What 300 owners told NHTSA about the 2017 Kia Forte Koup

My vehicle caught fire while driving also before fire vehicle started popping and stuttering rattling sound. I was on highway.

NHTSA ODI 11701841

my life was unsafe by being put in this vehicle whos engine was damaged and caught on fire while driving it as a MILITARY soldier.

NHTSA ODI 11688218

Unknown vehicle just went dead while driving

NHTSA ODI 11676143

Repeated engine failure. 10/1/2022 "internal problem required engine teardown found exhaust cvvt dowel pin had sheared off inside of exhaust camshaft causing excessive play. Replaced exhaust cvvt exhaust camshaft valve cover gasket rtv exhaust cvvt bolt timing chain tensioner timing chain and ocv. Replaced gaskets as needed." Paid $2877.01 to repair. Then on 5/15/2023, loud knocking in engine (sounds like a loose bolt knocking around). Took to dealer and got this quote. "•Exhaust system (Loose Parts, Visible Damage, Leaks) OBD 2 PERMANENT CODE FOR P0420- RECOMMEND CATALYTIC CONVERTER REPLACEMENT $10,106.27 •REPLACE ENGINE - NON ISG $4,232.81" Only has 127k miles and cannot pay this much... $14+k for a car that is worth $4k? Crazy! I question the work that was done in Oct 2022 and also question why it had to be done in the first place. Something is very wrong with this engine. It is available for inspections upon request. My daughter's safety was compromised as she commuted with a car that has a serious engine defects. Problem was diagnosed at dealership. It has been inspected by the Kia dealership. Engine light warning was on which is why my daughter took it to them in Oct. 2022. Came on again in May 2023 and she took it to dealership again as soon as she saw it which was when the knocking began. Link to outrageous quote on May 16, 2024. https://triage-america.superservice.com/home/en-us/customer-authorisation/#/A3zAAy&n2azet;VVM=&sms

NHTSA ODI 11522476

The contact owns a 2017 Kia Forte. The contact stated while driving at 30 MPH, when the contact heard a loud popping noise coming from the vehicle, the contact noticed that when depressing the accelerator pedal the vehicle would not accelerate. The contact saw the check engine light warning light illuminated on the vehicle. The contact had to pull the vehicle over to the side of the road and attempted to restart the vehicle which it did and contact smelled something burning from the interior of the vehicle and noticed smoke coming from the front hood of the vehicle. The contact was able to continue to drive to their work. The contact was able to restart the vehicle after work and continue drive to their destination, however, the failure persisted, The contact check the vehicle later that day and noticed the there was no oil in the engine and a major oil leak underneath vehicle undercarriage. The contact had the vehicle towed to the local dealer to have inspected the vehicle and diagnosed the failure engine sensor was damaged and the fuel pump was damage on the vehicle as well failure where the trunk latch will not open on the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage approximately 75,000.

NHTSA ODI 11433898

I ALREADY FILED A COMPLAINT ON THIS PREVIOUSLY, HOWEVER IN 2020 MY ENGINE FAILED STOP WORKING. AND I WAS UNABLE TO DRIVE IT OR FIX IT. I LOST MY JOB, I HAD TO GET A RENTAL CAR. THE CAR LOST SPEED WHILE DRIVING AND WOULD NOT GO ANYMORE..

NHTSA ODI 11408511

THE 2017 KIA FORTE MY CLIENT WAS DRIVING WAS INVOLVED IN AN ACCIDENT WHICH RESULTED IN MODERATE TO HEAVY FRONT END DAMAGE, APPROXIMATE SPEED OF IMPACT WAS 20-25MPH, THE AIRBAGS DID NOT DEPLOY. *TR

NHTSA ODI 11327763

VEHICLE WAS IN MOTION, SMELLED SOMETHING "OFF", WITHIN SECONDS ENGINE BURST INTO FLAMES. ENTIRE VEHICLE GUTTED. KIA LITERALLY JUST INSTALLED A NEW ENGINE, STARTER, BATTERY, AND INTAKE 2 DAYS PRIOR DUE TO ENGINE LOCKING UP - WITH 22000 MILES.

NHTSA ODI 11123010