What 194 owners told NHTSA about the 2017 Volkswagen Golf R

Safety: Had a charcoal canister saturated with gasoline resulting in a fuel leak; gasoline was dripping down the rear right side of the car via the charcoal filter and soaking the rear fender. Raw fuel was also being pumped into the air intake of the engine (where air is supposed to go). Fuel tank was bulging due to the high pressure and could have cracked. Other symptoms: Had fuel spillback while refueling, and also could not fill the tank because the handle kept clicking. Car was riding rough and jerking randomly. Failed component: Dealer determined a faulty suction pump was causing liquid fuel to fill the charcoal canister while the car is running. This is the same part that was previously recalled in earlier 2015-2016 Golfs (NHTSA Safety Recall Code: 20Y6, published December 2016). My 2017 Golf (16k miles) was manufactured April 2017 and sold to me in October 2017. On the 2017 Golf, the suction pump is now molded inside the fuel tank in an inaccessible location and cannot be serviced; the entire fuel tank must be replaced. Reproduction: The dealer disconnected the vent lines from the fuel tank and proved that liquid fuel was venting out of the fuel tank and into the charcoal canister via the suction pump (see attached invoice). Inspection: The car was not inspected by the manufacturer, only the dealer. Warnings: There were no warnings or lights. When I first noticed my car jerking, I ran my OBD-II scanner and found a code "P0461 Fuel Level Sensor Circuit Range/Performance" but the car did not report this to the driver (see attached image). Rectifications: The fuel tank should be recalled, and Volkswagen should release a software update to make the P0461 code trigger a Check Engine Light.

NHTSA ODI 11436229

My 2017 golf is 21,000 miles now. A gasoline leak occurred. It seems to be the same symptom as 2016 golf recall according to the report as attached. why 2017 golf is not covered for recall? In fact, gasoline leaked onto the street, which was a very dangerous situation. We can provide a video on this matter.

NHTSA ODI 11434613

UNABLE TO FILL GAS TANK. FUELING AT PUMP SHUTS OFF AFTER SMALL AMOUNT OF GAS FLOW. GAS THEN BACK FLOWED OUT OF FUEL TANK NECK ONTO GROUND. VEHICLE EXHIBITED LOSS OF POWER SYMPTOMS AT MID-RPM ENGINE SPEED PRIOR TO FAILED FUELING ATTEMPT. SIMILAR SYMPTOMS TO 2015-2016 RECALL ON PREVIOUS MODEL VW GOLF GTI; SERVICE # 20Y6.

NHTSA ODI 11403092

WHILE I WAS DRIVING, THE FUEL STARTED TO GET OUT FROM THE BOMB, LEAVING GASOLINA IN THE ROAD WITH A HIGH LEVEL OF RISK FOR A EXPLOSION. WHEN INGET TO THE RED LIGHT, THE CAR TURN OFF IN THE MIDDLE OF THE A VERY TRANSITED ROAD WITH A HIG AMOUN OF FUEL UNDER THE CAR. ADDING THAT THE TEMPERATURE WAS OVER 90 DEGREES. EVEN THOUGH THIS SITUATION HAD HAPPENED TO 3 CARS THAT DAY, THERE IS NO SAFETY RECALL FOR THIS PART OF THE CAR. THERE HACE BEEN MORE FOR THIS CASES BEFORE AND NO ACTION HAD BEEN TAKEN..

NHTSA ODI 11344021

TL* THE CONTACT, AN INDEPENDENT MECHANIC WAS CALLING ON BEHALF OF HIS CLIENT WHO OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL ON THE PASSENGER'S SIDE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE LEAKED FUEL WHEN THE VEHICLE WAS HOT. THE CONTACT INFORMED THE VEHICLE OWNER THAT THE FUEL TANK AND CANISTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE OWNER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE OWNER WAS INFORMED BY THE MANUFACTURER THAT HE WOULD RECEIVE A CALLBACK WHICH WAS STILL PENDING. THE FAILURE MILEAGE WAS APPROXIMATELY 35,800.

NHTSA ODI 11331893

TL* THE CONTACT OWNS A 2017 VOLKSWAGEN GOLF. THE CONTACT BECAME AWARE THAT THERE WAS FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DIAGNOSED THAT THE FUEL TANK, FUEL PUMP ASSEMBLY AND VAPOR CANISTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

NHTSA ODI 11322047

YOUR SYSTEM IS MISLABELING CARS. SEARCH FOR 2017 GOLF R. IT SHOWS 58 COMPLAINTS. IF YOU LOOK AT THE CARS TIED TO THESE COMPLAINTS IT'S VW ALLTRACKS. I WANT PEOPLE TO SEE THE ISSUES I'M HAVING WITH MY CARS BUT I NEED YOU TO FIX THE WEBSITE. PLEASE HELP. I FIND IT STRANGE THAT THIS IS HAPPENING TO VW AFTER ALL THE ISSUES THEY HAVE HAD.

NHTSA ODI 11287489

EVAP CANISTER FAILED WITH LESS THAN 40,000 MILES ON THE CAR. I FIRST NOTICED WHEN I WAS PUMPING GAS ONE DAY, I OPENED MY TANK AND HEARD A LOUD WOOSH NOISE LIKE PRESSURE HAD BEEN BUILDING UP INSIDE THE GAS TANK. I THEN WENT TO FILL UP MY TANK AND GOT MAYBE $3 WORTH OF GAS IN THE TANK BEFORE THE PUMP SHUT ITSELF OFF LIKE THE TANK WAS FULL THOUGH IT WASN'T. WAS TOLD IT'S NOT COVERED UNDER WARRANTY BY VOLKSWAGEN, AND EVEN THOUGH THE 15-16 GTI HAD RECALLS FOR THE SAME ISSUE THE PROBLEM WAS SUPPOSED TO BE FIXED FOR THE 17 GTI. I EITHER HAVE A LEMON OR THE PROBLEM HAS CARRIED OVER FOR A 3RD STRAIGHT YEAR.

NHTSA ODI 11180563

TRAVELING ALONG A SLIGHTLY HILLY ROAD AT 35MPH WHEN THE ENGINE SUDDENLY SPIKED TO 3000RPM AND THE CAR'S ACCELERATOR PEDAL STOPPED FUNCTIONING. HAD TO APPLY BRAKES AND PULL TO THE SIDE. ONCE CAR REACHED 0MPH IT IDLED AND THE ACCELERATOR PEDAL BEGAN FUNCTIONING AGAIN. TOOK TO VW DEALER SERVICE CENTER NEXT DAY. THEY REPORTED THAT THEY COULD FIND NO PROBLEM CODES. THEY CHANGED OIL, ROATATED TIRES AND RETURNED THE CAR. PROBLEM WAS NOT RESOLVED AND REOCCURED ON AUGUST 8.

NHTSA ODI 11121660

THIS IS THE SECOND RECORDED INSTANCE OF THIS ISSUE. A SIMILAR INCIDENT OCCURRED ON JULY 27. WHILE DRIVING ABOUT 45MPH ON AN INCLINE THE VEHICLE ENGINE SUDDENLY INCREASED TO 3000RPM AND THE ACCELERATOR PEDAL STOPPED RESPONDING. HAD TO APPLY BRAKES AND PULL OVER TO SIDE OF THE ROAD. ONCE VEHICLE REACHED 0MPH IT IDLED AND THE ACCELERATOR PEDAL BEGAN FUNCTIONING NORMALLY AGAIN. TOOK THE VW DEALER SERVICE CENTER THE NEXT DAY. ONCE AGAIN THEY COULD FIND NO PROBLEM CODES. SERVICE CENTER TRIED TO RETURN VEHICLE AGAIN BUT WE PERSISRED. MECHANIC OFFERED TO TEST DRIVE FOR A FEW DAYS TO SEE IF HE COULD RECREATE THE ISSUE BUT IT DID NOT REOCCUR. CONTACTED VW CORPORATE AND REGION CASE MANAGER INFORMED US THAT THEIR TECHNICAL TEAM WOULD WORK WITH THE SERVICE CENTER. AFTER ABOUT A WEEK THEY STILL CONTINUE TO CLAIM THEY CAN FIND NO PROBLEM WITH VEHICLE TO REPAIR.

NHTSA ODI 11121667

VEHICLE IS A 2017 VW GOLF ALLTRACK S WITH A 6-SPEED MANUAL TRANSMISSION; LESS THAN 2 WEEKS OLD WITH ~400 MILES ON ODOMETER AND A LITTLE OVER 1/4 TANK OF 87-OCTANE GASOLINE. ISSUE OCCURRED AT APPROXIMATELY 10PM ON AUGUST 25TH, 2017. VEHICLE WAS ACCELERATING AWAY FROM A RED LIGHT AT A HIGHWAY INTERSECTION CROSSING ON A SLIGHT DOWNHILL GRADE. MANUAL TRANSMISSION WAS SHIFTED FROM 1ST INTO 2ND GEAR DURING ACCELERATION, AND THE VEHICLE PROMPTLY LOST ENGINE POWER, POWER STEERING AND BRAKES NEAR THE MIDDLE OF THE INTERSECTION. MY WIFE COASTED THE VEHICLE ACROSS THE INTERSECTION AND WAS ABLE TO MOVE IT TO THE SIDE OF THE ROAD WITH THE HELP OF PASSING MOTORISTS WHO WERE KIND ENOUGH TO STOP AND HELP. THE "ENGINE" LIGHT AND "EPC" LIGHT WERE BOTH ILLUMINATED ON THE DASH. DURING THE 45 MINUTE WAIT FOR A TOW TRUCK, MULTIPLE ATTEMPTS WERE MADE TO RESTART THE VEHICLE. THE ENGINE WOULD TURN OVER AND SOMETIMES "CATCH", BUT WOULD NOT START OR IDLE. HEADLIGHTS, BLINKERS, WIPERS, ETC. REMAINED FUNCTIONAL THROUGHOUT THE ORDEAL. VEHICLE WAS TOWED TO THE VW DEALERSHIP AND REMAINS THERE FOR DIAGNOSTICS. THERE IS NO IDENTIFICATION OF A CAUSE FOR THIS ISSUE AT THE MOMENT. IT IS WORTH NOTING THAT THIS ISSUE IS A MAJOR SAFETY CONCERN FOR MY FAMILY AND MOTORISTS AROUND US: A NEW VEHICLE SUDDENLY AND UNEXPECTEDLY LOOSING POWER AND ALL CONTROL FEATURES IS ENTIRELY UNACCEPTABLE, AND COULD VERY EASILY LEAD TO A SERIOUS ACCIDENT.

NHTSA ODI 11019841

WHILE TRAVELING AT HIGHWAY SPEEDS THE VEHICLE FLASHED THE EPC WARNING LIGHT AND SUDDENLY LOST ALL POWER AND RAPIDLY DECELERATED. THE CAR HAD TO COAST OFF THE HIGHWAY AND WOULD NOT RESPOND TO THROTTLE INPUT ONCE STOPPED. CAR WAS TURNED OFF AND ON WHICH RESULTED IN "LIMP" MODE BUT CAR WAS UNSAFE TO DRIVE ON THE ROAD. HAD CAR TOWED TO DEALER AND WAS DIAGNOSED WITH A FAULTY FUEL INJECTOR. CAR HAS 700 MILES ON IT.

NHTSA ODI 10944077