What 1,671 owners told NHTSA about the 2017 Ford Explorer Police Intercept

VEHICLE STARTED JERKING, SO TOOK IT TO FORD AFTER SCHEDULING AN APPOINTMENT AND STILL COULDN'T GET IT SEEN. CLERK SAID IT NEEDED TO STAY OVERNIGHT BUT WILL NOT GIVE ME A LOANER SO LET ME LEAVE WITH THE SAME CONDITIONS. THE VEHICLE STOPPED MOVING FORWARD OR IN REVERSE AS I ENTERED A PARKING GARAGE, SO TOWED IT BACK TO DEALERSHIP TO ONLY FIND OUT THAT THE TRANSMISSION IS BLOWN AND WILL COST $7K TO REPAIR. THE VEHICLE IS A 2017 WITH 75,000 MILES, BOUGHT NEW AND WITH NO ISSUES UNTIL NOW. CLERK STATED IT IS OUTSIDE POWER-TRAIN WARRANTY OF 5 YEARS 60,000 MILES. HOWEVER THIS IS A KNOWN ISSUE WITH FORD AS THEY ARE GOING THROUGH A LAWSUIT NOW DUE TO THEIR TRANSMISSIONS BUT WILL NOT FIX THE ISSUE.

NHTSA ODI 11282406

FAILURE OF THE HEATER CORE RESULTING IN THE RELEASE OF A FINE MIST OF ANTIFREEZE INTO THE PASSENGER COMPARTMENT AND FOGGING UP THE INSIDE DRIVERS WINDOW WHILE DRIVING DOWN AN INTERSTATE. VISIBILITY REDUCED TO ZERO THROUGH THIS WINDOW. FAILURE OCCURRED AT 37.8K MILES ON THE VEHICLE. REPAIR COST $1,722.00 TO OWNER.

NHTSA ODI 11281122

TL* THE CONTACT DRIVES A 2017 FORD EXPLORER POLICE VEHICLE. WHILE THE VEHICLE WAS STATIONARY, SMOKE APPEARED UNDER THE HOOD. THE VEHICLE WAS PUSHED OUT INTO AN OPEN PARKING LOT WHERE IT CAUGHT FIRE. PRIOR TO THE FIRE, THE CONTACT HEARD A LOUD NOISE. THE CONTACT STARTED TO EXTINGUISH THE FIRE UNTIL THE FIRE DEPARTMENT ARRIVED TO FINISH THE JOB. POLICE AND FIRE REPORTS WERE FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO VILLAGE FORD (23535 MICHIGAN AVE, DEARBORN, MI 48124, (313) 565-3900) WHERE IT WAS CURRENTLY BEING INVESTIGATED. THE CONTACT THAT THE FUSE PANEL MAY HAVE MELTED AND CAUSED THE FIRE AFTER RESEARCHING OTHER VEHICLES OF THE SAME YEAR, MAKE, AND MODEL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000. *LN*JB CONSUMER WAS TOLD THAT VEHICLE WAS A TOTAL LOSS. VEHICLE WAS SENT TO HIS COMPANY'S ATTORNEY FOR A POSSIBLE REPLACEMENT VEHICLE. *DL

NHTSA ODI 11280833

ROOF RACK RAIL CAP DEPARTED THE VEHICLE WHILE ON THE FREEWAY.

NHTSA ODI 11280848

TL* THE CONTACT OWNED A 2017 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. PRIOR TO THE FAILURE, THE BATTERY SPONTANEOUSLY EXPLODED AND WAS REPLACED. THE VEHICLE WAS TAKEN TO ANGELA KRAUSE FORD (1575 MANSELL RD, ALPHARETTA, GA 30009, (770) 649-5100) WHERE THE CONTACT WAS INFORMED THAT THE BATTERY ACID WAS NOT CLEANED UP PROPERLY AND CORRODED EVERYTHING UNDER THE HOOD, INCLUDING THE BRAKE LINE. THE VEHICLE WAS NOT REPAIRED. THE INSURANCE COMPANY STATED THAT THE VEHICLE WAS A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

NHTSA ODI 11280392

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 45-70 MPH, THERE WAS AN ABNORMAL EXHAUST ODOR IN THE VEHICLE. THE CONTACT BECAME NAUSEATED AND SUFFERED HEADACHES WHILE THE VEHICLE WAS BEING OPERATED. MEDICAL ATTENTION WAS NOT RECEIVED. THE VEHICLE WAS TAKEN TO JACKY JONES LINCOLN (2407 BROWNS BRIDGE RD, GAINESVILLE, GA 30504, (800) 835-5249) TO BE DIAGNOSED, BUT THE CAUSE OF THE ODOR COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT PAYMENT WOULD BE MADE TO THE LOCAL DEALER TO SEAL ANY OPENINGS IN THE EXHAUST AND ENGINE COMPARTMENTS IN AN ATTEMPT TO REMEDY THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

NHTSA ODI 11279775

EXHAUST AND CARBON MONOXIDE COMING INTO CABIN OF CAR. FORD SAID THEY FIXED THE ISSUE WITH TSB17-0044, BUT THAT HAS NOT FIXED THE PROBLEM. MY WIFE AND I GET DIZZINESS AND THE KIDS COMPLAIN OF THE SMELL AND HEADACHES.

NHTSA ODI 11277173

VEHICLE LOSES ACCELERATION, STALLS AND SHAKES WHEN AT A STOP. JERKS WHEN BACKING UP. VEHICLE HAS BEEN TO FORD TWO TIMES. FIRST TIME REPLACED THROTTLE, AND SECOND TIME UNABLE TO DUPLICATE ERROR. CURRENTLY WILL BE PICKING UP VEHICHLE FROM SHEEHY FORD ASHLAND IN VA. THIS IS EXTREMELY UNSAFE

NHTSA ODI 11276949

HERE WAS A PROBLEM WITH THE TRANSMISSION STALLING HAD THE TRANSMISSION REPLACED AT 44000 MILES.

NHTSA ODI 11271187

2017 FORD EXPLORER: ALL 4 ORIGINAL EQUIPMENT TIRES (HANKOOK 255/50 R20 105H VENTUS S1 NOBLE 2) EXPERIENCED ACCELERATED TREAD WEAR. TREAD DEPTH IS DOWN TO 4/32 AT 30,000 MILES.

NHTSA ODI 11270403

THERE WAS A PROBLEM WITH THE TRANSMISSION STALLING AND LATER THE MOTOR MOUNTS HAD TO BE REPLACED VEG ONLY HAD 62,000 MILES ON IT. THE POWER TRAIN HAPPENED SEVERAL MONTHS BEFORE THE PROBLEM WITH THE MOTOR MOUNTS

NHTSA ODI 11270237

THE VEHICLE HAS 34,450 MILES ON IT AND WAS PURCHASED OCT 1 2016 BUT IS A 2017 MODEL. THE STEERING FAILED ON OCTOBER 13TH WHILE I WAS IN ESTES PARK COLORADO. THE VEHICLE HAD SEVERAL ISSUES JUST PRIOR TO THE FAILURE WITH A WARNING THE TRACTION CONTROL HAD STOPPED WORKING FOLLOWED BY A HILL START ASSIST FAILURE AND THE STEERING LOSS STOP SAFELY. I'VE ATTACHED PICTURES OF THE WARNINGS. THIS FAILURE OCCURRED 14 DAYS AFTER THE 36 MONTH WARRANTY ENDED. THANKFULLY I HAD PARKED THE VEHICLE JUST PRIOR TO THE STEERING FAILING AS I WOULD HAVE BEEN DRIVING DOWN A POTENTIALLY DANGEROUS MOUNTAIN CANYON WITHIN THE NEXT 10 MINUTES. THE FORD DEALER THUS FAR HAS REFUSED TO COVER THE REPAIR TO THIS KNOWN ISSUE WHICH IS A SERIOUS SAFETY ISSUE.

NHTSA ODI 11268884

HANKOOK VENTUS S1 NOBLE 2 TIRES, SIZE 255/50/R20/105H FOR FORD EXPLORER 2017 WORE OUT UPON INSPECTION. MILEAGE WAS UNDER 21, 000 AND TIRE THREAD WAS REALLY BAD. NEEDED TO BE REPLACED. DEALER SAID IT WAS MY RESPONSIBLITY. HANKOOK TIRES ARE SUPPOSED TO LAST FOR 50,000 MILES. THESE TIRES SHOULD BE RECALLED. DEALER WAS ABLE TO PAY FOR 60% OF TIRES AND REPLACED WITH NEW ONE, HOWEVER, I HAD TO PAY FOR 40%. RIDICULOUS NEVER HAVE I PAYED FOR NEW TIRE WITH A LEASED CAR. WILL NEVER DO BUSINESS WITH FORD. THIS IS A SAFETY HAZARD, TIRES NEED TO BE RECALLED, NOTICED SAME TIRES ON BRAND NEW FORD EXPLORER 2020. DEALERSHIP HAS PICTURES ETC.

NHTSA ODI 11267897

I WENT OUT TO MY CAR THIS MORNING TO GO TO WORK AND FOUND THAT THE REAR WINDOW OF THE VEHICLE HAD SHATTERED. IT SEAMS LIKE IT MAY HAVE ORIGINATED FROM WHERE THE WIPER GOES THROUGH THE REAR GLASS. I KNOW THAT IT WASN'T BROKEN BY ANYONE BECAUSE I HAVE SECURITY CAMERAS. THE VEHICLE WAS PARKED IN MY DRIVEWAY.

NHTSA ODI 11267847

WHILE DRIVING AT SLOW SPEEDS (25 TO 40 MPH) THE STEERING WILL FEEL LIKE IT IS "BINDING UP" SLIGHTLY WHEN TURNING. THIS WILL NOT HAPPEN EVERY TIME SO THE DEALER WAS UNABLE TO DUPLICATE IT. ALSO AFTER DRIVING ON THE FREEWAY IN A STRAIGHT LINE FOR A LONG PERIOD OF TIME, WHEN YOU TURN THE WHEEL SLIGHTLY I WILL FEEL THAT SAME BINDING. IF YOU PUSH THROUGH IF IT GIVES WAY AND THEN ACTS NORMALLY. FEELS LIKE THE CARS STEERING GEAR BOX HAS A GEAR LOOSE OR A GEAR IN MISS ALIGNING INTERNALLY. WE BOUGHT THE CARE WITH 15K MILES ON IT. WE NOTICED THE PROBLEM AT AROUND 20K AND IMMEDIATELY TOOK IT TO THE DEALERSHIP WHERE THEY WERE NOT ABLE TO RECREATE THE PROBLEM. THE CAR NOW HAS 30K MILES ON IT AND THE PROBLEM IS GETTING WORST.

NHTSA ODI 11267350

PURCHASED 2017 FORD EXPLORER DECEMBER 2017 WITH ORIGINAL HANKOOK VENTUS S1 NOBLE2 255/50R20 105H TIRES. HAVE 17,000 MILES AND HAVE BEEN ROTATED AT EACH OIL CHANGE; BEEN HAVING EXTREME TREADWEAR AND WAS TOLD BY THE AUTHORIZED DEALER THAT ITHE TIRES ARE BAD AND NEED REPLACED. DEALER SUGGESTED TO CONTACT HANKOOK DIRECTLY BECAUSE OTHERS HAVE EXPERIENCED SIMILAR ISSUES. I CONTACTED HANKOOK CUSTOMER SERVICE AND WAS TOLD THAT THE TIRES ARE BAD BUT THEY HAVE TO BE 4/32 TO GET A PRO RATED DISCOUNT, AT THIS TIME I HAVE 1-3/32, 2- 4/32 AND 1- 5/32, THE FORD DEALER WOULD NOT HONOR THE NEW CAR WARRANTY BECAUSE THEY SAID IT ISN'T A SAFETY ISSUE AND HANKOOK NEEDS TO TAKE CARE OF IT. MEANWHILE, NO ONE WANTS TO TAKE FULL RESPONSIBILITY FOR THESE BAD TIRES AT ONLY 17000 MILES, EVEN THOUGH THE EXPLORER IS RATED ON TOP FOR ROLLOVERS WITH A BLOWOUT... THIS IS ANOTHER DANGEROUS ISSUE SIMILAR TO THE FIRESTONE DISASTER. ARE THEY GOING TO WAIT UNTIL THERE ARE DEATHS BEFORE THEY START REPLACING THESE DEFECTIVE TIRES?

NHTSA ODI 11267139

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE TRAVELING ON THE HIGHWAY AT AN UNKNOWN SPEED WITH THE CRUISE CONTROL ENGAGED, IT SUDDENLY DISENGAGED ON ITS OWN. THE FAILURE CAUSED THE VEHICLE TO BRAKE ON ITS OWN AND SWERVE FROM SIDE TO SIDE. SAYVILLE FORD (5686 SUNRISE HWY, SAYVILLE, NY 11782, (855) 561-1191) STATED THAT THE LEASING MILEAGE LIMIT WAS EXCEEDED, BUT THEY WOULD NOT COVER THE COSTS. THE MANUFACTURER PROVIDED THE SAME INFORMATION AS THE CONTACT. THE CONTACT ALSO MENTIONED THAT THE BATTERY EXPLODED, BUT THE DEALER DISMISSED THE CONCERNS AND STATED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 50,000.

NHTSA ODI 11266806

THE CRUISE CONTROL AT MY SPEED OF 65 MPH STOPPED ALONE CAUSE THE CAR TO BREAK MAKING ME LOOSE CONTROL, 2ND THE VOICE COMMAND DON'T WORK OR RESPONDING, TO HELP NAVIGATION OR PHONE PERPOUSE ( DON'T USE CELL WHILE DRIVING) AROUND DECEMBER 2018 BRING TOTHE ATTENTION OF THE DEALER AT SERVICE AND THE MISS. KENYA AFTER I PICK THE CAR SHE MANSION THAT THE RESET TO THE MANUFACTURE DAY WAS RELASED , BUT THE PROBLEM CONTINUE AS TODAY 10/07/2019 ON JUNE THE BATTERY EXPLODED, AND THANK GOD HOW NO BODY GET INJURY. THE CAR IS LEASING FOR 3 YEARS , ALL PROBLEM STARTS DECEMBER 2018 , PLUS THEARE IS A RECALL, AND FORD SAYVILLE IN 5686 SUNRISE HGWY , SAYVILLE, NY 11782 631 567-3800. REFUSE TO REPAIRE THE ISSUES, CLAIM THE CAR IS MILE COVERAGE IS OVER, BUT THE PROBLEM STRAT BEFORE PLUS ALL THIS IT'S MANUFATURE ISSUES, PLEASE HELP ME.

NHTSA ODI 11266910

I HAVE HANKOOK TIRES ON MY FORD EXPLORER. BOUGHT IT NEW WITH THESE. LESS THAN 25,000 MILES AND THEY LOOK TO BE TEARING UP ALL OVER. HANKOOK SAYS THERE'S NO WARRANTY ON THEIR TIRES. TECHNICIAN SAYS I NEED THEM CHANGED RIGHT AWAY OR THEY WILL 'BLOW OUT.' *JS

NHTSA ODI 11266310

HAVE A NOISE ON FRONT PASSENGER SIDE SUSPENSION

NHTSA ODI 11258696

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH FOR TWO HOURS, AN ABNORMAL ODOR WAS PRESENT INSIDE THE VEHICLE AND THE CONTACT BEGAN TO FEEL DIZZY. THE CONTACT MANAGED TO DRIVE HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

NHTSA ODI 11258273

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING 65 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE DECELERATED TO 20 MPH. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. CONTACT STATED CAR WOULD NOT PICK UP SPEED AND LOST POWER. THE VEHICLE WAS TAKEN TO HERTRICH FORD LINCOLN (LOCATED AT 1427 BAY RD, MILFORD, DE 19963, (302) 725-0031) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 29,177. *BF

NHTSA ODI 11258062

I PURCHASED A 2017 FORD EXPLORER LIMITED SUV AT THE WINNIPEG,CANADA FORD 4S (MID-TOWN FORD SALES LIMITED ) IN JULY 2017. TIRE MODEL: 255/50R20 105H VENTUS S1 NOBLE 2. IT WAS FOUND THAT THE FOUR TIRES ABRASION MORE SERIOUS THAN OTHER VEHICLES UNDER NORMAL USE. IT WAS DISCOVERED THAT THE FOUR TIRES OF THE CAR HAD DIFFERENT PEELING SKIN PHENOMENA, AND THE TIRES HAD A SLOW LEAKING AIR PHENOMENON IN JULY 2019. AFTER THAT, I NEED TO REPLENISH THE AIR OF TIRES 2-3 DAYS REGULARLY IN ORDER TO KEEP THE TIRE PRESSURE. I CONTACTED THE MID-TOWN FORD SALES WHERE WE BOUGHT THE CAR AFTER DISCOVERING THIS PROBLEM, UNFORTUNATELY, THEY SAID THAT THEY ARE NOT RESPONSIBLE FOR THE TIRE, AND LET ME CONTACT HANKOOK TIRE MANUFACTURERS TO FEEDBACK THE PROBLEM BY MYSELF. I HAVE TRIED TO CALL THE HANKOOK CUSTOMER SERVICE SEVERAL TIMES FROM JULY, BUT THERE IS NOBODY ANSWERS. I ASKED THE LOCAL HANKOOK DEALERS IN WINNIPEG, THEY TOLD ME THAT I CAN ONLY GET FEEDBACK WITH HANKOOK HEADQUARTERS. NOW I FEEL THAT THE SKIN PEELING OF TIRES ARE GETTING MORE AND MORE SERIOUS WHEN DRIVING EVERY DAY. I AM WORRIED THAT THE TIRE WOULD BE BURST EVERY TIME WHEN I AM DRIVING. I SEARCHED ON THE INTERNET THAT THE TIRE HAD BEEN HAVING PROBLEMS FOR A LONG TIME. NHTSA ID NUMBER: 10127409 SSM: 46905. I DON'T KNOW WHY I HAVE NEVER RECEIVED A RECALL NOTICE FROM FORD. WHEN I WENT TO FORD 4S(MID TOWN FOR SALES), THEY SAID THAT THEY DID NOT HAVE ANY CLUE, THEY DID NOT ANYTHING ABOUT THIS ISSUE, AND ASK ME TO I CONTACT HANKOOK, BUT THEY DID NOT GIVE ME ANY CONTACT INFORMATION FOR THE HANKOOK. THERE IS NO CLEAR CUSTOMER SERVICE PHONE ON HANKOOK OFFICIAL WEBSITE. I AM SO DISAPPOINTED AND I DON'T KNOW HOW TO SOLVE THIS PROBLEM.

NHTSA ODI 11257254

EXHAUST IS COMING INSIDE THE CABIN CAUSING ME TO HAVE HEADACHE AND SOME NAUSEA,,DRIVING DIFFERENT TIMES ,,UP HILLS AND SPEEDING UP,

NHTSA ODI 11257130

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION) AND TOOK THE VEHICLE TO BE SERVICED AT VIVA FORD (5550 N DESERT BLVD, EL PASO, TX 79912, 915-834-2800). AFTER THE VEHICLE WAS SERVICED, THE CONTACT STATED THAT THE MIDDLE OF BOTH REAR TIRES BEGAN TO WEAR ON THE TRACTION. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS INFORMED THAT THE TIRE WEAR WAS NOT RELATED TO THE RECALL. THE CONTACT SPOKE WITH THE SUPERVISOR WHO AGREED TO PAY FOR THE REPLACEMENT TIRES AND OFFERED A FREE ALIGNMENT. THE DEALER SWITCHED THE TWO FRONT TIRES AND PLACED THEM IN THE REAR OF THE VEHICLE. THE DEALER THEN PLACED TWO NEW TIRES ON THE FRONT END OF THE VEHICLE. AFTER THE REPAIR WAS PERFORMED, THE CONTACT'S WIFE DROVE THE VEHICLE OUT OF STATE. UPON REACHING HER DESTINATION, SHE NOTICED THAT THE SAME FAILURE OCCURRED AGAIN WITH THE REAR TIRES. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 18,000.

NHTSA ODI 11256253