What 32 owners told NHTSA about the 2016 Land Rover Lr4 (7 Seat)

The contact owns a 2016 Land Rover LR4. The contact stated that while driving at 75 MPH the low coolant warning light was illuminated, the steering wheel became difficult to maneuver, the brake pedal was depressed and traveled to the floorboard without stopping the vehicle. The vehicle was shifted to neutral, and the start/stop button was depressed in order to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with cracks in the coolant and fuel systems that caused a leak and needed replacement. The coolant reservoir tank and fuel flange was replaced however the low coolant warning light and other lights were still on. The vehicle was then taken to a certified Land Rover repair facilities were the mechanic informed her that the coolant tank was not replaced but sealant was placed on the cracks. The independent mechanic replaced the coolant reservoir along with the brakes that the dealer that the dealer had install backwards. The contact stated that the low coolant warning light was still illuminated and that neither facilities could remedy the issue. The contact state that she received a notice for NHTSA Campaign Number: 21V635000 (Fuel System, Gasoline). The dealer was contacted and informed her that there was no recall for her vehicle. The contact stated that the manufacturer was notified and informed her to contact the dealer to schedule a recall repair appointment. The contact stated that while waiting for the dealer to verify the recall, she was driving at 75 MPH, when the power steering and braking capability was lost with smoke and fire coming from the engine compartment. The contact stated she pulled over and her and her child exited the vehicle without injury. The fire and police department were contacted. The fire department extinguished the flames. A police report was not filed. The vehicle was towed to the dealer where it sat for several months without repairs. The failure cause was not diagnosed or repaired. The vehicle was still at the dealer . The insurance company was contacted and stated that the manufacturer was responsible to repair the vehicle. A case was opened with the manufacturer. The approximate failure was 73, 000.

NHTSA ODI 11605899

The contact owns a 2016 Land Rover LR4. The contact had recently taken the vehicle to a dealer to be repaired under NHTSA Campaign Number: 21V635000 (Fuel System, Gasoline). The contact stated that while attempting to refuel the vehicle, he observed that fuel was puddling underneath the vehicle. The contact stated that he had not refueled the vehicle prior to the recall repair. The contact had the vehicle towed back to the residence. The contact called the dealer and was advised to bring the vehicle back to the dealer to be diagnosed. The vehicle was not repaired. The contact related the failure to the repair performed on NHTSA Campaign Number: 21V635000 (Fuel System, Gasoline). The manufacturer was informed of the failure. The failure mileage was approximately 110,000.

NHTSA ODI 11590180

• Ask the customer (and document verbatim) what occurred or what the alleged defect is? I attempted multiple times to have Land Rover complete Safety Recall N623 – NHTSA Recall Number 21V-635 on my 2016 Land Rover LR4 -Gasoline Fuel Tank Flange Assembly Crack. A number of the Land Rover dealerships stated that no recall existed. After multiple attempts to confirm this recall was required for my vehicle, I was able to schedule the repair at Land Rover Cary. I reduced driving the vehicle to only minimal driving requirements while I was awaiting the recall requirement. The recall repair was canceled twice after I drove to Cary from Pinehurst, NC due to a lack of service technicians. I was driving to the dealership this third time for the repair when the fire occurred in the vehicle. I was driving to the dealership, for this recall repair, when a number of warnings flashed on the driving display. Smoke began to bellow out of the vehicle. I put on my hazards and pulled off the main highway and onto the shoulder. I turned the ignition off, exited the vehicle, and opened the hood to observe the engine bay. There were flames shooting out of the engine compartment. I went to grab my extinguisher and called 911. The flames died down rapidly. I could see that the fire melted a number of components on the bottom of the engine causing oil to spray all over. I would like to add that the driveway to my home sits at about a 30-degree incline and I typically park with the vehicle pointing down towards the nose. I wonder if the slow gas leak traveled down the vehicle towards the engine and saturated the parts with gasoline causing this issue.

NHTSA ODI 11555274

Engine MIL Illuminated With DTC P0089-64 Stored [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11553764

I had done a safety recall repair 'RECALL N623 FUEL TANK' on my 2016 Land Rover LR4 Landmark edition (32,051 miles) on 6-19-2022 at LAND ROVER PASADENA, 3485 East Colorado Blvd, Pasadena, CA 91107. Few days after they did the free recall fix I got the below error code 'P0442, Evaporative Emission system leak' that the dealership claims is not related to the recall fix that they did and wants to charge me $250 just to evaluate the issue. But I'm 100% certain this leak is some thing they didn't seal properly at the time of the recall. I'm very unhappy of the outcome and hope I can get this issue fixed without spending any money as before the recall I had no errors what so ever in this car and all started after the free recall fix.

NHTSA ODI 11534663

The contact owns a 2016 Land Rover LR4. The contact received notification of the NHTSA Campaign Number: 21V635000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available. The manufacturer was notified of the issue and the contact was informed that a temporary repair was available and to notify the dealer of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11505446

GAS TANK DUST COVER CRACKED, LEAKING FRANK FUEL OVER THE TANK, ONTO VEHICLE COMPONENTS AND ONTO THE FLOOR WITH ASSOCIATED FUMES. VEHICLE LEAKED FUEL WHILE STATIONARY IN THE GARAGE, LEAKING FUMES INTO THE HOUSE. VEHICLE WAS TAKEN TO LAND ROVER FOR REPAIRS. REPAIR TEAM NOTED THIS IS A KNOWN ISSUE AND THE COVER WAS RE-DESIGNED. I WAS CHARGED APPROXIMATELY $800 FOR THE PART AND LABOR. THIS IS A KNOWN ISSUE WITH THIS MAKE AND MODEL.

NHTSA ODI 11255062