What 124 owners told NHTSA about the 2018 Mazda Cx-90

My wife was driving the vehicle when the emergency lights started going off. She had to pull over because the car wouldn't run and said it was overheated. All the maintenance has been done to the car. We took it to the dealership and they said it is a cracked head and it is a known issue. They even issued a extended warranty for it. It is TSB 01-002/23. There should be a recall on this not just a partial credit.

NHTSA ODI 11742255

My 2018 Mazda CX-9 experienced catastrophic engine damage after a radiator failure allowed coolant to enter the engine. The vehicle provided no dashboard warning, overheating alert, or coolant warning before the failure occurred. Modern vehicles are designed to alert drivers to overheating or cooling system failures. The lack of warning prevented me from addressing the issue and resulted in catastrophic engine damage. I believe this represents a potential safety defect in the vehicle’s cooling system monitoring and warning system.

NHTSA ODI 11723876

Here the facts, bought a car out of state (Illinois) from Iowa with 130,131 miles on Sept 12th 2025, Mazda CX9, the dealer did not disclose any problems with the car, after 3 months of ownership, the car overheats on highway whit family including a [XXX] infant, white smoke under the hood and exhaust pipe, towed home, radiator was replaced, few days after that a coolant leak, vehicle was sent to an authorized Mazda dealership for diagnose, the technician told us, according to Mazda procedures, a cod P111A, the vehicle's engine reached unsafe level of temperature and the whole engine needs to be replaced because a cracked head cylinder. This problem is well known by Mazda because they addressed on a TSB01-002/23 and CSP11 extended warranty, there is a flaw in the design of the engine near the cylinders manifold area, that cracks the engine and requires a full replacement of the engine. its just a flaw in the design of the engine. This issue can appear at any point threatening the life of the occupants of the vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11716057

Cracked cylinder head/leaking coolant.

NHTSA ODI 11681066

. In January 2024, I purchased a used 2018 Mazda CX-9. The vehicle ran well until [XXX], when I discovered an engine coolant leak. My mechanic diagnosed it as a known defect involving the cylinder head. My husband contacted Mazda Customer Service (CS), and they advised us to get an official diagnosis from a Mazda dealer. We brought the car to Orland Park Mazda, where a diagnostic confirmed the defect (report attached). We later received an email from Mazda CS saying that since our car was at the dealership, Mazda would take the lead in submitting the goodwill repair claim (email attached). When we followed up with Orland Park Mazda, they informed us that no one from Mazda CS had contacted them to authorize the repair. We relayed this to Mazda CS and gave them the direct number of our service advisor, Adrian. Mazda CS said they would follow up and get back to us within 48–72 hours. On a follow-up call, I spoke with Nancy at Mazda CS, who again told me that our case manager Cindy would contact us within 48–72 hours. Instead, we received an email denying the repair, stating the vehicle exceeded the 120,000-mile limit for the extended warranty (our vehicle has 133,500 miles). While our car is outside the warranty period, this is a textbook case of a well-documented defect covered under TSBs for the 2018 CX-9. Mazda has previously approved goodwill engine replacements for other customers well beyond this mileage. We are seeking fairness and consistency in handling known product defects. Our request is that Mazda approve the engine repair under goodwill coverage as they have in many similar cases. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11674928

Our Mazda CX-9, having roughly 86,000 miles, had catastrophic engine failure while driving. This is caused by coolant leaking at the cylinder head and around the exhaust manifold. This in turn caused a crack in the engine block. Mazda refused to fix this as it wasn’t a “recall” and only a tsb sent out. 1000 of people have reported this issue, causing failure while driving but Mazda will not recall the engines nor fix them under an extended warranty. After a 4 month battle with Mazda they refused to fix this in our car even though they know the engine is a bad manufacturing issue. A recall needs to be made and Mazda needs held accountable. Our exact cause was exactly what the TSB stated but Mazda stated our crack was not in the correct spot. They need a recall covering all engine block cracks due to faulty manufacturing

NHTSA ODI 11657829

coolant leaking from engine block cracked cylinder head

NHTSA ODI 11654683

Fan is not working and car is overheating when driving in traffic or low speeds - from forums this seems to be a common issue with this make/model and year

NHTSA ODI 11624426

coolant leaks at the cylinder head around the exhaust manifold. Caused crack in the head. The Mazda 2.5t engine has this common issue that Mazda knows about. Mazda has a bulletin out but has not issued a recall. Car over heated and I was left stranded. Took car to mechanic who says I need to replace my entire engine.

NHTSA ODI 11624296

My vehicle was low on antifreeze. I brought it into the dealer and had them look at it. They told me there was an antifreeze leak inside the engine. I told them, I think there's a service bulletin on it. TSB-01-013-21 And there are updates to it. They told me that the antifreeze leak does not pertain to this service bulletin. I told them, how can that be? When it's an antifreeze leak with an engine that only has 66000 miles on it so far. I spoke to mazda customer service in California They said the dealer is trying to get some financial relief for me to replace a $10000 engine. Which they said is on back order till march 2025. I said how can this leak not be a problem when the engine is on back order, I feel that this should not have happened With a engine, that has 66000 miles on it? And it should be fixed free of charge because antifreeze leak is a known problem with these engines since 2016, and they never notified me to bring it in and have the defective part fixed Which causes the antifreeze leak. If they did that, my engine would not have blown and would not need replacement. I'm hoping they understand and do the right thing and fix this.

NHTSA ODI 11622142

I purchased a 2018 Mazda cx9 from a local used car dealer several weeks ago. Check engine light came on after a few weeks for cylinder 3 misfire and there was a steep decline of the vehicle performance (hard start, rough idle, lower mpg, sluggish driving). Took it to Berge Mazda who charged me for diagnostics/spark plugs, and ignition coil. They informed me the next steps were a compression tests, fuel injectors and if that didn’t fix the problem then they wanted to strip down the engine to evaluate the cylinder head. At this point I decided to take it to my local mechanic who I trust, he diagnosed a cracked cylinder head. Now I’m stuck with a car I just bought that’s unsafe to drive needing a 6-8k repair. Upon further research there is a widespread problem with Mazda’s manufacturing of there cylinder heads on certain models (including the 2018 Mazda cx9). This is confirmed by TSB’s from Mazda along with a class action lawsuit recently filed. Upon more research on my vehicles history, I gathered that my vehicle was traded into Horne Mazda and then a couple days later auctioned to the used car dealer I bought it from. The fact that Mazda is selling off their own defective vehicles that are unsafe at auctions is absolutely disgusting and something needs to be done about it.

NHTSA ODI 11620834

- My 2018 Mazda CX 9 started stalling and jittering at idle and then eventually during slow driving. - Next day I got a check engine light, took to Mazda service center at the dealership I have been going to for last 6 years since I bought the car. - Service center diagnosed that there was a coolant leak through the cylinder head which seems to have cracked. - Further investigation indicated that this has been identified on many other similar Mazda engines and a Technical Service Bulletin had been issued by Mazda to Dealers. - On probing initially, dealership declined they were aware of any such problem. - The amount of repair for the engine replacement (cylinder head and other parts) is exuberant and is almost half of the value of my car, and is not expected for a low 44,000 miles car. - This had posed safety issue for my family since the stressed engine with leak in cylinder head could lead to fire and fatality. - I am awaiting response from Dealership and Mazda corporation case#[XXX] for a response especially when this issue has been filed under a class action lawsuit: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11618999

Engine cylinder head is leaking coolant. This is a known issue by Mazda as they have submitted a TSB on the issue but have yet to submit a recall. The leak causes overheating along with pollution of coolant fluid into the environment. The problem was diagnosed by a Mazda dealership. The leaking occurred before a light came on the dashboard. The light on the dashboard only came on once the engine began overheating.

NHTSA ODI 11617788

Over heating /coolant leak

NHTSA ODI 11616967

coolant leaks at cylinder head , Mazda of America knows issues but not willing to recall , they hava a bulletin number 01-002/23 . pls help

NHTSA ODI 11615751

While driving on an interstate service drive in Michigan, my 2018 Mazda CX9 GT suddenly lost power and began flashing overheating warnings. I tried to move my vehicle to a safe spot while the warning and sudden loss of power was happening, which took a moment due to traffic flow and my family being in the car. I moved the car off the road, and let it cool. I slowly drove the car to a parts store to get coolant. Once the cooling system was filled, I brought the car home and began researching the problem. According to internet threads like Reddit this is a wide spread problem happening among Mazda vehicles with several law firms researching class action lawsuits. My car is stuck at the dealership until I can find $12,000 to fix it, and sadly there are hundreds more just like me according to sites like [XXX] and [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] And includes a Mazda Service Bulletin which indicates that there are design faults in the original cylinder head that causes the issue and that repair techs should replace failed parts with the updated and redesigned cylinder head. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11614956

Approximately three weeks ago, a message on my dashboard said to pull over immediately. Your car is overheating. I pulled over to a nearby auto shop, which indicated that I was just low on coolant. They topped off the coolant, and everything appeared fine. Two weeks later, I got the same message on the dashboard, saying my car was overheating to pull over immediately. I pulled into a nearby auto parts store and purchased coolant for the vehicle. When I checked the reservoir, it was bone dry. I added coolant and drove the car home. The following day, I checked the reservoir to see if there was still coolant, but it was all gone. I scheduled an appointment with the Mazda dealer to have the car inspected. I also checked the Mazda Forum website to see if other vehicles of my make and model had similar issues since I had never experienced this before. I found that the overheating in vehicles of my make and model was a "known issue" with Mazda. When I took it to the dealer the next day, the service agent informed me that the "known issue" was only with the Turbo model. I explained that my vehicle is a turbo model. He said that Mazda did not have to cover any costs because no recall was issued, even though it is a known issue. Mazda is now refusing to cover the repair and has indicated that the repair and replacement of the engine will cost approximately $9800. If I had been alerted earlier, I would have been able to have the car repaired.

NHTSA ODI 11611415

Vehicle had bucking coming to a stop. Noticed coolant was l9w, and temp guage was fluctuating at a stop slightly. Brought it to Lester Glenn mazda in toms river NJ, service writer informed us it is the cylinder head, and that the repair is approx $11,000. Vehicle only has 85000 miles on it, and was told by dealer that there is nothing they will do. This is a known issue, with a TSB issued in 2021 due to a defect in design where the turbo charger is mounted to the cylinder head. At this point, we are requesting the manufacturer take at least part of the responsibility of the poor design they sold to the open market, that is clearly a safety hazard to my wife and 4 kids, 1 of which is an infant.

NHTSA ODI 11610568

Engine is leaking coolant apparently due to a cracked engine block caused by a manufacturing defect in the casting. Mazda has a Technical Service Bulletin, subject:Leaks at cylinder head and the number is 01-013/21. But they refuse to help cover their mistakes and now we owners are stuck with replacing an entire engine out of pocket. Shame on Mazda

NHTSA ODI 11609045

Mine Mazda 2018 CX9 had coolant leakage at 55K miles. Issue is with faulty cylinder head acknowledged by Mazda in below mentioned TSB. I open up a case with Mazda (File Number XXX). Dealer quoted 7500$ expense and Mazda is providing assistance of 3101$. I have always serviced at Mazda authorized dealership and this issue was never reported. TSB [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11605395

My car started leaking coolant from cylinder, it is known issue for these models, unfortunately Mazda cooperation doesn’t cover the expenses, there is Service Bulletin about it, so basically so many car got affected or will affect from this problem. It is manufacturer fault, not about customer usage or mistake.

NHTSA ODI 11603552

"High coolant temperature warning. Stop car at a safe place immediately " came up. Stopped car at a mechanic and diagnosed as coolant leak onto the engine.

NHTSA ODI 11596193

Due to the flawed engine design which is well documented for these engines, ours started leaking coolant and it was eventually discovered that the head had cracked, and we were forced to have the head replaced. This repair cost us approximately $7600. Our hope is that Mazda will eventually issue a recall.

NHTSA ODI 11595029

2018 CX9 with 74k miles. Took it back to the dealer where I bought it from and have an extended warranty. They are telling me the extended warranty denied the coverage for Coolant leak, engine replacement

NHTSA ODI 11589675

Cylinder head cracked at 100k. There is tsb knowing that this is a problem. It even stats that it happens during Manufacturing there was a defect. Coolant is leaking out the back side of the motor. Causing a over heating conditions stranding my family on the side of the highway.

NHTSA ODI 11586004