What 743 owners told NHTSA about the 2018 Ford Focus RS

While driving vehicle two "Oil Lights" on dash came on and car instantly began making a noise. Pulled over and had it towed to a service shop, they are telling me the "Oil Pump Drive Belt" broke and now the entire engine needs replaced. Upon researching this issue I come to find that this is a VERY COMMON issue that Ford is aware of but refusing to fix. This needs addressed!

NHTSA ODI 11554016

The purge valve problem persists well into this model year. The car is hiccuping and stalling at lights and has difficulty starting after fueling. I find it appalling that reprogramming the "check engine" light to acknowledge the defect, rather than actually repairing the defect was considered an adequate solution. My car has 59,000 miles and is just out of warranty. I think had this purge valve problem (rather than just the engine light symptom) been properly addressed by the NHTSA and Ford, my family would be safer in this car. I will never buy a Ford again.

NHTSA ODI 11553158

The contact owns a 2018 Ford Focus. The contact stated while driving approximately 65 MPH with the cruise control activated, the vehicle started losing motive power. The contact stated that he depressed the accelerator pedal and heard an abnormally loud bang and pulled over. The contact stated that the “Engine Fault - Service Immediately" warning light was illuminated. The contact stated that the vehicle was towed to the dealer. The dealer determined that the Transmission Control Module (TCM) needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 61,000.

NHTSA ODI 11551408

Car failed to engage transmission at low to moderate speeds particularly when accelerating. RPMs revved with no acceleration and then engaged suddenly causing the car to lurch forward and jerked while accelerating. The check engine light appeared. The car was brought to an independent service station. Repairs were made to the computer system and motors but the problem is still not resolved. Mechanic recommends full transmission replacement at this point. Called Ford Dealer who said this is a known issue with dual transmission system. Called Ford Motor Co to make them aware of the issue and no assistance was provided (they stated that my consumer score did not qualify me for assistance but would not disclose what was impacting my score).

NHTSA ODI 11551197

The contact owns a 2018 Ford Focus. The contact stated that after refueling the vehicle, the vehicle independently shut off. The contact was able to restart the vehicle after several attempts. The check engine warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,172.

NHTSA ODI 11550857

The contact owns a 2018 Ford Focus. The contact stated that while driving at various speeds, the vehicle hesitated while accelerating, which caused the vehicle to jerk. The power train warning light was illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty dual clutch transmission. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 66,200.

NHTSA ODI 11550632

The contact owns a 2018 Ford Focus. The contact stated that on two occasions while driving approximately 45 MPH, the oil warning light illuminated. The vehicle was towed to a dealer where it was not been diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 138,000.

NHTSA ODI 11550680

The contact owns a 2018 Ford Focus. The contact stated while driving 60-65 MPH, the vehicle started shuddering, failed to accelerate as needed and lost motive power and went into LIMP mode. The low oil pressure and the check engine warning lights were illuminated. Additionally, the messages "Reduced Engine Power" and " Service Vehicle Now" were displayed. The contact was able to coast the vehicle to the shoulder of the roadway. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the oil pump belt had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: SSM49918. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 106,000.

NHTSA ODI 11550574

The contact owns a 2018 Ford Focus. The contact stated while driving at various speeds, the vehicle was shuddering, the clutch was slipping, and the vehicle would not properly accelerate. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the transmission clutch was faulty and needed to be replaced. The transmission clutch was replaced but the failure recently reoccurred and the transmission clutch was replaced a second time. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 19,000.

NHTSA ODI 11550332

The contact owns a 2018 Ford Focus. The contact stated that the check engine light had been illuminated. The vehicle would suddenly stall while idle causing the contact to have to restart the vehicle or continually reeving in order to prevent stalling. The vehicle would also display a sputtering when slowing down. The contact noticed that the mileage per gallon ratio had decreased significantly. The vehicle had been taken to a certified mechanic who diagnosed that the purge valve had been stuck open causing multiple failures. The fuel tank had been warped a bit and may need to be replaced. The vehicle had not been repaired. The contact was informed that their vehicle's year/make/model was involved in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however their VIN was not included. The manufacturer was made aware of the failure. The approximate failure mileage was 72,000.

NHTSA ODI 11549558

The contact owns a 2018 Ford Focus. The contact stated while driving at approximately 35 MPH, and later at any speed, the vehicle would begin to idle roughly and then shake and lose forward momentum. The contact stated that the check engine warning was illuminated. The contact stated that she drove the vehicle to an independent mechanic who used a handheld scanner and stated that a vacuum purge valve code was showing on his scanner. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The failure mileage was approximately 22,000.

NHTSA ODI 11549484

-Engine service now message -stalling out while driving - loss of power - loss of gas mileage

NHTSA ODI 11548945

The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the engine block had failed and needed to be replaced. The vehicle was not repaired. An undisclosed dealer was notified of the failure and the contact was advised to contact the manufacturer for assistance. The manufacturer was notified of the failure and the contact was denied coverage due to the vehicle being out of warranty. The failure mileage was 47,686.

NHTSA ODI 11548489

The contact owns a 2018 Ford Focus. The contact stated that after parking the vehicle, moments later the vehicle was restarted, and the check engine warning light remained illuminated. Additionally, the vehicle failed to respond when shifted into reverse(R). The contact stated that while driving the vehicle failed to exceed 15 MPH and failed to drive in the lower gears. The vehicle was taken to the local service center who diagnosed that the transmission control module had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 134,000.

NHTSA ODI 11547334

Vehicle with no warning or signs displayed a transmission fault while in cruise control on flat straight road and began to rev. Pulled off of main road into parking lot and attempted to back into space but vehicle would not reverse. There was no issue backing up 15 minutes prior and of course it happens shortly after the 100,000 mile mark.

NHTSA ODI 11547024

The contact's daughter owns a 2018 Ford Focus. The contact stated while his daughter was driving 70 MPH, the low oil pressure and check engine warning lights illuminated, and the vehicle started shuddering and then lost motive power. The contact's daughter was able to veer to the side of the road. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed that the oil pump pretensioner belt had failed, which caused the engine and the turbo to fail. The dealer informed the contact that the engine and the turbo needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 70,318.

NHTSA ODI 11547071

The contact owns a 2018 Ford Focus. The contact stated that while driving at 20 MPH, the brake pedal was depressed, and the brake pedal became firm. The check oil warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 65,000.

NHTSA ODI 11546320

Vehicle has less than 70,000 miles on it. While driving lost oil pressure and brakes. Yes available for inspection. When pressure was lost and brakes failed I could not have stopped to avoid an accident. Multiple articles on the pump failure. Spoke with Ford they say not their problem. No warning. Engine light came on with brake light while driving. Car has been sitting parked. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11546390

The purge valve has been an ongoing continuous problem since we bought the vehicle. I have fixed it multiple times. It’s caused the vehicle to stall after putting gas in the tank, and just recently stalled while driving, causing me to hit a curb leading to the passenger front tire popping, the rim being dented, the tire rod bent, alignment out of wack, and the valance ripped off. It also caused a dashboard light to pop up saying Hill Start is Not Available. I was in the car thankfully alone and not with my children. The windshield wipers are a fairly newer issue, they come on whenever they want with the switch being touch. But won’t come on when I try to do it myself. I had my mom take a photo of the steering wheel/road while I was driving to show the severity of the alignment needed, it’s causing extra wear and tear EXTREMELY fast on tires. Rainy season has begun and this is absolutely unsafe and not my responsibility.

NHTSA ODI 11546145

The contact owns a 2018 Ford Focus. The contact stated while driving approximately 60 MPH, the vehicle suddenly stalled. The vehicle was later taken to the local mechanic who diagnosed that the purge valve was faulty and needed to be replaced. The vehicle was not yet repaired. The contact also indicated that the vehicle had previously experienced rough idling, check engine light illuminated, fuel gauge reading errors, and the Distance to Empty reading was incorrect. The local dealer was notified of the failures. The manufacturer was not notified. The VIN was not included in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.

NHTSA ODI 11545774

I was driving and could not get the transmission out of first gear and will not go in reverse. I was broke down waiting for a tow n 110 degree Texas weather. I have vertigo so I do not drive much. My car only has 55018 miles. I cannot afford a $6500 transmission repair. I am a single mom trying to put two girls through college. Help!!

NHTSA ODI 11545914

The contact owns a 2018 Ford Focus. The contact stated that the passenger’s side headlight was inoperable. The headlamp failure message was displayed. The vehicle was taken to the local dealer who informed the contact that there was condensation in the headlight housing. The contact was informed that the headlight housing needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 75,366.

NHTSA ODI 11544749

The contact owns a 2018 Ford Focus. The contact stated that after parking the vehicle, the following morning the vehicle failed to start. The battery was replaced however, after starting the vehicle, the vehicle was operating in LIMP Mode. The vehicle was towed to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The transmission was replaced; however, after retrieving the vehicle the check engine warning light remained illuminated and the RPM was revving too high. The vehicle was taken back to the dealer who diagnosed that the TCM was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 61,000.

NHTSA ODI 11543998

When you accelerate the car hesitates and shakes, the rpm needle goes way up even though you are creeping along. It seems like it is a recall issue on earlier model Ford Focus's. The recall should be extended to all model years. There is no reason I should have to spend money to repair a transmission issue on a 5 year old car. It is sitting out on the street not being driven while I make payments, not a happy camper. The check engine light comes on also, if someone was following too close and it starts sputtering it could cause an accident, a auto parts store checked it out- Most likely solution-"Replace Dual Clutch Transmission Clutch Assembly"

NHTSA ODI 11543480

My oil light is flickering. I have taken it to 3 different mechanics, one of which is a Ford dealership. Oil is getting on the timing belt, causing it to fray. Oil is being prevented from getting to the engine efficiently. They all state that the problem is a design issue, and that having it repaired will fix it for awhile, but the problem will continue later.

NHTSA ODI 11543210