What 982 owners told NHTSA about the 2018 Tesla Model 3 (all Variants)

Tesla Model 3 Performance (M3P) comes with unrealistic "thin" wall tires on 20" wheels that easily POP when they hit potholes, nails, gutters, median divides, gashes in the road, etc. American roads are poorly maintained if at all by transportation departments. Only thick walled tires are suitable for roads. Tesla Model 3 LR (Long Range) and SR (Standard Range) comes with 18" wheels and tires, giving it 2 inches more of padding for both a smoother ride and fewer replacements. Each tire on my M3P costs $400-$500 to replace! That's around $2,000 for a set of four tires! Whereas 18 inch tires are more common and cost about half of that, about $200 per tire, $800 for a set. The remedy here is at least 19 inch wheel and tire replacements as a recall provided for free by Tesla to provide more padding and fewer tire replacements to deal with typical crappy roads.

NHTSA ODI 11571746

A charging warning error msg appeared that there maybe something wrong with the cable leading to charging the battery and may lead to a fail charging and this the 2nd time. The first time I had a failed charging with no warning that it was failing amd that lead to the entire battery wouldn’t charge leaving me stranded and the car had to be towed to a Tesla service center., this time 02/08/2024 it’s sending me a notification that there is something wrong internally and I need to see service asap so this time it did send me a msg warning me there’s something wrong

NHTSA ODI 11570932

Clunk and popping sound while driving, especially while turning the wheel or going over bumps in road. Maneuverability and control of vehicle felt impacted which could have resulted in an accident, damage to property, and injury and/or death of people. The issue was reproduced at the vehicle's Service Center and identified as a lose bolt that connects the front suspension lateral links to the subframe. This issue sounds very similar to a previous recall for the same make, model, and year of this vehicle, but the VIN for this particular vehicle was not included in that recall.

NHTSA ODI 11570900

My bluetooth has not been connecting in my car. To preface this, my car was in twice this year alone, with a near $3000 bill, to replace the MCU, on a car with only 26k miles. Now this bluetooth connection issue is still a problem. After opening a service ticket with Tesla, I am told for an additional $180, I would need to replace my seat sensor. This means my seat (while I am driving) does not recognize that someone is on it and driving. My concern is the manufacturer remedy does not replace failed parts with improved design and that this has the potential to cause other safety issues if occupant detection compromised by faulty sensors. What if I am in an accident and the airbags don't deploy?

NHTSA ODI 11570445

I was driving when I received a service prompt on my Tesla Model 3 stating that there was a fault with my front passenger safety restraint. When I looked around the area, I noticed that the cable securing my seat belt to the vehicle was sticking out of the enclosure by about 6 inches. The car has not been involved in any violent collisions and the seatbelt has not otherwise been abused in any way. The car only has 23,163 miles on it.

NHTSA ODI 11570650

The steering of my model 3 became more difficult and clunky like I had to apply extreme amounts of force to turn. When I turned the wheel I could feel the wheel stop in each gear or grove of the steering mechanism. It got so bad at freeway speeds of 75 mph that it became extremely difficult to keep the car going in a straight line. As described before I would apply very heavy force to the wheel to turn it, when it did turn I would feel it clunk into the next stoping point and I would have to clunk back and forth this way to keep it going in a somewhat of a straight line. There was on time while using Full self driving on the freeway at 75 mph on a turn the full self driving was not able to turn the wheel and almost ran into the cement barrier. I was able to take control of the wheel and correct the car as soon as I saw the car cross the solid line. I took my car in for repair at the Tesla service center October 2023. I was charged $5k to replace the full steering unit in my 5 year old car at that time. I have owned 14 vehicles over my years of car ownership, vehicles age ranging from 1984 - 2018 and I have not once ever had to replace the full steering unit for any of those cars.

NHTSA ODI 11570337

The rear bumper fell off on [XXX] on the [XXX] of the [XXX] bound for [XXX] toward Long Beach Airport when driving in the rain through a puddle of water. It’s a serious safety hazard for the model 3 and the cars behind. This is a widely reported known design flaw, but Tesla refused to cover the repair cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11569452

The contact owns a 2018 Tesla Model 3. The contact stated that while starting the vehicle, the message "Front Passenger Safety Restraint System Fault" was displayed. The local Tesla Service center was notified of the failure and informed the contact the front passenger's side seat and air bag needed to be replaced; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 47,000.

NHTSA ODI 11568990

The new software update forced as part of the autopilot recall is terrible and the system needs to go back to the way it was. They adjustments make the feature useless. There are many unnecessary warnings and notifications, all of which destroy the driving experience and actually make the car less safe. Bring back the old system

NHTSA ODI 11568442

SERVICE ADVISORY FOR FRONT DRIVER'S SIDE SEAT BELT SYSTEM APPEARS ON CENTRAL SCREEN AFTER SEATBELT IS UNLATCHED AND RETRACTED. FRONT RIGHT SIDE ALSO HAD THIS WARNING BUT IT NO LONGER DOES. WARNING READS AS FOLLOWS : "! FRONT LEFT SAFETY RESTRAINT SYSTEM FAULT. SERVICE IS REQUIRED. NOTE: THIS WARNING REAPPEARS EVEN WHEN THE SEAT BELT IS HELD LOOSELY AND ALLOWED TO FULLY SNAP BACK INTO THE RETRACTOR. THE WARNING PERSISTS EVEN AFTER REBOOTING THE MAIN SCREEN (DOUBLE SCROLL WHEEL PRESS REBOOT)

NHTSA ODI 11568576

This seems to be related to NHTSA Campaign Number: 23V235000. My front right hand lateral link bolt managed to back itself out and broke off the nut that contains the bolt. This is confirmed by Tesla service center in Burbank. This is a HUGE safety risk as the front end was not properly fastened and at highway speeds could have caused an accident risking injury and death. The only warning of the issue was a knock sound being heard when the car is turned fully at slower speeds. There was also a slight rattle heard while driving over uneven roads. The result was an out of pocket charge of $3000+ to the car owner. The car was never included in the original recall or the subsequent expansion of the recall. Clearly the issue is more wide spread and should be fixed by Tesla

NHTSA ODI 11568634

Many Tesla owners are experiencing this issue: "Front left (or right) safety restraint system fault. Service is required" message on screen Tesla service quoted $430 for a repair of a problem that shouldn't exit on a privately owned, non commercial low mileage (<50k in 5 years) vehicle. Tesla service refuses to do a recall or warranty repair. Comparison; we have a family Volvo with ~250k miles and it has never had a seat belt issue!

NHTSA ODI 11568261

When seated in my car, I turned the steering wheel and I heard a clunk noise by the driver side. After trying to turn it back, my car dropped and I checked outside and it looks like something related to the axle or arms caused the issue. My axle seems to have separated and fell off and a bolt came off. This is a safety issue and I could’ve died if I was driving at higher speeds like on a highway.

NHTSA ODI 11567884

I have three potential safety hazards to report. Tesla has advised that there is no recall for any of these. 1) The car issued an alert that says "Front Passenger Safety System Fault." This seems like the most serious. 2) The horn malfunctions and does not work at safe level 3) The driver's side mirror does not consistently extend out preventing the driver from adequately using the mirror for driving.

NHTSA ODI 11567584

began receiving fault alert 'RCM_a021 - Front Left Safet Restraint System Fault' in December 2023. Web query indicates this has become a common problem, with the source being a loose connection of the seat wiring harness under the front driver's seat. No other observed malfunction of the vehicle. alert occurs whenever car is entered and powered on (seat adjusts for specified driver). Alert seems to be based on loose wire that is either loose or severed at the wire harness connection.

NHTSA ODI 11567614

On automatic setting, windshield wipers are erratic. Rain can be heavy and wipers don't engage. Requires manually operating wipers that are supposed to engage when windshield becomes wet from atmospheric rain.

NHTSA ODI 11567634

This vehicle has had steering squeaks for a really long time. I've had ball joints sealed, control arms replaced and now lateral links replaced for damaged bushings. This has cost me a significant amount of money and the bushings show tears that could have resulted in loss of control.

NHTSA ODI 11567235

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at approximately 35 MPH, the steering disengaged. The vehicle was difficult to steer. The driver was able to veer off the road. The driver steering assist disengaged message was displayed. The local dealer was contacted and scheduled an appointment. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 23,505. The contact stated Tesla accepted no responsibility for the failure and charged close to $3000 to replace the unit.

NHTSA ODI 11567025

At just over 50,000 miles, my Model 3 experienced a failure of its upper control arm on the drivers front wheel; the suspension was exhibiting loud creaking noises over bumps and road imperfections. While Tesla refers to this issue as "noise, vibration and harshness" and has previously applied a service bulletin to my vehicle where sealant was applied to prevent water ingress into the joint, continued driving on a failing component as critical as the suspension could cause an accident. Furthermore, they consider the repair something the customer has to pay for. My vehicle is currently sitting at Tesla service with no feedback as to the final cost of repair or even when they will complete the repair.

NHTSA ODI 11567041

the airbag light shows

NHTSA ODI 11566858

We intermittantly received alerts on the screen showing "Front safety restraint system fault (service is required)." After many hours of research, we found that other owners also have the same issue and they found that a wire from a electrical connector that connected to the seatbelt pretentension was broken from the seat being moved up and down.

NHTSA ODI 11565648

Live in Atlanta that seldom we get frost. We had an event in December and noticed my rear defroster would not defrost killing rear visibility. Got Tesla to check if connected which it is but doesn't work. They blamed the ceramic tint that was recently installed. Took car to film installer and he showed me how my car's rear window never had any embedded wire, just painted lines that do not heat up. Showed me newer tesla model 3's and showed how Tesla seems to have changed the design and you could feel the defroster wiring so seems I never got defroster wires. Going back to Tesla. All documented in you tube from statement from Tesla glass installer and film installer. Search for xpel vs Tesla defroster in youtube. My glass was recently replaced by tesla ln December 2022. Noticed the problem the first day we had frost in Atlanta

NHTSA ODI 11565231

Touchscreen went entirely blank. A few days prior to this, radio cut on and out. Rebooting procedures did not work. Tesla repaired, stating it was the cars computer. I asked for the old computer board but was told it was proprietary. The symptoms are very similar to those of the older memory issues.

NHTSA ODI 11564987

There is an ongoing issue with Tesla's seat sensors that give an error screen while driving. Tesla seems to be systematically charging a standard $1.5K repair to replace a $100 sensor harness, but they're charging so much because they claim an airbag replacement is required (for an extra $1.2K) as part of the new sensor/wire harness installation. From a quick google search, it seems this is a pretty widespread issue that MANY Model 3/Y owners are encountering as their car ages-- with many noting that they were able to self-service the issue with buying the required harness and replacing it themselves. I wanted to bring awareness that to this issue and Tesla's poor and systematic way of overcharging customers to fix a widespread defect in their car seat design.

NHTSA ODI 11564541

I got into my car and turned on the climate control as normal. The vehicle is always parked in the garage. It was blowing cold air, no matter the temperature setting, or vent selection. There is a message on screen that reads “climate keeper unavailable due to system fault.” It’s not just that the cabin has no heat, which is uncomfortable, but terrible in much colder climates than mine. The heat not functioning means the defrost feature is useless. Water sprayed onto my windshield while driving this morning and froze! It stayed frozen because I didn’t have a functioning defroster or a warm enough cabin to melt it off that way either. It’s a known issue for Tesla’s, particularly with Model 3s. Tesla has never done anything to rectify it. My car has a resistive heat system, and this is the first time this has happened to me. There was no warning or indication this would happen. Non working in cabin heat may not be a direct safety flaw, but not being able to defrost my windshield for proper visibility while driving is!

NHTSA ODI 11564550