What 141 owners told NHTSA about the 2018 Tesla Model X P100d

The horn on the steering wheel stopped working recently. Horns are important safety features on any vehicle, and electric vehicles are especially quiet so the horn is essential. The other buttons and scrollers on the steering wheel also stopped working. It's unclear if the airbag still functions.

NHTSA ODI 11633471

The car starts developing very loud squeaking noise when the suspension is at work, when turning, and when accelerating/decelerating

NHTSA ODI 11582137

I was driving on [XXX] from Carson City to Reno in Washoe Valley while on autopilot, the car suddenly alerted with very loud alarms, showed 1. steering assist reduced, 2. Automatic Emergency Braking is unavailable 3. Traction Control disabled 4. Stability control disabled 5. Park Assist unavailable. I pulled over to a safe parking area. Then the car locked out for 75 mins, in Neutral gear, can't shut off, can't park, can't reset the car at all even after talking to Tesla support. While waiting for the tow truck, I turned it into Tow mode, was able to change into Park mode finally, and hard reset the car. I took it in and Tesla told me the steering system was the problem and I was out of warranty so I had to pay A LOT OF money to repair/replace it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11579414

I am writing to you once again to emphasize and provide additional details regarding the critical safety issue I previously addressed concerning the Tesla Model X vehicles, which is similarly affecting Tesla Model S models. My personal experience underscores the severity of this problem: I have had to replace five tires due to accelerated inner wall wear. This specific wear pattern is a direct result of improper camber alignment, an issue that Tesla has continuously refused to rectify. This problem is not isolated to my vehicle alone. A growing number of Tesla Model X and Model S owners have reported similar experiences, indicating a widespread and systemic issue. The accelerated inner wall tire wear poses significant safety risks, as it can lead to unexpected and dangerous tire failures on the road. Despite the clear evidence and numerous complaints from Tesla owners, Tesla has consistently declined to address this issue adequately. It appears that the company’s reluctance is rooted in the fact that proper repair or recall to fix the camber alignment is not cost-effective from their perspective. However, this cost-cutting measure is putting drivers and passengers at risk. Given the scale and gravity of this issue, I urge the National Highway Safety Institute to take immediate action. It is essential to investigate these recurring problems with both the Tesla Model X and Model S models. The safety of Tesla drivers, passengers, and the general public is at stake, and a thorough investigation could compel Tesla to take the necessary corrective actions. Thank you for your attention to this urgent safety matter. I trust that the National Highway Safety Institute will act promptly to ensure automotive safety and hold manufacturers accountable for their vehicles’ reliability and safety.

NHTSA ODI 11561686

Feb 2022 while driving horn engaged and would not go off , had to pull over , steering wheel then locked up and car would not start again but horn continued to go off and had weird smell until it died out. Took vehicle to Tesla service center, was told multiple fuses were blown , mother board and several other electrical/computer issues. May 2023 while parked in driveway horn engaged wound not stop, steering wheel once again locked up and unable to use any features in the car, while looking for fuse to pull to stop horn, noticed smoke coming from under frunk and smelled like something was burning , pulled main front end fuse which stopped the horn and burning. Called Tesla emergency services, advised not to drive it and have it towed to Tesla service center . Tesla repair shop once again said horns were fried along with other electrical problems, the smell of something burning was still present , same as event in 2022. Rear safety belt malfunction alert pops on and off for past 2 years .

NHTSA ODI 11522248

Initially I noticed an issue with notchy steering, which is typically caused by faulty u-joints in the steering column. I took the vehicle in for service on 2/14/23, and the service center confirmed the issue and replaced the lower steering column. Almost immediately after picking up the vehicle from service, I noticed a loud creaking sound coming from the suspension when the steering wheel was turned. I brought the vehicle back to the service center on 3/29/23, where it was found that both upper control arms were "frozen" and required replacement, the lower aft links had play in them, and the lower fore links had cracked bushings. All front control arms were replaced. Luckily all work was covered for me under warranty, but the vehicle is less than 5 years old and has been driven less than 60,000 miles.

NHTSA ODI 11516840

After I started an update as requested on Tesla app, the car was giving error messages. I was able to drive but the errors were - 1. reduced steering assist 2. Autopilot and cruise control not available

NHTSA ODI 11493620