What 641 owners told NHTSA about the 2018 Ram 1500 Classic Regular Cab

Check Engine Light comes on and off on its own. OBD read that the engine is not getting up to normal temp. Had it diagnosed and was told that the 3.6 V6 has issues with the oil filter housing cracking/leaking. Somehow the housing cracking caused me to lose coolant. To have everything repaired would be $1400.

NHTSA ODI 11702570

Was driving vehicle, power steering abruptly stopped working, pulled over vehicle to side of road, Turned off vehicle for two minutes, turned vehicle back on, power steering warning notification was now activated.... Unknown if it is still able to be inspected, calling shop tomorrow to verify.... Issue was confirmed by Independent Service Center.... Piece was inspected by Warranty Representative.... There were no warning, messages, or symptoms prior to failure. Issue happened abruptly....

NHTSA ODI 11699483

The contact owns a 2018 Ram 1500. The contact stated that while driving at 50 MPH, his granddaughter smelled an abnormal burning odor coming from the vehicle. The contact looked out of the rearview mirror and saw heavy white smoke coming from the rear of the vehicle. The contact immediately pulled over and had the occupants exit the vehicle. The contact checked under the hood as white smoke filled the engine compartment. The contact stated that there were no warning lights illuminated prior to the failure. Due to the failure, the contact initially had the vehicle towed to the residence before it was later towed to an independent mechanic. Upon inspection of the vehicle, the mechanic discovered coolant had leaked into the EGR (Exhaust Gas Recirculation) cooler. The mechanic also discovered that the vehicle was previously serviced under NHTSA Campaign Number: 19V757000 (Engine and Engine Cooling); and the contact was referred to the dealer for assistance. The contact was informed that any repair to the vehicle would be an out-of-pocket expense. The manufacturer was notified of the failure, and the contact was given a case number. The vehicle was not repaired. The failure mileage was approximately 142,000.

NHTSA ODI 11698554

Power steering turn off for 2 seconds if I hit a bump or in the middle of a turn. It will then sometimes turn right back on or just not turn back on. Recalls are on many rams for this issue but not on my truck specifically even though its the same issue other rams are having in the recall list

NHTSA ODI 11698185

Took excellent care of my truck, doing all recommended maintenance and replacing parts as they wear out. I had catastrophic engine failure at 86k miles. Was getting off a highway on an off ramp and got a low oil pressure warning and lose of power/no throttle response from the truck. Pulled over and oil was spewing out. Had it towed to a shop and they said the engine was seized up and there was metal in the oil, recommended full engine replacement.

NHTSA ODI 11698230

I am writing to your Company regarding the unavailability of the ABS Control Module for 2017 Ram 1500 trucks. My truck, like those of numerous other Ram owners, has a malfunctioning ABS Control Module. Because of this malfunction, the ABS and cruise control do not work. In turn, this places me and other owners of this vehicle in an unsafe situation, in that the lack of an operating ABS system is conducive to skidding and accidents. Some owners have even reported that they cannot drive their vehicles due to locked brakes resulting from this malfunction. I have tried every source in existence in my efforts to find a replacement module, but I have been totally unsuccessful. I have been told by one of your Customer Service representatives that your Company is “…unable to maintain a complete inventory for an indefinite period and the lower the demand, the less likely it is we will have stocked parts. As such, the part you are requesting is no longer in our inventory.” I am aware of a current class action suit against your company for the RAM 2500 & 3500 for the same issue. I guess the owners’ lives of the Ram 1500 are not as important. Wilson, et al. v. FCA US LLC Case No. 4:22-cv-0044 This is absolutely appalling. Apparently, several thousand Ram owners who paid tens of thousands of dollars for their trucks are not important enough to your Company to warrant providing the necessary support for their products. I am thoroughly disgusted with the disrespect and value you place on the safety and lives of your truck owners and the other drivers on the road who are in danger due to the lack of support or concern you have for your “valued? owners”.

NHTSA ODI 11695759

Yes, the vehicle is inspection. If you're going around a curve at 55 miles an hour all of a sudden the electric power steering will come back on and jerk. Probably not explaining it well but extremely dangerous in my opinion and others. It is intermittent. The dealers say there is no recall, but the Internet says there is so I don't know who to believe. It has not been inspected. No there were no warnings just work sometimes and doesn't work sometimes and it's worse than the old days with no power steering. You can hardly turn the wheel when it's not working.

NHTSA ODI 11695404

The gas tank will not take fuel. Tried multiple pumps at multiple gas stations and the pump keeps turning off. You have to keep restarting the pump over and over again. If you look it up online, there are hundreds of people having the same issue and most cases seem to be a faulty rollover valve, the filler neck itself or a complete replacement of the gas tank. If someone isn’t monitoring the fuel level with the ignition on and they keep restarting the pump, they may over fill the tank and pump gas on the vehicle or themselves which is hazardous and could be potentially fatal.

NHTSA ODI 11692831

The contact owns a 2018 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

NHTSA ODI 11692099

The contact owns a 2018 Ram 1500. The contact stated that while driving at an undisclosed speed, the Uconnect infotainment system intermittently failed, causing the defroster and rearview camera to become inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 33,000.

NHTSA ODI 11690269

Uconnect is erratic Heated seats turning on, unable to call 911, climate control turns on and off or changes temp from hot to AC turning on. Radio changes stations. Apps flipping from on to another. Unable topair phone to uconnect.

NHTSA ODI 11690327

The vehicle had a recall of a high-pressure fuel pump. I was driving on the freeway when the vehicle suddenly stopped. I had the vehicle towed to the closes dealership. I was told that at the time the manufacture did not have the parts to replace the fuel pump and the debris passed through the system damaging filter and the catalytic converter. I was told by the dealership mechanic that there were metal shavings through-out the system. They partially repaired it and once I went to register my vehicle at the DMV they wanted proof of the recall repair. I took the vehicle back but the dealership does not wish to repair the consequential damage the recall caused. I still do not have my vehicle or proof the vehicle is in a safe working condition. Dealership and Manufacture refuse to repair the vehicle.

NHTSA ODI 11689692

While traveling the EPS shut off while at a high rate of speed and jerked the steering wheel out of my hands

NHTSA ODI 11687145

Electronic power steering is out car can not be driven safely. There was a recall of 2013-2019 dodge ram 1500 for the same peoblem

NHTSA ODI 11686457

The backup camera randomly gets a distorted picture or just goes black. The wiring harness at the tailgate is the issue. I can wiggle the harness and close the tailgate and it works again. I replaced the harness myself once and now it’s doing it again. There was a little kid on a bike behind me that I could not see from my mirrors and turning my head and I almost ran into him but luckily the parents were right there and yelled to him and I

NHTSA ODI 11686144

The strap that holds the gas tank has come loose from the frame causing the gas tank to drop. I took it to a mechanic for repairs and he told me that he was unable to repair it because the the frame was rotted out and there was no where to hook it back to the frame. He told me that there was a recall on my truck I should reach out to you for repairs.

NHTSA ODI 11683779

Traveling (cruising) at highway speed on interstate the engine suddenly made a clanking noise and engine oil pressure went to zero and engine stopped. I barley managed to just get out of major traffic without causing an accident and off the interstate coasting to a stop This could have been a tragic accident that was just barely avoided.the truck has 80043 miles. Just 43 miles out of warranty. It has been dealer serviced on time since day one. This seems to be an ongoing issue with these engines as they just decide to sop on their own with notice. If this had happened while passing another vehicle It would have been bad. FCA ( fiat, chrysler ,automobiles) refuses to help out or even listen. This is dangerous as is their fuel pump recalls. Truck is now out of warranty by 43 miles and the company FCA washes their hands of any kind of wrong doing. These engines in the vehicles are totally unsafe and unreliable and will some day cause a major death and harm to others !!!! Dealer have new upgraded engines in stock that the company send to them they are fully aware of an impeding disaster but yet dont care about human life.

NHTSA ODI 11683527

Request for investigation and recall of 2018 Dodge Ram Tradesman vehicles due to exhaust manifold defects, Carbon Monoxide (CO) poisoning causing driver impairment, indirect impact on steering system functionality, and documented cases of accidents. I became disoriented, severe headache, drowsy, confused, steering wheel vibrated, pulled over got out of vehicle set on side of road until feeling better. The manifold bolt broke leaking co2 into canon. I had no ideal and could have passed out causing death and potentially death to others. Was on highway doing 65mph. This is a common documented issue and must be addressed with Dodge ram trucks. Makes no since with all the evidence it has not been corrected already.

NHTSA ODI 11681654

There are countless number of individuals like myself who have paid good hard earned money to own these trucks only to find out that everyone I know has endured the issue with the ABS module it seems. And online that's all you can find now me owning other manufactured vehicles I've never encountered this issue before. But I don't understand how this is a known part that will fail and when it does fail it's up to the owners of the truck to have to pay out of pocket thousands of dollars to get it repaired after spending more than $50,000 to be able to own the truck. I can't imagine the other owners who are not able to afford these costly expenses to get repaired immediately and are forced to continue driving on the road ways endangering themselves and other innocent lives on the road ways

NHTSA ODI 11680748

While driving and turning the steering wheel totally locks up momentarily. At this point there is no control of steering. The first time it happened I just missed a parked car when turning a corner. When I took it to the dealer the mechanic almost ran into a building driving it into the shop.

NHTSA ODI 11678249

on or about 7/29/2025 while driving at approx 45 mph (2018 Dodge Ram Rebel) - multiple dash warning lights came on. Parked at safe location. Vehicle would not start and again multiple dash lights came on, steering wheel tight. Had vehicle towed to Reedman Dodge Langhorne, Pennsylvania. Service Rep said vehicles needs replaced drive train and other electrical work costing $5,000.00. Vehicle has less than 100,000 miles (original owner) serviced regularly. Reedman Dodge said no recalls for this but is aware of multiple complaints and "class action" lawsuit on this.

NHTSA ODI 11678269

While driving heard Clicking/Knocking noise then low oil pressure light came on we pulled over and turned truck off then truck would not restart. truck was towed to Dealer which has check truck and decided it was a complete engine failure main bearing. Truck only had 45,000 mile on Engine

NHTSA ODI 11677844

The contact owns a 2018 Ram 1500. The contact stated while driving 40 MPH up a hill, there was an abnormal banging sound come from the vehicle, and the vehicle experienced engine failure. The contact stated there was oil leaking from the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was determined that there was a large oil leak on the passenger’s side of the engine. The contact stated that there was a hole on the upper part of the engine and the vehicle was diagnosed with catastrophic engine failure. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 11,000.

NHTSA ODI 11676737

1 of 2 Gas tank mounting straps released, rusted thru the frame and the gas tank was hanging by the rear strap only. could have been a huge fire risk if tank released and ruptured on the road.. has not been reported thru dealer yet, had same issue on my 2011 ram 1500 which was recalled to fix. only warning was seeing something hanging under my truck and hearing a new noise as the metal strap rubbed on the drive shaft.. i crawled underneath and found as described above.

NHTSA ODI 11676530

Subject: Ongoing Power Steering Malfunction – Safety Concern I am writing to report a recurring and now potentially permanent issue with the power steering system in my vehicle. The problem began approximately 2 to 2.5 years ago. Initially, it was intermittent — the power steering would occasionally fail at low speeds, then resume normal operation. During these incidents, the dashboard would display a warning message: “Service Power Steering.” Over time, the issue has become more frequent, and in some cases, the failure occurs immediately upon startup, before the vehicle has even been driven. I first brought the vehicle to a local repair shop, where I was advised that the power steering unit might need to be replaced. They also mentioned that the problem could be related to a known defect involving contaminated components. However, after checking the serial number, I confirmed that my vehicle is not included in the current recall for this make and model. Next, I took the vehicle to a Ram Chrysler dealership. They were unable to replicate the issue during their inspection and advised me to bring the vehicle back on a tow truck if the problem occurred again. Since then, the issue has returned multiple times. I was previously able to temporarily clear the fault by disconnecting and reconnecting the battery terminals, but that method is no longer effective. The failure now appears to be persistent and ongoing. This is a serious safety concern. A sudden loss of power steering — whether at startup, low speeds, or while driving — poses a significant risk to both myself and others on the road. I plan to return to the dealership for further diagnostics, but I believe this issue deserves broader investigation and may warrant an expansion of the current recall. Thank you for your attention to this matter.

NHTSA ODI 11675484