vehicle began to not pick up speed and shop said the oil is burning and possible engine is getting ready to go. Called dealership and they said they won’t replace u less the engine is totally blown and I need to have all type documents showing I’ve been doing maintenance although this is a known issue. Constant oil changes.

NHTSA ODI 11663979

I was driving in the rain on the highway and engine light started flashing!

NHTSA ODI 11660178

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds, an abnormal engine oil consumption was noticed. The check engine oil warning light illuminated abnormally often, shortly after an oil change had been performed. The vehicle was taken to a local dealer, where it was diagnosed with defective piston oil rings. The vehicle was not repaired due to the warranty being deemed invalid. Upon further investigation, the contact related the failure to an unknown recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 65,000.

NHTSA ODI 11658158

Lights appeared on the dash and the vehicle locked and would not drive. This happened as I was actively driving. I had the vehicle towed and was told by the Kia dealership that it was my abs/hecu. Before this happened, there was no warning lamps or messages. The car was driving normally.

NHTSA ODI 11655299

My engine is burning oil at an alarming rate, my car is not recognizing low oil, so I no oil lights are appearing. I have to go to the oil change place weekly to have my oil checked. When my oil is low, I have to pay to have my oil replenished between months of my oil changes. My and my son safety was put at risk, when I found out at an oil change visit, I had less than an quart of oil I was driving around with. Which can cause engine failure while driving, overheating, and reduced performance while driving. This was confirmed by an oil change facility. I am currently in a ongoing dispute with the dealership I received my car from. The Kia dealership is refusing to do any maintenance until I can produce five years of oil change records that are not showing on car fax. To date my car oil light is not coming on, no signs are shown in my car showing this issue. I have to just get it checked weekly and pay for oil to be safe until, I can get a new engine.

NHTSA ODI 11652457

Oil is getting into cylinders causing spark plugs to misfire. Very high oil consumption so I have to put oil in it every other day in between oil changes. I’ve been to Kia Service department several times in the past 2 months.

NHTSA ODI 11651683

My 2019 Kia Optima purchased brand new. Kia released a service bulletin on 3/1/22 citing “excessive oil consumption for 2011-2021 Optima's”. I took it in for the "updates" for said service bulletin for the engine and was told that my engine is good and covered now for the life of the engine even past the 100k miles (mind you no one mentioned doing an excessive oil consumption test at this time). On 3/22/24 car had 104k miles on it and the oil light came on. I had an oil change just 2500 miles or so prior. Pulled into an autozone and it was almost bone dry. I put oil in it and the light went off. I took it to Evans Kia and was told that they couldn't do anything because it was past 100k warranty and that they couldn't run the DX test to determine if it was excessively consuming oil as per the recall. Apparently during the recall they did the DX tests if the consumer stated it was burning oil fast or something to that extent. Mine did not get said test, only the upgrade. They should have done the test, but they just did an "upgrade" which clearly did not work. They said since I had the "upgrade", if the engine fails, then Kia would fix it under warranty. Since then, this happened at least 4 more times with the oil light coming on and engine oil practically gone. Each time took less and less miles. I showed up to Kia 2 of those times in 2024 to show them the the oil change date, mileage, and check oil light on. Also physically showed them the oil being almost empty, yet they did nothing but say when the engine dies or "knocks" they can fix it under warranty. One of those times I had it towed but they determined it was the fuel pump, never mentioned anything else. Fast forward 3/15/25 the engine starts knocking and engine light comes on. I managed to drive it to Evans Kia without any accidents. After my car sat for 9 days, they call me on 3/25/25 and tell me there is a "burnt valve on cylinder 4 and the engine will need to be replaced and it is not covered. How? Help!

NHTSA ODI 11650841

UNKNOWN. Vehicle is burning through oil every 1,000 miles or so. Excessive oil consumption which i am aware there is a recall. However Kia states my VIN # is not included. While at the dealer service department for failed A/C system, we questioned the excessive oil consumption and engine replacement. We were told they found nothing wrong. Having to top off oil every 1,000 miles or so. It does not make it to the next oil change before the light comes on. No oil leaks. Mechanic said known problem with this engine. Most recently the starter went bad, alternator, and battery. Replaced with a second brand new battery and car won't start again. Dash is lighting up erratically, new battery dead. As if something is drawing all power and draining brand new batteries. This car has a little over 86,000 miles and one thing after another is failing. The car lost power and power steering in a curve leaving us in a dangerous situation after replacing the starter. Dash lighting up erratically with front end collision warning message on the display. We had it towed to our residence which our auto insurance reimbursed us for. Replaced alternator and battery yesterday, and the car lost all power again turning back onto our street, again with the Dash lighting up erratically.

NHTSA ODI 11650922

HAD CAR FOR 2 AND 1/2 YEARS STARTING ABOUT 9 MONTHS AGO STARTED HAVING ISSUES WITH OIL LEAKING ISSUE. I NOTICED WHEN STARTING CAR AND MADE SHAKING SOUND BOUGHT TO MECHANIC AND TOLD ME THE OIL LEAKED HAVE TO REPLACE SPARK PLUGS AND HAVE DONE ABOUT 4 TIMES NOW SEPT 2024, FEB 2025, 03-14-25 AND THIS MORNING 03-23-25. I'M STILL MAKING PAYMENTS ON THIS CAR BESIDES COSTS FOR REPAIRS. THANKS APPRECIATE ANY HELP. MY MECHANIC SAID WHEN ENGINE WAS BUILT NOT PUT IN STRAIGHT IN VEHICLE WONDERING IF THIS RELATED TO MY ISSUE.

NHTSA ODI 11649988

Oil consumption

NHTSA ODI 11646878

Excessive oil consumption for a car with 45,000 miles with no observed leaks under the car or on the outside of the engine

NHTSA ODI 11641346

P1326 code. Check engine light flashing. Is in limp mode with limited power.

NHTSA ODI 11640243

I recently had an oil change and not even 600 miles later the oil is completely gone. My engine is burning oil like crazy. This just started happening at the 95,000 miles mark

NHTSA ODI 11634082

Since January 2024 I have had to replace the spark plugs more than 3 times. It has also had to have an oil change done at least every two months regardless of the miles that were put in it. BURNING OIL LIKE CRAZY Mid October 2024 a full tune up was done as well as oil change and less than two weeks later it started bucking like a bronco and all oil was gone out of it. Check engine light is on and oil light goes on and off. Cannot drive at all

NHTSA ODI 11630663

Defective piston rings leading to excessive oil consumption, spark plug deterioration, and potential engine failure.

NHTSA ODI 11629409

Engine is consuming too much oil engine is shaking and knocking engine light is on reducing speed will cut off in mid drive

NHTSA ODI 11624375

The contact owns a 2019 Kia Optima. The contact stated while driving approximately 65 MPH, the vehicle made an abnormal knocking sound and started vibrating and shuddering. The contact stated that the vehicle started to lose motive power and failed to respond upon depressing the accelerator pedal. The vehicle stalled and failed to restart. The contact stated that the check engine warning light illuminated while attempting to restart the vehicle. Additionally, the contact stated that the vehicle had previously experienced engine failures and electrical fuse failures. The contact stated that the 12-volt battery was previously replaced three times. The contact had taken the vehicle to two local dealers. The second dealer referred the contact to the manufacturer for assistance. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

NHTSA ODI 11622422

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled. During the failure, a flashing check engine warning light was illuminated. The vehicle was towed to the local dealer who determined that the engine had experienced excessive oil consumption. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 30,449.

NHTSA ODI 11611383

The car is using oil like crazy and is not leaking anywhere out of the vehicle. Stalling out while driving and then accelerating. Has completely lost power and rolled down an onramp. Completely unsafe. Took for diagnostic and they wanted to say I needed a new gas cap. Replaced, still doing same thing. Hesitant to start even and the alternator is less than a year old.

NHTSA ODI 11609473

This vehicle is a lemon. It is a 2019 with 81,000 miles. How in the world does the engine start knocking when i have consistently, kept up with the maintenance on this vehicle. If i do not hear something soon im weakening legal action. Since May 18TH i have been without a car.i am a single mom and this is so difficult. Mind you it was towed July 5th from where it broke down on me.

NHTSA ODI 11608387

I am having to change the plugs in this car monthly. The car goes into limp mode and will not go over 15 miles an hour. There is oil getting in the plugs and causing them to burn. This car uses a lot of oil. Lots of oil!! these issues started at 100,011 miles. I have also noticed that this car has started accelerating on its own.

NHTSA ODI 11608257

The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the oil pressure warning light illuminated. The contact stated that shortly afterwards, the check engine warning light illuminated, and the vehicle started losing motive power while attempting to accelerate. The contact stated that the vehicle was shuddering and jerking while driving. The contact also stated that the Forward Collision Avoidance sensors activated inadvertently while driving or the vehicle was parked. The vehicle was taken to a local dealer where it was diagnosed with excessive oil consumption and the contact was advised that the failure with the Forward Collision Avoidance sensors was the regular function of the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 57,813.

NHTSA ODI 11605731

Subject: Complaint Regarding Excessive Oil Consumption and Engine Hesitation in 2019 Kia Optima SX To Whom It May Concern, I am writing to formally lodge a complaint regarding my 2019 Kia Optima SX. Despite meticulous maintenance and care, I have been experiencing significant issues with the vehicle that are concerning, especially considering its relatively low mileage of only 107,000 miles. The primary issues are as follows: 1.Excessive Oil Consumption: My Kia Optima SX has been burning an excessive amount of oil, necessitating frequent top-offs well before the recommended oil change intervals. This is not only inconvenient but also raises serious concerns about the long-term health and reliability of the engine. 2.Engine Hesitation: The vehicle exhibits extreme hesitation during acceleration. This hesitation occurs sporadically, making it difficult to anticipate and presenting a potential safety hazard, especially when merging onto highways or attempting to overtake other vehicles. These issues are unacceptable for a vehicle with such low mileage and are not in line with the quality and reliability I expected when purchasing a Kia. Given the prevalence of similar complaints from other owners of the same model, it is evident that these are not isolated incidents but potentially indicative of broader manufacturing or design flaws. I urge the National Highway Traffic Safety Administration (NHTSA) to investigate these issues thoroughly. Owners of the 2019 Kia Optima SX should not have to endure such significant and potentially dangerous problems with their vehicles. Thank you for your attention to this matter. I look forward to your prompt action and response.

NHTSA ODI 11592144

My car was having to get the spark plugs once a month loosing oil. Lots of Oil is coming out through the exhaust my grandfather just saw it. I still owe 20,00 on this car. I was told by Kia I’m going to need a new engine. I stopped driving it

NHTSA ODI 11592022

I currently have 119500 miles on my 2019 Kia Optima. I am losing oil somewhere between oil changes, and the car is beginning to hesitate while driving. I don't see oil on the ground but I have had to put in 2-3 1/2 quarts of oil way too often. For this to happen on some many vehicles, it must be a manufacturer defect. The hesitation just started and I'm taking it do get a diagnostic test. 11

NHTSA ODI 11589707