What 748 owners told NHTSA about the 2016 Kia Optima

These cars have a known issue for burning oil the motor thats in my car was recalled for same issue but they are not trying fix my car under that recall of the bad motor that they did recall

NHTSA ODI 11723153

2016 Kia Optima engine locked up, vehicle stalled on interstate,heard a rod bearing sound, left me in limp mode trying to get out the way of 18 wheelers traveling behind me. Towed into Kia dealership which confirmed the engine locked up which has a recall #PI1802B KSDS, but denied to cover it because I didn't have this recall done. I also called Kia Customer Service, they denied me too and just gave me a case #[XXX]. I explained to them that I never received notice of this recall. So how could I prepare for something like this to happen while traveling from Texas to Louisiana to visit my grand kids. The dealership gave me a Quote of $9735 for parts and labor, which I don't have, I am still making payments on this vehicle. Now I am stuck in Louisiana with my vehicle, also it's going to cost me even more to have it towed back to Texas. Please help me understand why the dealership won't stand behind a safety recall or what one person I spoke with called a campaign recall, which ever! That I never received notice about this recall. I hope the "President" or the "President of the Company" will step up and help, after all we as Citizens don't have a problem spending our hard working money on purchasing these vehicles from the dealerships, to have things like this to happen out of our control. Thanks for at least Listening. GOD BLESS...INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11722291

Engine oil light doesn’t work. Oil light flashed a couple of times in separate instances. Checking oil dip stick which smells like burning oil and dip stick hardly showed any oil left.

NHTSA ODI 11721839

engine light start blinking out of no where and speed started to reduce while on the highway. my fix finder gave me code P1326

NHTSA ODI 11719661

The contact owns a 2016 Kia Optima. The contact stated that while driving at 60 MPH, the vehicle stalled with the check engine light illuminated. The brake pedal was depressed, and the steering wheel seized. The contact was able to pull over to the side of the highway and contacted the Highway Patrol for assistance. The contact associated NHTSA Campaign Number: 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE); with the failure; however, the VIN was not included in the recall. The vehicle was towed to the residence. The dealer was not notified. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.

NHTSA ODI 11718486

The contact owns a 2016 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. No warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the knock sensor needed to be installed prior to the failure for the engine replacement to be covered under warranty. The failure mileage was approximately 143,000.

NHTSA ODI 11718631

My vehicle’s engine was previously approved for replacement under the lifetime engine warranty associated with the settlement, confirming that my vehicle falls within the covered class. However, I am now experiencing significant difficulty obtaining assistance regarding secondary damage that directly resulted from the engine failure, specifically the failure of the starter and related operability issues. Despite multiple attempts to resolve this matter through the dealership and warranty channels, I have been repeatedly redirected without meaningful assistance or clear resolution. I have also encountered discrepancies within the online settlement VIN verification tool, which appears inconsistent with Kia’s prior acknowledgment of my vehicle’s settlement-related coverage.

NHTSA ODI 11716972

In order to repair the recalled equipment on the vehicle the dealerships and Kia want us to pay for them to open the trunk ($280/hour service fee to remove the back seat to gain access to the trunk and then return the back seat once completed). If the trunk latch was NOT broken to begin with they would not have to remove and replace the back seat of the car at $280/hour you would be able to push the button and open it. I don’t feel it is the car owner responsibility to pay for that access to the trunk.

NHTSA ODI 11715623

The engine stalled without warning while I was pulling out of my driveway into the street, creating an unsafe condition due to sudden loss of power. After waiting briefly, the vehicle restarted and was moved back into the driveway. It was towed the following day due to loss of confidence in safe operation. The vehicle was diagnosed with engine failure consistent with known defects affecting Kia Optima vehicles equipped with Theta II engines. Kia denied coverage under the extended engine warranty / class action settlement solely because the KSDS (PI1802 ECU update) had not been installed prior to the failure. As the second owner, I was never notified of this update before the incident and had no opportunity to complete it. This failure was sudden, unanticipated, and safety-related. I am submitting this complaint to document an engine stall and loss of power condition posing a safety risk.

NHTSA ODI 11715316

The engine is a problem and all I’m ever told us “ this vehicle is know to have engine problems. This is dangerous to have in the road. Kia is aware of this. Why sale the vehicle knowing this and not disclosing this info to the consumer upon purchase. There is no truth in lending. It’s plain sight robbery. What if I’m far from home and stranded because vehicle set fire or broke down in hazardous condition weather. I constantly needing oil changes because of this engine. The dealership is aware. They tell me to trade it in or get rid of it because it’s going to go for a fact. I’ve never missed oil changes. I put oil every time the oil indicator light comes on. Now for the 3rd time the check engine light is on. 2 times for misfire code. The vehicle engine holds sludge no matter how much you get oil changes. The mechanic told me this year make and model is known for this very fact. I want my money back. Kelly blue book don’t give enough. I was scammed into this car but I managed to pay it off. A car the sales person scammed me and wouldn’t take the vehicle back. I complained to the general manager. They always act like he wasn’t available. They kept claiming new ones started. After almost a year of those games I had to move and the case never got solved. But even when I complained their maintenance person stole my rims. They told me prove it. Just all bad experience. I just want my money. Even if they gave me another engine. It’s still going to be the same problem. A bad engine. 2016 Kia optima’s should not have been continuously sold with them knowing it has bad engines. Even the headlights don’t work. Very dim. Car smells like burning fumes when driving. Please please help. This isn’t fair lending practice. People trust them and they are dishonest sellers.

NHTSA ODI 11714744

My 2016 Kia Optima experienced a sudden catastrophic engine failure in July 2025. The failure is consistent with widely reported Theta II engine rod bearing defects that cause engine seizure and stalling. The vehicle did not receive the Knock Sensor Detection System (KSDS) update prior to my ownership, and I was never notified of this critical safety-related update. The engine failure occurred without warning and could have resulted in loss of power while driving, creating a serious safety risk. This vehicle model year has a documented history of engine defects and class action settlements related to premature engine failure. I believe this represents an ongoing safety defect. I am requesting that NHTSA review this failure as part of its investigation into Kia Optima engine defects.

NHTSA ODI 11714650

While driving my 2016 Kia Optima, the vehicle experienced a sudden and complete loss of engine power and stalled without warning. At the time, I was Door Dashing for income. The engine seized and the vehicle came to an immediate stop in the middle of 4925 Wolf Creek Dr SW, Atlanta, GA, a narrow two-lane road with limited street lighting. I was forced to remain stopped in the roadway in darkness for over an hour while multiple oncoming vehicles passed by, creating a serious safety risk. The vehicle could not be restarted and had to be left on the roadside overnight. The following day, the vehicle would only start briefly when jump-started, ran for approximately 15 seconds, and shut off again. It could not move and was towed to an authorized Kia dealership. At the dealership, technicians jump-started the vehicle, performed diagnostics, added engine oil, cleared codes, reset adaptive values, and conducted a test drive. During that test drive, the engine seized again, and the vehicle had to be towed back. Kia approved a full engine replacement under its extended engine warranty, acknowledging engine failure consistent with known defects. However, after the engine replacement, the vehicle would not start at all. Kia stated oil intrusion from the failed engine damaged electronic components, leaving the vehicle non-operational. Kia denied coverage for the resulting damage and issued an estimated $6,000 repair bill for engine harness, injector sub-harness, and ECU replacement. The vehicle remains inoperable following an approved warranty repair. This incident involved sudden loss of propulsion while driving, occurred without warning, resulted in repeated engine seizure, and left the vehicle disabled in traffic at night. This appears consistent with known Kia engine defects and presents a serious safety concern that warrants investigation.

NHTSA ODI 11711035

Car is burning a lot of oil, took to dealer went through several tests and they claim burning 1.5 quarts was within limit for 1000 miles. Then started getting misfire codes and car went into limp mode a couple of times. They said to replace spark plugs because they were fouled and clean injection. Performed those requested actions, then 45k later getting misfire codes again, took to another dealer they said plugs are fould and clean injection again. Asked them to provide a permanent fix for the issue so the car does not keep fouling out the plugs and they said the only way to fix was to replace the motor. I asked, since you have no guaranteed fix why don't you replace the defective motor under warranty. They said because it is not locked up or throwing a specific code detecting a knock in the motor. So I said the motor will have to completely fail before a replacement would be approved they said yes (basically suggesting I somehow blow up the motor). This is wrong, a product under warranty from manufaturer and cannot be fixed without replacing the part should be covered. I do not know what my options are at this point, the milage warranty has run out and they will not do anything to fix it, just bandaids until it dies. the dealers would not put it in writing only verbally telling me.

NHTSA ODI 11709938

Engine brocked the pistones brock stock engine and pay for new engine

NHTSA ODI 11707061

The contact owns a 2016 Kia Optima. The contact stated that while driving approximately 40 MPH, a knocking sound coming from the engine compartment was heard, and the check engine warning light illuminated. The contact further stated that while driving at approximately 80 MPH, with the cruise control mode engaged, the vehicle started to stall and failed to exceed 30 MPH. The contact stated that the cruise control became inoperable, and the check engine warning was flashing. The vehicle was restarted; however, the vehicle continued to hesitate and failed to exceed 30 MPH while driving. The dealer was contacted, but the vehicle was not diagnosed or repaired. The contact was referred to the NHTSA hotline for further assistance. The manufacturer was not made aware of the failure. The approximate failure mileage was 70,000.

NHTSA ODI 11705384

My 2016 Kia Optima is experiencing severe internal engine oil consumption that matches known issues Kia has recalled and extended warranties for. The vehicle loses 1–3 quarts of oil every few days with no external leaks. A repair shop found a P0304 cylinder 4 misfire, P0010 cam actuator code, and spark plug damage caused by oil entering the combustion chamber. They confirmed internal engine damage and abnormal oil consumption. The Kia dealership refused to assist due to mileage, even though this issue matches the engine defects covered under Kia’s litigation settlement and warranty extensions. The excessive oil consumption creates a dangerous safety risk, including engine stalling, loss of power, and potential engine seizure while driving. I am requesting NHTSA review because the vehicle’s condition is unsafe and part of a widespread engine defect.

NHTSA ODI 11704086

The engine lost cylinder 3, piston came loose and broke the spark plug. This happened because the rod bearing came loose which has been a known issue with Kia. There’s already been a class action law suit, and recall with warranty. Now the Kia dealership in Lynchburg has refused to honor this warranty. Stating they can’t do the required rod bearing clearance test because the engine doesn’t have compression. The engine has no compression because the rod bearings came loose and shoved the piston into the head.

NHTSA ODI 11702141

The contact owns a 2016 Kia Optima. The contact stated that while driving at various speeds, the vehicle suddenly stalled. After restarting the vehicle, the vehicle operated normally. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was provided. The manufacturer was not notified of the failure. The failure mileage was 100,000.

NHTSA ODI 11700553

While driving, the vehicle suddenly developed a loud knocking noise from the engine. Within one block the vehicle began smoking heavily from under the hood. I pulled over, opened the hood, and flames were visible. This is a 2016 Kia Optima with the 2.4L Theta II engine. Approximately one year ago the original engine seized and was replaced by a Kia dealer under the Theta II engine recall (SC172/SC147) and class-action settlement. This is the second catastrophic failure of a Theta II engine in this vehicle. The replacement engine has now failed in the exact same manner as the thousands of other documented cases — rod bearing failure leading to knocking, overheating, and engine compartment fire. The dealership (Fowler Kia of Windsor, CO) inspected the vehicle and quoted over $6,000 in repairs (melted engine wiring harness, ECM connector, battery cables, airbox, intake boot, etc.) while claiming the fire was “unknown cause/not the engine,” despite the clear knocking immediately preceding the fire. Kia Consumer Affairs has an open case but has not yet resolved coverage. This is a known, ongoing safety defect covered under multiple NHTSA investigations (PE21004, EA22002) and Kia recalls. I no longer feel safe in this vehicle and am requesting immediate investigation and inclusion in any expanded recall or remedy.

NHTSA ODI 11700454

Vehicle: 2016 Kia Optima LX Turbo – Approx. 114,155 miles** This complaint concerns ongoing systemic defects affecting the electrical, braking, and engine management systems of the referenced vehicle. Despite multiple documented repair attempts, the failures persist, creating continuous and significant safety hazards. The vehicle has experienced repeated electrical system malfunctions, including multiple battery failures (three replacements within one year), sustained low-voltage conditions, and intermittent lighting loss. Notably, the headlights and exterior lighting have shut off unexpectedly during extended highway operation. The brake control system is also compromised. The electronic emergency brake has engaged spontaneously while the vehicle was in motion, causing abrupt deceleration without driver input. Additionally, the vehicle exhibits continuous fuel vapor and engine performance defects. The purge valve has been replaced four times, yet the failure recurs. The vehicle frequently hesitates upon acceleration, exhibits delayed throttle response, and jerks during takeoff, creating hazardous conditions when merging into traffic or crossing intersections. Given the repeated nature of these defects and the lack of resolution through standard repairs, I believe the vehicle may contain inherent design or manufacturing defects affecting the electrical charging system, ECU, fuel vapor management components, and electronic braking controls. I request that NHTSA conduct an investigation into these safety-related defects.

NHTSA ODI 11699731

My engine blew up and started smoking while driving

NHTSA ODI 11698745

Car stop accelerating when I went to get my oil change the shop reported my engine eating up my oil found out kia have a recall on engine

NHTSA ODI 11697872

Hear the driveshaft clicking and doesn’t accelerate like it should

NHTSA ODI 11697290

White paint is chipping away excessively

NHTSA ODI 11694901

The body paint is cracking and falling down. Since five years ago this problem started.

NHTSA ODI 11694035