What 301 owners told NHTSA about the 2017 Toyota RAV4 Hv

The contact owns a 2017 Toyota Rav4. The contact stated that while driving at approximately 35 mph, fire was detected near the engine and front of the vehicle. There were no warning lights illuminated. The fire department extinguished the fire. There were no reported injuries, crash,es or air bag deployment. A police report was not filed. The vehicle was towed to an independent towing lot. The contact called the local dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.

NHTSA ODI 11543875

POWER STEERING IS LOCKING UP, NOT WANTING TO TURN.

NHTSA ODI 11541236

Multiple times when coming to a stop the vehicle is stopped and then the brake pedal depresses further on its own while at the same time the engine roars and the vehicle lunges forward about 4 feet. It almost put me in front of oncoming traffic. Also I felt like I had no control over the brakes. It happened 4 times and also did this while I was parallel parking and almost slammed into the parked car ahead of me. It was in the shop last month. The brake calipers were cleaned and the brake lines were bled. This vehicle only has 40000 miles on it. I took it back to Toyota again today to see if they can once again try to figure out what is causing this. When it surges forward it sounds like if your foot was on gas in park, only my foot was on the brake Im afraid to drive it.

NHTSA ODI 11541318

225/65R17. I purchased 4 new tires on 02/24/23. On 6/27/23, I found my driver's rear tire was completely flat. I had the 'donut' put on and took to the dealers. There was a 'bubble' around the rim and the tire was replaced. The dealer explained it was likely due to hitting a curb or pothole which I took exception to as I had done neither. On 7/31/23, my passenger-side rear tire was almost flat and there was again a bubble near the rim. As well the front passenger tire looked mis-shapen. This time, I called a tow truck. The dealer refused to acknowledged that was a manufacturing issue and not a road hazard. Although many Continental tires were recalled, they said this wasn't one of them. They did not contact Continental only their service provider for road hazard. Replacing only the passenger rear tire was not a reasonable option. I chose to replace all 4 tires of another brand rather than fool around with what could be an exploding tire on the highway. Needless to say, no more continental tires for me and I will not use that Toyota dealership again either.

NHTSA ODI 11539820

Side Airbag failure: (all air bags didn't deploy) As I was making a left hand turn, My vehicle was hit in my drivers rear quarter, just behind the gas cap. The impact spun the car over 90 degrees, causing me to hit the left side of my head against the side drivers window, causing a concussion and cervical strain. No airbags in the vehicle were deployed, yet the car was totaled. The car that hit me was traveling at a high rate of speed and the impact totally destroyed that vehicles front end displacing the engine. In my opinion the airbags malfunctioned due to the water damage caused by the rail leaks common to that vehicle (which I had the dealer fix previously). If the airbag in question was operational I would not have hit my head. (yes, I was wearing my seatbelt.)

NHTSA ODI 11537736

Vehicle experienced an unexplained acceleration while at a complete stop with foot on the brake. This has happened several times.

NHTSA ODI 11536606

I was in the third, leftmost, lane on an urban highway coming out of a gentle turn going about 40-45 miles an hour. There was a loud metallic clank or bang and the vehicle pulled sharply to the right. I hit the brakes hard, the vehicle crossed two lanes and came to rest on the shoulder about 18 inches from the concrete barrier, having turned about 170 degrees. There was very little traffic and so there was no accident or injuries but had there been normal traffic it would have been a disaster. There were no indicator lights showing any problem, I examined the tires and underside and could not see any damage. I was able to drive away from the site. I took the car in to my regular Toyota dealer (Toyota of Lincoln Park, they perform all my service) and they test drove it, examined it closely, checked the computer, and could find nothing wrong. No other parties have examined the car. However, I would be afraid to drive it and need to dispose of the car without exposing anyone else to what might happen.

NHTSA ODI 11535758

The contact owns a 2017 Toyota Rav4. The contact stated while driving 65 MPH, the contact struck a sign on the side of the road causing front-end damages to the vehicle and the air bags did not deploy. The contact suffered a major injury to the chest from the seat belt and back pains where she was taken to the hospital and had to seek physical therapy. A police report was not filed. The vehicle was towed to the dealer that stated that the damages were not severe for the air bags senor to deploy. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 48,408.

NHTSA ODI 11532765

I was slowing at a stop sign and the car suddenly accelerated. My foot was not on the gas pedal but it continued to accelerate causing and accident at an intersection.

NHTSA ODI 11531426

Even when properly aimed, with new headlight bulbs, visibility is poor at night. I recently had an incident while driving in town at less than 25 miles hour where I almost hit a deer that I could see on the side of the street, and this is actually not the first of many such incidents. I feel unsafe driving the vehicle at night due to the poor amount of light put out by the headlights. Toyota should offer to retrofit these with LEDS for people with issues. It's downrigtht scary, especially on poor lit streets or driving on the highway.

NHTSA ODI 11527506

Vehicle surges when accelerating since it was new. Throttle goes dead where engine idles but now power at all. Does it from a standing start, does it on hills and when merging onto a freeway. Now it happens on cruise control, when set on 75 mph engine loses power and slows down to 45 for a few minutes then shutters and speeds back up to 75. This past month if you let the fuel get down to 1/4 of a tank it will happen all the time. On interstate this week it happened and slowed to 35 mph and wouldn't go any faster until more gas was added. No check engine light ever. Dealer has checked twice and says no codes found and can't get it to happen it's a intermittent problem. We almost got hit by a semi on the interstate this week week due to this happening and I was unable to get out of his way because I no throttle response at all.... But engine was idling that all. Had to turn the engine off for 45 minutes before it would have any throttle response at all. Drove down the emergency lane to the next exit and filled up with gas. Engine surged for next 60 miles home. This is a huge problem! I am going to my local Toyota dealer tomorrow to talk with them again about this problem. If they give me the run around again I am going to file a lawsuit against Toyota and the dealership!

NHTSA ODI 11524969

la transmisión de mi vehículo presenta ruidos extraños y ala ves se escucha un zumbido qué es bien molestoso perdió fuerza y velocidad también el consumo de combustible es demasiado mi rav 4 solo tiene 40,400 millas corridas es frustrante porqué la marca no a hecho nada para corregir el problema tengo muchos conocidos qué frecuentan el mismo problema

NHTSA ODI 11521058

As I drive about 70 MPH, the ABS and the brake lights come on and the car is momentarily out of control. As I grabbed the tearing and reduce the speed dramatically, the system correct itself and I am able to continue driving at a very low speed.

NHTSA ODI 11520601

A fire occurred in the engine compartment of the vehicle while the vehicle was parked in a garage with the engine off. Fire patterns and physical evidence suggest the fire originated as a result of a high resistance connection between the positive battery terminal and conductor to the power distribution center. The battery is original. The vehicle has not had any repairs beyond normal maintenance. The vehicle was not involved in a crash.

NHTSA ODI 11514101

Car will not start. Doesn't seem to be the battery. Got a jump start but same warning light illuminated.

NHTSA ODI 11509205

Both of my headlights burned out at the same time. I was driving on a rural mountain highway at about 7:30pm and was using my adaptive headlights. They were working fine, I noticed no issues, until they both burned out at the same time. It was dangerous, there was no shoulder to pull over on, and a steep drop-off i couldn't see and no warning whatsoever I'd be in pitch black dark in the middle of the road. Thankfully there was very little traffic, it could have been much worse. My dash camera captured the event and I've shared it to YouTube. https://youtu.be/plJlQYcA8-A No indicator lights ever came on, before or after. I had to drive the last hour to my destination through the mountains in the dark with only fog and running lights. I had been to the dealership for scheduled interval maintenance just the week before. A multi point inspection evidently didn't catch that both headlights were about to go out at the same time. Bulbs? Wiring? Relay? Not sure what happened.

NHTSA ODI 11507169

I WAS DRIVING COMING FROM THE STORE WITH MY GRAND KIDS AND MY TRUCK STALLED ON ME SO I TURNED IF OFF AND TURNED IT BACK ON BUT IT KILLED ON ME AGAIN AND THIS POINT MY GRAND BABY SAID HE SMELLED SMOKE SO I LOOKED UP AND THE HODD WAS SMOKING SO I GOT MY BABIES AND MYSELF OUT THE TRUCK AND RAN TO THE OTHER SIDE OF THE STREET AND THERE I WATCHED MY TRUCK START A FIRE SO I CALL THE POLICE AND THE FIRE PEOPLE , MY TRUCK WAS TOTALED I CONTACTED TOYOTA MAIN OFFICE TO LET THEM KNOW THEY SENTED OUR THEIRE PEOPLE TO LOOK AT THE TRUCK AND DECIDED THAT IT WAS NOT THERE FAULT AND THERE WAS NOTHING THEY COULD DO FOR ME , MY TRUCK CAUGHT ON FIRE I DID NOT SET IT ON MY FIRE MY GRAND KIDS WERE IN THAT TRUCK WHAT WOULD HAVE HAPPEN HAD HE NOT SMALLED SMOED AND IT DID NOT STALL BUT CAUGHT ON FIRE WHILE I WAS DRIVING IT . BUT NO ONE WAS TO DEAL WITH IT YOU WHETHER JUST WALK AWAY WHAT IF WAS SOMEONE IN YOUR FAMILY THEN WHAT

NHTSA ODI 11504621

Vehicle suddenly started to develop shuddering episodes that lasted 2-3 seconds, while driving at low speeds 20-50 MPH and between 1000-2000 RPM. Condition is intermittent, usually when the engine is hot and increasingly becoming worse and frequent. Took vehicle to local Toyota dealer and they diagnosed it with a malfunctioning Torque Converter and recommended replacement. No codes were reported during diagnosis. Toyota dealer mechanic promptly recognized problem as he encountered similar problems with other vehicles of same model. Mechanic reported of a known recall for models from 2009 to 2015, but not for later models. Transmission Control Module was reset by dealer's mechanic and condition improved but not resolved. Owner contemplating replacement of malfunctioning part to avoid catastrophic damages to vehicle's transmission and potential uncontrollable vehicle's behavior while driving.

NHTSA ODI 11504687

This and other year model RAV4s have a known and reported issue of the tail light lenses not being properly sealed with and connected to the tail light housing. This is allowing water intrusion into the tail light and electrical system and vehicle body. This is the case with both of my tail lights on my 2010 RAV4. Water has been entering the tail lights where the lens is not sealed to the housing. The lack of plastic welding / sealant can be seen at the lens and housing. Water is intruding corroding the electronics and electrical connectors as well as portions of the body. The lenses are becoming deteriorated and discolored due to the water intrusion diminishing the effectiveness of the rear lighting. Of course, this is a safety issue as well as the corrosion of the electrical connectors and electronics within the tail light that may cause them to completely fail. Toyota knows of these issues but refuses to address them.

NHTSA ODI 11503036

Went out to the vehicle one day to run an errand and the warning light came on and said Electrical System Malfunction. I took it into the repair facility and was told at first it was the battery then was told no it's the alternator. I remembered I had an extended warranty on the vehicle so I took it into the Dealership. They said it's the Wire Harness and it's not covered due to corrosion. I have put less than 20, 000 miles on this vehicle. This needs to be addressed by the Manufacturer Toyota. I am asking NHTSA to do a recall on this vehicle.

NHTSA ODI 11502679

We owned 2 Toyota cars, highlander and RAV4( this is our second RAV4), we bought both time new, the first one after one year has some break and noise issues and my wife did not like it and we traded and got 2017 RAV4, from her experience, she did not wanted Toyota but different car, though I told her that it has longevity and she should get another Toyota and she agreed and gotten RAV4 2017 new car. However, this RAV4 cars have issues and my wife was right and I was wrong and will never buy RAV4 again. Today, in Portland, there is rain and raining and that small snow also now start melting with the rain, I parked my wife car in our driveway and went in, after lunch came back to drive, saw water was dripping, immediately looked for the sun roof locks, it was completed closed, reach my hand to the place where is the leak is coming, its from headliner areas by driver side where sun visor located. This is 2017 RAV4 with 26k mileage, I drop the car by the dealer where did we bought this car, their tech will be back on Monday, I cannot wait what they have to say for this obvious defect from the factories, I read more about it and there are a lot of this issues with RAV4 and needs factory attention for recall. MY MAIN CONCERN IS NOW: The real danger with this roof leak is not so much cosmetic , the real danger is damage to the airbags over the door and corrosion to the wiring harness, it should warrant recall!!

NHTSA ODI 11498767

I have attached a letter that I wrote Toyota but did not mail. Vechicle is a 2017 Rav Hybrid. We bought it in CA April 2021 and it had 28230 miles. Car went to Renton WA in August, 2021. Vechicle was serviced a couple of times, but in October 2022, dealer gave us a bill for $9700 due to a faulty wire halter. The Toyota people said the car is out of warranty. Please read the letter with lots more details. Thanks.

NHTSA ODI 11496822

The contact owned a 2017 Toyota Rav4. The contact stated that while the wife was driving approximately 35 MPH, the odor of smoke was present inside the vehicle. After stopping to inspect the vehicle, smoke and flames were seen coming from under the hood. The fire department was called to the scene to extinguish the flames. During the incident, the vehicle was destroyed and later towed away. A fire report was taken at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 60,000.

NHTSA ODI 11495352

The door lock actuators failed I was locked out of my car

NHTSA ODI 11494219

While driving at about 55mph on an open highway, the moon roof exploded. There was a loud explosion inside the car by my right ear. The noise was deafening and distracting and caused a momentary loss of concentration on driving, a situation that was very dangerous and could have resulted in an accident with serious injury. I immediately pulled over and checked the tires, the body and underneath the vehicle, finding nothing. When I began driving again, I heard a loud wind noise and other strange noises above me. I started to open the cover of the moon roof, but shards of glass fell on me, so I closed it again. Pulling over again, I climbed on the door threshold to look at the roof of the car. Unbelievable! It looked like a volcano with the glass pointing upwards around a big hole. Toyota Corp. is claiming it was caused by an outside source. That is definitely not true. I was in the car, nothing landed on the roof. The highway I was on has no bridges, no overpass, no multi-story buildings, no schools or no place that would enable someone to drop or throw a large item on top of a car. And, there was nothing on the inside cover except broken glass. The glass on the roof was definitely pointing upwards. The result of my research on exploding roofs shows that this problem has affected multiple car brands and multiple sun/moon roof manufacturers. I'm asking the NHTSA to help protect USA drivers. If there had been a warning that the roof could suddenly explode while I was driving, I definitely would have selected a car without a glass roof. If the cover had not been closed, I would have been sprayed with glass in addition to the loud blast. Because this is a major safety issue, I'm begging the NHTSA to look into the problem and at the very least immediately issue warnings so drivers of vehicles with sun/moon roofs will be aware that this could happen. It would be much better to find out what defect is causing this to happen before anyone is killed! The consumer stated he feels that moonroof exploding should be reinvestigated and deemed as a safety issue.

NHTSA ODI 11491512