What 194 owners told NHTSA about the 2017 Volkswagen Golf R

I've been experiencing a recurring issue with my vehicle where the EPC light frequently activates. When this happens, the car significantly reduces its speed, making it difficult to drive safely. I've noticed this situation over the past six to eight months, and it typically requires me to pull over. After turning off the vehicle multiple times, I'm usually able to reset it and drive normally again. I'm seeking advice on how to address this problem effectively.

NHTSA ODI 11635575

The component that failed, according to Volkswagen, is the rollover valve in the gas tank. This issue caused large amounts of gasoline to leak and pool from behind the rear passenger wheel well, creating a significant fire hazard and risk of harm. The vehicle was inspected by a Volkswagen service center as part of the repair process, whereupon the Volkswagen service center documented that the issue was caused by a faulty rollover valve in the gas tank. There were no warning lamps, messages, or other symptoms prior to the failure.

NHTSA ODI 11622253

I had a suction jet pump recall due on the car. I took it to the dealer to fix. Mind you, I have never had an issue with this car ever. Now about a week later from the car being in the shop I get an engine malfunction light that comes on due to the evap system. Vw dealership of cool springs has not worked with me on this at all and it is frustrating to say the least.

NHTSA ODI 11616046

Car has been leaking fuel for over a year. Had to pay out of pocket to get it fixed and VW refused to refund cost of repairs even though there is now a recall over a year later acknowledging the issue.

NHTSA ODI 11611590

The contact owns a 2017 Volkswagen Golf. The contact stated that after refueling the vehicle, the contact became aware that the fuel had been consumed extremely quickly. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ODI 11608176

Starting January 2023, I had issues putting fuel in my car (symptoms align with the recall issued this year). I took it to VW and paid their diagnostic fee for them to say there’s nothing wrong with the car (approx. $170) continued to drive the car and eventually due to the issue, my fuel pump went out and I had to replace it. (See attached image). This time, I took the car to a local mechanic who charged a $100 diagnostic fee. All of this was prior to the recall this year and I am hoping for reimbursement on everything I spent trying to resolve this issue.

NHTSA ODI 11607650

July 30,2024 I own a Golf 2017. My suction jet pump has failed. I cannot drive my car because I can't put gas into it. I need my car for work. The recall does not have the part available and it seems there hasn't been a part to fix this for a very long time. I'm really at a loss. What are my next steps? Should I report this to the Better Business Bureau? So far I've been on Volkswagen Of America's phone wait for 40 minutes. I've already taken my car to a dealership to have this problem verified. There were no warning messages.  

NHTSA ODI 11605426

On July 7, 2024, the fuel tank system on my car (2017 VW Golf) failed. I was unable to pump gas into the gas tank. Upon arrival back to my house, gas started leaking out of the backside of the car near the gas tank (I later found out from the VW service manager it was leaking out of the charcoal canister). I had the car towed ($173) to a local VW dealership the next morning, 7/8/24. It is now 7/30/24 and the car is still not fixed. I was without a car for two and a half weeks (7/7 to 7/24), then finally got a rental from the dealership that is costing me $40/day (totaling $240 as of today). According to the service manager at the VW dealership, VW engineers are saying the failure is not due to the fuel tank suction jet pump (which there is a current recall on but no fix available) but all the symptoms I experienced point to that part being the problem. The service manager said that VW will cover the cost of the repair under a PZEV warranty, not the fuel tank suction jet pump extended warranty/recall. The replacement parts are taking weeks for the dealership to receive and there was confusion/miscommunication about which parts were included or needed. My complaints are: 1) the length of time it's taking for the car to be fixed, 2) the amount of money it's costing me for towing, rental car and any other potential expenses related to this issue, and 3) if it's not the fuel tank suction jet pump that is the problem, then there's potentially a larger problem at play with the fuel tank system not included in the original recall.

NHTSA ODI 11605490

The contact owns a 2017 Volkswagen Golf. The contact stated that when the vehicle was started, the contact heard an abnormal clicking sound. The vehicle was taken to the dealer where it was diagnosed with a failed suction jet pump. The contact was informed that the suction jet pump needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

NHTSA ODI 11604755

A recall was published on 02/14/2024 and remains unresolved. Since the safety risk of "leaking fuel, in the presence of an ignition source, may result in a fire" it seems like this should be a priority. (Manufacturer Recall Number20UF, NHTSA Recall Number24V110)

NHTSA ODI 11604527

***DATE OF OCCURRENCE: 07/03/2023*** SOLUTION REQUIRED IMMEDIATELY: I have been without a working vehicle for nearly 1 full year without recourse. ONE YEAR! Initially the recall for the exact suction jet pump issue did not include 2017 GTI models. I was furious. Repair estimates I received ranged rom $2,000-4,000 to replace the entire fuel system. Being unable to afford this, I was forced to leave it parked and completely unusable. I even had to change my car insurance to "garaged" status to avoid paying premium on a vehicle I couldn't even drive. I am extremely disappointed in the timeline for this recall. I'm glad that the recall for suction jet pump issue now includes my vehicle's year, but a repair solution is needed immediately. INCIDENT DESCRIPTION: Vehicle began losing engine power a day or so before the incident. I was driving home and noticed the intermittent engine power issue. Thankfully, I was not far from home. As I approached my neighborhood gate, I rolled down the window to enter the code. That's when I smelled a strong fuel odor. There were NO indicator lights or warning lamps displayed on my dashboard panel that suggested an issue with my vehicle. I looked around nearby for lawn maintenance trucks, suspecting they were refueling or had potentially spilled fuel from their equipment. As I pulled into my parking space and exited the vehicle, I immediately noticed fuel streaming down from the inside of the wheel well and pooling on the ground below the gas tank door. Honestly, it was a really scary experience. I was afraid for my safety. It looked like my car could explode at any moment. The only good news is that my gas tank was relatively low on fuel so the spill didn't last long. I have not started my vehicle since the incident, nearly 1 year ago. It's a gut punch every day to see it parked, unusable AND have to continue paying for it. Please issue a repair solution for this recall immediately. Thank you.

NHTSA ODI 11595545

Related to recall 20UF. VWoA refused to authorize repair under recall in March. My 2017 GTI is diagnosed with all symptoms of the 20UF recall. Random power loss, inability to add fuel, large fuel leak from rear fender (charcoal canister). I have been unable to drive the car since March, but VWoA refuses to pay for the repair. The recall was issued 3 months ago and there is still no repair, or offer from VWoA to give a loaner car or anything.

NHTSA ODI 11588685

VW is not acting fast enough to fix the active fuel tank suction jet pump recall, given the immense danger risk. The recall was issued a month and a half ago - they should have the parts available now to fix it. I have noticed fuel smells while inside and driving my car on and off for several months now!! I took my car to their dealership yesterday to get their faulty water tank replaced and when I asked about the recall I was completely dismissed and they said they had no idea when the parts would be available. I need my car to get to work. I can't just stop driving it but it feels incredibly unsafe to drive now that I know about the recall!

NHTSA ODI 11581571

Hello I am creating this inquiry about the suction pump and charcoal canister for my 2017 VW GTI. The suction pump on my vehicle has gone faulty and the car will no longer accept more than a gallon of gas. A faulty suction pump commonly leads to gas leaks and a faulty charcoal canister as well. The suction pump for the 2015 and 2016 golf gti was recalled due to this issue. There are hundreds of people with later models from 2017-2020 including myself that experience that exact same problem but VW has yet to extend the recall to our years. As of December 2023 the us transportation authority opened a probe into Volkswagen for not extending the recall. I am very frustrated over this because this can be close to $2000 in repairs. I should not be held financially responsible for a faulty pump that should have been recalled from the manufacturer.

NHTSA ODI 11564743

The fuel suction pump in my 2017 volkswagen golf r failed causing strong gas odors to emit whenever the car is running, loss of power, inability to put more than a small amount of fuel in, and gas leaking into the evap and charcoal canister causing them to fail. This creates a huge risk for ignition and fuel dumping onto the road which, only because I stopped driving it, has not happened to me. A check engine light has still yet to appear even after part failure. I believe you can see how big of a safety risk this causes to not only the vehicle's occupants, but those around it as well. I have already taken it to the volkswagen dealer and they themselves confirmed that yes the fuel suction pump has failed and that all those parts and the fuel tank itself need replaced totaling around 3,500 to 4,000 dollars. I have not gotten anything replaced. They refuse to cover it under the warranty extension titled VWP22-12 even though my car is obviously not 15 years old and it only has around 37,000 miles. They claim they revised the part for 2017 so that it doesn't fail anymore, but if that were the case then why is that warranty extension all the way up to 2020 models. I have looked through other complaints filed on this site and see you've already been contacted several times about my exact issue on 2017 models. I am urging you to please make this a recall. Volkswagen clearly knows this is a widespread issue evidenced by the fact the it affects such a large amount of models and years and by not making a recall you are allowing them to screw people over.

NHTSA ODI 11560614

Large amount of fuel dumped onto road from right rear side of car at stop light. Police stopped me and asked me get a tow and no longer drive. 1st garage said it might be faulty fuel pump, and only VW dealer can replace. towed to VW where they replaced the whole fuel assembly.

NHTSA ODI 11558501

Fuel evaporation canister started leaking raw fuel after a strong gas odor was present before hand. The fuel suction pump failed and pressure built up in my gas tank. I was at risk because the presence of raw fuel near ignition sources can cause a fire. Verified at Volkswagen dealership. No warning signs by car when issue first started. Only sign of problem before raw fuel leaking was poor car performance, car stalled and I could not put more than a gallon of gas in the fuel tank.

NHTSA ODI 11552952

While driving the vehicle I noticed hesitation and lose of power on the interstate. No MIL or check engine light illuminated on the dash. I was able to get the vehicle back to the house, but noticed a strong fuel smell coming from the car. I walked around the vehicle looking for a visible sign of a fuel leak and saw a puddle by the rear passenger tire. After further investigation I discovered that the fuel was coming from the air filter on my charcoal/evap canister. I did some research and see that VW has an extended warranty out for this issue but it is not currently a recall, Fuel Tank Suction Jet Pump Limited Warranty Extension (VWP-22-2). The safety issue is that while driving and stationary you have raw fuel and vapors on the exterior of the vehicle by an exhaust muffler and the inner fender liner absorbs some of the fuel in its fabric, so with the right circumstances could cause a vehicle fire. Thankfully this did not happen to my vehicle but the potential for it to happen is present. I took my vehicle to my local dealer and they diagnosed this issue but because my vehicle has a salvage title they will not cover the cost for the repairs, even though the reason that my vehicle has a salvaged/total title has nothing to do with the fuel/emission/evap system, so I will be doing the repairs myself. The parts that needs to he repaired are the same parts listed in the previous recall of the earlier model of the VW GTI (Safety Recall Code 20Y6)

NHTSA ODI 11548647

Vehicle would not take in fuel from the gas pump. Fuel would leak from the rear, passenger side of the vehicle. Dealer replaced Fuel Tank, ACF Valve and Evaporative Emission Canister to fix the problem.

NHTSA ODI 11547266

Vehicle EPC light comes on dash. OBD code is "P00AF00 - Turbocharger Boost Control "A" Module". This error causes sudden loss of power and loss of driver assistance (forward collision assist, blind spot assist, cruise control, etc.). Vehicle is available for inspection upon request. Upon checking turbo charger, the wastegate actuator arm is seized up, keeping the wastegate from functioning properly, failing to maintain boost pressure and entering limp mode causing sudden loss of power and acceleration. This has happened while on the roadway, attempting to merge into highway traffic, change lanes & pass other vehicles. This caused the vehicle behind me to close the distance very rapidly almost resulting in multiple rear end collisions. The vehicle has not been inspected by others, yet. The only warning that came on was when it first did it. I had a sudden loss of power, a warning beep from the dash and the EPC light illuminated. It fixed itself after a few moments then occured again. It is now stuck with this error and will not operate accordingly.

NHTSA ODI 11546483

While on a road trip we noticed that the car was missing slightly on steep hills, and we attributed it to needing new spark plugs. When we filled with gas later, we noticed it clicking off as full sooner than it should have. The next day we could not get more than a gallon in it, and gas pooled in the neck of the tank and started oozing out around the rear bumper and on to the ground. It was clearly unsafe to drive in that condition. We took it to a nearby mechanic where we were visiting and he diagnosed it as a failed EVAP that he couldn't replace because it's integrated into the tank, and he didn't do that kind of major work on VWs. Found another mechanic and he disassembled the fuel system to discover that the baffles in the gas tank had collapsed, the charcoal filter was destroyed, the fuel pump and simmy valve were broken. All will have to be replaced at a cost of about $4500. (No documentation yet--still in the shop, and I haven't yet been able to get through to VW.) No check engine or warning lights ever came on, and the damage was sudden and instantaneous, with no cause (never been in a wreck in this car, always use factory-recommended fluids and fuel). No mechanical problems until this, and it seems there are many reports of Golfs 2016-2018 having this same problem at 5 years, so it's clearly a defect. This needs to be a recall! Thanks.

NHTSA ODI 11542548

Tried to put gas in tank and the pump at the gas station kept shutting off. Pulled over to refuel at another gas station and had gas leaking out of the side of my car, above tire on rear passenger side and next to exhaust. Inside of the car filled with strong odor of gasoline. Extremely dangerous having fuel pouring out of the side of the car while vehicle was moving. Volkswagen issued a recall for this issue on the 2015 and 2016 vw gti models due to the suction pump getting stuck inside the gas tank and they need to do the same for the 2017 models. Having to pay out of pocket to fix this issue and its going to cost over $3,500.00. Local dealership saying I need to replace the entire gas tank to fix the issue. Vehicle has roughly 72,000 miles on it. No warning lamps or messages from the vehicle while driving.

NHTSA ODI 11537018

Driving I noticed the power getting cut intermittently. This happened for a couple days. When I parked the car there was a smell of fuel. Looked at the rear of the car and there was a massive puddle of fuel on the ground at the rear passenger side. Left car outside house for safety reasons. Incredibly dangerous. No warning lights, just a very strong smell of fuel. Scheduled to take vehicle to dealer as there is a recall on the suction pump for the fuel system for models 15-16. It appears this is an issue in other models as well.

NHTSA ODI 11535411

One day after a fuel fill-up, during hot weather, upon returning home my wife noticed the smell of gasoline when exiting my vehicle. Then she saw a steady stream of fuel pouring onto the ground just behind the passenger-side rear tire. She immediately got back in the car and drove it back out of my garage, onto our gravel driveway. The fuel continued running out of the wheel well, from a location approximately below the fuel filler door, for several minutes. After I opened the fuel filler cap there was a hissing sound, then the fuel leak appeared to stop. I called my local VW repair shop, who advised us to get the car towed to them, and NOT to drive it. The next morning it was towed to that shop. It took them a couple of days to get to our car, and they diagnosed that fuel had filled the charcoal canister, and presented us with a repair estimate of approximately $5,000. That included replacing the charcoal canister, the entire fuel tank, and several other related parts. After doing some research online, I believe this incident resulted from failure of the fuel tank suction pump, which was the subject of VW recall 20Y6, dated 12/21/2016. Apparently the same fuel suction pump continued to be used in the 2017 model year Golf. My online research revealed that this problem continues to occur with VW Golfs of model year 2017 and even later.

NHTSA ODI 11534630

Gasoline was leaking profusely out the back of near the right rear tire well. I had it inspected by Camelback VW (Dealer) and they said the fuel tank failed. The car has 55.8k miles on it, bought in December of 2017. Having the fuel leak out was eye opening along with the repair bill of $3967.79 from what I understand, the fuel tank has a molded pump in it, that failed, which caused fuel to leak out https://www.youtube.com/watch?v=p8k48eSbgVg (not my car, but exactly what happened, gurgling and all)

NHTSA ODI 11533709