What 941 owners told NHTSA about the 2017 Hyundai Santa Fe Hybrid Hev

The contact owned a 2017 Hyundai Santa Fe equipped with a Rockland Electric Mobility Scooter Lifter, Part Number: 10101194. The contact stated that after the mobility scooter lifter was installed on the vehicle, the vehicle experienced electrical failures. The A/C became inoperable, and the hatch opened intermittently. The contact stated that while the vehicle was parked approximately a month after the lifter installation, the alarm sounded intermittently during the day. The contact observed the vehicle from the residence, but did not notice any abnormality. The contact installed the mobility scooter on the vehicle in the evening. The contact stated that the vehicle alarm sounded at night, and the contact noticed that the vehicle had caught on fire and there were flames coming from underneath the hood by the engine and firewall location. The vehicle was significantly burned from the front end to the trunk. The fire was extinguished by the fire department. A fire department report and a police report were filed. There was no property damage. There was no physical injury sustained. The contact sustained mental trauma, causing headaches and the right side of the lip to quiver. The contact had called Gregory Fox, an investigative reporter and anchor at WESH 2 News(NBC), who notified the manufacturer of the failure. The manufacturer followed up with the contact and informed the contact that a third-party investigation would be conducted to determine the cause of the fire incident. The vehicle was towed to a salvage yard, where a third-party investigation was conducted, and the manufacturer informed the contact that the fire was caused by the Rockland Electric Mobility Scooter Lifter. The vehicle was totaled. The failure mileage was approximately 63,000.

NHTSA ODI 11729701

While driving, the vehicle lost its brakes and rolled to a stop on [XXX] at that point the vehicle compartment began to fill up with black smoke and soot and flames started to come out of vents. My daughter immediately grabbed her dog and exited from the vehicle to a safe spot away from the car. Within 10 seconds the vehicle exploded and erupted into a 20 ft fireball. If my daughter would have hesitated she could have been killed. Hyundai inspected the vehicle and found nothing conclusive except that this problem has been documented in other Incidents. The vehicle was declared to be totaled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11636163

Purchased Vehicle 6/2022 has had an electrical problem since day one randomly does not start and must be jumped. I have taken in 2 times only to be told there is nothing wrong. I called Hyundai Corporate to see what steps I should take to resolve issues was told to take car in a third time and again told nothing wrong. A new battery was placed two months after my purchase date. And again this past February and issues still exist. Was given two option should problem not be resolved 1) Buy back vehicle 2) replace with different vehicle. Both options have been withdrawn. Explanation car has been on the road to long. I put $13500 down and have made payments for 2 years. There is still $12000 on the loan. Is there anything I can do to recoup at least my down-payment. I am a senior on social security and a part time job in which i am a caregiver and do not feel safe driving this vehicle. I and do not have a down payment to trade the car in. I do not want the vehicle there are other issues starting and with a parasitic draw there are bound to be additional issues down the road. Can you help please. Expected ResolutionHyundai take car back and return my down payment so I can purchase a reliable vehicle o Additionally just recently discovered vehicle was in 2 accidents which this information was never disclosed. I would not have purchased had I known.

NHTSA ODI 11592250

On June 22, 2023, I went to start my 2017 Hyundai Santa Fe in a shopping center parking lot. I had recently driven from the Pgh airport to Monroeville and stopped to run errands. Upon reentering my vehicle I used the push button start to start the car. The engine started and the center computer screen turned on, however the dashboard did not light up and I was not able to shift into Reverse. I cycled the car ~5 times trying to get it going, but the same start-up happened. Upon calling husband (after trying to start another few times) he recommended that I look at the fuses. At this point I opened the driver side door and was outside looking at the fuse panel. This is when I heard someone shouting from the highway across from the parking lot that my car was on fire. I looked at the rear of my car and saw flames coming from the rear bumper. I quickly stepped away from the vehicle. The entire drivers side of the rear bumper was engulfed in flames. Both the police and fire departments came to the scene. We were collectively able to extinguish the flames and the car was totaled.

NHTSA ODI 11532234

I bought this vehicle and there was a complete break down malfunction due to the ABS module system! This lack of due diligence caused both myself and my 7 year old to unwillingly enter a vehicle that put our lives at risk and a near death experience that still traumatizes my daughter until this day who refuses to enter any vehicle! This is an unfortunate mistake on your end and there is no where near enough compensation that will ever withdraw the fear from my innocent child’s eyes anytime I need to drive her to school, or basketball practice, or anywhere to run our daily errands and live a normal life! I have nothing else to add except I expect compensation for a safe vehicle and compensation necessary to help my child, my innocent child to get through this fear!

NHTSA ODI 11520592

Car began to smoke from engine compartment. Stopped car in a driving lane on interstate 78 where construction barriers had closed both shoulders. Car then burst into flames. Car was a total loss before fire trucks were able to arrive. Just prior to the fire the Warning light for the abs system malfunction appeared on the dashboard.

NHTSA ODI 11503664

This will be my second report to the NHTSA. I was originally told my car needed a new engine, but then it was confirmed that was not the issue since the car started and drove just fine, the recall for the ABS mod was brought up to two different Hyundai dealerships and their corporate office, I requested if it could not be fixed to buy back my car. It was denied. My car then caught fire while driving, resulting in my husband almost dying on the highway. Fire shot from the bottom of the car up into engulfed flames within seconds…and then blew. Determined it was an electrical engine fire. All could have been avoided if Hyundai had just listened to my concerns and checked my ABS. However due their refusal to do so, and refusal to inspect my engine for the recall, my family, kids included were put at risk. It seems to be happening all over the world with these cars and NOTHING is being done.

NHTSA ODI 11476720

My O2 sensor failed and is under my insurance investigation due to engine light that came on and upon inspection it was determined to have caught on fire under the vehicle. My safety and my children's were at risk potentially may have gone up in flames. Currently the insurance is pending review of any recalls for O2 sensor to determine if Hyundai is handling damages. At this time Hyundai has not taken responsibility.

NHTSA ODI 11468965

I went to a drive through car wash. Put my car in neutral and it drives your car through the wash. Once it was done I changed to drive and tapped lightly to get out. I was going to have the car wash attendant wipe down my car. As I approached him my brakes wouldn’t work and the car continued to accelerate despite not pressing down on the gas pedal. None of my electrical lights were working. It took me onto a busy street in Chicago and kept accelerating at full speed. I was trying to brake, put it into neutral or drive, use emergency brake system and nothing was working. I was swerving to avoid hitting other cars or pedestrians. I erratically drove about 1.5 blocks until I hit another SUV. All my airbags deployed. My full trauma work up was negative at the hospital. I am not sure if anyone sustained major injuries in the other car. I filed an insurance claim and my car was deemed a total loss. Insurance company thinks there was definitely an electrical shortage but did not further investigate. They said it would take more money to investigate the cause rather than paying a lump sum for car. I filed a claim case with Hyundai 2 days after the accident. The initial representative said a case manager would call within 5-7 business days and would like the car preserved in case of investigation. I have called over 5 times and have never received a call back nor an initial call from the case manager assigned. There was no active recalls out at the time and the car was serviced a month prior at a Hyundai dealership. Since the accident occurred we received a new recall that the anti-lock brake system could malfunction and cause an electrical short. But according to recall notice there is still no remedy available.

NHTSA ODI 11460464

Smelled smoke at a stop light. Continued when light turned green. Pulled over about 30 car lengths later because smoke was coming in the vents. Jumped out of car and ran. Within 2 minutes, entire front engine was completely engulfed in flames. No indicator light came on before. Car was driving perfect.

NHTSA ODI 11419067

TL* THE CONTACT OWNED A 2017 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED AND UNOCCUPIED. THE FIRE DEPARTMENT WAS PRESENT, EXTINGUISHED THE FIRE, AND STATED THAT THE FIRE INITIATED AROUND THE BATTERY AREA. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT MENTIONED THAT A NEW BATTERY WAS INSTALLED A WEEK PRIOR THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER WAS NOT CONTACTED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

NHTSA ODI 11257848

CAN WAS SITTING FROM 7:00 PM ON 5/2 AND WE WOKE TO FULL ON FIRE FROM REAR OF VEHICLE AT 4:50 AM ON 5/3 - FIRE CO BELIEVES ELECTRICAL

NHTSA ODI 11205494

I BOUGHT THE VEHICLE ON 5/7/16. ON 6/2/16 I WAS DRIVING ON HIGHWAY 395 WHEN I NOTICED SMOKE COMING OUT OF THE ENGINE COMPARTMENT. THE CAR STARTED LOSING POWER AND EVENTUALLY DIED. WHEN I GOT IT PULLED OVER TO THE SIDE OF THE ROAD I NOTICED FLAMES COMING OUT FROM THE FRONT OF THE ENGINE. I GRABBED WHAT I COULD AND GOT OUT OF THE CAR. WITHIN 5 MIN THE FRONT OF THE CAR WAS ENGULFED IN FLAMES. I HAD APPROXIMATELY 675 MILES ON IT. I HAVE CONTACTED HYUNDAI BUT THEY HAVE NOT RESPONDED TO ME. I ORDERED A COPY OF THE POLICE REPORT BUT HAVE NOT RECEIVED IT YET. I HAVE PICTURES THAT I HAVE ATTACHED. I AM CONCERNED ABOUT THIS HAPPENING TO OTHER PEOPLE. THANKFULLY I DIDN'T HAVE GRANDKIDS IN THE CAR, I'M NOT SURE I WOULD HAVE BEEN ABLE TO GET THEM OUT.

NHTSA ODI 10874600