What 1,236 owners told NHTSA about the 2016 Kia Sorento

Vehicle inspection catalytic converter fumes coming inside vents causing fire an frame issues

NHTSA ODI 11533117

WHILE DRIVING ON HIGHWAY WE WERE ALERTED BY OTHER DRIVERS THAT THERE WAS FIRE AND SMOKE COMING FROM THE ENGINE COMPARTMENT. WE PULLED OVER IMMEDIATELY AND WITHIN MINUTES THE ENTIRE VEHICLE BURST IN FIRE. WE CONTACTED KIA MOTORS REGARDING THIS AND THEY SIMPLY DENIED RESPONSIBLY FOR THIS, DEEMING THE CAUSE OF FIRE TO BE UNRELATED TO FAULTY ENGINE COMPONENTS.

NHTSA ODI 11322056

OCTOBER 10, 2018 DROVE CAR INTO DRIVEWAY, SHUT CAR OFF, PARKED, WENT INTO HOUSE FOR ABOUT 2 MINS, CAME BACK TO CAR, IT WAS SMOKING FROM UNDER HOOD. I TURNED ON FAUCET IN GARAGE, AND SPRAYED WATER ON CAR. CALLED 911. WITHIN 2 MINS, I SAW FIRST SPARK, LEFT AREA, RAN OVER TO MY SISTERS HOUSE, NEXT DOOR, ON PHONE WITH 911 AND WITHIN 4 MINS OF CAR SMOKE, BURST INTO FLAMES, 2 EXPLOSIONS. FIRE DEPT ARRIVED WITH IN 10 MINS OF SMOKE DETECTION. FLAMES HIGHER THAN THE HOUSE. CAR TOTALED, AND HOUSE SIDING MELTED AWAY FROM HOUSE.

NHTSA ODI 11150346

I WAS DRIVING ON A MAJOR INTERSTATE IN GA (I-75 SOUTHBOUND). TRAFFIC CAME TO A STOP; I WAS AT A COMPLETE STOP WHEN I WAS REAR ENDED AT 70MPH BY A 3500 DODGE RAM. I WAS PUSHED INTO THE CAR IN FRONT OF ME WHICH CAUSED MAJOR DAMAGE TO THE FRONT AND REAR OF MY VEHICLE. MY DRIVER'S SEAT BROKE, NOT A SINGLE AIR BAG DEPLOYED AND MY SEAT BELT DID NOT LOCK. THIS CAUSED MY FACE TO HIT THE STEERING WHEEL WHICH BROKE MY JAW IN TWO PLACES, DISLODGED TEETH AND CAUSED ME TO TEMPORARILY BLACK OUT. MY JAW REQUIRED EMERGENCY SURGERY AND I NOW HAVE A PLATE AND FOUR SCREWS IN MY JAW FOR THE REST OF MY LIFE - I'M 25 YEARS OLD. IN ADDITION TO THE PHOTOS BELOW, I HAVE DASH CAM FOOTAGE OF THE ACCIDENT AS IT HAPPENED WHICH I CAN PROVIDE. MY EMAIL IS [XXX] I CAN EMAIL IT IF NEEDED. THANK YOU FOR YOUR TIME PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *JS *TR

NHTSA ODI 11115749

TL* THE CONTACT OWNS A 2016 KIA SORENTO. WHILE STATIONARY, THE VEHICLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT STATED THAT SMOKE ENTERED THE VEHICLE THROUGH THE AIR CONDITIONING VENTS AND THAT FLAMES EMERGED FROM THE FLOORBOARD AREA NEAR THE DRIVER'S SEAT. IMMEDIATELY, THE CONTACT PULLED THE VEHICLE OVER TO THE RIGHT SIDE OF THE ROAD AND EXITED THE VEHICLE AS THE FRONT END BURST INTO FLAMES. THE CONTACT WAS UNSURE IF A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 50,000.

NHTSA ODI 11021721

TAKATA RECALL RENTED CAR FROM BUDGET. EXITED CAR AND THE BOTTOM CORNER OF THE DRIVER'S SIDE DOOR CAUGHT MY LEG PRODUCING A LARGE GASH IMMEDIATELY. UPON INSPECTION IT WAS CLEAR THAT THERE WAS A VERY SHARP PLASTIC MATERIAL AT THE BOTTOM CORNER OF THE DRIVER'S SIDE DOOR. THE VEHICLE WAS PARKED IN A LOT.

NHTSA ODI 10907351

MY WIFE HAD THE VEHICLE PARKED ON A SLIGHT SLOPE IN HER MOMS DRIVE WAY MAYBE A 10 DEGREE HILL. SHE PLACED THE VEHICLE IN PARK AND LEFT IT RUNNING WHILE MY DAUGHTER FINISHED A BIRTHDAY CARD SHE WAS MAKING IN THE BACK SEAT. MY WIFE STEPPED OUT OF THE VEHICLE TO GET SOME TISSUE PAPER OUT OF THE BACK WITH THE DRIVERS DOOR OPEN SHE PRESSED THE REAR DOOR /HATCH RELEASE OR OPEN BUTTON LOCATED ON THE DASH. SHE PRESSED THE BUTTON AT THAT MOMENT THE VEHICLE CAME OUT OF PARK AND WENT INTO REVERSE NEARLY RUNNING HER OVER SHE TRIED TO GET IN BUT THE VEHICLE TOOK OFF TO FAST SHE WAS KNOCKED OVER MY DAUGHTER WAS IN THE CAR ROLLING OUT OF CONTROL DOWN THE DRIVE WAY. THE VEHICLE FOLLOWED THE DRIVEWAY DOWN CROSSING THE MAIN ROAD ONLY DOING SOME LIGHT DAMAGE WHERE IT RAN OVER THE MAIL BOX AND STOPPED BY HITTING A TREE. WE CONTACTED KIA AND OUR INSURANCE. KIA OPENED A CASE #K3237787 AND THEN THEY HAVE NOT RESPONDED SINCE. WE TOOK THE VEHICLE TO THE DEALER WHERE IT WAS PURCHASED AND LEFT IT THERE. WE HAVE STILL NO ANSWERS WHAT THEY ARE PLANNING TO DO WITH THIS VEHICLE. THIS EVENT HAPPENED ON 7-25-2016. WE ARE REQUESTING SOME HELP DUE TO NOT HAVING A VEHICLE WE FEEL IS SAFE TO PARK AND NOT WORRYING ABOUT IT COMING OUT OF GEAR AND POTENTIALLY KILLING SOMEONE IN ITS PATH. WE ALSO WOULD LIKE TO HAVE OUR VEHICLE REPAIRED AND BACK TO DRIVE SINCE WE ARE PAYING FOR IT.

NHTSA ODI 10893348