What 743 owners told NHTSA about the 2018 Ford Focus Bev

The contact owns a 2018 Ford Focus. The contact stated she had experienced a failure with the rear-view camera since she purchased the vehicle. The contact stated that whenever the vehicle was shifted into reverse(R), the rear-view camera appeared blurry. The contact stated that there was no warning light illuminated during the failure. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.

NHTSA ODI 11482498

My Vehicle has been with me since I’ve had It since 32,000 miles it’s up to 87,000 miles now The first thing I had to replace the starter at 32,000 the alternator and CV axle on the passenger side and the clutch is second and third clutch And the inside dome lights an the dash lights shorted out all went out the day after I got it now since then at 84,000 the The front clip just fell off going down the road it never dragged the ground an it was never broken but going down the interstate at 70 the speed limit it fell down an ripped out from under the car an hit the car behind me costing me a lot of money but now currently at 87,000 The cv axel on the passenger side has started knocking again bye far one of the worst cars I’ve ever bought

NHTSA ODI 11481954

Steering rack locked up while driving down the road out of nowhere

NHTSA ODI 11481707

I informed the dealership twice that something was wrong with my vehicle. I had it serviced twice, now I’m being told my TCM needs to be replaced.

NHTSA ODI 11481610

The contact owns a 2018 Ford Focus. The contact stated that after refueling the vehicle, the vehicle would not start immediately. The contact stated that after several attempts the vehicle started and operated normally. On another occasion, the vehicle failed to start-up. The vehicle was taken to the dealer and the contact was informed that the purge valve needed to be replaced. The contact explained to the dealer that the vehicle had experienced the failure listed in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) and was informed that the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was 90,000.

NHTSA ODI 11481447

The contact owns a 2018 Ford Focus. The contact stated while driving at various speeds, the vehicle would hesitate and shutter upon the depression of the accelerator pedal. As the failure persisted, the check engine light appeared on the instrument panel. The vehicle was taken to an independent mechanic who diagnosed the vehicle with a defective canister purge valve. The contact stated that an unknown part was repaired to correct the failure; however, the failure returned. The vehicle was taken back to the mechanic who then linked the failure to NHTSA Campaign Number: 18V735000( Fuel System, Gasoline). The manufacturer was then notified about the recall and informed her that her vehicle was not included in the recall. The vehicle had yet to be repaired. The failure mileage was approximately 70,000.

NHTSA ODI 11480823

The contact owns a 2018 Ford Focus. The contact stated that the clutch pedal was vibrating and slipping. There was an abnormal transmission noise detected. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that an electronic update was needed. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 18V845000 (Power Train). The manufacturer was not contacted. The failure mileage was approximately 98,000.

NHTSA ODI 11480118

The fuel pump keeps burning out even though the tank is clean and there are no other obvious issues.

NHTSA ODI 11480187

Engine just stopped working and white smoke came out the exhaust.

NHTSA ODI 11478645

The contact owns a 2018 Ford Focus. The contact stated that upon starting the vehicle, the "Transmission Failure, Service Immediately" message appeared on the instrument panel. The contact had the vehicle towed to the dealer where she was informed that the electrical wiring was soy based, which attracted rodents to chew on the wires. The contact stated prior to the failure, the oxygen sensor warning light had appeared on the instrument panel and was serviced by the dealer. The manufacturer was notified of the failure and a complaint was filed. The vehicle was not repaired. The failure mileage was approximately 15,000.

NHTSA ODI 11478338

The contact owns a 2018 Ford Focus. The contact stated while driving 70 MPH, the check engine warning light illuminated; the contact pulled over and turned off and restarted the vehicle and the vehicle operated normally. The contact stated that the failure continued and the vehicle would not accelerate as needed. The contact stated that the vehicle also shifted to neutral(N) independently. The contact was able to pull over safely. An independent mechanic diagnosed the vehicle and stated that the transmission was defective. The contact was referred to the local dealer for assistance. The dealer was contacted and they stated that the VIN was not under recall. The manufacturer was not contacted. The failure mileage was 70,000.

NHTSA ODI 11477746

Car will not start after I get gas. When it does start, it "jumps"

NHTSA ODI 11477570

On 07/13/22, I was driving my 2018 Focus from a stop light, when I noticed that it was not accelerating properly. I looked down and both the check engine and oil pressure light had come on. I immediately pulled over and called my mechanic, to whom I drove it to (approx 3 miles) after being instructed to check the oil levels, which there was plenty of. Upon my mechanic inspecting the vehicle, he informed me that he believed the oil pump belt had snapped, but he didn't feel comfortable working on it because it is in the engine. I contacted the dealership and had it towed there. A few days later they confirmed that it was a snapped oil pump belt, and I would need an engine replacement. Further research has shown that this is a fairly widespread problem with Ford Focuses and other vehicles with the EcoBoost 1.0L engine. Others have expressed that their engines have flat out seized in the middle of driving. There were at least 2 TSB's issued regarding this specific engine problem as well. It should also be noted that per Ford's own service recommendations, this part should not need servicing until 150k miles. I believe it is fairly obvious to see how this could pose a significant safety risk and that the manufacturer is far past the point of addressing this.

NHTSA ODI 11477689

The contact owns a 2018 Ford Focus. The contact stated that while driving the clutch was sticking. The vehicle hesitated and almost stopped before shifting into gear. The check engine warning light was illuminated. The transmission overheating message was displayed. The vehicle was towed to an independent mechanic who informed the contact that the transmission needed to be replaced. The contact called the local dealer who informed her that the clutch was rusted; however, the vehicle was not diagnosed or repaired. The contact stated the failure was similar to NHTSA Campaign Number: 18V845000 (Power Train). The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 82,171,

NHTSA ODI 11477115

The contact owns a 2018 Ford Focus. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to the dealer who diagnosed that the EVAP system was leaking and that the fuel tank needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 76,800.

NHTSA ODI 11476963

I own a 2018 Ford Focus and am experiencing the same symptoms as other 2018 Focuses involved in NHTSA Campaign #18V845000, however my VIN was not part of the batch that was recalled. The car stutters/shudders when accelerating at low speeds/take off. It switches gears hard, often with a jerk or a clunk. It also switches gears inconsistently, ramping the RPMs at times. We visited the Ford dealership on 3 separate occasions to address this issue to no avail. The third time was 7 months after I purchased the vehicle - 1 month too late to qualify as a lemon under my state's lemon laws. I believe this recall needs to be expanded to include other 2018 Ford Focuses sooner rather than later.

NHTSA ODI 11476986

Occasionally, car lurches forward at stop signs without pressing the gas pedal, and other times, the car doesn't initially respond to gas pedal at a stop, stalling for 1-2 seconds and then lurching forward unexpectedly. Vehicle also trembles and shakes when upshifting from gears 1-2, and 2-3.

NHTSA ODI 11475868

Automatic transmission shudders going into 2nd gear, and can be felt through the steering wheel.

NHTSA ODI 11474278

My 2018 Ford Focus has less than 35K miles on it. It has sat at a dealership since December 2021 waiting on a TCM while I am stuck with car payments and zero help from Ford. Ford has stranded over 50k customers and has no ETA on this part. Their dealerships are advising customers the vehicles are safe despite the fact that they shudder, lurch while braked, and decelerate for no reason. This is a known issue that Ford already lost a lawsuit for ok earlier models and now they’ve been sued for the 2017/2018 models. NHTSA needs to investigate this. These cars are not safe and should not be on the road.

NHTSA ODI 11473767

1) The car shuts off and has difficulty turning on after filling up the gas tank. It will turn on for five seconds, lung forward, and then shut off. It has not been inspected yet. There is a check engine light on and showed up about 2 months ago (same time as when the issue started). 2)The center media screen shut off. This is a risk because the backup camera no longer works as the screen no longer turns on. It has not been inspected yet. There were no warning lamps or messages.

NHTSA ODI 11473587

Vehicle stopped working June 21. Car refused to start up. Had it jumped, battery was completely drained. Discovered had no reverse, drive works up to 10-15mph. Drove it short distance to a Ford dealer service center. Discovered they said it's a powertrain issue and they're 3 weeks behind as they have no available mechanic to look at it. Called another dealer and was told the same thing. Had it towed home. Took it to a highly recommended mechanic and they said the powertrain is shot and needs replacing. Discovered it's a well known documented issue as of 2020. I have extended warranty on it but it may be denied because A) one ford dealer who did some work on the car within first few months of purchase "lost" my service records as they claim its not in their system. B) possibly denied because it's a known defect and they'd lose money to replace it. There's no recall on this defect. I wonder why!? This is a well known issue and seriously affects the value of my vehicle if I want to trade it in or sell it since it's all over the place and all mechanics know to "RUN" away from this car. No engine light on until arriving at dealer. No leaks, bluetooth stopped working as well. In early 2020 I did take it to get serviced and complained of shuddering and shaking upon acceleration but was told it's fine and within normal specs. Car left me stranded so they knew since then they've got a problem. Car is currently available for inspection at the garage where I'm expecting it to get fixed.

NHTSA ODI 11473441

Engine shudders and sometimes stalls out when accelerating from complete stop and from low speed. Shudders also after changing gears or when trying to accelerate quickly like to change lanes. Especially after being driven more than about 50 miles without stopping. Has to be cranked 2 or 3 times after fueling and engine will only stay on if accelerator is pressed almost to the floor. Check engine light comes on and goes off randomly.

NHTSA ODI 11471195

While driving on a very mountainous, winding road, the steering became stiff as I was in the middle of navigating a corner. For a few moments, the steering was completely unresponsive, before I was able to regain control with much force and effort. As I regained control of the vehicle, a warning light came on, which indicated: "System check, Steering Assist Fault, Service Required." I tried basic trouble shooting, but could not check the power steering fluid levels and the fuse that controls the system was in good working order. My normal mechanic stated that this must be serviced by Ford. The vehicle is putting out a code, but the mechanic and O'Reillys were not able to get the code to read. The loss of power steering assist, in the area I was in, nearly caused me to drive in to a creek. Unexpected loss of power steering caused me to Jam my wrist while trying to keep control of the vehicle. Iced the wrist but it is still sore. Seeking medical treatment in the AM Vehicle (less than 4 years old) has now had: 1) cannister purge valve issue resulting in an out of pocket fix (this car not covered under canister purge recall) 2) clutch forks and clutch assembly issues 3) power steering assist issues

NHTSA ODI 11470928

My car sounds like its going die when putting fuel in my car, I have to leave car running while fueling. No matter the level of fuel. If I turn on my car after fueling, it takes a few tries to get car started back. Sometimes my car shakes when taking off or speeding up. This has been going on for the last year. Check engine light is on.

NHTSA ODI 11470612

I'm pretty sure my car is having the problem with the fuel something because EVERY TIME I put fuel into my car it wants to choke up and die. It's very annoying now. It's been doing it for a couple weeks now but my car is not on the recall list and my car also is doing a thing when I accelerate it is very jumpy and feels like I'm going over rumble strips. I'm very unsatisfied with my car.

NHTSA ODI 11469869