What 982 owners told NHTSA about the 2018 Tesla Model 3 Bev

The center display that houses all of the cars instrumentation including gauges randomly goes out while driving. It will go out for 10 to 15 minutes until it recovers. This leaves me with no gauges at all including loss of backup camera, turn signals, speed and various other functions. I purchased the car two weeks ago and this has happened 5 times already.

NHTSA ODI 11534978

Received an error "Front left safety restraint system fault. Service is required." error on my vehicle yesterday (7/11/2023) which disappears when lifting seat to highest position. As soon as seat is lowered more than 1/2" the error reappears and airbag light is illuminating notifying that the airbag is not enabled. This error is clearly an issue with the safety restraint system on the vehicle but Tesla will not honor fixing this under their Supplemental Restraint System Limited Warranty. The vehicle is within coverage period (<5 years and <60,000 miles). I am being told this SRS Limited warranty covers air bags, seat belt, seat belt buckles, sensors, and modules only. I have not taken the vehicle in for service as the quote I received is too expensive ($601). Please see photos for my conversation with Tesla service as well.

NHTSA ODI 11531934

My car and every other 2018 or older Tesla doesn't have an audible sound safety system when reversing or driving in low speeds. I work with a blind girl who can't hear me coming. This is dangerous.

NHTSA ODI 11522944

Charging power conversion system component fail to take the full capacity the charging station able to give causing very slow charging. Warranty was not covered and costing over $1500 to fix & replace. When asked that this should be Battery warranty, I was turned down and was told that it's not 'part of the battery'. This is safety concern and fire hazard

NHTSA ODI 11521348

Tesla Vehicle safety concern. Safety May 1, 2023 on Rt 95 south from Washington DC to Richmond VA (near Richmond VA) at about 10:45 pm. (Please note the clock time on the vehicle is incorrect—it is about 5 minutes slower and sets to a time I hr. earlier than the current eastern time). Vehicle: 2018 Model 3 VIN [XXX] The computer system failed in the middle of highway. The computer screen where all system functionality is monitored went bank except for a Tesla icon. Losing control of vehicle including turn signals in the middle of the highway was dangerous and a safety concern. For fear of being stranded on the road I carefully drove the vehicle to home in Yorktown Va. It was scary! Much of the settings on computer and navigation info was lost. This is a vehicle defect I need to report. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11520191

On April 21st 2023, by pure chance I happened to notice that, after plugging in my Model 3 to recharge at a local charger, the charging rate was lower than normal: instead of its full 32A charge, the rate was only 16A. I kept getting a notification of an issue with charging, Error: PCS_a019 "Charging slowed - Poor Grid power quality possible, unplug and retry / try different charging location" I've attempted several charging stations and all the same outcome. I've done research on this issue online and others are having the same issue. Tesla did cover a few from what I read as "battery warranty" that I've reach but most are denied as it wouldn't be part of the "battery warranty". I've reached out to Tesla and was informed my warranty was expired almost 28 days on March 23rd 2023 as it was April 21st when I made the service appointment. The cost to repair was $1,987.58 and NOT covered by the battery warranty. I've asked if Tesla would waive the fee as my car was just out of warranty and has a mileage of 30,193. It was declined as she "informed" management at the Burbank, CA repair location. I'm very sadden by this issue as Tesla advertises the electric car is "low maintenance" compared to the average gas vehicle, this is false advertisement. Other manufacture do cover this part under their battery warranty. The vehicle isn't operable if not repair to charge at a normal faster speed. I'm now considering to sell my vehicle once repaired and give people my honest opinion about my experience with Tesla. I hope there's a recall for this issue so other don't have to go through this issue.

NHTSA ODI 11518740

the Power Conversion System (PCS), 1 of the 3 module fails, therefore, it limits the AC charge current to 32A out of the max of 48A the car was never pullged into a 48A AC charging connector, therefore, the PCS module likely to be defective

NHTSA ODI 11517926

Recommended Software update is not available. Tesla App has stopped working for the past 2 months.

NHTSA ODI 11516432

Power conversion system failure. Only charges 32/48 amps at destination chargers. Unsure how long this has been a problem because I just upgraded my power panel to be able to charge at 48 amps. Being told $1800 to get car to charge at expected amp limit. 90k miles on car.

NHTSA ODI 11516601

The Tesla was parked and locked unoccupied with all security features enabled. When I returned to the car the front driver's side was completely crumpled with the bodywork torn , like it was reveresed in to. I was gone about 30 minutes. The car gave no notification on the app, the car alarm didn't activate and the sentry mode did not record the incident. All the things they say the car will do. I called Tesla and was told it works 99% of the time ,(but clearly when you need safety and security it doesn't) they stated that if the car gets hit a certain way it can cause the system to shut down /reboot ,so that none of these systems work... Seems wrong that this can be allowed to be the case that not only all the systems fail, that when they do fail there's no backup or way for the car to know something is wrong. That if there is a unexpected forced reboot it doesn't tell you or acknowledge something is wrong in any way . They seem to think that this is ok . I have reported to them and they really didn't seem to care , just said the statement above about it working 99% of the time..However all the things they say the car can do ,and several reasons you think you are buying the car for with it's increased safety and security, apparently don't work at all. Now I have a 4 figure out of pocket to get the car repaired because I have no way to find the person who hit my car because the none of the cars security or safety warnings worked.

NHTSA ODI 11516334

My Tesla Model 3 without any warning stopped working suddenly. I could not put the car in drive and there were error messages about climate control and electrical system. I had to get the car towed to the service center as it was blocking my other car in the driveway. The service center in Sunnyvale, CA diagnosed the problem to be a faulty PTC heater and has charged me over $1100 to replace it. I beileve it is quite absurd to have a fault in the HVAC system render the whole vehicle completely immobile and useless. This seems like a serious design flaw and it could lead to serious health or safety concerns.

NHTSA ODI 11515708

Heater suddenly stopped working. Will not produce any heat or defrost windshield. Passenger/Driver safety affected by lack of warmth in extreme cold and visibility while driving with iced windshield. 35,000 miles on well maintained vehicle w no damage or accidents. Dealer states that resistance heater and wire harness will need replaced. No cause identified.

NHTSA ODI 11514726

The power conversion system is failing on my vehicle. It is causing faults that trip the breakers at my charger and could potentially cause a major problem at my charging station. It could also cause my vehicle to be stranded or possibly lose power while driving.

NHTSA ODI 11514403

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the display screen intermittently went blank and failed to display the speedometer. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 37,740.

NHTSA ODI 11514482

I experienced premature failure of all 3 modules is the vehicles PCS (Power Conversion System) part of the HV Battery System. Although a TSB was issued to replace the same part in other cars with "affected" VINs Tesla has ignored this faulty part and has declined to replace it under the vehicles HV Battery warranty even though the unit is replaced as a single unit when the HV Battery requires replacement. This is a well known issue that is being intentionally ignored by Tesla. It could leave a driver stranded in an unsafe condition or situation. I would like to see the part recalled. https://static.nhtsa.gov/odi/tsbs/2018/MC-10148850-9999.pdf

NHTSA ODI 11514190

The window switches on the driver window panel have deteriorated and broken not allowing the driver to pull up the windows. For a car that’s only 3 years old this should not happen and is a major safety issue as the driver has no way of controlling the windows. I have searched online regarding this issue and have found that many other owners have experienced the same exact defect that I have, most a VIN number around 30000

NHTSA ODI 11514094

Our Tesla Model 3 had a failure of LV contactor which engages the HV circuit while driving the car in a 45MPH side road. The car had a sudden shutdown with emergency brakes engaged and the car came to a stop violently. It was providence that there were no vehicles following or car was not being operated in a 75MPH freeway and hence did not end up in a rear collision accident or worse involving an 18 wheeler. We talked to Tesla service and they indicated that such contactor failures occur and the car would typically behave like it did with stopping immediately as per design. I was telling Tesla service that the car should probably move into Neutral mode rather than stopping immediately. I also heard other instances where Tesla has stopped suddenly in the media. I would like Tesla to review their current logic with handling contactor failure and prevent violent and sudden stops of the vehicle to prevent accidents.

NHTSA ODI 11510912

Power Conversion System (PCS) failure. This happened without warning over 60 miles from home and service center on x-range Model 3, less than 50,000 miles. Tesla did the repair, and took no responsibility for its premature failure, nor did they provide any explanation for why the failure occurred, leaving me (the owner) with a very expensive repair bill.

NHTSA ODI 11508989

This is a report of suddent unintended acceleration on a 2018 Model 3 performance with 47,800 miles on the odometer - the first known occurrence on this car. At 50% state of charge, I drove the Tesla on a 10 minute trip and pulled into an underground parking garage with 3 lanes of valet parking. At about 5-10 MPH, the forward collision warning came on as I was driving towards the cones and stop sign. I brought the vehicle to a full stop with the friction brakes (not regenerative braking, which was set to LOW). The drive mode was set to HOLD, which lets the car roll forward but not backwards and doesn't CREEP when foot is off the brake. About 15-30 seconds after coming to a complete stop, my foot was hovering over the brake with maybe slight pressure up to 5%. The car suddenly lurched forward with wide open throttle type acceleration. It has over 450 electric horsepower from 2 motors. The car moved between 2 feet and 5 feet. My passenger noticed and asked what I did, if anything. I did not ever once touch the accelerator. Since my foot was on the brake pedal but not pushing hard on it, I was able to depress it with my foot and stop the car. There was a concrete wall perhaps 25 feet in front of the car. No people were in the front of the car. I was at the stop sign in the garage where valet takes over. I do not know if the car would have kept accelerating if I wasn't able to engage the brakes hard.

NHTSA ODI 11508223

The contact owns a 2018 Tesla Model 3. The contact stated while driving 68 MPH, the vehicle experienced phantom braking. The contact stated no warning light was illuminated. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 41,023.

NHTSA ODI 11507813

Interior camera malfunctions which affects the full self driving package I paid for. As purchased the car was said to be feature complete for full self driving. When the software was available to me two years after purchase the interior camera was finally turned on and it doesn’t work. A cursory internet search shows that this is common. This is a hazard it can malfunction at any time due to defective camera. The service center verified that the camera doesn’t work today 1/27/2023.

NHTSA ODI 11504079

On Saturday the 21st my car had been charging overnight inside my garage using the supplied Tesla charger. As I entered the car to attempt to unlock the charger, I received many system malfunction errors on the screen, stating such that the 12v battery needed to be replaced and some system could not be completed. This definitely seemed odd as I had just replaced the 4 year old battery last July after receiving such an error. Eventually the car released the charging cable, but the car was still inoperable due to the errors. I used the Tesla app to request mobile service for the first available time, which was Tuesday the 24th, and used my wife's car in the meantime. The day of the appointment I attempted to enter the car to move it outside of the garage, but the car had completely died at some point - couldn't open doors, windows, hood or trunk. When the service tech arrived, he too thought it odd to need to replace the 12v battery so soon but continued to attempt it after jumping the car's system through the tow area. After some time, he told me the systems power up but it does not retain a charge for long, indicating a larger issue that needs to be serviced. He advised to have the car towed. I put in another service request for this, and when they arrived, we discovered that the Tow Mode accessible through the car's interface could not be engaged. They were able to skate the car onto the tow bed and transport it to the nearest service center, which I already had to pay for out of pocket ($200). The next day I received a call from the service center stating that the issue appears related to the power conversion module. Unfortunately they claimed that this was also out of pocket due to the car being out of warranty (car has just over 53k miles) and that it would cost $2000 to fix! I decided to do my own research before proceeding and discovered this was a KNOWN ISSUE by Tesla as they posted a TSB about it some time ago!

NHTSA ODI 11503755

The contact owns a 2018 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that recently the rearview camera intermittently flickered while in use. The failure mileage was 49,000. Parts distribution disconnect.

NHTSA ODI 11502200

The Power Conversion System is failing, this makes charging the car difficult. The charge rate is reduced and charging fails without warning. There is no warning from the vehicle that the part is failing but instead says the power grid is the issue. The issue started while the car was still under warranty, but falsely claimed the problem was with the evse or the wiring to the evse. Had the failure been properly reported rather than being misleading, the vehicle could have been repaired under warranty,

NHTSA ODI 11501150

This is regarding NHTSA Recall Number21V-00D. This recall is from December 21, 2021 -- i.e., over a year ago. I scheduled an appointment with Tesla in August 2022 to get this taken care of, but at the time Tesla canceled the appointment. They told me that the parts aren't available yet, but they would reach out via email or the Tesla app "soon". It has now been 4+ months, yet they still have not reached out to me. On my Tesla app, when I click "Rear Harness Recall" button, it says "You will receive a notification in your Tesla App when parts are available for your vehicle." It is difficult to understand that it takes over a year to put in a simple cable harness.

NHTSA ODI 11499599