What 2,628 owners told NHTSA about the 2017 Ford Escape Gas

My low beam headlights for the past year burn out every 4 to 6 weeks. In the past 3 months, they began to burn out every 2 to 3 weeks. Recently I went to have my headlight changed once again and they told me that the headlight assembly kits were actually burnt/melted and would need replaced on both sides. The cost of those was quoted to be over $2000 each. I was also told that certain Ford Escapes had a previous recall for this very problem but I cannot locate that recall for my vehicle. Could you please help me in this matter? I truly cannot offered to pay to have that repaired and I don't feel that this is an issue that is from routine use. If it was just a burnt out light I would understand and take care of it myself. The mechanic feels that I should reach out and see what Ford can do. Thank you so much.

NHTSA ODI 11733187

There is a known issue with coolant intrusion into the engine with this vehicle. The vehicle has less than 40,000 miles. The engine stalled three times over a two mile trip and completely shut off during a left hand turn with oncoming traffic putting my family and other drivers in danger.

NHTSA ODI 11733324

I had noticed the "sluggish" during my travels either to/from work, I had thought that it may be local gasoline. After fueling once again, my car started with an emblem on the dash, which I later looked up in the book provided and it stated that I needed to have the "coolant" looked at, I believe it was a engine emblem.?. My last oil change was October 2025. I stopped 03/10/26 by AutoZone to see if they could do a diagnostic. Which stated several options that could be evaluated. The AutoZone information suggested: spark plugs, coil packs and two other options that it might be. Then the next signal my car gave me was during driving from my evening job on 04/02/26, which was so quick I did not get to see it, however, the alarms were loud enough that I was scared. I pulled over for safety d/t the "emblem that I remember seeing said something about "Fire and Safety". I allowed about 20 minutes to pass and nothing had taking place, so I call to husband re: the warning lights. **Wrench Sign: with the signage of Engine Fault Service Now. I was traveling to work after the car sat in my garage over the weekend. The alarms started going off and suddenly I was without control over the vehicle, the car stopped and there was no power.

NHTSA ODI 11733435

I started having trouble with my car idleing hard and driving jerky. Around November of 2025, I took it to the local Ford dealership and they couldn’t find anything wrong with it. The check engine light was on at this point So I took it to an independent local shop. They looked at it and saw that the valve in cylinder one was broken and not firing. At this point I took it back to Ford along with pictures of the busted valve. I went back to Ford because I have a lifetime power train warranty they are my authorized repair shop. So with the pictures of the busted valve they filled a claim. The warranty people said that if the head gasket was the only thing messed up they would cover the repairs. If the block was warped they would not cover anything because Ford knows about the problem and there is a Technical Service Bulletin TSB 22-2229 about the problem. I just want to know what to do. How do I proceed ?

NHTSA ODI 11732784

Low beam headlight bulbs fail consistently every 90-120 days. I've replaced them approximately 20 times in 9 years. This is a common failure across this vehicle line, as noted in many online forums. This is a safety hazard.

NHTSA ODI 11732317

coolant intrusion

NHTSA ODI 11732551

The contact owns a 2017 Ford Escape. The contact stated that the vehicle was losing coolant, and the coolant pipes were replaced; however, the failure persisted. The vehicle was inspected, and the contact was informed that coolant was leaking into the engine cylinders. Due to the failure, the contact was informed that the engine needed to repaired or replaced. The dealer was notified of the failure. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 77,000.

NHTSA ODI 11732552

Engine fault light came on took to mechanic nothing popped up on the codes. Then check engine light came on took to another mechanic it showed it was misfiring along with other codes. Then check engine light went away. Then moved car out of driveway and engine overheating light came on.

NHTSA ODI 11732279

We received notification about the PCM needing reprogrammed and we had that done in 2020 at 41K miles. In Oct 2025 we had the water pump and timing belt changed at 106,236 miles then 5 months later it started shaking and the check engine light came on. The light had never come on before this. It has 109,630 miles. I put a scanner on it and it showed P0302 misfire so I replaced the plug and coil in the #2 cylinder and no change. I had already replaced all spark plugs around July/August in 2025. We had it towed to a local mechanic shop and they did a compression check and said the #2 cylinder had 15% left and that the mechanics didnt see any evidence of a coolant intrusion and we needed a new engine.

NHTSA ODI 11732037

coolant intrusion

NHTSA ODI 11732078

Coolant intrusion in the engine. Causes failure if engine and oil leak on engine. Had it diagnosed with a mechanic.

NHTSA ODI 11731860

The contact owns a 2017 Ford Escape. The contact stated that while driving at 45 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle with coolant intrusion in two cylinders and determined that the engine long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 87,000.

NHTSA ODI 11731932

1. The failed component is the engine. The dealer confirmed that coolant intrusion caused internal engine damage and that the engine requires full replacement. This is especially serious because Customer Satisfaction Program 19B37 had already been performed on the vehicle and was supposed to correct this exact coolant intrusion issue. The dealer even acknowledged that this repair should have prevented the failure, yet the same problem still occurred less than 30,000 miles later. The vehicle has low mileage, has been properly maintained, and should be available for inspection upon request, depending on whether the dealer or repair facility retains the parts. 2. This created a major safety risk. My teenager was driving the vehicle when the engine died, which put them in immediate danger. A sudden engine failure can cause loss of power, rough running, misfiring, or stalling in traffic, at intersections, or at highway speeds, leaving the driver unable to accelerate or move out of the way of other vehicles. This was not just an inconvenience; it created a very serious risk of a crash and potential injury to my child, passengers, and others on the road. 3. Yes. The problem was confirmed by the dealership service department. They diagnosed the failure as the 19B37 coolant intrusion issue and stated that the engine needs to be replaced. They also acknowledged that the prior CSP repair should have fixed this problem. 4. The vehicle has been inspected by the dealership/service center. Ford has also been contacted regarding the issue. To my knowledge, it has not been inspected by police or insurance representatives. 5. Yes. Before the failure, there were symptoms consistent with coolant intrusion, including coolant loss and engine performance problems such as rough running or misfiring. Warning lights and engine-related symptoms appeared before the complete failure and worsened over time until the dealer confirmed internal engine damage. The vehicle had low mileage, all ma

NHTSA ODI 11731610

Mechanic looked at vehicle couldn’t find a coolant leak from anywhere, could be a cracked head.

NHTSA ODI 11731688

The contact owns a 2017 Ford Escape. The contact stated that the check engine warning light was illuminated and was turning on and off. The thermostat gauge increased to hot. The contact became aware that there was no coolant in the coolant reservoir. Additionally, the oil light was illuminated even though an oil change had been performed two months prior. The vehicle became undrivable. The vehicle was towed to the local dealer, but was not diagnosed or repaired. The contact stated that there was an internal coolant leak. The manufacturer was not notified of the failure. The failure mileage was approximately 121,000.

NHTSA ODI 11731405

The contact owns a 2017 Ford Escape. While driving at an undisclosed speed, the vehicle suddenly stopped on several occasions and lost automotive power. The Automatic START/STOP message was displayed. The contact manually turned off the feature, but the Automatic START/STOP feature was activated independently. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 193,000.

NHTSA ODI 11731437

The failure appears to involve the vehicle’s auto start/stop system and related electrical control systems, including the battery management system and/or body control module. The vehicle shuts off unexpectedly while driving and fails to automatically restart, displaying “Auto Start/Stop – Manual Restart Required” and “Shift to Park.” The vehicle is available for inspection upon request. The vehicle has shut off unexpectedly in active traffic, causing a sudden loss of power. This creates a dangerous situation where I am unable to accelerate or move with traffic flow, increasing the risk of being rear-ended or involved in a collision. This has occurred on public roads with other vehicles present, putting both myself and others at risk. The issue is intermittent and has not consistently been reproduced on demand. However, it has occurred multiple times during normal driving conditions. I am in the process of having the vehicle inspected and documented by a dealership. The issue has been reported to the manufacturer, and a case has been opened with Ford Motor Company. At this time, the vehicle has not yet been inspected by police or insurance representatives. There were no consistent warning lamps prior to the failure. At the time of the incident, the vehicle displayed messages including “Auto Start/Stop – Manual Restart Required” and “Shift to Park.” These messages appeared simultaneously with the loss of power. The issue has occurred intermittently without advance warning.

NHTSA ODI 11731444

I am reporting a serious engine defect with my 2017 Ford Escape EcoBoost. Coolant has leaked into cylinder number 4, causing engine damage and failure. The dealership confirmed this diagnosis and stated that a full engine replacement is required, with an estimated cost of 9,000–10,000. I purchased this vehicle new in 2016 and have been the sole owner. This issue is consistent with known defects affecting EcoBoost engines, including internal coolant leaks and engine block failures. I am submitting this report to ensure it is documented and to request investigation of this safety and reliability concern.

NHTSA ODI 11730907

My transmission blew had to be towed home

NHTSA ODI 11730635

2017 Ford Escape 65,000 miles,1.5l coolant intrusion.#2 cylinder misfire code. First thing upon raising the hood noticed and acknowledged there was no coolant in resevoir. Attempting to replace spark plugs. Removed/replaced #4 plug. Attempting to replace #3 spark plug, plug broke off. Researching and collaborating with reputable mechanic concluded that short block coolant intrusion has occurred. Upon disassembly have encountered turbo boost and catalytic converter full of oil, also needing replaced. Head has been sent to machine shop for inspection and repair. Presently awaiting for repairs to be completed and costs established. Present estimate over $5000. I paid cash for this vehicle in 2019. Vehicle had been leased for 2 years previous. Vehicle had 20,000 miles on it. Ford was well aware of the coolant intrusion (bad engineering) is before they sold me the vehicle in November 2019. They never mentioned or offered any warranty specific to this issue. They sold me a a vehicle knowing that if enough things went wrong while driving this vehicle, catastrophic situation was possible. They should have corrected this issue before they sold it to the next customer.

NHTSA ODI 11730565

The vehicle suddenly began running roughly, and produced a loud clicking/knocking noise and engine shut off while driving. We were advised by the Ford mechanic we had it towed to that it was due to the EcoBoost engine failure, and that this is a known issue.Ford has issued technical service bulletins related to this defect, but no recall has been initiated. Given the safety implications of an engine shutting off while driving, the widespread nature of this problem, and the refusal of Ford to own up to this dangerous defect I felt I had to report it.

NHTSA ODI 11730441

Coolant leaking into cylinders. Repair shops said it was a known Ford issue with the 1.5 ecoboost engine. Causes the coolant to leak out and the engine to overheat and the overflow tank to leak.

NHTSA ODI 11729587

Engines has a severe issue with coolant leaking into the engine cylinders due to a design defect in the engine block. This "coolant intrusion" lead to misfires, engine overheating, and complete engine failure, and is requiring a full engine replacement.

NHTSA ODI 11729473

The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle shuddered, causing the RPM to fluctuate. The contact received notification of NHTSA Campaign Number: 26V011000 (EQUIPMENT); however, the part to do the recall repair was not yet available. The vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 157,000.

NHTSA ODI 11728885

The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the engine temperature warning light illuminated. The vehicle was towed to a local independent mechanic to be diagnosed. The contact was informed that the engine needed to be replaced due to coolant intrusion into the engine. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not under recall. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 26V011000 (Equipment); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 105,459.

NHTSA ODI 11728467