What 41 owners told NHTSA about the 2017 Mercedes-benz GLS

Feel unsafe fuel rails and more where recalled in April 2022 Not all gls550 were recalled at the time due to no reason Drive to Florida with my wife and kids and car gave up on the side of a bridge hwy over the ocean We were stuck car smelt like gas and wouldn’t turn on we had nowhere to get out on a 25ft bridge with no ac no emergency lanes with 5 kids all under age of 6

NHTSA ODI 11678641

Vehicle check engine light came on early August 2024. Vehicle was brought in for service and checked for codes. B1F4500 Battery has excessive resistance B21059A The operating conditions of component have not been satisfied. Battery was replaced and rechecked. Po4427A Evap leak detected P04F000 Charcoal canister has a malfunction Smoke tested EVAP system to see if there was any leaks and tested the valves to make sure EVAP system was working correctly. Charcoal canister not actuating correctly so was replaced and checked. Gas cap also replaced Several days later Check engine light returns. Code continues to say "Small leak in the EVAP system." Every time the code is cleared it returns and Check Engine light returns. This has been going on for 7 months. Car cannot obtain the required SMOG inspection in California that is required for an annual registration of the vehicle. I believe the vehicle may need to be part of the Emission Service Campaign 2024030005 which has effected 16 other vehicles. Mercedes tells me that an update to the Engine Control Software will not be allowed because my vehicle is not one of the 16 vehicles that are currently effected by this issue. The issue is for the same make, model and year as my vehicle.

NHTSA ODI 11646348

Fire started in the Engine and consumed the entire vehicle in less than 5 minutes

NHTSA ODI 11619840

Car destroyed by fire on March 19, 2023 while at a quick stop near Chickasaw, OK. Car was last serviced by Mercedes-Benz of Oklahoma City in December 2022. No personal injuries just a total loss of the vehicle. Cause of the fire at present is unknown. Pictures are available.

NHTSA ODI 11513006

Our car, Mercedes GLS 450, caught on fire after pulled into the garage from a short drive on local streets, which resulted a total loss on our house. After pulling into the garage, the home link didn't work when tried to use it to close the garage door. Upon coming out of the car, smoke came out from under the hood and soon after it became flame. We attempted to extinguish the fire with a fire extinguisher as it appeared with hood still closed and fire immediately came back. By the time the firefighters came, there was a full fledged fire. The fire has burned the car beyond recognition and the garage was burned too. The fire and smoke has caused a total loss on our house. There were NO warning lights or warning messages at all before smoke or fire started. Investigators hired by Mercedes Benz inspected the burnt car and concluded the fire was due to a missing oil cap. While questionable the oil cap was the source of the fire, it seems the GLS 450 didn't have a sensor for missing oil cap to trigger a warning light or warning message, which is what some less sophisticated cars have because modern engines have positive crankcase ventilation. If indeed missing oil cap could cause full fledged fire, shouldn't Mercedes put a sensor to warn the customers? There is a recall, see link below, on almost all Mercedes model cars in Jan. 2022 for the reason that the car could catch on fire. Our GLS was built just two months before the starting timeline on the recall and it caught on fire and burned our house. Could it be coincidence or did our car catch on fire due to the exact same reason on this recall? (https://www.forbes.com/sites/zacharysmith/2022/01/04/800000-mercedes-benz-owners-warned-their-cars-could-catch-fire/)

NHTSA ODI 11452172

2017 MERCEDES BENZ GLS450. CONSUMER WRITES IN REGARDS TO MALFUNCTIONING BRAKES. *LD THE CONSUMER STATED THE VEHICLE EXPERIENCED PREMATURE WEAR OF THE BRAKES. THE VEHICLE LEAKED FUEL. THE INTERIOR DOOR TRIM WAS NOT SECURE. *JS

NHTSA ODI 11196350