What 842 owners told NHTSA about the 2017 Ford Focus RS

UNSAFE CONDITION: WHILE DRIVING AND ACCELERATING UPON SHIFTING THE ENGINE WILL CONTINUE TO ACCELERATE RIGHT TO THE REDLINE THERE IS NO CONTROL OF THE THROTTLE AT THIS POINT ALSO TRAVELING DOWN THE HIGHWAY I CAN STEP IN ON THE CLUTH AND RELEASE THE THROTTLE AND THE ENGINE WILL ACCELERATE OR MAINTAIN ITS RPM SPEED YOU CAN SHIRT TO NEUTRL AND COAST TO THE CURB AND IT WILL MAINTIN THE ENGINE SPEED WHEREVER IT DECIDES ON AGAIN THERE IS NO CONTROL OF THE THROTTLE I HAVE BEEN TO THE FORD DEALER TWICE NOW 1ST TIME THEY COULD NOT DUPLICATE SECOND TIME AGAIN THEY COULD NOT DUPLICATE THEY HANDED ME A SHEET STATING IT WAS NORMAL FOR THE ENGINE RPM TO MAINTAIN FOR A FEW SECONDS DURING SHIFT TO EASE THE SHIFTING AND MATCHING OF TRANSMISSION SPEED THIS IS AN UNSAFE CONDITION, WHEN YOU RELEASE THE THROTTE IT SHOULD CLOSE IMMEDIATLY AND RPM SHOULD RETURN TO BASE IDLE. I HAVE BEEN AN ASE CERTIFIED MASTER AUTO AND TRUCK TECHNICIAN FOR 33 YEARS. I HAVE SIT DOWN WITH THE SERVICE MANAGER AND THE GENERAL SALES MANAGER AND I DONT THINK FORD MOTOR COMPANY OR THE DEALER IS TAKING THIS MATTER SERIOUSLY SOMEONE IS GOING TO GET HURT HERE PLEASE HELP

NHTSA ODI 11089313

CLUTCH PEDAL LOSES PRESSURE/SPRING AND GOES TO FLOOR LEAVING VEHICLE IN GEAR AND VEHICLE STALLS WHEN DRIVING - DID THIS ON A HIGHWAY TWICE WHEN ATTEMPTING TO SHIFT GEARS. VERY DANGEROUS AS IT ALMOST CAUSED A BAD ACCIDENT ON THE HIGHWAY AT ALMOST 70MPH. VEHICLE LUCKY MADE IT TO THE SIDE OF THE ROAD COSTING IN AFTER STALLING WHEN CLUTCH WOULD NOT RETURN TO ITS NORMAL STATE. DEALERSHIP NOT ABLE TO REPRODUCE ISSUE BUT ISSUE IS INTERMITTENT AND I FEAR IT COULD CAUSE A SERIOUS ACCIDENT AS IT CAUSES THE CAR TO STALL WHEN THE CLUTCH GOES TO THE FLOOR AFTER LOSING PRESSURE ALL OF A SUDDEN WHEN VEHICLE IS STILL IN GEAR - IT WILL STALL OUT. SEEMS TO BE A POPULAR ISSUE AMONG MANY OTHER 2016-2017 FORD FOCUS RS VEHICLES. OTHERS REPORTED ISSUE WAS FINALLY RESOLVED BY REPLACING MASTER AND SLAVE CLUTCH CYLINDERS. SIMPLY BLEEDING LINES AND/OR REPLACING CLUTCH AND/OR FLYWHEEL DOES NOT RESOLVE ISSUE. FORD NEEDS TO RESEARCH AND ISSUE A RECALL ASAP AS THIS IS LIFE THREATENING BECAUSE THE VEHICLE WILL STALL OUT WHEN THIS OCCURS.

NHTSA ODI 11088509

STOPPED AT TRAFFIC SIGNAL, BEGAN ACCELERATION AND VEHICLE BECAME SLUGGISH AND CLUNKY, REVVED HIGH AND WOULD NOT SHIFT PROPERLY. SHIFTED IN AND OUT OF GEAR WITH PERIODS OF PROLONGED HESITATION. TRANSMISSION FAULT SERVICE NOW WARNING SOUND AND DISPLAY. CAME TO A STOP AT THE NEXT SIGNAL AND CAR LURCHED FORWARD IN SEVERAL JUMPING MOTIONS AND WAS DIFFICULT TO CONTROL BEFORE COMING TO A COMPLETE STOP. CAR HAS 5900 MILES WHEN THIS OCCURRED. CAR TOWED TO DEALER WHERE PURCHASED, SERVICE "CLEARED CODES, PERFORMED ADAPTIVE LEARN AND TEST DRIVE, CODE P2701-TCM STATES TO REMOVE CLUTCH AND INSPECT FOR WEAR" WHICH WAS NOT DONE. SERVICE FOUND VEHICLE NOW IS "OPERATING AS DESIGNED" AT THIS TIME. IF CODE RETURNS TECH WILL REMOVE CLUTCH FOR FURTHER DIAGNOSIS. PICKED UP VEHICLE AND WITHIN 20 MILES DRIVING SAME CODE RETURNED AND SYMPTOMS WERE WORSE THAN 1ST TIME, NOW WITH 5980 MILES ON VEHICLE. THE VEHICLE WAS IN MOTION WHEN THESE PROBLEMS OCCURRED AND WAS VERY DANGEROUS WHILE DRIVING AS THERE WAS NO CONTROL OVER ACCELERATION, SHIFTING OR STOPPING. VEHICLE WAS TOWED BACK TO THE DEALERSHIP FOR SERVICE AT TIME OF WRITING THIS DESCRIPTION.

NHTSA ODI 11081017

JANUARY 2018 I WAS STOPPED AT A RED LIGHT (SR 99- LAKE STEVENS, WA / SPEED LIMIT 55 MPH) WHEN I WAS REAR ENDED BY A HYUNDAI ELANTRA TRAVELING ABOUT 45 MPH, I WAS STRUCK FROM THE REAR AND PUSHED INTO THE CAR IN FRONT OF ME (NISSAN PATHFINDER). HOWEVER, MY AIRBAG DID NOT DEPLOY AFTER THE REAR (1ST) OR THE FRONT (2ND) IMPACT.THE DAMAGE TO MY VEHICLE WAS EXTENSIVE ($10K). AS A RESULT FROM THE ACCIDENT I AM CURRENTLY IN CARE FOR MULTIPLE DISC BULGES IN THE CERVICAL SPINE.

NHTSA ODI 11074123

DRIVING CAR , CHECK ENGINE LIGHT CAME ON AT 5800 MILE, SCAN TOOL STATED CODE P0340 AND P0344, REPLACE CAM SENSOR. CLEAR CODES, DROVE CAR 3 DAYS 5980 MILE ,CHECK ENGINE FLASH COUPLE TIME AND STAY ON STARTED SMELL OIL AND SOUND LIKE IT WAS MISFIRING, SCAN IT AGAIN AND IT SAID CODE P0340 AND P0344, CALLED DEALER BOB BELL FORD GLEN BURNIE MD. TOLD ME NEXT OPENING FOR APPOINTMENT WOULD BE WEEK 1/2 , I SAID OK. TOOK CAR THERE, THEY CALLED AND SAID THERE A HOLE IN PISTON # 4 , NEED NEW ENGINE AND NOT COVER UNDER WARRANTY BECAUSE OF MODIFICATION, I ASK WHAT MODIFICATION AND THEY SAID CALL FORD MOTOR, WE DON'T HAVE ANY PAPER WORK. CALLED FORD MOTOR CUSTOMER SERVICE , THEY SAID CALL BOB BELL. COMPLETE RUN AROUND.

NHTSA ODI 11065568

DRIVING DOWN INTERSTATE 97 AT 65 MPH SHIFT TO 6 GEAR AND CLUTCH PETAL STUCK TO FLOOR, SMELL OF CLUTCH BURNING , PULLED TO SIDE OF ROAD TURNED CAR OFF. REACH DOWN AND TRY TO PULL CLUTCH PETAL BACK UP AND IT WOULD NOT COME BACK UP. WAITED 30 MIN, TRY AGAIN, COULD NOT PULL IT UP. CALL FOR TOW TRUCK.. CALL BOB BELL FORD SERVICE DEPT. THEY STATED IT A WEAR PART AND IT WAS NOT COVER BY WARRANTY, I TOLD THEM WITH ONLY 1896 MILES ON IT, THEY STATED AGAIN IT A WEAR PART. I CALL FORD CUSTERMER SERVICE AND THEY GAVE ME A COMPLAINT NUMBER AND GOT BACK WITH ME AND THEY SAID NOT COVERED IT A WEAR PART.

NHTSA ODI 11065569

I BUY A 2017 FORD FOCUS SE. ON SEPTEMBER 2017 THE ENGINE LIGHTS TURN ON, I LEAVE THE CAR IN GREENFORD EAST COLONIAL TO FIXED. NOW ON DECEMBER THE ENGINE LIGHT TURNS ON AGAIN. I DON'T WANT A CAR THAT I HAVE TO LEAVE ON GUARANTEE TO FIXED THE ENGINE LIGHT. I DON'T WANT THIS LEMON CAR. I WANT THE RELEASE OF THIS CAR TO BUY OTHER BRAND NEW CAR. THE CAR RUNS , BUT IS A NEW CAR AND IT'S NOT SUPPOSED THAT HAPPEND

NHTSA ODI 11053864

CAR FAILS TO SHIFT INTO GEAR WHEN ACCELERATING, CAR WILL NOT 'GO' IN SOME INSTANCES WHEN THE GAS PEDAL IS PUSHED, 'GRINDING' NOISE COME FROM ENGINE WHEN SHIFTING GEARS, WILL HESITATE OR 'SHUDDER' WHEN YOU ACCELERATE, RPM'S WILL GO VERY HIGH IN THE 7000 RANGE BEFORE SHIFTING INTO GEAR, WILL FAIL TO GO INTO GEAR WHEN SHIFTING FROM REVERSE TO DRIVE AND CAR WILL CONTINUE TO ROLL BACKWARDS UNTIL YOU STOP AND IT FINALLY FINES A GEAR. HAVE PULLED OUT FROM A SPOTLIGHT, 4-WAY OR FROM A PARKING LOT AND CAR WOULD NOT GO. THIS HAS CAUSED US TO ALMOST BE REAR-ENDED SEVERAL TIMES. THIS HAS HAPPENED TO BOTH MY HUSBAND AND I. HAD TO PULL OVER ON THE SHOULDER OF AN ENTRANCE RAMP WHEN ATTEMPTING TO GET ON HIGHWAY BECAUSE THE CAR WOULD NOT SHIFT AND GO. THIS ISSUES ARE A HAZARD AND WE HAVE TAKEN IT IN 3 TIMES TO TWO DIFFERENT DEALERSHIPS AND THEIR RESPONSE IS THEY CAN'T DUPLICATE THE CONCERN. WE BOUGHT THE VEHICLE AT THE OF MARCH 2017 BRAND NEW AND IT HAS BEEN IN THE SHOP AND NOT IN OUR POSSESSION FOR A TOTAL OF 25 DAYS SO FAR. WE WILL NO LONGER PUT OUR CHILDREN IN THIS CAR FOR THE FEAR OF BEING INJURED OR KILLED. DEALERSHIP HAS NEVER PROVIDED US ANY TYPE OF PAPERWORK AND WE HAVE A CURRENT CASE WITH CORPORATE, BUT THEY REFUSE TO HELP IN ANY WAY UNTIL THEY GET A DIAGNOSIS OF SOME KIND.

NHTSA ODI 11039921

AS I AM DRIVING AND THE CAR WANTS TO SHIFT GEARS THE TRANSMISSION SLIPS A BIT. THERE IS A LAG FOR THE TURBO TO KICK IN. WHEN STOPPED AT A STOP LIGHT THE ENGINE TURNS OFF WHICH IS NORMAL, BUT WHEN YOU LET GO OF THE BRAKE FOR THE ENGINE TO START BACK UP, THE CAR JUMPS AS IT I JUST PUSHED THE GAS PEDDLE. THIS RECENTLY HAS STARTED TO HAPPEN. I BROUGHT THIS TO THE ATTENTION OF A DEALERSHIP WHERE MY CAR IS SERVICED BUT THEY CAN'T FIND THE ISSUE AS TO WHY.

NHTSA ODI 11039629

WHILE DRIVING THE CAR ON I395 SOUTH, THE CAR SUDDENLY STALLED AND WOULDN'T NOT START BACK UP. HAD IT TOWED TO THE CLOSEST FORD DEALER AND IT TURNED OUT TO BE A FUEL BUMP FAILURE.

NHTSA ODI 11039162

THE CROSS TRAFFIC ALERT SYSTEM IS NOT WORKING CORRECTLY, THE DEALER HAS HAD THE CAR FOR A MONTH AND A HALF, FORD TOLD THE DEALER THEY NEW THE PROBLEM BACK IN FEBURARY 2017, I BOUGHT THE CAR IN JUNE 2017, THIS IS A SAFETY ISSUE FOR THE CAR AND FORD TOLD THE DEALER THAT THEY TURNED OFF THIS FEATURE FOR AN UNKNOWN REASON, I PAID FOR THIS EXTRA FEATURE AND THEY STILL SOLD THE CAR KNOWNING THIS FEATURE WASN'T WORKING

NHTSA ODI 11034025

THE LEFT REAR TIRE LEANS IN AT TOP 2-3 DEGREES. DEALER CHECKED, IT SHOWED OUT OF CAMBER/ALIGNMENT, BUT WAS "WITHIN SPECS". AT UNDER 1200-MILES, TIRE IS ALREADY SHOWING UNEVEN INSIDE TREAD WEAR. DEALER KNOWS BUT REFUSES TO CORRECT IT UNLESS FORD AUTHORIZE. I FOUND THIS ON FORD WORLD; "FORD MOTOR COMPANY TOLD DEALERS THAT THEY MAY NEED TO REPLACE THE REAR UPPER CONTROL ARMS ON FORD FOCUS MODELS. THE MODELS INCLUDE: FOCUS SEDAN SE SERIES, WAGON, ZX3 AND ZX5 SERIES. ACCORDING TO FORD, CONSUMERS HAVE BEEN EXPERIENCING MORE THAN NORMAL WEAR TO THE INSIDE OF THE REAR TIRE(S). SHOULD OWNERS EXPERIENCE SUCH A CONDITION, THEN THEY SHOULD BRING THEIR VEHICLE IN TO A FORD OR LINCOLN MERCURY DEALERSHIP FOR A POSSIBLE ADJUSTMENT. FORD WILL CHECK THE REAR CAMBER AND, IF POSSIBLE, MAKE AN ADJUSTMENT. IF AN ADJUSTMENT TO THE VEHICLE'S REAR CAMBER IS NECESSARY BEYOND THE NEGATIVE END OF SPECIFICATION, THEN THE DEALERSHIP WILL NEED TO SOURCE REPLACEMENT REAR UPPER CONTROL ARM(S)." THE FORD MOTOR COMPANY PARTS SERVICE KIT REQUIRED FOR THIS REPLACEMENT IS 3S4Z-1A154-AA. FORD WILL PERFORM THE REPLACEMENT OF PARTS UNDER PROVISIONS OF THE BUMPER TO BUMPER WARRANTY UNDER TSB T31305. THIS IS CONSIDERED A "SILENT RECALL" WHERE UPON FORD MAY NOT NOTIFY OWNERS OF THIS CONDITION. OWNERS SHOULD CONTACT (313-322-3000) AT FORD WORLD HEADQUARTERS OR CLICK HERE FOR A FORD EXECUTIVE ASSIGNED TO YOUR AREA."

NHTSA ODI 11033134

A/C VENTILATION IS PRODUCING A MUSTY/ MOLDY SMELL, I HAVE OWNED THE CAR FOR ONLY 4 MONTHS, THE ODOR IS STRONG, AND MAY BE DANGEROUS AS MOLD GROWTH MAY SEEP THROUGH VENTS AND INTO ONES AIRWAYS. I AM CONCERNED FOR MY HEALTH, ALONG WITH WHO EVER ENTERS THE VEHICLE. PLEASE INVESTIGATE THIS FURTHER. INTERNET RESEARCH AS ALLOWED ME TO VIEW VARIOUS IDENTICAL CASES WITH MOLD ODOR & A/C VENTS ON FORD VEHICLES, THERE MIGHT BE AN ISSUE AT FORD MANUFACTURERS. THE ISSUE MAY OCCUR AT ANY TIME BUT IS MORE PROMINENT WHEN TURNING ON THE A/C.

NHTSA ODI 11019332

BRAND NEW FOCUS ELECTRIC, LESS THAN 3 DAYS OLD FROM DEALER ON 8/17/2017. FOR THE LAST TWO DAYS, I HAVE DRIVEN LESS THAN 100 MILES. CAR WAS CHARGED OVERNIGHT AND SHOWS FULL CHARGE THIS MORNING. I DROVE THE CAR LESS THAN 30 MILES TODAY. IN THE EVENING, WHEN I WAS DRIVING, THE CAR SUDDENLY LOST POWER AND THE ENGINE STOPPED SUDDENLY ON THE ROAD. THE CAR WAS IN STEADY SPEED ON A CITY STREET IN A STRAIGHT LINE. I WAS NOT ACCELERATING. I WAS NOT BRAKING. ALMOST GOT HIT BY A CAR BEHIND ME. I WAS UNABLE TO RESTART THE CAR. BATTERY STILL SHOW 80 MILES CHARGE. INDICATOR WARNING SHOWS: "STOP SAFELY WARNING LAMP" AND "ELECTRIC MOTOR WARNING LAMP". ALL INTERIOR LIGHTS ARE BRIGHT WHEN THE CAR DOOR IS OPENED, IT DOES NOT APPEAR THAT THE BATTERY CHARGE IS LOW. ALSO THERE IS NO WARNING OF "LOW BATTERY" BEFORE THE CAR SUDDENLY LOST POWER. I ALSO NOTICED WHEN I TURN OFF THE "POWER/START BUTTON", THE "INFORMATION AND ENTERTAINMENT DISPLAY/GPS" STAYED ON. EVEN AFTER I HAVE CLICKED THE "LOCK" BUTTON ON THE REMOTE CONTROL KEY. AFTER PRESSING THE "POWER/START/STOP" QUITE A NUMBER OF TIME AND SWITCHING BETWEEN THE TWO KEYS, THEN THE "DISPLAY CENTER" FINALLY TURN OFF. WE HAD TO CALL ROADSIDE ASSISTANCE TO HAVE CAR TOWED.

NHTSA ODI 11016442

TL* THE CONTACT OWNS A 2017 FORD FOCUS. THE CONTACT STATED THAT WHILE THE VEHICLE WAS OPERATED, THERE WAS ABNORMAL NOISE COMING FROM THE VEHICLE AND IT FAILED TO PROPERLY SHIFT WHEN DRIVING UP AN INCLINE. THE CONTACT ALSO STATED THAT THE VEHICLE EXPERIENCED HESITATION WHILE BEING OPERATED ON AN INCLINE. THE VEHICLE WAS TAKEN TO LENIORE CITY FORD DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS REFERRED TO THE NHTSA HOTLINE. THE FAILURE MILEAGE WAS APPROXIMATELY 1,500.

NHTSA ODI 11006697

THIS WILL BE MY SECOND COMPLAINT, AS I HAVE A COMPLAINT # CAS-12526659-Q7S5M2 WITH FORD BUT I AM BEING TOLD THAT THIS IS HOW THE CAR IS. ACCIDENT WAITING TO HAPPEN. CAN NOT SEE SPEEDOMETER DURING DAYLIGHT HOURS OR DUSK OR DAWN.

NHTSA ODI 11004684

THE TACHOMETER AND SPEEDOMETER HAVE A AUTO DIM AT NIGHT TIME . CAN NOT READ SPEEDOMETER AT DUSK OR DAWN WHEN DRIVING UNDER OVERHEAD LED STREET LIGHTS THAT LEAVE GLARE ON WINDSHIELD. AUTO DIMMER HAS NO ADJUSTMENT TO BRIGHTEN PAST CERTAIN BRIGHTNESS. LIGHTS IN OTHER FORD VEHICLES WORK DIFFERENTLY THEN FOCUS AS BOUGHT 2017 ESCAPE AND DOES NOT HAVE THIS PROBLEM

NHTSA ODI 11000318