What 328 owners told NHTSA about the 2018 Toyota RAV4 Hv

On October 27, 2025, I was housesitting and watching a friends' son and dropped him off at school. I returned to their house, shut off the car, went into the house, started cleaning home in preparation of returning to my home. I was in downstairs master suite on opposite end of home when I heard a car horn. I went to the door, looked out and saw fire emitting from under the driver’s side wheel well, front of engine, from under the engine hood and half way up the windshield of the RAV4. I called [XXX] and informed the dispatcher that my car was on fire. The [XXX] fire department responded and extinguished the vehicle. I called my insurance company and also reported the incident to Toyota BEC, they assigned the incident Liability Case# XXX. I had also received 2 recall notifications from Toyota (NHTSA# 23V734). The car had been serviced by Grappone Toyota (now known as McGovern Toytota) in [XXX] on August 14, 2025 and the recall was documented as fixed on that date. The vehicle was a total loss and towed to a Coparts Salvage Yard in Candia NH. An inspection was performed by an inspector assigned by Toyota. I later received a letter from Toyota stating that the cause of the fire could not be determined and Toyota assumes no reponsibility whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11729761

The contact owns a 2018 Toyota Rav4. The contact stated that upon entering her carport in an attempt to park(P), the vehicle surged forward without warning. The vehicle blew through the carport's back wall and crashed into her neighbor's fence before coming to an independent stop. The air bags did not deploy upon impact. The contact did not seek medical attention but did sustain soreness in her neck, shoulders, and back. The carport's back wall, a bicycle, the neighbor's fence, and the hammock were all destroyed as a result of the accident. A police report was filed. The dealer was notified of the failure and immediately referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was filed. The manufacturer informed the contact that an engineer could be sent to a nearby dealer or independent mechanic to perform an investigation into the defect. The vehicle had yet to be serviced or diagnosed for the failure. The vehicle was not repaired. The failure mileage was approximately 134,000

NHTSA ODI 11685349

The contact owned a 2018 Toyota Rav4. The contact stated while driving into a parking lot at a very low speed when the vehicles engine shut off, the contact proceeded to attempt to restart the vehicle however the engine would not start, and upon inspecting underneath the hood of the vehicle the contact noticed that a flame had began to arise from the battery. The contact immediately proceeded to extinguish the fire with a towel. The vehicle was unoccupied as soon as the fire was noticed. A fire department report was not filed. A police department report was not filed. The vehicle was not destroyed. The vehicle was towed to a local dealer, where the vehicle was diagnosed however, the contact was advised that further diagnosis was required in order to determine the cause for failure. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM) as pthe robable cause for the failure experienced. The approximate failure mileage was 78,000.

NHTSA ODI 11666071

The vehicle's battery area caught fire. I was able to get out of the vehicle on time and call the fire department. Over 50% of the vehicle was consumed by the fire. Vehicle was my spouse's and she usually drives it alone with my [XXX] and she is [XXX]. Thankfully, I was driving it alone. NHTSA recall 23V734 came out on 11/2023 and they expected to have the fix by the end of 2024 but it never happened. The last vehicle maintenance by the dealer was in 02/15/2025. The vehicle has not been inspected yet but the insurance will make an appointment soon to do so. The preliminary findings of the fire department pinpointed the problem in the battery area. Prior to the fire, the vehicle shut down and the steering wheel locked. I turned it on and drove it out of the road and it did it again and when I came out of the vehicle, I saw smoke coming out of the hood and that's when I saw the fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11659003

I was on the freeway driving home and a vehicle cut me on the freeway which resulted in me breaking a little heavier than usual but wasn't abnormal and resulted in the vehicle shutting down due to the battery jumping around in the engine compartment and then instantaneously catching on fire with no way of steering or guiding myself to safety the highway did arrive on scene as well as ambulance and they only asked for registration and vehicle ownership which I hadn't presented but since a tow truck was on its way already they really had no reason to be there other than to make sure I was okay I do have case number and any other information needed for my vehicles abrupt explosion. This incident has been reported to Toyota of Anaheim as well as brand engagement been calling but haven't received helpful information on my loss

NHTSA ODI 11643058

On Dec 5, 2024, our 2018 Toyota Rav 4 caught fire in our garage. We had turned on the car for a few minutes and then turned it off. Shortly thereafter smoke came out of the passenger side of the front wheel well and then flames. It just happened that we came back out into the garage and were able to put out the fire with a fire extinguisher. If we had not returned to the garage, our house would have caught on fire and perhaps with us in the house. Toyota shows no concern for us. Wouldn’t consider paying for a loaner car. Have told us it will be 40-60 days to perhaps tell us what happened. They did send an inspector to look at the car Dec 26 2024. He sent us some information that we do not understand.

NHTSA ODI 11637384

My car caught on fire due to the battery shifting in February. I have all documentation of the process it took for Toyota to ever reach out just to tell me there was nothing they could do. I had to file a claim through insurance and pay some out of pocket for a fix. All for them to still have no remedy almost a year later. I can’t trade it in or else I’ll be under and have nearly 4-5k in negative equity since the car is now worth nothing due to the safety recall.

NHTSA ODI 11615112

The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 60 MPH, the brake pedal had to be depressed with excessive force after being cut off by another vehicle. The contact stated that the vehicle stalled, the steering wheel seized, and the instrument cluster went black. The contact was able to pull off the roadway. The contact attempted to restart the vehicle and became aware that there was smoke coming from underneath the hood. The contact stated that there were flames coming from under the hood on the driver's side near the fire wall. The contact was able to smother the flames. The contact stated that the Fire Department arrived, and examined the engine compartment, and informed the contact that the battery was loosened, causing the cables to detach from the battery terminals, caused the short circuit and flames. The contact had the vehicle towed to the residence. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The failure mileage was approximately 180,000. VIN tool confirms parts not available.

NHTSA ODI 11606611

Basically the car keeps short circuiting and causing so many electric problems, it has caught a small flame. It randomly shut off on us while driving . I contacted my Toyota dealer and the manufacturer and i have not received any help. It is very dangerous to be driving my family in this vehicle.

NHTSA ODI 11605930

My 2018 RAV4 caught fire and completely burned in a matter of minutes. I was sitting in traffic that had stalled because of road construction when I first smelled something hot. No dashboard lights or gauges indicated any issues. Then I saw smoke coming from underneath the hood. I immediately pulled the car over to the shoulder and got out to look under the hood. Flames already visible and fire too hot to raise hood. Vehicle was completely engulfed in minutes. Vehicle had 65000 miles and regularly serviced at a certified Toyota dealership. Original factory batteries still on vehicle.

NHTSA ODI 11555798

On the morning of November 4, 2021, at 6:15 a.m., driver was driving to her job as a shuttle driver. She made no stops on her way to work. At approximately 6:30 a.m, drive exited South Padre Island Drive off of Nile Road in her silver 2018 Toyota RAV-4. As she exited the freeway, her car’s console screen went blank, all electricity to the car cut out, and the engine shut off. The car restarted once, cut out again, and then restarted again as she pulled into her employer's driveway. The car cut out once more, and coasted into the parking lot in front of employer. Driver smelled electrical burning and shortly thereafter saw black smoke coming out of the hood. She quickly got out of the car and called 911 after moving safely away from the vehicle and inside the building. A police patroller arrived first and was unable to put out the fire, and at about 6:45 a.m. the Fire Department came and put the fire out.

NHTSA ODI 11520116

We bought our Rav4 fresh of the lot in 2018, since then e we have replaced the headlight bulbs 43 times. Now our fog lights and license plate light are out. This time the bulb (installed by a professional) melting the actual socket and we have to built the entire thing out and replace it.

NHTSA ODI 11519723

My daughter and I were driving a Toyota RAV4 from 2018 just like any normal day, the car was working properly, no warnings lights were turned on. While taking a sharp right turn and passing an unevenness on the road the car lost complete power. My daughter couldn’t control the steering wheel of the car, it was stuck. As the car stopped completely, due to gravity, she tried to turn it back on but it didn’t work. A smoke started coming from the front left side of the car’s hood ( or the side of the driver) it was a white smoke. The car didn’t function in any way possible. We stayed inside the car and called roadside assistance. Meanwhile as the electronical gadgets started to turn back on (e.g. radio)the more smoke started coming out of the hood . We noticed that a red light with a car and lock symbol was flashing on top of the radio display monitor, later we learned it was the anti-theft system of the car. We got out of the car and noticed a the flames coming out of the car’s hood. My daughter tried to open the back doors and trunk of the car to save anything if possible, but they didn’t open. Many truckers tried to help us with using their extinguisher (severals) but unfortunately the front hood didn’t open ( was locked). The car ended up burning completely as we waited for firefighter to arrive. A police report was fill out 2023-6-13-6249.

NHTSA ODI 11519622

I only had possession of the vehicle for less than 3 weeks and it seemed to be running without problems. Besides driving the car on the date I picked it up, this was only the fifth time I had driven the car. On April 17, 2023, I was driving the car to an appointment when it stalled while in motion. It did restart without any problem (though I did detect a faint odor that I thought might be a rubbery smell, but now believe was probably an electrical smell), and I drove it the remaining approximately half mile to the appointment. When I got out of the car, I noticed what I thought might be steam (thinking the problem may be the radiator) coming from under the hood. I now know this to have been smoke. I went in the building, signed in, and looked back to the car to see flames coming from under the hood. The fire department was called to put out the fire, and a fire marshal came to investigate the cause. The fire marshal told me that the fire initiated at the battery. I have requested a copy of the investigation report, which he told me will be forwarded to me when it is completed. The car has since been towed to LKQ Pick Your Part salvage yard. Two other cars parked next to me were also damaged by the fire. My safety was at risk as I now know that I was in the car when the incident initiated and the fire began. Others in the area could also have been injured as the fire accelerated. The car was parked in a school parking lot, so had the car exploded, there could have been many injuries. No warnings (lamps or otherwise) appeared. I have since done some research, and have found that spontaneous fires such as these have happened to many other Rav4s year models 2013-2018, most particularly 2018. This was a 2018.

NHTSA ODI 11519105

The contact owns 2018 Toyota Rav4. The contact stated that while driving approximately 30 MPH a burning odor was present inside the vehicle and smoke and small flames was present coming from the dashboard and air vents. The vehicle was immediately driven to the local mechanic. After turning the vehicle off the flames and smoke continued. The mechanic unplugged the engine battery and the smoke and the smoke and flames extinguished. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet notified of the failure. The contact referenced that NHTSA Action Number PE21005. The failure mileage was 21,000.

NHTSA ODI 11514751

During a turn... The steering locked up and a julting from all wheel drive system. No warning, slammed into road railing.

NHTSA ODI 11498691

UNKNOWN since insurance or fire department does not want to investigate. However car randomly caught on fire when driving. Could be due to a new battery installed a week prior. Driver and daughter claim as well an electrical issue with AC turning on by itself the morning of car fire which it has never done before. Driver suspects faulty battery since a new battery installed by dealer a week prior and the year before and it is not the first case late model RAV4s are caught on fire due to battery issues.

NHTSA ODI 11496455

My husband and I were driving down the road when we had warning lights and signals going off in the car and the electric was trying to reset in the car. The car was sputtering and stalled out. we managed to pull the car over as white smoke came from under the hood of the car and we jumped out and grabbed our dog as flames started to shoot from under the hood. We have never had any incident happen prior to this to indicate there would be any problems. The car is available for inspection if requested. The insurance company has not inspected the vehicle yet and is transporting it to a salvage yard for inspection.

NHTSA ODI 11460628

The contact owned a 2018 Toyota Rav4. The contact stated that while idling in the pharmacy drive-through line, smoke was suddenly present coming from under the hood of the vehicle. The vehicle was quickly parked before flames were seen coming from the engine compartment. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed. No injuries were reported. A fire report was taken at the scene. The cause of the fire was not yet determined. The manufacturer and local dealer were notified of the incident. The failure mileage was 49,000

NHTSA ODI 11450795

The first incident happened on June 9, 2021. I was turning right very slowly into a parking spot at a grocery store when the car suddenly accelerated rapidly, even when I depressed the brake very hard. My car hit a row of small trees that formed a border between the parking lot and the street. The impact was so hard that there was over $5,000 in damage to the front of the car. I was in shock as it felt like the car was out of control. The second incident July 27, 2021. Again, I was turning right to reach the exit of a parking garage at a medical clinic. I was going very slow because I was approaching the ticket booth to exit the parking garage. Just as I completed the turn, the car accelerated and lurched forward toward the arm that keeps cars from exiting. I was able to stop the vehicle by pressing the brake hard, and I did not hit the arm at the exit point. Again, it was shocking and very frightening for this to happen.

NHTSA ODI 11428580

We were driving when I made a right turn and suddenly the steering wheel locked on me and at the same time various warning lights lit up on my dashboard. The car slowed and I was able to regain control of the steering wheel to pull over. After driving a few miles further we once again came to a right turn and everything happened as before except with greater intensity. We tried to straighten the steering wheel for control and were able to pull over into an empty parking lot. By the time we came to a stop, which took all of just one or two minutes, smoke was coming out from under our hood. We quickly got out of our car and opened the hood to see the battery in flames. I called 911 while my husband poured his cup of water over the flames. It stalled the fire but it continued to spark until help arrived. I am certain if we had not had water the whole car would have caught on fire. The car was towed to a Toyota dealership where we were told that their was an issue with battery installation. At present it is being worked on but I have lost confidence in this vehicle especially since we got no warning that there was a problem and we could have been badly injured or killed if the circumstances had been different and we had not been able to pull over and get out or have water with us. We have since learned that this is an issue for many people who own this 2018 RAV4 vehicle. I also learned there is no recall on this issue. I hope that Toyota isn't waiting for someone to be seriously injured or die before they fix this problem.

NHTSA ODI 11417783

TL* THE CONTACT OWNS A 2018 TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING AT 55 MPH, WHEN THE VEHICLE STALLED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED SHE SAW SMOKE EXIT THE HOOD. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO HER RESIDENCE. THE CONTACT CALLED LOCAL DEALER EASTERN SHORE TOYOTA (29732 FREDERICK BLVD, DAPHNE, AL 36526: (251) 250-0161) AND WERE MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.

NHTSA ODI 11399349

PULLED INTO DRIVEWAY AND HAD FOOT ON BREAK. GOING VERY SLOW TO PARK . WENT TO PUT CAR INTO PARK AND CAR LUNGED FORWARD AND HIT GARAGE. BACKED UP AND CAR WENT VERY FAST SO HAD TO MOVE FORWARD AGAIN OUT OF ROAD. PUT CAR INTO DRIVE AND CAT SURGED FORWARD AND OUT OF CONTROL. ABLE TO AVOID GARAGE BUT CAR WENT BESIDE GARAGE, AND INTO SLIGHT DROP OFF. I WAS ABLE TO STOP CAR BY FLOORING BREAK AND PUTTING INTO PARK. CALLED POLICE THEY MADE REPORT, CALLED ROADSIDE SERVICE AND TOWED TO DOWNEAST TOYOTA IN BREWER MAINE. IT'S NOW GOING TO HAVE INFORMATION PULLED AND RESEARCHED TO DETERMINE WHAT HAPPENED. NO PICTURES. A LOT OF DAMAGE TO FRONT AND MAYBE UNDERNEATH. CAR WENT OVER A CEMENT BLOCK.

NHTSA ODI 11328730

I WAS DRIVING TO WORK AROUND 740AM ON 287 SOUTH JUST PAST RT 24. DASHBOARD HAS "4WD" WARNING AND SMOKE COMING OUT FROM HOOD. I QUICKLY MOVED TO THE SHOULDER AND FIRE BROKE OUT BEFORE CAR CAME TO FULL STOP, ALL WITHIN ONE MINUTE. I BARELY ESCAPE THE CAR AND CALLED POLICE AND FIRE DEPT. THEY CAME AND PUT OFF THE FIRE. THERE ARE TWO EXPLOSIONS BEFORE THE FIRE WAS PUT OFF.

NHTSA ODI 11183106

AFTER PURCHASING OUR BRAND-NEW 2018 RAV4 FROM AUTHORIZED TOYOTA DEALER, WE WERE HEADING BACK HOME. ON OUR WAY, WE NOTICED BURNING SMELL FOLLOWED BY BLACK SMOKE FILLED FRONT SIDE OF THE CABIN. I QUICKLY MOVED MY CAR TO THE RIGHT SIDE PARKING LOT. WHILE CHANGING THE LANE I COULD NOT EVEN SEE THE RIGHT MIRROR BECAUSE OF THE BLACK SMOKE IN THE CABIN. AS SOON AS I PARKED THE CAR AND WE GOT OFF THE CAR, WITHIN A FEW SECONDS FLAMES FROM THE HOODS WERE NOTICED I CALLED EMERGENCY SERVICE (911) AND TO OUR DISBELIEF TO WATCH OUR NEW CAR BURNING IN FRONT OF US. IT WAS ONLY 15 MINS DRIVE FROM DEALER WHEN WE THE INCIDENT HAPPENED. IT TOOK ONLY 10 MINS TO SEE MY CAR WAS DESTROYED BY FLAMES. I COULD NOT GET ANYTHING OUT FROM FRONT OR BACK SEATS

NHTSA ODI 11164698