What 1,669 owners told NHTSA about the 2017 Ford Explorer Gas

Transmission torque converter attempts to lockup when vehicle is in gear, at idle and brakes applied. This causes the engine rpm to drop or stall. This causes an unexpected delay and hesitation when accelerating from a stop followed by an unexpected acceleration surge. This issue has been confirmed by an independent service center. No computer codes or warning signals on the dash are present.

NHTSA ODI 11749549

This has happened several times where the transmission will not go into drive and makes an electronic noise while trying to shift into drive. If you turn the car off, open the driver's door, wait for complete power down then restart the vehicle, it will then go into drive. Sometimes it just takes one attempt, sometimes several. Seems to be a computer malfunction similar to a recent recall but for different year explorers.

NHTSA ODI 11747883

I’ve had three transmissions replaced from 2023 to 2026. Ford no longer makes 2017 Ford Explorer transmissions so I keep getting bad parts. In 2026 engine light came on , coolant leaking into cylinders, $11K to fix. This car has left me stranded on the side of the road , not to mention months at the dealership trying to find transmission parts. Ford Corporation refuses to buy back vehicle based on lemon law. Rear seatbelts defective.

NHTSA ODI 11740383

The contact owns a 2017 Ford Explorer. The contact stated that while driving 60 MPH on the highway, the vehicle hesitated and stalled. No warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 176,000.

NHTSA ODI 11733322

My 2017 Ford Explorer suddenly started vibrating intensely whenever I am at a stop or start slowing down. Episodes of hesitation when attempting to take off from a start with significant rpm surges. I am told I need to have my torque converter replaced. My vehicle has 84,697 miles on it, and was bought brand new from a dealer. I already had to have a new engine a month ago. This level of multiple engine and powertrain failures puts consumers and other drivers at risk for harm on the roadway. Not to mention the economic and employment impacts it has on the vehicle owners.

NHTSA ODI 11731706

I purchased 2017 ford explorer from Mark Ficken. It was still under warranty. The transmission went out in a week something with the torque converter. They replaced the transmission free of charge. Two years two months outside of the warranty the transmission fails again due to the torque converter. I explained how ridiculous this was and they gave me a discount for replacing the transmission which I still had to pay thousands of dollars. Another two years and two months later outside of the warranty and the tourqe converter is bad again. Since they helped the last time they could not help again. They said it was normal wear and tear which is impossible because normal wear and tears on the same part within the same time frame is a faulty transmission period. I will NEVER purchase another vehicle from them as they wouldn’t even acknowledge that was a problem. This experience with Ford has been horrible. This Ford dealership took no accountability and the corporate division didn’t seem to care that this dealership allows stuff like this to happen with the Ford name. I ended up taking my vehicle to a outside mechanic, he replaced the fly wheel, that repair lasted about 6 months until fly wheel has now broken again with in 3 months. Now my mechanic is saying he will no longer honor the warranty on the fly wheel because he keeps having to replace it too much and he insists that ford knew something else was going on with the vehicle and its not normal to have to replace this many transmissions and fly wheels with in this time frame. Has anyone else had this problem?

NHTSA ODI 11729682

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly vibrated and shifted in and out of gear with the transmission warning light illuminated. The contact stated that the vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 106,135.

NHTSA ODI 11727502

The car was up on ramps, to replace a sensor, in park and slipped out of gear rolling backwards with force. Someone could have been under or behind the vehicle. Other vehicles could have been behind, property could have been damaged. The cars door caught the building and pulled it all the way back against the front fender.

NHTSA ODI 11724328

Vehicle was brought to an authorized Ford dealership for coolant leak. The dealer confirmed a coolant leak originating from the internal water pump. The water pump on this engine is chain-driven and located inside the engine behind the timing cover, requiring approximately 12 hours of labor to access and replace. This is a known design defect affecting millions of Ford vehicles with the 3.5L Cyclone/Duratec engine across multiple model years (2007-2020). The defect allows coolant to leak past the bearing seal, with potential to mix with engine oil and cause catastrophic engine failure. This is a serious safety risk as failure can occur without warning while driving. The problem was confirmed and documented by the Ford dealership. No warning lights appeared prior to the leak being discovered. Repair cost exceeded $4,300. This defect was the subject of a federal class action lawsuit (Roe v. Ford Motor Company, Eastern District of Michigan) which was settled confidentially in January 2024 without a recall being issued. Ford has not notified owners of this known defect or offered any remedy program to US customers, despite a Canadian class action resulting in relief for affected owners there. I am providing the cost invoice but will provide an itemized invoice once repairs are finished.

NHTSA ODI 11723964

When i start the vehicle, and press the bbrake and shift into drive, the vehicle shakes and jolts. When I remove my foot from the break to push the gas petle, there is a hesitation/stall out unless I push it quickly. The shaking and jolting occurs when the vehicle is in drive and reverse, but stops when the car is in neutral or park. In order to operate the vehicle in traffice, I have to put it in neutral at stop signs and traffic lights, or it will shake, jolt and stall out. This can not be safe!

NHTSA ODI 11695739

On [XXX] as I stopped at the stoplight my car started to shake/shudder when it was green I started to drive and it stopped. Then when I stopped again while in drive I experienced the same thing. Contacted the dealership where I've been servicing my car since I bought it. I was hoping they could take in that day but they were booked. Next available was July 17, 2025. They did a diagnostic on my car and said it was the motor mounts. Had to order the parts and will call when parts are in. Parts came in and it was scheduled. Took them all day and even after shop closed to put the motor mounts on. When I picked it up I was told it was still shaking/shuddering but not as bad. Told me to take it home and see. Called them back to bring it back in due to shaking/shuddering, they did another diagnostic this time its my torque converter. Total with parts and labor $2819.19 plus tax. I started doing some research and found this was a common problem for my type of car. It's on Fords customer satisfaction 20N07. My car fall meets all that is required. Contacted Ford multiple times and was turned down saying there was no recall for mines even though it was manufactured at that specific plant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11679578

intermittened starting problems, vechile wont start, clicks, then starts and power train light comes on. Waiting at a red light, press the gas and the car does not go, also when speeding up transmission slips.

NHTSA ODI 11677550

The contact owns a 2017 Ford Explorer. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. In addition, while driving at undisclosed speeds, there was an abnormal sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that on a separate occasion, while driving 40 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle jerked before slamming into gear. The check engine warning light was continuously illuminated. Additionally, the vehicle was leaking oil onto the ground and the engine was consuming an excessive amount of engine oil. The vehicle was taken to an independent mechanic who diagnosed the vehicle with coolant intrusion into a cylinder, which caused the engine failure. The spark plugs were replaced. The mechanic also informed the contact that the transmission had failed. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred contact to the NHTSA Hotline to report the failure. The failure mileage was 52,590.

NHTSA ODI 11676807

Delayed in transmission in gauging when going down hills especially going up them and causing vibration slowing down while vehicle moving.This is Ford Explorer XLT model 2.3 motor type 6 Speed automatic VIN:[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11674662

I periodically have unintended acceleration ; it has occurred off and on for the past two years . The Ford dealer said no faults were detected so they can't fix the problem . It most often when I am shifting into reverse then the RPMs increase dramatically and when I put it in neutral they shoot up even more . A few days ago I was putting the car into the garage , waiting for the door to open , with my foot on the brake and the shift in drive when the RPMs started to increase . Feeling the car starting to move I shifted to neutral when the RPMs shot up tremendously . This is a dangerous situation where someone can get injured or killed . Ford should be able to correct the problem !!!

NHTSA ODI 11666226

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and approaching a stop, the vehicle briefly jump and jolted. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 50,000.

NHTSA ODI 11665841

The transmission has totally failed at under 69,000 miles while my wife was driving down a 45 MPH road. The vehicle intermittently lost power and she was nearly rear-ended with my child in the car. All warning lamps came on and the engine totally lost power. 2 shops have looked at the car and stated that the transmission failed completely. There were no warning lamps prior to this occurring.

NHTSA ODI 11665073

The contact owns a 2017 Ford Explorer. The contact stated while driving 65 MPH, the vehicle made an abnormal whining sound. The message to "See Owner’s Manual" was displayed with a wrench symbol. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate, nearly causing a crash. The contact was able to pull over to the side of the road. The contact stated that upon shifting from park(P) to drive(D), the vehicle failed to respond. The vehicle was towed to Matt's Repairs, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the vehicle could not be covered because the vehicle was out of warranty. The failure mileage was approximately 97,000.

NHTSA ODI 11658548

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the vehicle made an abnormal clunking sound, went into LIMP Mode, and failed to exceed 25 MPH. The check engine warning light was illuminated. The contact shifted to reverse(R), but the vehicle failed to respond. The contact called the independent mechanic whom the vehicle was purchased from, but no assistance was provided. The vehicle was taken to a local dealer, where it was diagnosed with catastrophic transmission damage. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. There was no warranty coverage on the vehicle for the failure. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 145,000.

NHTSA ODI 11652789

In November of 2024 my 2017 Ford Explorer XLT began to vibrate and shake immensely when put into drive or reverse. The vehicle was taken to repair shop to diagnose the problem, and I was informed that the codes came back as a FORD recall for a torque converter. The vehicle was taken to Karl Flammer Ford in Florida for another diagnostic and I was informed that there was NO RECALL for a torque converter failure from the Chicago plant where my vehicle was manufactured. Ford Motor Company issued a Customer Satisfaction Program 20N07 for engine and 6F35 transmission, also CSP 20B27 in October 2020. It states that: "this program extends the warranty coverage of the automatic transmission torque converter for (12) months from the RO date of Powertrain Control Module reflash under Customer Satisfaction Program 20B27 (I bought vehicle 2/2021). It also states that: "the vehicles covered by this program are Ford Explorers 2016-2019 from assembly plants Louisville and Chicago, build dates Sept. 29, 2014 through March 3, 2019. However, FORD is not honoring the Customer Satisfaction Program. Basically, I bought a vehicle from a dealership with an existing Power Train problem that could have been repaired under an out of date recall (failure to disclose). My vehicle is now inoperable at 80,000 miles and I have to spend $6,500 for a new transmission that should be covered through FORD. Shame, Shame. This major issue needs to be RECALLED at this point.

NHTSA ODI 11651337

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds and depressing the accelerator pedal, the transmission skipped gears. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the torque converter had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 95,000.

NHTSA ODI 11648075

Passenger seatbelt frayed, inside electrical goes haywire when cold weather, transmission slipping was rebuilt under warranty lasted one week and is slipping again shifting hard, B panels falling off A panel was recalled but panel wasn’t?

NHTSA ODI 11647199

Transmission is not shifting correcting. Will be traveling down the road and loses power, loses it's acceleration. When trying to proceed after making a stop at a light, car will not go. Bucks hard when putting in reverse. I heard there was a recall on the torque converter's awhile back, but I never received any notification about it. Now that I know, the ford dealerships are telling me there are no recalls for this.

NHTSA ODI 11636279

The transmission stops switching gears after going 70 mph on the highway no acceleration was possible Just stopped working. I had my kids with me I had a tractor trailer behind me and in front of me and beside me on a very busy highway going 70 mph and the transmission just stopped working no gas was it was just redlining when it was supposed to be accelerating no gears were reached I had to throw it in park throw it back into sports mode they're back into drive they're back into sports mode they're back in the drive before it kicked in and would go all while in the middle of a busy highway and not able to get off the road and declining in speed. The manufacturer or Ford did purchase the vehicle from me and made me roll over my negative equity from that car into a new car was my only option or paying 10 grand to get it fixed. Nothing no lights were displayed no lights came on at all no warning signs nothing Just happened. When I took it in to get it looked at the mechanic immediately told me that I need to trade the car in and that I shouldn't have this vehicle it's transmission has been having multiple issues over four times in one year it was in the shop for transmission issues they told me nothing was wrong and they drove my car 200 mi they gave it back to me not even two weeks later this happened no lights and nothing was pulling on the codes The mechanic Harper from Malloy Ford is the one that told me that I should need to trade it in he contacted the Ford company they offered $2,000 to help with the cost to get the car fixed but it wasn't going to fix the problem from happening again and it was traumatizing to have to go through that with my kids I didn't want to put my kids back in that vehicle because we literally could have died. PLEASE REACH OUT WITH ANY ADDITIONAL QUESTIONS with my phone or email .. THE CAR HAS HAD TRANSMISSION ISSUES SINCE I BOUGHT IT.THE DEALERSHIP REFUSED TO TAKE THE CAR BACK AFTER I PURCHASED IT TO PUT ME IN SOMETHING ELSE

NHTSA ODI 11630775

I have a 2017 Ford Explorer with a water pump that needs replacing per a Ford dealership. It has 59K. It should last at least 150k. There should be a recall as there are thousands of these vehicles with the internal water pump. Apparently it's a problem if they are no longer making them internal. I want to file a complaint and would like some type of compensation.

NHTSA ODI 11628265