What 61 owners told NHTSA about the 2016 Mercedes-benz Sprinter 3500 Cargo Van

I OWN AN RV ON A MERCEDES 3500 SPRINTER CHASIS. I HAVE EXPERIENCED NUMEROUS FAILURES THAT CAUSE THE RV TO SPEED UP RAPIDLY AND I HAVE TO TAKE EMERGENCY ACTION TO AVOID AN ACCIDENT. USUALLY, I SHIFT INTO NEUTRAL TO DISENGAGE THE TRANSMISSION. I HAVE ~43,000 MILES ON MY RV AND I HAVE EXPERIENCED THIS ISSUE AND MERCEDES HAS REPLACED THE WHEEL SENSORS 6 DIFFERENT TIMES. ALL MAINTENANCE PERFORMED ON THE VEHICLE HAS BEEN PROVIDED BY A MERCEDES DEALER SERVICE CENTER. DOESN'T SEEM TO MATTER IF I AM DRIVING ON THE FREEWAY OR CITY STREETS, WHEN THE FAILURE HAPPENS, THE VEHICLE STARTS TO ACCELERATE RAPIDLY, RPMS SKYROCKET, THE DASHBOARD GETS THREE TROUBLE INDICATOR LIGHTS THAT COME ON, THE CHECK ENGINE LIGHT COMES ON. I AM PICKING UP THE VEHICLE FROM THE LOCAL MERCEDES DEALER TODAY AFTER JUST HAVING ANOTHER SENSOR FAILURE. I WAS DRIVING ON I-10 WHEN THE MOST RECENT FAILURE OCCURRED. THE VEHICLE BEGAN TO ACCELERATE, RPMS WENT VERY HIGH. VERY SCARY SITUATION. THE "WHEN DID THIS HAPPEN" DATE I'VE ENTERED IS FOR THE MOST RECENT FAILURE. I HAVE EXPERIENCED THIS ISSUE NUMEROUS TIMES.

NHTSA ODI 11387156

DRIVING ON A DRY DAY, SMOOTH ROAD, WITH CRUISE CONTROL ON 65MPH AT 7:45PM. THIS VEHICLE IS CONVERTED WITH A THOR 24HL CAMPER ON THE CHASSIS. FIVE HOURS INTO THE DAYS DRIVE THE VEHICLE FLASHED ASR/ESP TRIANGLE - AND JERKED ABRUPTLY BUT INSTANTANEOUSLY BUT REMAINED ON CRUISE CONTROL. 2 SECONDS LATER: ABS LIGHT ON, ASR/BAS LIGHT ON, ESP LIGHT ON CRUISE CONTROL STOPPED FUNCTIONING (FYI - A VERY HEAVY ACCELERATOR PEDAL SPRING MAKES DRIVING DIFFICULT, FOR HOURS ON END, WITHOUT CRUISE WORKING - ESPECIALLY FOR THE OLDER DRIVERS LIKELY TO BE DRIVING THIS RIG.) PULLED OFF THE SIDE OF THE ROAD, SET FLASHERS, AND TURNED OFF ENGINE FOR ONE MIN HOPING TO RESET THE FAULT. TURNED BACK ON - NO CHANGE OFF THEN BACK ON AND THE YELLOW CHECK ENGINE CAME ON STEADY ALONG WITH THREE PREVIOUS AUCTION LIGHTS (ABOVE) VEHICLE HAD EXPERIENCED (WITH THE PREVIOUS OWNER) A PREVIOUS 'WHEEL SPEED SENSOR FAILURE' AND IT WAS REPAIRED. . 'WHEEL SPEED SENSOR FAILURE' APPEAR AT EPIDEMIC LEVELS ON THE TWO RV FACEBOOK GROUPS ASSOCIATED WITH THIS VEHICLE. THE 5TH KEY TURN AFTER INITIAL FAULT AND FAILURE OF CRUISE CONTROL THE THREE LIGHTS WENT OUT BUT THE CHECK ENGINE LIGHT REMAINED ON. ON APPROXIMATELY THE TENTH KEY TURN THE CHECK ENGINE LIGHT WENT OUT. VEHICLE RETURNED FOR SERVICE AT MERCEDES DEALERSHIP 'UNDER WARRANTY'. MY ISSUE LAYS IN THE POTENTIAL FOR THE VEHICLE TO ENTER INTO THE LIMP MODE IF ANOTHER CENSOR SHOWS A FAULT AND I'M ON THE ALASKA HIGHWAY 200 MILES FROM THE NEAREST POSSIBLE SERVICE. DEALER REFUSES TO SHARE TECH DATA CONCERNING RESET OF FAULT CONDITION OR A MERCEDES FIX FOR THIS NOW WELL KNOWN AND DOCUMENTED VEHICLE SHORTCOMING. THIS ISSUE CAN AND WILL GET PEOPLE KILLED AS THEY 'LIMP' DOWN THE HIGHWAY TO GET SERVICED OR ARE FORCED TO PULL OVER IN HEAVY TRAFFIC TO CHECK OUT WHAT MERCEDES SHOULD BE WARNING IS ALL ABOUT PROACTIVELY.

NHTSA ODI 11386418

WHILE DRIVING ON A MOUNTAIN ROAD THE VEHICLE BEGAN TO SEND FIRE, SMOKE AND STEAM FROM THE MOTOR COMPARTMENT UNDER THE DASH BOARD AND OVER THE WIND SHIELD, CAUSING THE MOTOR TO STOP RUNNING AND SUBSEQUENTLY CAUSING THE BRAKES TO FAIL SENDING MY WIFE AND I DOWN A WINDING MOUNTAIN AND ULTIMATELY RESULTING IN A NEAR FATAL CRASH INTO A MOUNTAIN RETAINING WALL. THE VEHICLE WAS COMPLETELY DESTROYED. THIS VEHICLE WAS BRAND NEW WHEN PURCHASED BY US AND ONLY 5 MONTHS OLD WITH 4500 MILES (2325 MILES WERE PUT ON VEHICLE BY THE TRANSPORTER TO GET IT FROM FACTORY TO POINT OF SALE). *TR*DT*JB*DT*TR

NHTSA ODI 11079855

THE AIR CONDITION SHUTS DOWN AFTER A COUPLE OF HOURS. IT JUST COMES FROM THE VENTS HOT AIR AND STAUNCHY (BAD ODORS) ODORS. CONTACT MERCEDES BENZ AND THEY SAY THAT THEY AWARE OF THE PROBLEM BUT ARE NOT WILLING TO FIX IT.

NHTSA ODI 11052317