What 188 owners told NHTSA about the 2019 Chevrolet Malibu Eco

Since 2024/2025 car has been malfunctioning, I’ve had it checked out but it just got worse and nothing was fixed l, it is I driveable and very unsafe. When driving it abruptly stops like it’s crashing Messages that pop up (Multiple ones at one time flashing as well) - service “ESC” -“service power steering drive with care” -“shift to park” -“low fuel” (but car has gas in it) - check engine light on -all lights flashing at once while jerking -car stops abruptly when you’re driving it -radio blacks out while driving -dashboard blacks out as vehicle is running -jerking while trying to stop -sensor malfunctions -transmission slippage -engine still on and running sounds like it’s cooling down and smells of it as well

NHTSA ODI 11742162

I am reporting a safety concern involving a 2019 Chevrolet Malibu. The vehicle was previously involved in accidents prior to my purchase and had known mechanical issues, including a gear shifting problem that was not properly repaired. In February 2024, while the vehicle was insured under Ocean Harbor Casualty Insurance Company, it sustained a significant front-end collision impacting the driver side. The impact was severe enough to cause structural damage, including a dent to the vehicle frame. Despite the severity of the collision, the airbags did not deploy at all. Based on the extent of the damage, airbag deployment would reasonably be expected. Prior to this incident, the vehicle had ongoing issues following repairs, including system errors and concerns that repairs may not have been properly completed by a certified facility. This raises concern that the airbag system may have been defective, improperly repaired, or compromised prior to the accident. I was not informed of any airbag or safety-related defects at the time of purchase from HGreg. I am submitting this complaint due to concerns of a potential safety defect involving failure of the airbag system during a serious collision.

NHTSA ODI 11727960

The component that failed is the internal microswitch/sensor within the gear shifter assembly. The specific part that requires replacement is often documented in General Motors Technical Service Bulletin (TSB) 19-NA-206 or 23-NA-119. The faulty component is available for inspection if the dealership removes the old part and retains it. My safety and the safety of others are put at risk because the vehicle often fails to register that it is fully in "Park," which prevents the vehicle from shutting off properly, potentially leaving it in accessory mode. This could lead to a dead battery, leaving me stranded. More importantly, the failure to confirm the 'Park' state introduces a risk of the vehicle not being securely immobilized, creating a roll-away hazard if parked on an incline. The problem has been confirmed by local Chevrolet dealership service centers (receipts available). The issue is identical to the defect that prompted official safety recalls for numerous other GM models, including the 2017-2018 GMC Acadia. Furthermore, the symptoms described match those outlined in the active class-action settlement for 2016-2019 Malibu owners (STPLawsuit.com).

NHTSA ODI 11704338

Shift to park issue. After putting the car into Park and attempting to shut off the vehicle, an alter to SHIFT TO PARK came up and the car could not be shut off. Vehicle stalls at lights and in traffic because of the START / STOP system GM has put in this 2019 Malibu. This is dangerous as the vehicle moves if on incline (sometimes backwards). There is no control. The vehicle then has to be shifted into PARK and then restarted

NHTSA ODI 11695435

Was driving on the freeway maneuvered over to exit vehicle lost power and engine completely shut off while in motion. Same incident occurred while on surface street as I was approaching a red light vehicle completely shut off while in drive and in motion.

NHTSA ODI 11694001

Shift to park issue. After putting the car into Park and attempting to shut off the vehicle, an alter to SHIFT TO PARK came up and the car could not be shut off. This happened several times. Car was taken to the dealer where it was originally purchased. The issue was known to the service department as having been seen many times on same type of vehicle. The repair was to replace the shifter assembly and pig tail at a cost of over $700. which included the cost of the diagnostic. The vehicle is not driven often and has only 13,500 miles on it.

NHTSA ODI 11689935

Car was running fine then next day wont turn over. Code reader said fuel injectors weren’t injecting fuel. And ECM failed

NHTSA ODI 11687750

After shifting the vehicle into park and then attempting to turn the vehicle off a message displays to shift into park, even though the vehicle is already in park.

NHTSA ODI 11685209

My vehicle fails to shut off when placed in Park. •It fails to start properly when the ignition is engaged. •It experiences shifting malfunctions that directly prevent safe operation. These issues are ongoing and remain unresolved despite being well-documented in GM Technical Service Bulletin 19-NA-206 and related bulletins, which identify the root cause as a defective shifter park switch and wiring harness.

NHTSA ODI 11681177

Door electrical caught fire and the inside of the vehicle was destroyed. Fire started from the electrical in the driver door.

NHTSA ODI 11678675

Vehicle stalls at lights and in traffic because of the START / STOP system GM has put in this 2019 Malibu. This is dangerous as the vehicle moves if on incline (sometimes backwards). There is no control. The vehicle then has to be shifted into PARK and then restarted. THIS HAPPENED July of 2024 and August 2025

NHTSA ODI 11678433

The contact owns a 2019 Chevrolet Malibu. The contact stated that the message "Shift to Park" was display on the instrument panel while the gear shifter was in park. The dealer was not contacted. The manufacturer was informed of the failure and stated that the VIN was not under recall. The manufacturer referred the contact to the dealer for assistance. The failure mileage was approximately 53,500.

NHTSA ODI 11676879

The Apple CarPlay system, specifically the GPS/navigation function, froze and malfunctioned. This occurred in two separate vehicles I’ve owned: a 2019 Chevy Malibu and now a 2019 Chevy Equinox (the vehicle involved in the accident). Both cars frequently experienced lagging and freezing while using Apple CarPlay. The infotainment system and vehicle are available for inspection. On June 28, 2025, while driving at night with GPS active via CarPlay, the system froze and gave me an incorrect instruction — telling me to turn left onto a one-way street in the wrong direction. I did not realize I was going the wrong way until reaching the intersection, and by that point, I was involved in a head-on car accident. This presented a significant danger to me and others on the road. The issue has not been officially reproduced or confirmed by a service center, but it occurred consistently in two different GM vehicles. I have text message documentation sent to my family over the months before the accident describing the freezing and lagging of CarPlay. The accident and vehicle were reviewed by insurance representatives, but no inspection was done specifically on the infotainment/GPS system by the manufacturer. There were no warning lamps or dashboard messages. However, the symptom was consistent lagging and freezing of the CarPlay interface, which had been happening for months prior. There were no official error codes displayed before the crash.

NHTSA ODI 11674821

Not in park warning when shifter is placed in park.

NHTSA ODI 11658750

The clutch solenoid started failing without warning or notice. This was finally confirmed by a transmission shop after a warning lamp related to the issue finally popped up after months of issues. My safety was put at risk due to the sudden and intermittent failure to shift into drive. This would sometimes lead to the engine stuttering then shutting off while still in drive. Attempts for dealers and private shops to nail down the issue were unsuccessful due to the system not reporting or recording any information related to this failure to shift. Again the danger came intermittently and suddenly when, shifting from park to drive, shifting from park - reverse - then drive. It would cause my vehicle to “stall out” in an active lane of traffic. This issue occurs from probably 60,000 - 90,000 miles when the system finally threw P0700 and P2714 codes to point to the issue.

NHTSA ODI 11658353

My vehicle has been having issues for the past 2-3 years with its engine acceleration, the bcm and ecm are faulty and or my fuses continue to fail, my check engine comes on with a service esc, power steering depleted, shift to park, and a service security system warning.

NHTSA ODI 11652904

Shift to park sensor does not recognize the vehicle is in park. I am unable to shut off or lock my vehicle. Ongoing prior to ownership.

NHTSA ODI 11647349

My wife drove the car into the church parking lot and placed the shifter in park. Turned off the engine and the Display stated "place the car in Park." She restarted the car backed up and pulled back into the space, shut off the engine and it did the same thing again,. She got out and attempted to lock the car with the FOB and it stated place in Park, and Key fob in car. It wasn't , and she had started walking into the church with the audible alert beep and headlights behind her. I went out started the car shifted it into park and it did the same thing. I backed up a little bit engaged drive and slowly moved the shifter to park and it worked that time. Will take it to our certified mechanic tomorrow.

NHTSA ODI 11619746

Purchased this vehicle (2019 Chevy Malibu) in September 2024. Put the vehicle in park and the display keeps saying "shift to park" when it's already in park.

NHTSA ODI 11618386

SHIFT TO PARK ISSUE - CAR WOULD NOT GO INTO PARK AND MESSAGE KEPT COMING UP ON DASH DISPLAY. THIS HAPPENS INTERMITTENTLY AND MORE OFTEN NOW. DONT KNOW IF VEHICLE IS IN PARK OR NOT. BATTERY WAS DRAINED AND REPLACED. GM CAR DEALER MIKE SAVIOE AND GM BOTH SAY BULLETIN 19-NA-206 WILL NOT BE HONORED BECAUSE 2019 MALIBU IS NOW OUT OF WARRANTY. GM KNEW THIS ISSUE ON 5/21 AND WILL NOT HELP OUT ON CORRECTING THIS ISSUE.

NHTSA ODI 11610812

Vehicle occasionally hesitates to accelerate past 1st or 2nd gear & produces no power until the turbo & gears finally kick in. Has put myself & my passengers (my children) in danger of traffic’s way while trying to merge into traffic from a stop. Have had to pull to the side until the car is able to go past 5-15 miles per hr. Have taken the vehicle for inspection to Chevrolet of Watsonville & the tech there was unable to replicate the issue & was told to take it back when present. The issue recently happened again late evening but then resolved on its own when I planned to take the following morning. The vehicle has horrible MPG ranging from 18-24MPG when the rated MPG is 27-36MPG. I don’t understand how I am supposed to resolve this issue if the problem doesn’t persist when I am able to finally get an appointment for the vehicle to get seen. This issue is very concerning & would like help as I am nearing the manufacturer 100k warranty expiration mileage. Also There are no service lights present on the vehicle.

NHTSA ODI 11588968

I've had a 2019 Chevrolet Malibu since December 2018. After my last visit to the dealership to have my oil changed (January 22), I began experiencing a "Park to Shift" alert appear after I had shifted the car into park and turned it off. This happened within the first day of having it serviced. Since then it has happened pretty much every time I've driven the car and turned itr off. I'd say it's happening 90% of the time. Sometimes it's resolved if I cut the car back on shift to Drive or Reverse, then back to Park (usually have to do that a few times to get it to stop). Just today, I could not get it to go off while making a quick stop and had to leave the car essentially on while I hopped out. Once, I was able to "jiggle" the gear shift for a few seconds to get it to stop. I don't understand why this is suddenly happening. It was not happening before the visit, although I am aware that it is a known issue - however no recall has been issued. What are my options beyond spending another chunk of money to have this fixed?

NHTSA ODI 11569604

Check engine light came on and the car shut down while stopping.

NHTSA ODI 11557331

The contact owns a 2019 Chevrolet Malibu. The contact stated that while at a complete stop, and releasing the accelerator pedal the auto Start/Stop system engaged with delay, and the vehicle shuddered while resuming normal driving. The instrument cluster and the infotainment system were inoperable and turned off temporarily while driving. The contact stated that the failure recurred several times while attempting to drive from a complete stop. Messages indicating low fuel and key fob malfunction were displayed. The vehicle was taken to the dealer, where the battery was replaced. The contact stated that the Start/Stop system operated as needed after the battery replacement. Additionally, the contact stated while driving an undisclosed speed in a parking lot, the auto Start/Stop system engaged inadvertently, and the vehicle shut off. The message "Shift to Neutral. Restart Vehicle" was displayed. The contact followed the instruction and restarted the vehicle. The contact stated that while driving 5-8 MPH, and making a turn from a middle lane, the failure recurred while there was oncoming traffic. The contact shifted into neutral (N) and restarted the vehicle. The contact stated that the message "Power Steering Reduced. Drive Carefully" was displayed when the failure occurred. The vehicle was taken to the dealer, where the battery was replaced 4-5 times; however, the cause of the failure could not be determined. The contact stated that each battery had lasted 9-10 months. The manufacturer was notified of the failure, and a case was opened. The manufacturer advised the contact to take the vehicle to the dealer to be diagnosed and informed the contact that they would consider buying back the vehicle. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

NHTSA ODI 11548291

The vehicle has failed to shift to park. I have pulled the vehicle into a parking spot on multiple occasions and placed the shift knob into park. A message on the screen pops up after I turn the car off, that says "Shift Vehicle to Park." I then have to start the car again and backup and pull forward attempting to get the car to engage into park.

NHTSA ODI 11535428