What 134 owners told NHTSA about the 2018 Kia Forte Koup

Recently, while my boyfriend was driving my vehicle, the engine suddenly lost power without warning. He had the accelerator pedal fully depressed, yet the vehicle would barely move. He was fortunate to safely maneuver the vehicle off the road. Upon inspection, he discovered there was no oil present in the engine. Critically, neither the low oil warning light nor the check engine light had illuminated prior to this failure, providing absolutely no warning of a severe mechanical problem. After adding oil and performing a proper oil change, the engine began violently shuddering and shaking upon startup, and only then did the check engine light illuminate. The vehicle was immediately towed to an authorized Kia dealership, where I was informed that the timing chain had failed.

NHTSA ODI 11720401

While driving the car with the flow of busy traffic, the engine failed and the car stopped. It eventually turn back on (side of the road) but now drives with hesitation, a strange noise, and with the engine light on. This cycle continued until we arrived at the repair shop. And after much research, it seems that this experience is common for other Kia engines. Why was mine not included? Someone could have been badly injured!

NHTSA ODI 11719191

Engine would run fast and then sound like was going to stop and then it would start shaking and rumbling while driving on highway and in town. Car would stall while at a stop. Gas smells inside the car. Did not feel safe driving. Had the car towed to an independent garage on February 7th and They did an oil change, change 2 Sensors, changed all the spark plugs and changed all 4 Cylinders and on the way home from Starks garage the car was doing the same as before going to the garage with gas smells inside the car, shaking, rumbling and stalling of the engine. And the car wanting to stall while on the highway speed limit of going 60 mph. the next morning My mom and stepdad had the car towed again to another mechanic close to them at Hudson Import Automotive -Napa Auto Care and they emailed a list of problems after inspecting the car. Attaching the list of codes from a diagnostic test from Auto Zone Store # 00791 , and the Estimate for Service from Hudson Import Automotive - Napa Auto Care. Have no paperwork from Starks mechanic shop.

NHTSA ODI 11718356

The car turn off while driving it. This creates a serious safety concern. We took the car to a mechanic and he was not able to identify the problem, he suggested we take it to the dealership. We then took it to the kia dealer ( Covina) and they have had it for months and yet are not able to fix it. Yesterday we received a call telling us, the engine failure is related to the oil pressure and it would need a new engine. This is no longer covered under warranty. This same car has already had the engine replaced once before. When we bought the Kia in 2018 (new) just weeks after we took it home, it required a new engine, which Kia replaced. The current issue appears to be related to oil pressure and is consistent with engine concerns reported on this model year.

NHTSA ODI 11714130

No warning lights/ indicators at all. Well taken care of vehicle 84,400 miles on the vehicle second owner. Had an oil change and my husband noticed bad blow by, had it diagnosed by a mechanic. They said we need a whole new engine. Dont understand how this would happen unless some manufacturer defect. No recalls apparently for this vehicle. Seems to be a common issue. Really sucks that I dont even have 100000 miles and need a new engine. We got screwed over as first time buyers with a huge loan ended up paying nearly 30000 dollars for this vehicle and the engine is already no good. I hope something comes of this because people are tired of getting screwed around by major corporations. Theres no reason why my engine should be no good with only 84400 miles and well maintained. Luckily my husband noticed when he did because who knows what would have happened if it had gone out while driving with no indicators that anything is wrong whatsoever. Could have been a bad crash for all I know.

NHTSA ODI 11714332

While driving on U.S. 69 highway in Overland Park, Kansas, the engine in my 2018 Kia Forte suddenly failed without warning. I was entering the northbound lanes from the 95th Street on-ramp and was accelerating to merge at about 50 mph. There had been no prior warning lights or messages. Just after getting into the right lane to merge with traffic, the engine lost power and the car began slowing down quickly. I had vehicles behind me that were still moving at highway speed. I had to react immediately, and fortunately the driver behind me was able to brake. I turned on my signal and coasted as best I could to the shoulder of the highway. Only after the failure did the check engine light come on. The engine never restarted and the vehicle had to be towed. This incident created a serious safety risk to me and to other drivers on the highway. A car entering the highway and then immediately losing power is not something other drivers expect, and I could have been hit from behind. There was no prior warning or symptom before the failure. The vehicle has since been diagnosed by a Kia dealer as needing an engine replacement.

NHTSA ODI 11704388

MY VEHICLE IS USING ALOT OF OIL AND WILL NOT START THE WARNING COMES UP IS CONCERNING THE OIL PUMP.

NHTSA ODI 11700717

the engine was burning oil unknown to me. You had an oil change completed at 101k miles and 106k miles and there was no oil left in the engine per mechanic. This caused the check engine light to turn on. Upon running the engine scans the code for a crankshaft error was discovered. P0017 The mechanic has now stated that a new engine is required due to the damage done to the engine because of the oil loss.

NHTSA ODI 11695139

Unknown. Fire was located under in the engine compartment area and fire was visible from below the engine under the car. When it happened I was driving on the freeway when noticed my car seemed to be struggling stay at the current speend and to loose speed then a it suddenly l no longer would accerlatoed so I pulled over to call 911 a passing vehicle stopped and informed me there was flames under my car. I safetly exited and called for emergency services. The Safety risk of major bodily harm by fire to myself or risk of harm to the environment around me a risk. The check engine light had come on before the fire. Reached out to manufacturer for a fire investigation and was instructed to take car to dealership to for service department to inspect. Was told a ETA of 2 weeks before they will check out my car.

NHTSA ODI 11685190

In January 2025, Shortly after an oil change (6-7days after), the vehicle first slowed down abruptly while driving and had a clinking sound. The vehicle was then pulled into a parking spot, refrained from driving due to the clinking sound. It was then towed to a Kia dealership in Jacksonville NC, diagnosed as engine failure at the cost of over $9000. The vehicle has been at the lot since January of 2025 because we can't afford the cost. Similar Kia vehicles have been recalled, and we would like this particular vehicle investigated. We purchased the vehicle in November of 2022 from a used car sales lot.

NHTSA ODI 11674423

Timing, VVT sensor. Oil pressure

NHTSA ODI 11672136

Same defective engine issue as other saftey recalls for other vehicles.

NHTSA ODI 11669687

Oil pressure problems blew the engines. Yes it’s available to look at at this time Car stalled multiple times while driving Has been confirmed by two mechanics Oil light went on when stalled

NHTSA ODI 11665928

The engine went out in the middle of a busy highway road leading to a dangerous situation that I almost lost my life the vehicle was purchased in 2021. There shouldn’t be no reason that the engine should have went out that quickly when maintenance was kept up not only that there was an airbag defected issue, which is a safety hazard as well. It was the most scariest situation ever when the engine shut off in the middle of the road. Also, there was many concerns of my vehicle being reported of also being almost stolen by Kia boys I have a report on that.

NHTSA ODI 11657445

While I was driving, the check engine light, oil pressure light and battery light came on and my engine shut down in the middle of the road multiple times. Right before the lights came on my engine started making a weird noise that sounded like puttering. I used a car scan tool that showed the camshaft senser B needed to be replaced. We replaced it and the issue wasn't resolved. I then checked online for any recalls and there is a recall SC210 that describes the exact issue I'm having. This recall should be reinvestigated. I will be calling the KIA Roadside Assistance number to have this fixed.

NHTSA ODI 11655148

The contact owns a 2018 Kia Forte. The contact stated while her daughter was driving approximately 45 MPH and approaching a red traffic light, the vehicle stalled. There was no warning light illuminated. The driver was able to pull into a nearby gas station. The vehicle failed to restart and was towed to Priddy Automotive, where the engine was taken apart, and the mechanic diagnosed that the engine had seized. The mechanic determined that the engine needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not contacted. The failure mileage was approximately 79,000.

NHTSA ODI 11650883

The contact owns a 2018 Kia Forte. The contact stated that while driving 35, the vehicle slowed down, there was an engine misfire, and the vehicle stalled. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 150,000.

NHTSA ODI 11646980

The contact owns a 2018 Kia Forte. The contact stated while driving 55 MPH, the engine was running unusually rough. The oil warning light was illuminated. In addition, the engine seized. The vehicle was restarted and driven to the residence. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had been taken to the dealer two days prior to the failure and the dealer confirmed there were metal shavings in the oil pan. The manufacturer was not made aware of the failure. The failure mileage was approximately 163,000.

NHTSA ODI 11626721

I noitce a werid sound the cooling fan was making and car started run different so I turn around came home park it came out few hrs later ND oil spilled on floor and all over the engine

NHTSA ODI 11613349

Driving car at about 40/mph and suddenly acceleration was lost. Released foot off of gas pedal and reapplied pressure but car continued to lose velocity and came to a full stop. Engine is now unable to turn over and car is completely not functional

NHTSA ODI 11608921

Check engine light came on, engine started vibrating while driving on highway and lost power. Could not continue driving, vehicle was towed to service workshop.

NHTSA ODI 11598552

The contact owns a 2018 Kia Forte. The contact stated that while the vehicle was running, the check engine warning light illuminated. There was an abnormally loud roaring sound detected while accelerating. While depressing the accelerator pedal, the vehicle was slow to respond while shifting or reversing. The contact stated that the vehicle failed to shift to second gear. The vehicle was taken to an independent mechanic, who determined that the failure was due to the electrical solenoid, P337, shift valve, and transmission. The contact called the local dealer, where an appointment was scheduled; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 143,000.

NHTSA ODI 11596437

1945 Credit one: 65 Nordstrom: 116 Taxes: 133 Discover: 148 Care credit: 54 Cap: 60 (small) Cap: 187 (big) *75* 2018 Kia Forte was brought to a Kia Dealership within standard time frame since release of Ignition Coil recall to remedy said issue (released recall dated: 2020). Ignition Coil has since went out, resulting in the 2018 Kia Forte being brought back to the [same] Kia Dealership for the [same] repair. Kia Dealership has stated the Ignition Coil that was placed in 2018 Kia Forte is not “under warranty”, and full market value price plus diagnostic, and labor is warranted. It appears the mileage of when the original 2020 Ignition Coil repair was complete, is “coincidentally” the exact mileage the Ignition Coil went out again (20k miles). Assuming the Ignition Coil used to remedy said recall back in 2020 is faulty; as Ignition Coils should last within 80k-110k miles. Thus, should not be the financial burden or responsibility of the consumer.

NHTSA ODI 11584226

Started my car it was making a tapping noise. I tried driving home the noise got worse and my car didn’t want to accelerate very much. I noticed a recall for other 2018 Kia fortes as mine is doing exactly what others are but my car isn’t included in the recall. I think the recall outlook is bigger than imagined.

NHTSA ODI 11580324

My vehicle has 90,000 miles on it. I was leaving from work when I started to drive it, it was making a noise so I checked before leaving the parking lot I didn’t see anything wrong. As I drove home the noise got worse and the car was having problems accelerating. The noise turned into a thumping and the car slowed even more. When I got home I realized the engine is knocking and there’s a recall out but not for my VIN. It’s having the same issue as other 2018 Kia fortes with engine malfunctions.

NHTSA ODI 11579217