What 982 owners told NHTSA about the 2018 Tesla Model 3 Bev

The door handles have a defect. The chrome peels off unexpectedly, outside of normal wear and tear, and may cause a deep cut to a person’s finger. It cut my son’s finger, causing bleeding. After researching, I found online that that this has happened to many other people.

NHTSA ODI 11740487

The chrome trim on exterior door handle on driver side failed, peeling back to create a sharp, blade-like edge. When i tried opening the door, it sliced my finger causing bleeding and a trip to urgent care. Aparently many other consumers are facing the same problem. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11727386

Hello, I have a Tesla model 3 that I bought back in 2018 . On [XXX] when I sliced my finger while opening the door, because the chrome coating on the door handle started peeling. The cut was very deep ( see attached pictures). I contacted Tesla for resolution and they said that the car is not under warranty and I have to pay $340 for each handle to replace them. Apparently the peeling chrome happened to many other Tesla 3 owners and the company is aware of it and they told me that it might be caused by the car washing detergent (?!!) I think it was a defective design and the peeling chrome coating is a major health hazard. The child cand slice their fingers and if person has a bleeding issues and cut themselves while on the road it can be bad. I think it should be treated as a recall for bad design and should be fixed for free. I lost couple of days of work since I work in the Operating room and my finger was severely cut. I will wait for your response, thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11703600

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at approximately 30 MPH through an intersection, another vehicle t-boned the driver's side from the driver's side front bumper to the rear passenger door. The contact stated that the air bags did not deploy as intended. Medical attention was needed after the contact sustained lower back, left shoulder, neck, tailbone, and internal bleeding injuries were sustained. A police report was filed. The vehicle was taken to a collision center, where it was currently pending an inspection. The manufacturer was not notified of the failure. The failure mileage was approximately 88,894.

NHTSA ODI 11700182

Main incident: Time: 2025-08-28 ~12:41 PM PST What happened: After searching for a parking space, the driver was preparing to reverse into the spot, the driver pressed up the stalk to shift the gear into reverse, a sound was heard and something showed up on the screen, the vehicle once again started accelerating and running forward suddenly and sharply (3 mph to 28 mph in 3 secs), driver tried to steer the vehicle away from cars and buildings to minimize danger, the car rushed onto a concrete curb, hit one blue Tesla, then hit the side of a concrete utility pole, and ran over a plant and last crashed into the chain-link french before it finally stops Injuries: * Spine pain for one passenger Damages: ** All tires blown out, tire falls off ** Severe damages throughout the vehicle body * One Tesla parked on the parking lot was severely damaged * The utility pole's base box was scraped and deformed * One plant was knocked down Similar case 3 few mins ago: Time: 2025-08-28 ~12:38 PM PST What happened: The driver entered a oneway parking lot, but found no available spot and was trying to back up, the vehicle suddenly accelerated on its own. The driver performed an emergency brake and stopped the vehicle. At the time the vehicle stopped, it was only about 20 inches away from two cars in front of it Injuries and damages: None What component or system failed or malfunctioned, and is it available for inspection upon request? Malfunctioning of the electronic control or braking system leading to abnormal acceleration Conflicting gear shifting and autopilot engagement design The right stalk is used to both shift gears and engage autopilot features, this design makes it very easy for the system to confuse the two actions Autopilot feature safety issues Autopilot features (whether its FSD or cruise control) should not be allowed to initiate abrupt acceleration to a dangerous speed in a low speed area (for example parking lot) Insurance claim filed, number: 25-647243342

NHTSA ODI 11684449

October 12, 2024. I was using the Tesla on autopilot. I was in the far right lane and the freeway was curving to the left. The car was following in the lanes, but then all of a sudden it stopped following the freeway and drove into the right guardrail. There were no alerts by the car. It did not warn to take over the vehicle or attempt to avoid the collision. The car drove directly into the guardrail without warning and was totalled.

NHTSA ODI 11646940

Right front upper control arm began making noise and was replaced under warranty at 42k miles in Sept 2019. Left front upper control arm failed around 50k miles and caused a wreck resulting in $8,365 in damages in April 2021. When fixing one side it is standard to replace the other and Tesla was negligent. Upon fixing the left side suspension at Blue Ash Auto Body in 2021, the brake caliper came loose while driving on the highway while on a vacation. This caused an additional $1500 or so in charges. Both of these incidents put my life and my son's life in danger. About a week or two after the caliper problem, Tesla issued a recall for that part stating that it is now single use only.

NHTSA ODI 11643968

Tesla 3 was self parking backwards and failed to stop when the car in the adjacent parking spot started moving. The result was a small scratch, but this is definitely a bug in Tesla self-parking software: it had to stop when another car moves into the stop Tesal selected for self-parking. Here is link to 30 sec video: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11634721

I was at a stoplight behind a Toyota Tacoma. I must have stopped around 8 feet behind it. I was not using FSD and I was not one-pedal driving. My foot was on the brake. I must have been at a complete stop for approximately 10 seconds when my Model 3 suddenly accelerated full throttle on its own and rear ended the Tacoma, directly hitting its trailer hitch, causing my car's driver-side airbags to deploy. When it happened, the light was still red and my foot was still on the brake. I never touched the accelerator. Luckily I was driving alone. After the inital contact, my car sort of bounced off of his hitch then slowly lurched forward before it stopped. After that, it was immobile, leaving me stuck in traffic until it was towed away.

NHTSA ODI 11632896

I took my car in to Tesla to have the tires replaced, during the service appointment my frunk was opened and closed by the technicians. Within ten miles of leaving the dealership my hood/frunk flew open and broke my windshield and frunk hood

NHTSA ODI 11628995

I have a 2018 Tesla Model 3 that was involved in an accident on 10/12/2024. It has Enhanced Autopilot, which was the most advanced version of self driving when I bought the car. It was engaged in "Navigate on Autopilot" on the freeway. The car was following the freeway as it veered to the left, but then it stopped following the lines and crashed into the side of the freeway. The result of the accident was a total loss on the vehicle. I had shoulder and neck pain that have not required serious medical attention, but it was almost a week of discomfort and difficulty sleeping. My insurance company has deemed the vehicle a total loss and I will have to get a replacement. There were no warning alerts and the vehicle did not recognize that it was leaving the freeway lines. I was not going over the speed limit. The car did not prompt me to take over the vehicle because of danger. It just went straight towards the freeway guardrail. The car is not drivable due to the damage it sustained.

NHTSA ODI 11622010

I was driving (~42 m/h) my Model 3 Tesla on a freeway and the traffic in front of me suddenly slowed down. The driver in front of me (she was a new driver with a new car) braked hard and came to a complete stop even though the traffic in front of her was moving. I ended up colliding with her as a result. I would have expected the Tesla Forward collision system or the Automatic Emergency Braking system to have activated and prevented this crash. Further, it seems Tesla brakes behave differently when it is fully charged as the engine braking does not engage. In fact the car seems to accelerate instead. If the Tesla Forward collision system and the AEB do not work and prevent such accidents, what is the point of having these systems?

NHTSA ODI 11621424

I was involved in a rear-end collision where I was completely stopped at a green light due to traffic congestion and the person driving behind me hit my car from behind that caused me to hit the car in front of me. The impact was hard that the Tesla model 3 immediately turned on the hazard lights and called 911. The screen of my Tesla model 3 stated "airbag deployed;" however, no airbags deployed. The Tesla immediately became inoperable and did not let me drive the car to the side of the road out of traffic. Also, the Tesla did not let me change to towing mode (since the screen eventually went black); which made it more difficult to tow the vehicle out of the way of traffic.

NHTSA ODI 11612041

My Tesla Model 3 Made an Accident on [XXX] on [XXX] exit at [XXX] . The Tesla Model 3 is driving under Full Auto Drive. The Model 3 was waiting at traffic light at [XXX] exit at [XXX] . There is an other car stopped in the middle of cross road waiting on traffic. The light goes green, my tesla start to move trying to make left turn. But the other car still block the way. My car first stop and about 1 second the car suddenly run into the car and driver side mirror and door hit the other car’s tails light and rear bumper. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11598404

I may have figured out the common link between Tesla Autopilot crashes. Distracted operators have the accelerator pressed while the TACC is engaged, thinking (for many reasons) that the vehicle will stop if there are any obstacles in front of them. However, when the accelerator is being pressed, the vehicle will not stop. It will happily run into a wall. One second before impact, the forward collision warning turns on, followed by the ABS and the slamming of the brakes, but by then it's too late for a distracted driver. The raw Tesla "Vehicle Data" on Column D, shows "Accelerator Pedal Position (%)." I strongly encourage you to take a look at the data for the autopilot crashes and review this column to see how many had the accelerator pressed until 1 second before the accident, even if the autopilot was engaged. The 4/25/24 update to Investigation EA22002 states that in 82% of the crashes, the operator did not apply the brake until <1 second prior to impact. Tesla's Director of Autopilot Software Ashok Elluswamy also made a claim that the vehicle can switch pedals if the accelerator is pressed instead of the brake, and that technology saves 40,000 crashes per year: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11590838

Tesla Model 3 autopilot engaged. The car steered itself off the road and into a tree as it was accelerating on a residential street from 8 mph to approx. 30 mph.

NHTSA ODI 11583340

There are 2 separate issues with our door handles. The first issue is that they are slow to retract, and in the cold, the often remain in an open position. This has happened numerous times over this winter when my child gets in her car booster. The second issue relates to the method in which tesla adhered the chrome to the handles. There is a small seam on the bottom of the handle that peals off, This results in a VERY sharp metallic layer on the handle. I have now sliced my hand twice on this handle. (I’ve scheduled Tesla to replace this handle. Unfortunately this is coming at a cost to me as the consumer.

NHTSA ODI 11581007

While in FSD the car swerved to the left and hit a Tree. Youtube of the Crash.. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11571866

Me and my wife cut the finger on vehicle door handle. The thin chrome covering the handles has peeled off cousin hazard. Can you fix your website, I’m unable to upload photos.

NHTSA ODI 11562596

I had come to a complete stop at the red light for about 1-2 minutes when, unexpectedly, my car surged forward and collided with the vehicle in front of me. Initially, I believed someone had rear-ended me and caused the accident, but that turned out not to be the case. Although I attempted to apply the brakes to prevent the collision, it was unfortunately too late.

NHTSA ODI 11562621

Unknown

NHTSA ODI 11559604

Dear NHTSA, I am writing to report a safety defect with my Tesla Model 3, VIN [XXX] . On July 28th, 2023, at 3:34 PM PST, My wife [XXX] was driving into my driveway at my home at [XXX] . The weather was sunny and car was traveling at 5-10 mph. The car was not in Autopilot and the driving mode was set to Chill mode. When pressed the brake pedal to slow down, the car did not stop and went straight into my garage, causing significant damage to my home and the car. Very experienced driver and I am confident that wife was applying the brake pedal correctly. However, the car simply did not stop. I am very concerned that this is a software glitch in the Tesla car, and I am worried that it could happen to other Tesla drivers. I have tried to contact Tesla to report the issue, but I have not been able to reach anyone. I had the car towed to a body shop, but the car is now totaled and I cannot take it back to Tesla. I am requesting that NHTSA investigate this safety defect and take appropriate action to protect Tesla drivers. I am also requesting that NHTSA help me to get in touch with Tesla so that I can resolve this issue. Thank you for your time and attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11545300

Driving in full self driving made a sharp unexpected last second turn directly into a pilón at 30 mph causing front end damage. I have the the incident recorded on video from the Tesla. Full self driving did not disengage prior to crash and hands were on the wheel, it just happened within .5 seconds and there was no way to react in time. I reported to Tesla many times and was ignored Here is a link to the video [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11542320

I was driving down a residential street at approximately 20 miles per hour. The emergency braking system suddenly activated and the car slammed on the brakes. There was nothing in the road at all. Some people were on the side of the road and they confirmed that there was absolutely nothing in front of the car to cause the braking. The brakes engaged so rapidly that I have whiplash in my neck. This was a very scary incident and felt very unsafe. Had there been a car behind me, they would have rear ended me for sure. I feel traumatized by this event and am now scared to drive. The emergency braking warning came on at the same time the brakes slammed.

NHTSA ODI 11542200

I was exiting the highway onto a Blvd and I slowed down. The car all of a sudden accelerated by itself, went over the exit curb and hit the central median of the blvd. Fortunately, no vehicles on the blvd wer crossing when this happened. I was fortunately not physically hurt in the incident but it could have been afr worse if I had a vehicle in my front or on the lvd when the incident happened.

NHTSA ODI 11539903