What 800 owners told NHTSA about the 2016 Kia Soul

TL* THE CONTACT OWNED A 2016 KIA SOUL. WHILE DRIVING 30 MPH, THE VEHICLE SKID AND CRASHED. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK AND BACK INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED DESTROYED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ODI 11206184

WHILE TRYING TO DRIVE UP A SNOW COVERED ROAD I HAD SMOKE START COMING INTO THE CABIN OF MY VEHICLE. I WAS GOING TO PULL INTO A GAS STATION WHEN SOMEONE CAME RUNNING OVER AND STATED THAT THE UNDERSIDE OF MY CAR WAS ON FIRE. THE FIRE WAS EXTINGUISHED AND THEN MY CAR WAS PULLED OFF THE ROAD. IT WAS TOWED TO A LOCAL GARAGE WHERE MY INSURANCE AGENT WENT TO LOOK AT IT. THE OIL WAS SO LOW THAT THEY WOULDN'T CHECK IT UNTIL IT RECEIVED AN OIL CHANGE. ONCE THAT WAS PERFORMED THEY WERE STILL UNABLE TO DETERMINE WHAT CAUSED THE FIRE. THEY THEN HAD ME TOW IT TO A KIA DEALERSHIP. IT HAS BEEN AT THE DEALERSHIP FOR OVER A MONTH AND THEY HAVE DETERMINED THAT IT IS NOT A WARRANTY ISSUE. WHEN I INQUIRED AS TO WHAT WAS WRONG WITH THE CAR THEY INFORMED ME THAT IT WOULD BE $110 DOLLARS TO DIAGNOSE THE VEHICLE. THEY FINALLY WENT OVER THE VEHICLE, BUT STILL NO ANSWERS TO WHY MY VEHICLE CAUGHT FIRE AND IF IT COULD POSSIBLY HAPPEN AGAIN.

NHTSA ODI 11193526

MY WIFE HIT A CAR (T BONED) THE FRONT OF THE CAR WAS TOTALED. THE AIRBAGS DID NOT DIPLOID. SHE WENT IN THE HOSPITAL. THE S BELT WENT IN HER CHEST AND SHE HAS NECK AND BACK PAIN. I REPORTED IT TO THE KIA DEALER AND NEVER GOT AN ANSWER.

NHTSA ODI 11187165

AFTER A SHORT DRIVE, I PARKED MY 2016 KIA SOUL IN THE GARAGE AND 15 MINUTES LATER I HEARD A NOISE IN THE GARAGE. MY HUSBAND OPENED THE DOOR TO THE GARAGE AND FOUND FLAMES COMING FROM THE STATIONARY KIA. THE ENTIRE GARAGE CAUGHT FIRE AND INCLUDED MY OTHER CAR WHICH WAS AN INFINITI G35. THE PRIMARY FLAMES WERE COMING OUT OF THE HOOD/FRONT RIGHT FENDER SEAM WITH MINOR FLAMES UNDERNEATH THE KIA. WE KNOW THAT THE FIRE STARTED IN THE PASSENGER SIDE OF THE ENGINE COMPARTMENT OF THE KIA SOUL. THE VEHICLE WAS LESS THAN ONE YEAR OLD, HAD APPROXIMATELY 6000 MILES, AND HAD ONLY BEEN SERVICED ONCE AT THE HENDERSON KIA DEALERSHIP FOR AN OIL CHANGE. WE BELIEVE THAT THE CAUSE OF THE SAFETY RISK WAS THE FUEL VAPOR LEAK BECAUSE MY SON'S 2016 KIA FORTE, ALSO PURCHASED FROM HENDERSON KIA, HAD A SEVERE FUEL VAPOR LEAK THAT HE HAD REPAIRED AT THE DEALERSHIP ABOUT THREE MONTHS AFTER MY KIA SOUL FIRE. THE SPEED OF MY GARAGE FIRE IS CONSISTENT WITH A FUEL VAPOR LEAK THAT WAS DOCUMENTED BY THE HENDERSON KIA SERVICE DEPARTMENT ON MY SON'S KIA FORTE. WE HAD TO MOVE OUT OF OUR HOME FOR FIVE MONTHS WHILE THE HOUSE WAS BEING REPAIRED. THERE WAS OVER $142,000 DAMAGE TO OUR HOME AND PERSONAL PROPERTY.

NHTSA ODI 11180538

I WAS IN A CAR ACCIDENT A FEW MONTHS AGO THAT INVOLVED ME LEAVING THE ROAD AND THAT I WAS COMPLETELY AIRBORNE LANDING ON THE OTHER SIDE OF THE EMBANKMENT MY AIR BAGS DID NOT DEPLOY UNDER THE FORCE OF MY CAR GOING AIRBORNE AND LANDING SO HARD THAT MY UNDERSIDE OF MY CAR WAS TORN UP NEEDING ALMOST 6,000 DOLLARS IN REPAIRS. INCLUDING BREAKING MY OIL FILTER OFF OF THE CAR. I WAS TOLD THAT MY AIRBAGS SHOULD HAVE COMPLETELY DEPLOYED. BUT THEY DID NOT. I REALLY AM SCARED THAT IF I WAS IN ANOTHER ACCIDENT THEY WILL NOT DEPLOY WHEN NEEDED TO SAVE MY OR MY FAMILIES LIFE.

NHTSA ODI 11165917

ON HIGHWAY IN RAINY CONDITIONS HYDROPLANED IN TO CONCRETE BARRIER WALL AT ABOUT 70 MPH FIRST IMPACT ON DRIVERS FRONT CORNER NEAR HEADLIGHT. AIRBAGS NEVER DEPLOYED.

NHTSA ODI 11155517

I WAS GETTING READY TO MERGE ONTO THE INTERSTATE WHEN I HEARD NOISE COMING FROM THE ENGINE COMPARTMENT. WHEN I GOT ONTO THE INTERSTATE THE CAR WOULD NOT ACCELERATE, SO I PULLED OVER TO THE SHOULDER, AND THE ENGINE DIED. SMOKE WAS COMING FROM UNDER THE HOOD, AND TWO MEN IN TWO VEHICLES STOPPED AND OPENED THE HOOD AND FLAMES WERE COMING OUT FROM UNDER THE HOOD. THEY HAD WATER AND A FIRE EXTINGUISHER AND ALSO THREW SOME DIRT ON THE FIRE TO PUT IT OUT. THE VEHICLE WAS TOWED TO THE KIA DEALERSHIP WHERE IT WAS BOUGHT. THE INSURANCE COMPANY HAD THE KIA SOUL TOWED TO DENVER COLORADO TO HAVE THEIR AGENT LOOK IT THE KIA. IT WAS DECLARED A TOTAL LOSS AND WAS NOT AN ARSON FIRE. THE KIA DEALERSHIP FROM WHICH THE KIA SOUL WAS BOUGHT NEVER INSPECTED THE SOUL. ALL ROUTINE MAINTENANCE WAS DONE ON SCHEDULE BY THE KIA DEALERSHIP FOR THE 9 MONTHS I OWNED THE KIA. IT WAS BOUGHT NEW IN DECEMBER OF 2016 AND CAUGHT FIRE IN SEPTEMBER OF 2017. THE CAUSE OF THE FIRE WAS NEVER DETERMINED AND KIA NEVER TOOK ANY RESPONSIBLE.

NHTSA ODI 11153156

CAR WAS IN GOOD CONDITION AND WELL MAINTAINED ACCORDING TO MANUFACTURER'S SERVICE SCHEDULE. IT WAS LAST SERVICED ON 7/31/18 WHEN IT PASSED NYS INSPECTION. THE OWNER WAS INFORMED ON 9/18/18 @ 7:03 PM BY DAUGHTER THAT CAR STARTED MAKING A STRANGE SOUND ON 9/17/18. PLANNED TO HAVE DEALER CHECK OUT CAR ON 9/19/18. ON 9/18/18 @ APPROXIMATELY 8:35 PM, WHILE BEING DRIVEN ON THE LOCAL PORTION OF AN INTERSTATE HIGHWAY, THE CAR'S OIL LIGHT BLINKED ON AND OFF. A FEW MINUTES LATER THE CHECK ENGINE LIGHT WENT ON. A FEW MINUTES LATER THE CAR ENGINE BEGAN TO SMOKE AND SMOKE CAME INTO THE CAR THROUGH THE AIR VENTS. THE DRIVER, MY DAUGHTER'S BOYFRIEND, PULLED OVER INTO THE BREAKDOWN LANE, TURNED OFF THE CAR, GOT OUT, STEPPED AWAY FROM IT AND THE ENGINE ERUPTED IN FLAMES. BY APPROXIMATELY 8:50 PM THE CAR WAS TOTALLY ENGULFED IN FLAMES. THE CAR LOOKS LIKE IT WAS FIRE BOMBED.

NHTSA ODI 11133366

BACKED UP DRIVEWAY TO PARK CAR IN GARAGE. PUT CAR IN "PARK". GOT OUT TO CLEAR PARKING SPACE IN GARAGE. TURNED AROUND TO SEE CAR ROLLING DOWN DRIVEWAY INTO WALL- WHILE IN "PARK".

NHTSA ODI 11129274

TL* THE CONTACT OWNS A 2016 KIA SOUL. WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A RIGHT TURN, THE VEHICLE TURNED TO THE LEFT AND CRASHED INTO A CURB. THE INCIDENT DAMAGED ONE OF THE TIRES. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (SUPERIOR KIA, 260 W. MITCHELL AVE, CINCINNATI, OH) AND WAS AWAITING DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 31,000.

NHTSA ODI 11112207

THE ACCELERATOR PEDAL BROKE IN HALF AND SOMEHOW STUCK ON. [XXX] WAS UNABLE TO STOP THE VEHICLE AND IT JUMPED OFF A THREE FOOT WALL, RAN THROUGH A WOODEN FENCE AND HIT THE BRICK WALL OF AN APARTMENT BUILDING. DAMAGE WAS EXTENSIVE, BUT COULD HAVE BEEN MUCH WORSE. THE 2014 AND 2015 MODELS HAVE BEEN RECALLED FOR BREAKING ACCELERATOR PEDALS, HOWEVER THE 2016 HAS NOT BEEN INCLUDED IN THE RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 10994478

ON 2/18/17 MY DAUGHTER WAS INVOLVED IN A FRONT END COLLISION IN OUR 2016 KIA SOUL. SHE STRUCK A STOPPED TOYOTA CAROLLA AT OVER 45MPH ON SOUTHBOUND I-5 IN SEATTLE WA. THIS WAS A DIRECT FRONT END COLLISION AND THE AIRBAGS IN THE KIA SOUL DID NOT DEPLOY EVEN THOUGH THE METAL BUMPER BAR WAS COMPLETELY BENT IN A "V" SHAPE BACK BEYOND THE RADIATOR. KIA USA FIRST CLAIMED THAT THIS WAS DUE TO UNDER RIDING. SENT THEM DAYTIME PHOTOS FROM THE NEXT DAY WHEN WE VISITED THE CAR TO REMOVE PERSONAL ITEMS AND THEY CHANGED THE STORY TO "THE AIR BAG SENSORS ARE IN THE CONNECTING PILLARS SO THIS STILL WOULD NOT HAVE TRIGGERED THE AIR BAGS. KIA USA IS ACCEPTING NO FAULT AND IT TAKING NO ACTION. BASED ON MY RESEARCH, THIS COLLISION SHOULD HAVE TRIGGERED BOTH FRONT AIRBAGS AS BOTH FRONT SEATS WERE OCCUPIED BY ADULTS AT THE TIME OF THE COLLISION. MY HOPE IS YOU CAN USE THIS INFORMATION AND MY PHOTOS TO INVESTIGATE THIS SITUATION AND RESOLVE IT WITH KIA. FROM MY POINT OF VIEW WE EXPERIENCED A COMPLETE FAILURE OF ONE OF THE CARS MAIN SAFETY FEATURES, FRONT DRIVER AND PASSENGER AIRBAGS. I HAVE ADDITIONAL PHOTOS AND A VIDEO THAT I AM WILLING TO SHARE IF YOU WOULD LIKE THEM. [XXX] [XXX] [XXX] [XXX] *DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*JB

NHTSA ODI 10957400

ON A RESIDENTIAL STREET DOING ABOUT 15 MPH. WITHOUT ANY WARNING VEERED TO THE RIGHT HITTING A PARKED CAR AND DOING EXTENSIVE DAMAGE TO MY KIA SOUL AND MODERATE DAMAGE TO A FORD EXPLORER. IT WAS MID DAY AND GOOD VISIBILITY AND I WAS ALERT ON FAMILIAR TERRITORY IN MY OWN NEIGHBORHOOD. I AM CONCERNED THAT EVEN THOUGH KIA AND NHTSA DON'T SHOW THIS VIN # IN THE STEERING RECALL HOW CAN I AND OTHERS BE SURE IT SHOULDN'T BE? CHP DID COLLISION REPORT. NHTSA CAMPAIGN NUMBER: 15V736000. PLEASE RESPOND THAT YOU HAVE RECEIVED THIS REPORT AND ANY FURTHER INVESTIGATION. *TR

NHTSA ODI 10939501

WHILE DRIVING IN REGENERATIVE BRAKE MODE AND COMING UP TO A STOP LIGHT, I LET THE REGENERATIVE BRAKE TO SLOW THE CAR TO AROUND 10 KM/HR THEN APPLIED THE NORMAL BRAKE TO SLOW DOWN THE REST OF THE WAY. THE BRAKE PEDAL DID NOT ENGAGE WHATSOEVER. I DID NOT FEEL ANY RESISTANCE AND THE PEDAL WENT ALL THE WAY TO THE GROUND. BECAUSE I COULDN'T STOP, I HIT THE CAR IN FRONT OF ME - LOW SPEED SO LUCKILY NO ONE WAS HURT. THERE WERE NO WARNING LIGHTS ABOUT BRAKE FAILURE EITHER BEFORE OR AFTER THE INCIDENT OCCURRED. PEDAL WAS FLOORED AND THERE WAS NO ACCELERATION, ONLY MILD DECELERATION (I.E. STILL FROM THE REGENERATIVE BRAKES PRESUMABLY) THUS I AM QUITE CONFIDENT THIS WAS NOT A CASE OF PEDAL MISAPPLICATION.

NHTSA ODI 10891740