What 2,628 owners told NHTSA about the 2017 Ford Escape Gas

I am filing this complaint due to repeated and dangerous safety-related failures in my Ford vehicle involving both the transmission and engine. Prior to a transmission recall repair, my vehicle experienced severe drivability issues, including sudden jerking while driving, loss of power on the highway, unexpected stopping, and shutting off at traffic lights. These incidents nearly caused multiple accidents and placed me and others at serious risk. The transmission was later replaced under recall by a Ford dealership. After that repair, I am now experiencing a major engine failure related to coolant intrusion. This defect is well documented by Ford in Technical Service Bulletin (TSB) 22-2322, which supersedes TSB 22-2134. The bulletin states that to resolve the condition, the engine short block and head gasket must be replaced. This effectively requires replacement of the core of the engine and confirms the severity of the defect. The symptoms associated with this engine issue overlap with the drivability symptoms I reported earlier (stalling, loss of power, unsafe operation). The vehicle was previously evaluated by a Ford dealership while this bulletin was already published, yet the engine defect was not identified or addressed at that time. Despite Ford’s acknowledgment of this defect through its own bulletin, I am being denied assistance and left responsible for an extremely costly repair involving what is essentially a partial engine replacement. This defect poses a serious safety risk due to the potential for sudden engine failure without warning. I am concerned that Ford is failing to proactively address a known safety-related defect and that similar vehicles remain on the road with the same risk. I believe this issue warrants further investigation to prevent serious injury or loss of life.

NHTSA ODI 11715214

Engine suffered coolant intrusion known design defect on ford escape 1.5 L engines. Needs engine replacement.

NHTSA ODI 11715298

Unknown. There's a white puff of smoke that comes out on a cold start every time. There is a small loss of coolant as well that I have to replace regularly. I was already told by the dealership to get rid of the car because it would need a complete engine fix that would cost 7000 to 10,000 dollars. It started doing this at 92k miles. The car was well maintained with regular oil checks and all maintenance recommended was done in a timely manner. All of the symptoms point to coolant intrusion.

NHTSA ODI 11715370

The contact owns a 2017 Ford Escape. The contact stated that while driving at 35 MPH, the vehicle hesitated while depressing the accelerator pedal. The low oil warning light was illuminated on the instrument panel prior to the failure. Despite the failure, the contact was able to drive to the residence. An independent mechanic inspected the vehicle and determined that a faulty wire connected to the spark plug had caused the failure. The dealer was notified of the failure, and the contact was informed that there were no recalls on the VIN for the failure. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 28,000.

NHTSA ODI 11714185

My wife had driven the car, it had given an error and I tested it for a code. The Code was PO304 Cylinder 4 Misfire detected. We scheduled a maintenance appointment with our local Ford dealership to have them look at this error and address a recall. We were informed that "coolant and freezant were leaking into cylinder #4!" The mileage is ~150300 and the vehicle has been serviced regularly. Prior to the Engine light on/code on, there have been no indication there was a problem. I am now reading about other 1.5L Escapes that have this same recall but mine was not included? This doesn't make sense, it's the same problem with the same motor that was manufactured in other facilities, with the same parts, and those engines were recalled but mine wasn't?? just fix my engine guys!

NHTSA ODI 11714228

Engine failure when coolant leaked into #4 cyclinder causing loss of power, excessive smoke and total engine failure while driving on interstate. Ford supposedly knows this was an engineering problem in the 2 liter eco-boost engine for several years yet sold vehiles anyway.

NHTSA ODI 11713413

The engine light came on. I plugged a diagnostic scanner in under the dash and it read “misfire on cylinder 1”. I installed a new spark plug and cleared the code. I also noticed the coolant level was low so I added some. I checked it the next day and the coolant was low again but it was not puddled on the driveway. The check engine light was back on again. I took the car to the local Ford dealer and after they run a couple of test, I was informed the car had coolant intrusion on cylinder #1. They said the engine had cracked and needed to be replaced . I did not drive the car until I was able to have it repaired. The cost was $9451.51.

NHTSA ODI 11713469

My engine light went on and the car was shaking, stumbling. When I took the car to the dealership, and then to another shop, it was reported that the gas analyzer showed presence of combustion gases in the coolant system. The coolant present in cylinder is due to coolant intrusion that is a defect from factory. Ford refused to fix the problem because they would only fix the problem for cars with less than 84,000 miles and I was told by a representative at the dealership that recall letters were sent but only to those customers who presented with this issue between 2015 and 2019 or before that mileage. I never received any notification that this was an issue, or I would have brought my cay in. Now, I cannot afford a new engine and I have been left without a car since the incident, which was almost a year ago.

NHTSA ODI 11712707

In my 2017 my check engine light came on at 70,000 miles throwing a bunch of different codes, ignition coil misfire and actuator making vehicle overheat and run rough, made extensive repairs to the vehicle based on what the codes were which didn’t repair the vehicle, finally engine gave out on me at 93,000 miles and I had the vehicle towed to Classic Ford In Mentor Ohio and they diagnosed the vehicle with a bad engine requiring the engine to be replaced, I was then informed by the service department that what killed the engine was coolant leaking into the cylinders due to a design defect by Ford Motor Company and these issues with these Ecoboost engines are very well documented across the internet, Dealership quoted me over $9,000 to replace the engine which I definitely can’t afford at all, Due to this not being my fault and I’ve kept up with all maintenance but again what killed the engine was Ford’s design that allowed coolant to leak into cylinders, I’ve made several calls to Ford Motor Company and there corporate offices and they are declining to do anything to help this issue, my case number is [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11712252

The **engine system** failed due to **coolant intrusion into cylinder 2**, causing engine misfires and loss of power. This condition is consistent with known EcoBoost engine defects in this model year. The vehicle is available for inspection upon request. This failure created a **safety risk** due to potential **loss of power or stalling while driving**, increasing the risk of a crash. An additional issue exists with the **electrical system**, specifically the **driver’s door control panel circuit**, which intermittently malfunctions and affects vehicle operation. The engine issue has been **confirmed by diagnostic trouble codes indicating a cylinder 2 misfire**. Dealer confirmation: **UNKNOWN**. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. Prior to failure, the vehicle displayed a **check engine light**, rough idle, and misfiring. Electrical issues occurred intermittently. Exact onset date is **UNKNOWN**.

NHTSA ODI 11711844

Coolant intrusion into the engine from a manufacturer defect.

NHTSA ODI 11711856

Coolant leaking into engine cylinder 2 possible head gasket issue associated with known problem for this vehicle. Will cause overheating due to coolant levels needing to be refilled on a regular basis.

NHTSA ODI 11711689

My [XXX] daughter was driving her 2017 Ford Escape 1.5L EcoBoost check engine light came on and a message to pull over immediately. Vehicle was out of coolant. The coolant isn't leaking. The vehicle has a design flaw that causes coolant intrusion into the cylinders. Extremely dangerous and could leave someone stranded. The cost to fix is about the same as the value of the car!! Thousands of dollars!! This is a known design, flaw, and thousands of customers are experiencing it. It can leave drivers stranded and dangerous situations, including drivers like my teenage daughter. Ford should be responsible to fix this dangerous design flaw! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11711547

The engine started sputtering. Took it to a mechanic, and they said that the engine block had a crack.

NHTSA ODI 11711136

Coolant intrusion due to engineering defect in engine. Ford is more than aware of this, but will not help us at all. Car is effectively dead and unusable. Ford TSB admits to this defect and requires a "long block" replacement (full engine replacement), but is doing nothing to help customers. This is fleecing.

NHTSA ODI 11710870

On 1/13/26, vehicle was taken to Don Hinds Ford, Fishers, IN 46038-2892 for loss of coolant and sporadic shaking during start. Service performed diagnostic "Diagnostic: PERFORMED COOLANT PRESSURE TEST AND USED BOROSCOPE TO INSPECT EACH CYLINDER. FOUND CYL# 3 & 4 TO HAVE COOANT INTRUSION. RECOMEND REPLACEMENT OF ENGINE LONG BLOCK." Service recommendation "Engine Rebuild/Replace: REPLCEMENT OF ENGINE LONG BLOCK VIA TSB 22-2229" totaling $9,229.68 to be paid by customer. TSB 22-2229 is expired and vehicle has 82K miles. Known issue with this engine design, but not covered by Ford. I contacted Ford Customer Service requesting goodwill assistance or out-of-warranty coverage. Both were denied over the phone.

NHTSA ODI 11710955

Coolant leaking into cylinder car has under 60,000 miles.

NHTSA ODI 11710958

Coolant intrusion due to head gasket wear from Ecoboost, a known defect on the Ford Escape from 2013-2019. Yes, safety was put at risk, as the entire vehicle started shaking violently without warning on the expressway due to misfire caused from coolant intrusion. Vehicle is currently at Roy O'Brien Ford, SCS MI, where it was diagnosed having coolant intrusion. No warning lights appeared until the incident on [XXX], with a flashing check engine light while driving, with the vehicle shaking violently. Prior to, I could feel and see the RPM's bouncing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11710595

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine, Yes. There is a known coolant intrusion engine fault with ford escapes. ford has issued TSBs over this How was your safety or the safety of others put at risk? Engine abruptly died. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No

NHTSA ODI 11710753

I am the single owner of this 2017 Ford Escape with an Eco-boost 2.0L engine. This vehicle has only been serviced by Ford dealerships. at approximately 60K miles I noticed a lag in acceleration between 1200-2200 RPM. At 88K this lag became more violent, and I took the car to a Ford dealership for diagnosis. No warning lights had illuminated. The ford dealership advised me that there was coolant intrusion in the cylinders, and an entire new long block engine was required. After researching I learned that the 2017 had a design flaw that allows coolant to leak into the combustion chambers. in 2020 Ford redesigned the engine from an open deck to a closed deck. Due to Fords design flaw, I required a completely new long block engine and was able to confirm it was the new closed deck design at a cost of $14K. This problem boils down to the engine's open deck cooling design, which causes premature gasket failure and sometimes cracks between the cylinders. These problems don't affect the earlier versions of these engines due to their closed deck system, which was used prior to the introduction of the 2017 Escape. Ford has acknowledged this problem, but the fix isn't a simple one - it requires a long block replacement, which is obviously a labor intensive and expensive job. How to we get Ford to be responsible for the costs associated with changing the engine out from their flawed design? This could have been an on highway incident since there were no warning lights or other visible issues.

NHTSA ODI 11710333

Coolant Intrusion: A design flaw in the open-deck engine block allows coolant to leak into the combustion chambers, leading to misfires, white smoke, and severe engine damage. Affected Vehicles: Primarily 2017-2019 Escapes and 2014-2019 Fusions with the 1.5L EcoBoost engine, built before specific dates. Symptoms: Low coolant, white exhaust smoke, rough idling, check engine light, and DTCs like P0300, P0301-P0304.

NHTSA ODI 11710449

I bought my 2017 Ford Escape from Cocoa Ford in Cocoa, FL on 8/23/2025. Less than a month after purchase, I noticed the coolant was low, and that the engine was making a weird noise. I also had the check engine light come on two different times and after using an OBD reader, I got code P0303. After the first instance, around Mid-November, 2025, I cleared the code myself, but then immediately scheduled an appointment with my mechanic. Seaside Auto Repair in Satellite Beach, FL on November 24, 2025. They came back stating that the problem is a known issue with Ford Escape cars, citing [XXX] & [XXX] . No repairs were made at this time, as I was assessing my options. Shortly after taking the car to the mechanic was when the check engine light came on again. Around December 5, 2025. Due to the holidays, and the car seemingly getting me to point A to Point B without too much trouble when I wasn't driving far, and constantly monitoring the coolant levels, which continued to drop, even after topping off, I have been waiting until after the new years to seek further mechanical fixes, however on Jan 1, 2026, while driving on the highway, my car began to shake, and I had a flashing check engine light on. I immediately returned home, about an additional 25 minutes of driving, and have not driven the car since. Since this is a known issue, Ford should be responsible for the fixes and/or replacement of my car. It is asinine that this issue does not yet have a recall. I will be reaching out to Ford directly to see if they will assist with this matter, but for now, I wanted to voice my concern about this issue. I'm lucky I was close to home when the issue became more serious. I have attached the invoice from my mechanic, which also includes a descriptions of their findings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11708750

This is related to the class action lawsuit 2:20-cv-01796-DAD-CKD Miller v. Ford Motor Co. Concerning alleged engine defects in Ford vehicles, specifically focusing on issues like excessive oil consumption and premature failure in certain EcoBoost engines. My engine has developed symptoms regarding the known coolant leak into the engine. The engine looses power when accellerating, and produces white exhaust after starting cold. Replacing spark plugs and coils did not resolve the issue. I checked the coolant level and it was below the minimum, and I had to add more coolant. The ECU has logged misfires at cylinder 2 and 4. The MIL turns on intermittently.

NHTSA ODI 11708694

Two different things are happening with my car. 1) the paint is chipping and has caused corrosion on the body. Apparently this is a known issue but the peeling/chipping has gotten worse and will keep doing so until it is fixed. 2) car keep running hot and losing coolant but no leak to be found even after several rounds of tests.

NHTSA ODI 11708001

Vehicle is slowly losing collant, and when I park I get a strong smell of collant. I took vehicle to have collant flushed and was took system was ok. From what I have researched is that there is a history of coolant entering engine cylinder because of defective engine and causeing engines to event ually seize.

NHTSA ODI 11708094