What 1,237 owners told NHTSA about the 2016 Kia Sorento Plug-in Hybrid

The contact owns a 2016 Kia Sorento. The contact stated that while reversing out of the garage, she noticed there was a puddle of oil on the ground. The vehicle was taken to the dealer and diagnosed with an engine oil pressure switch leak. The oil pressure switch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that they would contact her back in 3 - 5 days. The contact related the failure to NHTSA Action Number: DP21002 (Engine, Engine and Engine Cooling). The failure mileage was approximately 78,000.

NHTSA ODI 11443877

the car is very bad for manufacture the gasket rocker is in bad conditions almost fired my car the oil is allot the liquid inside the my motor .is allo the noise , the dealer can responsibility for recall because kia close the recall is not fair my car is 2016 is dangerous for my family and for my kids almost pay for this car 25,000.00thousand dollars . am pay for the fixed yesterday 336.32, and the car is not work very well .am make the appointment in july 17 and the dealer give me the appointment very late september 23 , and later say is closed the decal ....am very sad now for my car.... and for the money for fixed this car....the car stop in the avenue almost dead for crash the other car with me and my kids.

NHTSA ODI 11434214

The contact owns a 2016 Kia Sorento SX. The contact stated while driving at 65 MPH, the vehicle inadvertently became overheated and he saw smoke coming from underneath the hood of the vehicle. There were no warning lights illuminated. The contact veered to the side of the road and turned off the vehicle. The vehicle was towed to the dealer who informed the contact that the head gasket or the engine would need to be replaced. Then, the vehicle was towed to a second dealer(Matthews Kia of Cartersville 595 E Main St, Cartersville, GA 30120) who diagnosed that the engine bolts were backing out of the engine block allowing the exhaust to be released into the cooling system. The manufacturer was notified of the failure and advised the contact that they could not assist as the vehicle was out of warranty. A case was opened and the contact was awaiting a call back from the manufacturer. The vehicle was not repaired. The approximate failure mileage was 115,000. The service manager at Matthews Kia said he was replacing seven engines per week and that this was a manufacturers defect from the factory that affected early 2016 models. He also said that the defect normally occurs between 100,000 miles and 120,000 miles, just as the vehicle goes out of warranty. Consumer purchased an enhanced warranty at the time of purchase of the automobile. There were no warning lights or codes thrown when engine failed. The service manager said there was nothing consumer could do to prevent this because it is a manufacturing defect.

NHTSA ODI 11434099

In the past year my vehicle has exhibited a high consumption of oil. At present it has 92000 miles. At last check it consumed 1.7 quarts of oil in 750 miles. I have done as request by Kia. They request I do an oil change at the dealer followed up by checks at 1000 miles ( 2 quarts low). At the check at 2000 miles it was again 2 quarts low. They performed what they called a combustion chamber cleaning that was again followed by a check at 1000 miles (1.1 quarts low). After the next check it was at the 1.7 quarts used in 750 miles. Although Kia advertises a 10 year 100000 mile warranty they are excluding me from repair because I am the second owner. I did purchase an extended warranty for 4 years and up to 100000 total miles but I didn’t find the problem until March / April of this year. Kia admits this was caused by soft, improperly heated rings but will not offer any assistance to alleviate the problem. Do I have any recourse with Kia on this and can you help?

NHTSA ODI 11429503

2016 KIA SORENTO. CONSUMER WRITES IN REGARDS TO VEHICLE WILL NOT SHIFT PROPERLY AND FAILED TO ACCELERATE OVER 30 MPH. *SMD THE MANIFOLD ASSEMBLY INTAKE WAS REPLACED THREE TIMES. *JB

NHTSA ODI 10816108