What 1,536 owners told NHTSA about the 2016 Hyundai Tucson Fuel Cell

TL* THE CONTACT OWNS A 2016 HYUNDAI TUCSON. WHILE DRIVING AT A LOW SPEED AND MAKING A SHARP LEFT TURN, THE STEERING WHEEL SEIZED WITHOUT WARNING. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A BARRIER. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO HERITAGE HYUNDAI TOWSON (801 YORK RD, TOWSON, MD 21204, (877) 387-5495) WHERE IT WAS DIAGNOSED, BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,738.

NHTSA ODI 11174490

VEHICLE WAS IN DEALERSHIP FOR TRANSMISSION MULTIPLE TIMES THEN LAST WEEK A FUEL PUMP NOW AT THE DEALERSHIP DUE TO THE FACT VEHICLE CAUGHT FIRE AS I WAS DRIVING IT AND PULLING UP T =O MY HOME

NHTSA ODI 11171030

I WAS AN OWNER OF A 2016 HYUNDAI TUCSON WITH TURBO. UNTIL JANUARY 23, 2018. I OWNED THIS VEHICLE FOR MORE THAN A YEAR AND ALTHOUGH THIS WAS A GREAT VEHICLE WE HAD AN ISSUE WITH THE TRANSMISSION SINCE A WEEK AFTER OUR PURCHASE DATE.WE HAVE HAD IT BACK TO THE SERVICE DEPARTMENT AT WRIGHT WAY HYUNDAI IN STAUNTON, VA NUMEROUS TIMES OVER THE SAME ISSUE. THE TRANSMISSION WOULD ALLOW THE MOTOR TO SEND THE RPMS TO EXCEED A HIGH LEVEL BEFORE ENGAGING. SO BAD AT TIME THAT IT WOULD PULL YOU TO ONE SIDE OF THE ROAD OR THE OTHER, ALSO FROM A STOP IT WOULD REV UP SO BAD THAT IT WOULD TAKE OFF SPINNING. I HAVE CONTACTED HYUNDAI OVER THIS MATTER INCLUDING OTHER DEALERSHIPS. I HAVE BEEN TOLD EVERYTHING FROM 'THAT'S THE WAY IT WAS DESIGNED' TO 'YOU HAVE TO LEARN HOW TO DRIVE IT'. IT ALWAYS WOULD COME DOWN TO THAT IT WAS THE WAY WE WERE DRIVING IT. I'M SORRY BUT A TRANSMISSION SHOULD NOT RESPOND IN THAT MATTER. I ALSO WAS TOLD BY A HYUNDAI REP. THAT THEY HAVE HAD MANY COMPLAINTS OVER THE SAME ISSUE.I WAS TRAVELING DOWN THE ROAD AND WAS APPROACHING A CURVE WHEN I LIFTED MY FOOT OFF THE ACCELERATOR AND WHEN I WENT BACK TO THE ACCELERATOR THE RPMS SHOT UP. IT WOULDN'T GO. I PUSHED AGAIN, AND THE RPMS SHOT UP AND THEN SUDDENLY IT ENGAGED AND WHEN IT DID I WAS PULLED LEFT ACROSS THE ONCOMING LANE AND OVER A STEEP 30-FOOT EMBANKMENT INTO ABOUT 5 FEET OF VERY COLD WATER. I WAS TAKEN TO THE HOSPITAL IN AN AMBULANCE AND I WAS CHECKED OUT WITH MINOR INJURIES. AND NO I WASN'T SPEEDING.

NHTSA ODI 11079183

DRIVER TRAVELING AT 30-40 MPH, STRUCK ANOTHER VEHICLE BROADSIDE. ON CITY STREET. FRONT END OF VEHICLE SMASHED. CAR DECLARED TOTALED. AIR BAG DEPLOYED BUT ONLY 1-2 INCHES THEN DEFLATED. DRIVER STRUCK STEERING WHEEL AND SUFFERED FACIAL, AND BODY INJURIES INCLUDING CRACKED STERNUM. LEASER, AND INSURANCE COMPANIES NOT CONCERNED ABOUT AIR BAG. OFFERED ONLY MEDICAL ATTENTION. ATTORNEY NOT INTERESTED AS THIS BAG NOT ON RECALL LIST, YET. WARNING TO OTHERS OF POSSIBLE FAULTY AIR BAG.

NHTSA ODI 11010256

WE PURCHASED A 2016 TUCSON LIMITED ON BLACK FRIDAY OF 2016. THIS VEHICLE WAS EQUIPPED WITH THE AUTONOMOUS EMERGENCY BRAKING (AEB) SAFETY OPTION, AS IS ADVERTISED AND DEMONSTRATED ON THE HYUNDAI WEBSITE WITH VIDEO. WE EXPERIENCED A MINOR FRONT-END COLLISION AT APPROXIMATELY 8-10 MPH WHILE MERGING INTO TRAFFIC AT A YIELD FROM HIGHWAY EXIT RAMP. BASED ON THE ADVERTISED FUNCTION AND VIDEO, SHOULD HAVE BEEN PREVENTED BY THE AEB. SUBSEQUENT TO THIS COLLISION, WE BEGAN SEEING INTERMITTENT WARNING NOTIFICATIONS TO CLEAN THE FRONT RADAR EVEN THOUGH THERE WAS NO DIRT OR ANY OBSTRUCTION. THESE MESSAGES WOULD SPONTANEOUSLY CLEAR AFTER APPROXIMATELY 30-60 SECONDS. WE TOOK THE VEHICLE TO THE DEALERSHIP TO BE EVALUATED. THE VEHICLE WAS WITH THE DEALERSHIP FOR ALMOST TWO WEEKS AND AFTER EXTENSIVE TESTING - WHICH INCLUDED MULTIPLE ROAD TESTS, MULTIPLE SIMULATED OBSTRUCTION DETECTION, A PEDESTRIAN CHALLENGE BY THE SERVICE MANAGER, LITERATURE REVIEWS, AND AN ONSITE EVALUATION FROM HYUNDAI ENGINEERING ' AND AFTER ALL OF THESE EVALUATIONS, THE SERVICE DEPARTMENT WAS ALSO UNABLE TO TRIGGER THE AEB UNDER ANY CONDITIONS ALTHOUGH THE ELECTRONIC SCAN INDICATES THAT THE RADAR IS OPERATIVE. THEY HAVE RETURNED THE VEHICLE TO US WITH THE STATEMENT THAT IT IS FUNCTIONING AS INTENDED. THE AEB IS NOT DEMONSTRABLY FUNCTIONING, REGARDLESS OF RADAR OPERATION.

NHTSA ODI 10970019

HAD AN ACCIDENT WHILE PARKING THE ACCELERATOR JUST TOOK OFF ON ITS OWN IT STOP BECAUSE IT HIT A CONCERT WALL./REPORTED THE ACCIDENT TO HYUNDAI AND THEY SAID TO JUST FIX.I LATER FOUND OUT THAT THEIR IS A RECALL ONLY ON CERTAIN VIN NUMBERS WELL CAR VIN NUMBER IS NOT ON THE LIST BUT I STILL HAD THE ACCIDENT. GOT IN TOUCH WITH THERE CORP OFFICE THEY CALL ME TOOK ALL MY INFORMATION AND I HAVE NOT HEARD FROM NOBODY. I STILL FEEL UNCOMFORTABLE WITH THE DRIVING. *TR

NHTSA ODI 10923734

I WAS STOPPED AT A STOPLIGHT, BUT WHEN THE LIGHT TURNED GREEN THE CAR WOULDN'T GO FORWARD. INSTEAD THE ENGINE JUST REVVED AND RPMS WENT UP, BUT NO MOVEMENT FORWARD AND NO WARNING LIGHTS OR SOUNDS CAME ON. I IMMEDIATELY FLIPPED ON MY EMERGENCY FLASHERS AND TRIED SEVERAL TIMES TO RESTART AND GO AGAIN, BUT TWO CARS CRASHED INTO EACH OTHER NEXT TO ME AS THEY TRIED TO GO AROUND ME. I SAT IN A PANIC IN TRAFFIC WITH PEOPLE HONKING AT ME AND FLIPPING ME OFF. THE CAR WOULDN'T DRIVE FORWARD, BUT IT WOULD GO IN REVERSE SO AS THE CARS CRASHED INTO EACH OTHER AND WERE COMING TOWARDS ME I DODGED GETTING HIT BY A FEW INCHES AND DROVE SLOWLY DOWN THE STREET IN REVERSE AND INTO A NEARBY PARKING LOT IN REVERSE. THEN I PARKED AND HAD THE CAR TOWED TO A DEALER. IN THE PARKING LOT I TOOK VIDEO EVIDENCE OF THE CAR NOT DRIVING FORWARD, BUT ABLE TO DRIVE IN REVERSE SO I DO HAVE VIDEO PROOF. THE CAR HAS ABOUT 5,500 MILES ON IT AND ALREADY HAD AN ECM RESET / ACTIVE TRANSMISSION RELEARN DONE AT ABOUT 1,000 MILES BACK IN JANUARY WHEN THE CAR WAS LAGGING THE FIRST MONTH I OWNED IT. MY CAR IS STILL AT THE DEALERSHIP AND FOR A CORRECTION THEY DID ANOTHER ACTIVE TRANSMISSION RELEARN/PROGRAMMING RESET AND SAY THE CAR WORKS AND IS FINE NOW AND READY TO PICK UP. I'M NOT COMFORTABLE DRIVING A CAR THAT'S BEEN IN TWICE FOR TRANSMISSION PROBLEMS AND HAD THE SAME CORRECTION DONE. I DON'T FEEL CONFIDENT THIS WON'T HAPPEN AGAIN AND MOST ONLINE REPORTS I READ WITH THE SAME PROBLEM AND CORRECTION SAY IT HAPPENS OVER AND OVER AGAIN. I FILED A COMPLAINT WITH HYUNDAI CUSTOMER CARE. I'VE ALSO READ THERE IS A PART THAT MAY BE REPLACED AS A FIX (FP NUMBER 41470-2D011 ACTUATOR ASSY-CLU) AND POSSIBLY A RECALL COMING UP, BUT THE DEALER SAID I NEED TO WAIT FOR THE RECALL. IT WOULD BE GOOD TO EXPEDITE ANY FIX AND REPAIRS BEFORE MORE ACCIDENTS HAPPEN, DRIVING THIS CAR IS NOT SAFE FOR ME OR OTHER CARS AROUND ME.

NHTSA ODI 10892643

PARKING VEHICLE AT MY APARTMENTS WHEN THE ACCERLATER JUST TOOK ON ITS OWN. IT CAUSE ME TO HAVE AN ACCIDENT. HAD TURN KEY OFF AND HIT THE BULIDING. IT WAS STATIONARY. JUST PARKING ON A FLAT PARKING AREA

NHTSA ODI 10889197

TL* THE CONTACT OWNS A 2016 HYUNDAI TUCSON. WHILE DRIVING 40 MPH, THE VEHICLE DECELERATED AND THE TRANSMISSION OVERHEAT WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE THROUGH THE REARVIEW MIRROR. THE CONTACT COASTED TO THE SIDE OF THE ROAD, RESTARTED THE VEHICLE, AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED, BUT THE TECHNICIAN COULD NOT FIND A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5,000.

NHTSA ODI 10884924

PURCHASED JANUARY 2016 - LIMITED AWD WITH FACTORY INSTALLED TOW HITCH. IMMEDIATELY NOTICED FLICKERING INTERIOR LIGHTS AND BOTH HEAD LIGHTS LEAKED, ONE SIDE HAS BEEN REPLACED. LATER ON DEVELOPED HARD START UPS, SHIFTING AND ACCELERATION ISSUES. ALONG WITH INTERMITTING FRONT SAFETY SENSORS AND A GLITCHING CENTER CONSOLE/BACK UP CAMERA. 7,500 MILES IN THE AC STOPPED WORKING FROM FREEZING OVER. TOOK TO DEALER WHILE ON VACATION AND DISCOVERED A MELTED FUSE BOX COVER AND BURNT TOW HITCH/ECU WIRES WITH AN ABUNDANCE OF CORROSION. DEALERS COULD NO CONFIRM RESPONSIBILITY OF THE TOW HITCH HARNESS, CLAIMED IT WAS NOT FACTORY INSTALLED WHEN IT WAS FACTORY INSTALLED AND EVEN ON THE ORIGINAL WINDOW STICKER. WE CALLED HYUNDAI CORPORATE EVERYDAY FOR OVER A WEEK BEGGING FOR HELP WITH NO CALL BACKS. ROADSIDE WOULD NOT COVER A TOW TO THE SELLING DEALER. ENDED UP DRIVING OURSELVES AN HOUR SOUTH TO THE DEALER WHERE IT WAITS FOR A HYUNDAI ENGINEER TO FLY IN AND LOOK AT IT. THERE ARE RECALLS FOR THIS WIRING HARNESS IN OTHER MODELS, THE DEALER WASN'T EVEN ABLE TO ORDER A REPLACEMENT PART BECAUSE IT WAS DISCONTINUED. WE WERE NEVER NOTIFIED OF THIS AND THERE ARE NO RECALLS CURRENTLY OUT FOR OUR CAR. WE CONSIDER THIS A LIFE THREATENING ISSUE AS THE MELTING WIRES ARE A SERIOUS FIRE HAZARD ALONG WITH THE UNRELIABLE TRANSMISSION AND SAFETY SENSORS.

NHTSA ODI 10873526

I WAS DRIVING APPROXIMATELY 65MPH EAST ON INTERSTATE 10 IN LOUISIANA AROUND MILE MARKER 257.3 WHEN THE HOOD LATCH FAILED AND MY HOOD FLEW UP, SMASHING MY WINDSHIELD AND COMPLETELY BLOCKING MY FIELD OF VIEW. THERE WERE NO CARS AROUND ME AS IT WAS 4:30 AM AND I WAS ABLE TO SAFELY PULL OFF TO THE SIDE OF THE HIGHWAY. IT APPEARS THAT BOTH THE PRIMARY AND SECONDARY HOOD LATCHES HAVE FAILED, CAUSING THE HOOD TO FLY OPEN.

NHTSA ODI 10860551