What 182 owners told NHTSA about the 2017 Lincoln Mkc

Coolant leaks into the engine cause the engine to eventually breakdown and a whole new engine is needed.

NHTSA ODI 11603067

Engine light came on.Noticed some hesitation. Took to the dealer. Was diagnosed as coolant intrusion into engine. Engine could have failed on the highway or exploded. After investigating & seeing other incidents like this on-line, I noticed there were fires & breakdowns that did occur. I called Ford/Lincoln to report. They are aware of issue, but would not cover the repair even though they have been aware of the issue for years. Bought my certified 2017 Lincoln MKC in 2020 with 25k miles with extended warranty; Currently has 68k miles. I had extended warranty thru Feb 2024, and was not aware it had expired. If my warranty was still current & had less than 70k miles, it would have been covered. I believe there should have been a recall on this type of engine. I believe that FORD/LINCOLN is responsible for the repair.

NHTSA ODI 11601467

My engine kept misfiring upon starting and not accelerating while I was driving it. A coolant leak into the cylinder caused the engine to malfunction. I had to replace the entire engine block which cost over $7,000.00. The Ford repairman & service center told me that Ford had issued a service bulletin regarding this issue but then refused to pay for the engine damage. I only have 70K miles on the Lincoln.

NHTSA ODI 11599592

2.0 Ecobooster engine. Coolant started leaking into engine right after an oil change at dealership. Now I need a new engine. I have researched that this is a known engine problem for Ford. We need a recall. I cannot afford a $9,000 repair for something Ford knew about.

NHTSA ODI 11598896

My 2017 Lincoln mkc 2.0 . My mechanic confirmed it has a coolant leak going into the engine. There is a known defect with the 2.0 engine.Which is requiring me to have to purchase a brand new engine with only 33,000 miles warranty expired 2023. The code that was present at the time was p0301. This is a safety concern this vehicle will leave u stranded and in worst case scenario dead because of engine failure. Lincoln should recall the engines on these vehicles!

NHTSA ODI 11598679

In the ecoboost 2.0 models, The engine block has a failure point which Ford is aware of and coolant leaks into combustion chambers and causes misfires, constant loss of coolant, and possible total engine failure. The 1.5L engines were recalled for same exact issue. So far, Ford is unwilling to do anything about this potentially disastrous issue that affects thousands of ford/lincoln owners. Repair costs are over $9,000.

NHTSA ODI 11597899

Coolant leakage into #4 cylinder due to the malfunction of the engine blocks gasket. Yes, the vehicle is available for inspection. I live in the country so if there is a breakdown the possibility of me being stranded on the highway or on some back road would be terrible. Yes, I had a mechanic look it over and confirm, Engine over heated on Saturday, daughter and son came to bring antifreeze and water. Had no idea where the coolant had gone, looked for a leak and found none. 2 days later the engine light came on, had mechanic come out and put code reader on it. The #4 cylinder we replaced spark plugs, 2 days later the engine light came on, mechanic replaced the # 4 coil. Nothing is working.

NHTSA ODI 11595586

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined there was a misfire in cylinder #3, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 71,000.

NHTSA ODI 11592820

Blown head gasket

NHTSA ODI 11591955

A couple weeks after recall of battery monitor sensor and an oil change was done (NHTSA CAMPAIGN ID: 23V378000) at a Lincoln dealership, cylinder 1 had a misfire and check engine light came and has stayed on. The vehicle has 61,000 miles and I am now told, by the dealership, it has coolant intrusion. Again the vehicle was taken to the same Lincoln dealership that did the original work. Research seems to show the 2017 Lincoln MKC has a known issue. Ford has technical service bulletin # 19-2346 released 19 December 2019 and it appears that do not disclose this to avoid fixing under their 6 year or 70,000 mile warranty. They redesigned the 2.0L ecoboost engine in 2020. Our engine could fail and put our 3 year old son at risk of injury.

NHTSA ODI 11591526

Through testing at Fiesta Ford in Indio, CA, it was determined that my 2017 Lincoln MKc had a blown engine which needed to be replaced. Fiesta Ford determined that there was coolant intrusion on cylinder #1. Fiesta Ford then removed and replaced the engine long block assembly and coolant.

NHTSA ODI 11585679

Intermittent P0302 CEL codes fired for Cylinder 2 misfire, over last month. Replaced plugs and coil, Code cleared. Same CEL indicator and code fired again. Symptoms are Rough start up, coolant needing replenishment, took into dealer, coolant intrusion into cylinder 2 requiring engine replacement. This is obviously not an isolated incident with this 2.3L Ecoboost engine, what was know by Ford to flawed during the 2017-2020 period. Two months after purchase of my 2017 MKC, had to have the short block replaced, under warranty, but the head was already warped and they replaced the head gasket on a warped block knowing it was only a matter of time that it started leaking. Now out of the range of that warranty and with looming $8k expense, not happy.

NHTSA ODI 11585213

Car acted like it was overheating. It broke down on the road and did not turn back on. Due to it being broke down on the road the vehicle was towed and now I have an outstanding fee to get it out of impound.

NHTSA ODI 11583730

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at approximately 45 MPH, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic two times where it was diagnosed that there was carbon build-up that might have blocked the valve and needed to be cleaned, and the spark plugs needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken to a dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 65,479.

NHTSA ODI 11583248

2.0L ENGINE FAILURE DUE TO COOLANT IN CYLINDER AN ISSUE THAT FORD is aware. I only see after the fact, of all the numerous complaints in the Lincoln forum. Why has this not been recalled, it so sad that us consumers have to deal with a known problem. Please help us!

NHTSA ODI 11580429

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that when the accelerator pedal was depressed, the vehicle lunged forward and shook. Additionally, the check engine warning light illuminated. The vehicle was taken to an independent mechanic and the contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer several times. However, the failure was unable to be duplicated. The contact stated that the fluids were replenished, and the fuel line was cleaned. The failure reoccurred. The vehicle was taken to another dealer where the failure was diagnosed with a coolant leak and a failed engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised that the repair was not covered under warranty or recall. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 62,500.

NHTSA ODI 11577086

I don’t have the eco boost engine so they told me my car is NOT in the TSB even though I was just told that I need a new engine due to coolant intrusion. I have a ford engine with a defect that caused the problem!! Only MKC’s with eco boost are included. How many people with these ford engines are affected but not included??

NHTSA ODI 11574813

-Coolant intrusion into cylinder heads, causing engine issues and overheating -Requires full long block engine replacement -Known issue by manufacturer, TSB 22-2229, no support to fix outside of warrant -Confirmed by manufacturer, dealer, independent servicer -No warnings prior to issue

NHTSA ODI 11574725

Recently, my 2017 Lincoln MKC has exhibited concerning symptoms that warrant further investigation. Upon starting the engine, I have noticed a slight but noticeable tremor. Though this subsides once the vehicle is in motion, a persistent roughness persists during gear changes, accompanied by the emission of white exhaust from the tailpipe. The situation escalated further with the illumination of the "Check Engine" light. Consequently, I sought professional diagnosis from a certified mechanic. Unfortunately, the diagnosis revealed a significant issue: a broken head gasket leaking into the engine. Remedying this requires a complete engine rebuild. Disturbingly, the mechanic indicated that this problem is not entirely uncommon in Lincolns, and even a full rebuild may not guarantee a permanent solution. I have come across information regarding a class action lawsuit entitled "Reed et al v. Ford Motor Company 2:2021cv00417," which I intend to contact to report my experience and contribute to their investigation. Additionally, I have contacted the original dealership where I purchased the vehicle and am actively exploring all available options to address this concern.

NHTSA ODI 11568747

The contact owns a 2017 Lincoln MKC. The contact stated that coolant was leaking into the engine. Additionally, the brakes were firm while being depressed. The contact stated that the battery was replaced. The check engine warning light was illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact stated that the failure was related to NHTSA Campaign Number: 23V378000 (Engine). The failure mileage was approximately 95,000.

NHTSA ODI 11558910

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11553427

The contact owns a 2017 Lincoln MKC. The contact stated that the vehicle failed to start. There were no warning lights illuminated. The vehicle was started by Roadside Assistance. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 35,040. Parts distribution disconnect.

NHTSA ODI 11550636

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11549800

The contact's wife owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11549658

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (Engine) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11548147