What 743 owners told NHTSA about the 2018 Ford Focus RS

recurring transmission problems. Clutches and clutch actuator have been replaced and still studdard shifts and loud noises. same problems as our 2012 ford focus that did have a transmission recall. why has this not been recalled

NHTSA ODI 11516317

Car does not start or stalls when new fuel is added, poor fuel mpg. Check engine light with 1450 code. Recall on other fords 18s32 has the same issues but is not covering this model.

NHTSA ODI 11515795

1) purge valve, available for inspection 2) causes stalling when driving and difficulty starting after a fresh refueling unless completely pressing onto the gas pedal 3) problem confirmed, Ford refused to fix the issue 4) inspected through diagnostic tools 5) several codes and the check engine light. Identical to recall 18S32 but 2018 Ford Focus S is not within the accepted years. Any sudden change in speeds will cause it to jolt and seize and/or rev the engine to over 4000 rpm even if less than a 5mph shift in speed Ford has a audio recording of several calls tied to the matter within the last week (31Mar-6APR and ongoing) Issue has been ongoing for several months

NHTSA ODI 11515800

JUST CAME FROM DEALER AND THEY TOLD ME i NEEDED NEW LUG NUTS BECAUSE OF THE DESIGN THEY SWELL AND CANNOT BE TAKEN OF EASILY AND MUST BE REPLACED AT A COST OF $150

NHTSA ODI 11515438

The contact owns a 2018 Ford Focus. The contact stated that while the vehicle was idling, the check engine warning light illuminated. The vehicle was taken to a Good Year Service Center to be diagnosed. The mechanic retrieved DTC code: P1405 (EGR Valve). The contact stated that a smoke test was performed that indicated that one of the valves remained open. The contact then stated that the valve was lubricated, and the vehicle was presumed repaired; however, the failure recurred. The check engine warning light was illuminated. The vehicle was not repaired. The dealer and the manufacturer were notified of the failure and the contact was advised to call the NHTSA Hotline to file a complaint. The failure mileage was approximately 111,000.

NHTSA ODI 11515111

Transmission Control Module (TCM) does not work and the car does not start on.

NHTSA ODI 11514918

Initially the check engine light came on; took it to service center and the fuel sensor was replaced. Check engine light comes on the next day which revealed an evap code error. Suggestion was take it to dealer for recall check. Safety became an issue when the vehicle sputtered and stalled on the highway. I visually inspected the fuel tank which appeared "sunken" which suggested a vacuum pressure problem which the dealer also confirmed. All this is part of a recall which "should" include my VIN, make, model and year.

NHTSA ODI 11514534

The contact owns a 2018 Ford Focus. The contact stated while attempting to shift gear, the transmission was slipping and failed to register the intended gear. The failure caused the vehicle to stall, and the vehicle needed to be restarted to change gear. The contact took the vehicle to a certified mechanic who diagnosed that the transmission was malfunctioning and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 63,000.

NHTSA ODI 11514636

The engine component transmission failed. Yes it’s available for inspection on request. I was driving my car on the highway and out of nowhere the car went into limp mode, no lights or anything appeared on the car prior to this, when the car went into limp mode it began going 7 mph on the highway causing myself to be in danger. Multiple repair shops have inspected the vehicle. No warning lamps or symptoms appeared prior to failure.

NHTSA ODI 11514313

The check engine light came and the code for CPV show up. When you put gas in it doesn't start up right away like it suppose to. And the acceleration take time on occasion. Basically what the recall said for the car. But the dealship says my Vin numbet doesn't match the recalled so I don't know what to do.

NHTSA ODI 11512425

The check engine light came on and the code reads P0456. The car also has a rough idle and loss of accleration power. We had the car inspected at the mechanic and the shop said the Cannister Purge Valve (CPV) needed replaced and the PCM software needed to be updated. They notified us there was a safety recall on 2012 - 2018 Ford Focus - #18S32 that describes this exact issue, but when we contacted Ford, they said even though our car was a 2018 Ford Focus the VIN # was not included in the recall. Ford suggested we report the issue.

NHTSA ODI 11511916

I keep having an off and on check engine light with a P1450 code for the last two months. I’ve looked up my vehicle history. I found that my vehicle came up as a 2.0L GDI engine type which my car would qualify under the recall. But when I look up my vin, it tells me no. What do I do? I just financed this vehicle in October.

NHTSA ODI 11511687

The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission failed to shift into 2nd gear at 4,000 RPM. The vehicle was taken to two independent mechanics, who diagnosed that the clutch needed to be replaced; however, the replacement part was on backorder. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11511711

The contact owns a 2018 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle lost motive power with the battery and check engine warning lights illuminated. The contact pulled over into a parking lot. The vehicle was able to be restarted. The vehicle was taken to an independent mechanic, who diagnosed that the failure was related to NHTSA Campaign Number: 16V735000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The vehicle was then taken to the dealer, where it was determined that the canister purge valve needed to be replaced. The vehicle was taken to another independent mechanic, who replaced the canister purge valve. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.

NHTSA ODI 11511512

The contact owns a 2018 Ford Focus. The contact stated that while driving 25 MPH, the vehicle stalled. The contact stated that the vehicle was pushed into the driveway after stalling on the street. The vehicle was taken to an independent dealer where the vehicle was diagnosed with a leak in the evaporative emission control and EVAP purge valve. The contact stated that the check engine warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 61,000.

NHTSA ODI 11511564

My 2018 Ford Focus has a recall, it has been in the service center since November for non-repairable issues. Ford Motor company has lacked transparency and disclosures by lying about the recalls and defects as more than one the Ford certified dealership confirmed my emissions warranty and recall on parts but the manufacture continues to deny any sort of warranty and recall which is “VIN” specific but my engine and transmission falls under the classification of the recall “1.0L Fox GTDI engine and a 6-speed manual transmission.” Recall is for 2016-2018 and mine is a 2018. The condition and symptoms of just under 49k miles has these ongoing, Non-repairable issues as it’s since had its Clutch motor replaced, Transmission Control Module that was on a National back order because thousands of other vehicles identical to mine have the same issues but some do and some have “no recalls on their VINs” but after even this part was replaced, my vehicle still being in the service center, just like other past and pending lawsuits have stated - one part is replaced and the other malfunctions because now, after 5 months and four clear diagnostics - after the TCM was replaced, my vehicles Clutch Levers have malfunctioned all while still not operating the vehicle. The battery was also completely dead after being tested and fully replaced less than 3k miles ago. These Clutch Levers part is apparently not covered under any warranties and the manufacturer is not willing to pay for out of pocket expenses nor am I in the position to continue to invest in repairing, diagnosis, insurances, transportation, etc., but I don’t want to sell a vehicle that’s not safe to drive. I’d like some sort of an arbitration or buy-back option with the manufacturer but they’ve declined accountability because they’ve stated my VIN has no recall, and they’re administered from this department. I’ve filed several ongoing claims and I really hope this could be investigated internally as time is of the essence!

NHTSA ODI 11510910

Hesitation, stuttering, and lack of power have plagued me since purchasing 2022. When I put my foot on the accelerator the car should go. My car decides to take a coffee break, then smoke break, then bathroom, another smoke break then decides to go.

NHTSA ODI 11510311

The contact owns a 2018 Ford Focus. The contact stated that while driving at various speeds, the vehicle jerked, lost motive power, and stalled. The vehicle was able to restart. The check engine warning light was illuminated intermittently. The contact stated that the vehicle hesitated while starting, and while shifting into reverse(R). The contact used an ODB reader and retrieved fault codes for the fuel pressure sensor and fuel pump. The vehicle was taken to a local dealer, where it was diagnosed that the fuel pressure sensor and fuel pump needed to be replaced. The contact became aware of NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 70,000.

NHTSA ODI 11510357

The contact owns a 2018 Ford Focus. The contact stated while driving at various speeds, the vehicle shuddered and vibrated abnormally. There was message indicating that "transmission was overheating" displayed. The contact also stated that after refueling the vehicle would fail to immediately start. The vehicle was taken to the local dealer who diagnosed that the purge valve, motor mounts, and shift motor were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed that the vehicle was not included in the NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

NHTSA ODI 11508678

Vehicle GPS goes out and I have no idea if/when the road changes (curves, turns, and if I'm on the correct road or not) apparently APIM module goes out all the time. From stop to start vehicle shudders, lurches, and hesitates. Several times wrecks were miraculously avoided. It's only a matter of time before one does. While driving vehicle looses power, high revs, and losing MPG. For being fuel efficient its burning a lot of it. Ford refuses to even acknowledge my problem. Waiting for my powertrain warranty to expire which is very soon.

NHTSA ODI 11508257

The contact owns a 2018 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle hesitated and stalled. The contact attempted to restart the vehicle however, the engine failed to turn over. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed that the oil pump tension assembly and the turbo charger failed to operate as designed. The contact was informed that the engine and the oil pump tension assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 80,000

NHTSA ODI 11508288

MY VEHICLE IS THE SAME YEAR MAKE AND MODEL AND ENGINE AS THE ONE ON RECALL. BUT MY VIN ISNT. BUT I HAVING ISSUE WITH THE RECALL PART . OCTOBER AS PUMPED GAS , MY VEHICLE STARTED SPUTTERING AND CUT OFF, THOUGHT MAY OF BEEN BAD GAS. WELL EACH TIME I ADD GAS , IT STARTS SPUTTERING, DIES AND STALLS AT STARTING. I LOOKED IT UP AND REALIZED PURGE VALVE ON CAR WAS OBVIOUSLY CAUSING ,MY ISSUE. COUPLE WEEKS AGO ON JANUARY 20TH I DROVE VEHICLE TO DO A DASH AND MY CAR DIDNT WANT TO CHANGE OUT OF FIRST GEAR , LIKE THE TRANSMISSION WAS GOING BAD, I LITERALLY HAD TO SHIFT TO LOW GEAR ADN BACK TO DRIVE AND NEXT DAY IT DIED ON ME AT RED LIGHT BUT STARTED BACK UP . WELL 1/30/23 WAS ON WAY ABOUT MILE FROM STORE TO ADD GAS, HAD 10 MILES TO E AND MY CAR DIED GOING 45 MPH AND WOULDNT EVEN START BACK. LUCKILY NOONE WAS BEHIND ME OR MY SON AND HIS FRIEND MAY OF BEEN HURT FROM GETTING HIT. DUE TO CAR SHUTTING OFF GOING DOWN THE RD. I CONTACTED DEALERSHIP AND WAS TOLD NO RECALL ON MY VIN BUT SAME YEAR MAKE AND MODEL AND 2.0 GDI ENGINE.

NHTSA ODI 11508032

The Ford DPS6 transmission has lost reverse and buck, jerks and possibly sudden acceleration. It’s a 2018 Ford Focus with the same issues as the 2012 models and up.

NHTSA ODI 11507540

FORD REFUSAL OF NO COST SERVICE/REPLACEMENT for an ACTIVE RECALL on 2018 FORD FOCUS Canister Purge Solenoid Issue: Engine stalls at idle. Engine underperforms at lower speeds (under 40mph). Engine does not start immediately after refilling gas tank. Check engine light is on. Independent (i.e. non-dealer) mechanic checked on 09Feb2023. Diagnostic codes report Canister Purge Solenoid error. Independent mechanic noted a FORD recall (reference: 18S32) for 2018 Ford Focus Canister Purge Solenoid replacement, but my VIN does not show an active recall. FORD Customer Service and local dealers refuse to include my VIN on the active recall. FORD has not offered any opportunity for an appeal to have my VIN included on the recall.

NHTSA ODI 11507639

The contact owns a 2018 Ford Focus. The contact stated while driving 35 MPH, the vehicle started to shudder and then decelerated without warning. The contact stated that after several minutes the vehicle started operating normally. The vehicle was taken to the dealer and the clutch was replaced, but the failure reoccurred. The vehicle was taken back to the dealer and the transmission module was updated, but the failure persisted. The vehicle was taken to the dealer again and the mechanic stated that the transmission module needed to be updated. The manufacturer was not contacted. The failure mileage was 8,000.

NHTSA ODI 11507497