What 1,671 owners told NHTSA about the 2017 Ford Explorer Police Intercept

Windshield trim panels have come off vehicle while driving in normal conditions. This includes the factory installed drivers and passengers side moldings as well as numerous replacement pieces. Local dealership states there are no issues with components.

NHTSA ODI 11539540

I had a piece of window trim fly off while I was driving on the highway at 70 mph. When it flew off, it may have hit another car. With the piece gone, I am not unable to open the hatch and the dome lights stays on for a considerable amount of time. There is no way to turn off the dome lights, you have to wait for them to go off, which is sometimes more than 10 minutes. When the piece was replaced, the hatch worked as normal. I had the window trim replaced and the same thing happened. I was traveling down the highway over 70 mph and the piece flew off in heavy traffic. I, again, have not been able to open the hatch nor turn off of the dome lights.

NHTSA ODI 11539307

WATER PUMP FAILURE. ENGINE LIGHT CAME ON. BY THE TIME I COULD PULL OFF THE FREEWAY (1 MINUTE) THE ENGINE HAD STALLED AND THE CAR WOULDN'T START. TOWED TO REPAIR SHOP AND LEARNED THE PUMP FAILURE HAD ALLOWED WATER AND OIL TO MIX THROUGHOUT THE ENGINE. METAL SHAVINGS WERE FOUND IN THE ENGINE. ENGINE HAD TO BE REPLACED. TOTAL COST BEFORE THE VEHICLE WAS READY: OVER $11,000

NHTSA ODI 11539317

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the front passenger’s side windshield pillar fractured. The dealer was notified of the failure and the contact was given an estimate for the repair. The manufacturer was also notified of the failure and the contact was informed that the vehicle was not covered under recall or warranty. The contact also noticed that the front driver’s side pillar had also become loosened. The vehicle was not repaired. The failure mileage was approximately 76,000.

NHTSA ODI 11539138

I noticed that I had to refill the coolant/water on my car because it was low. When I got out of my work I noticed there was water on the floor, but I didn't think of anything because my car was doing fine. When I was almost home I noticed the car fans were like trying to compensate for the heat, but when I look at my dash. My car was overheating with the engine light. I parked it and noticed the water I put this morning was all gone and the car was still leaking. Come to find out it was the water pump and the engine.

NHTSA ODI 11539028

Windshield trim became detached while driving 70 mph on the freeway.

NHTSA ODI 11538692

2017 Ford Explorer with 114,000 miles. Engine coolant light came on while driving. The car was taken to a Ford Dealer and diagnosed with a failed water pump. As the water pump is installed inside of the engine this is now a major repair and if not caught early, can cause permanent damage to the engine. This failure can cause the engine to stop leaving you stranded. Currently having the engine repaired at Ford Auto Nation in Tustin Ca.

NHTSA ODI 11538399

The driver's side window trim blew off, striking the side of my car and hitting a car passing me. Also - the piece that holds the keypad on the driver's side has come off once, tried to come off a 2nd time and is currently being held in place by a binder clip.

NHTSA ODI 11538166

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 10 MPH and making a right turn, the steering wheel did not return to center. The contact stated that the steering wheel failed to respond normally while turning the steering wheel to center. Additionally, the contact stated that the instrument cluster went black, and the vehicle stalled. The contact pulled over safely and restarted the vehicle. The contact stated that the “System Communication Error" message was displayed on the infotainment screen after the restart. The contact later had the vehicle towed to a local dealer, where it was diagnosed and determined that the wiring harness and the GWM harness needed to be replaced. The vehicle had been repaired. The contact stated that after the repair, the battery had started to drain very quickly. The vehicle was towed back to the same dealer but was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was 43,833.

NHTSA ODI 11537949

The contact owns a 2017 Ford Explorer. The contact stated while starting the vehicle, the vehicle was shaking violently. The contact stated that the engine failed to turn over after several attempts while starting the vehicle. There was an abnormal rotten and sulfur odor entering the cabin of the vehicle from the front end of the vehicle. The vehicle was overheating with the check engine warning light illuminated. The catalytic converter had failed due to oil leaking from the turbo charger onto the catalytic converter. The contact was informed that the catalytic converter and turbo charger needed to be replaced. The vehicle had not been repaired. The contact became aware of NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer was not made aware of the failure. The approximate failure mileage was 155,000. The consumer is requesting that their VIN be included in the recall that applies to the turbo charger failure. The vehicle has not been repaired.

NHTSA ODI 11537960

Power steering locked up during a drive around the block, had to turn off the engine and turn it back on. After the car was running again, no issue. If this issue persists or comes back again, drivers aside from myself will be put in danger on the road as the steering can lock up anytime during the drive. I was lucky enough to only have it happen during a short drive around the block.

NHTSA ODI 11538022

I bought the SUV Used in January/2023 from a Ford dealer. It had brand new tires on it. 6 months later and the outer tread of the tires are bald, that’s when I realized the toe angle was pointed in. I went to Discount Tire to get new tires and an alignment. They put new tires on and then they told me they couldn’t do the alignment on my truck because it has a recalled part on the rear suspension. The toe angle rods are not adjustable. He showed me what they are supposed to look like on his computer for him to do the alignment. He then proceeded to tell me how dangerous it was because if the rod cracks, my wheel will fall off. I called ford, but they are claiming there is no recall for that part, but that can’t be true.

NHTSA ODI 11537761

Passanger side pillar broke off while traveling about 60mph. Hit window and almost hit a motorcycle traveling in adjacent lane. Looking for a replacement online and found several forums requesting it to be reported for a possible recall.

NHTSA ODI 11537366

PASSENGER SIDE WINSHIELD TRIM FLEW OFF GOING DOWN THE ROAD

NHTSA ODI 11537448

The trim surrounding the windshield on the passenger side detached and flew off at high way speeds. While no vehicles were close enough to be impacted by this part of the vehicle detaching, it could create a hazard had there been a vehicle close by. I have seen evidence that this is prevalent on this year, make, and model and it should be remedied. There was no evidence that this would happen and it occurred randomly while driving ~70 MPH.

NHTSA ODI 11536866

The contact owns a 2017 Ford Explorer. The contact took the vehicle to a dealer for routine maintenance and was informed by the service technician that the water pump was leaking coolant into an engine cylinder. The contact was provided an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.

NHTSA ODI 11537007

While driving on the interstate at speed of around 65mph, plastic piece that is mounted between windshield and passenger side door detached and flew into following traffic

NHTSA ODI 11536654

The contact owns a 2017 Ford Explorer. The contact stated while driving 35 MPH and attempting to accelerate uphill, the vehicle lost motive power with difficulty while shifting gears. After a visual inspection, the contact observed excessive amounts of fumes coming from the exhaust. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that the engine was extremely low on oil due to excessive oil consumption. Additionally, the turbocharger had failed. The vehicle was then taken to the dealer, and the diagnostic test result was confirmed. The vehicle was not repaired. After investigating the failure, the contact related the failure NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer was notified of the failure but was unable to provide any assistance. The failure mileage was 103,000.

NHTSA ODI 11536057

The drivers side windshield trim molding A-pillar flew off of my 2017 Explorer on the highway, hitting my rear view mirror and startling me causing me to veer. The Ford dealer body shop has ordered a new one at $547 for the part, but it still has not come in I ordered both sides as the passenger side is very loose. They are sharp and present danger of injury and/or property damage when they fly off. I saw on-line that this is a common problem for this model. The consumer stated that the repair was completed, however promptly after the repair work, the same piece broke off again. The vehicle was returned to the dealer where they reinstalled the piece and added urethane.

NHTSA ODI 11535777

Coolant was found to be infiltrating cylinders 2 & 3 of the engine. The engine was idling roughly and just about died before the check engine light came on. The service center did a pressure check and used a bore scope to confirm that there was coolant in the cylinders. My understanding of this problem is that the engine begins to misfire as coolant and oil mix and the cylinder walls start and other components deteriorate. When deterioration is bad enough the engine can quit. This can happen at any time including at high speeds on the highway. I'm not totally sure how long the rough idling had been going on, but the incident where the engine almost died and the check engine light came on was at about 80,000 miles. My guess is that the rough idling started around 70,000 miles -- give or take. Ford has not yet done a diagnostic teardown to determine how the coolant is infiltrating the cylinders, but it is a known problem for other sizes of the Ecoboost engine. I have the 2.3L Ecoboost. There was a recall on the 1.6L Ecoboost and there is a class action lawsuit for the 1.5L, 1.6L, and 2.0L versions of the engine.

NHTSA ODI 11535354

2017 ford explorer. Driving down the interstate and the window trim around front window starts flying off. It’s completely dry rotted. No warning, have not taken it to the dealership because they charge $150 just for diagnostic.

NHTSA ODI 11535185

Heard a flapping noise from the upper drivers corner of the windshield at highway speed. Stopped before anything catastrophic occurred, but part of the drivers side windshield trim was loose and flapping in the wind. It was striking the drivers window and the windshield as it flapped back and forth. The stiffer cover piece was also loose, but removing the flapping piece of trim resolved the immediate concern. The trim apparently needs replacement.

NHTSA ODI 11535270

The passenger side of windshield trim flew off on highway when driving. There was no indication or evidence that it was loose or coming off.

NHTSA ODI 11534749

The water pump went bad which cost me 1500 dollars and the shop whom done it had replaced 15 water pumps on the exact make and model car as mine this year!

NHTSA ODI 11534879

The vehicle would not properly accelerate while depressing the accelerator pedal. Additionally, the vehicle would not properly shift gears while attempting to accelerate. The vehicle was taken to an independent mechanic who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 60,000.

NHTSA ODI 11534582