What 1,061 owners told NHTSA about the 2016 Honda Civic Type R

Both steering and brake system warning lights came on and steering wheel locked in to place with no prior warning indications of power steering rack failure.

NHTSA ODI 11544169

The contact owns a 2016 Honda Civic. The contact stated that while driving at various speeds, the steering wheel became firm, and was sticking while turning in either direction. The contact stated that the failure was more noticeable while driving at highway speeds, and caused the vehicle to drift to either side, causing the driver to make addition steering wheel adjustments to keep the vehicle driving straight. The vehicle was taken to the local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 60,000.

NHTSA ODI 11541144

I have a 2016 Honda civic around 48,000-50,000.00 miles I have noticed that the steering in my vehicle gets sticky/stuck while driving. This usually occurs on the highway while I’m driving at higher speeds and when I’ve been on the road for about 30 minutes. While driving on the highway the steering wheel gets “stuck” towards the left and I have to pull it to correct this position. It has made me fearful while driving especially at high speeds and I feel like the entire drive I have to white knuckle the wheel. If I do not continue to make the correction then the car would veer off into another lane. This is extremely dangerous and unsafe. It has also happened while I’ve slowed down to a traffic light and when I pulled the steering wheel back out of the sticky position I heard an adamant click. I started researching and saw there are hundred if not thousands of these reports. I did send Honda a message to open a case which they sent a standard message back just saying to bring it to the dealer and closed the case. This needs to be fixed or rectified by Honda. I saw that there were some lawsuits but that they didn’t include 2016. It seems that the problem with all of these is the EPS Rack Assembly which is a fault with the manufacturer.

NHTSA ODI 11540717

Our vehicle has just over 60,000 miles and has developed a significant "sticking" in the steering. This starts at around 50 miles per hour and gets progressively worse as speed increases. It doesn't completely seize but requires significant pressure to break the sticking. This could easily result in an overcompensation that leads to a loss of control. Once over 50 miles per hour, this issue requires constant attention by the driver. It is not an intermittent issue. We took this vehicle to a Honda dealer for repairs in July, but it still hasn't been repaired yet due to a shortage of the parts needed to repair this issue that is apparently well known by the Honda service technicians. Insult to injury is that once this is repaired, it will cost me over $3,000 as Honda has rejected our request to cover this repair.

NHTSA ODI 11540494

Steering wheel sticks and you are not able to change direction without using excessive force. This happens when driving at highway speeds and seems to be worse (more force needed to turn wheel) at higher temperatures, 80+. The sticking steering causes you to oversteer and may cause you to lose control of the vehicle and crash.

NHTSA ODI 11539240

I bought my Honda new in 2016 from Space Coast Honda in Cocoa, Florida. It had 0 miles. Since 2016 I have had 5 separate issues with the air conditioner, and have had to repeatedly go back to Space Coast Honda. They released a warranty for the condenser, but refuse to acknowledge problems with the evaporator. There are many many people with a 2016-2018 Honda Civic who experience issues with the evaporator and Honda wants people to pay over $2000 to fix the issue. I find it hard to believe that these issues aren’t all related. Honda needs to be held accountable for manufacturing faulty models of the 2016 Honda Civic.

NHTSA ODI 11538723

Sticky steering wheel, feels notching while driving

NHTSA ODI 11538102

My Honda Civic with manual transmission, suddenly would not go into gear and lost power (engine still running). Fortunately, I was able to coast to the opposite side of the road across oncoming traffic, since there was no right shoulder. After a tow home, I discovered that the manual clutch slave cylinder was detached from the engine block (photo attached) and of the 2 connecting bolts (photo attached), one was sheared and the other was intact but unconnected. The last service to the vehicle was with Manly Honda service in Santa Rosa, CA replacing the AC condenser and compressor. I called them to see if they had not secured the 2 bolts after completing the AC service. The service manager said that they would not have removed this clutch slave cylinder in the AC service. I advised the service manager that if the clutch cylinder had not been removed by them, then it could be a safety hazard issue that should be reported to Honda Motors. After some online research, I have discovered that this problem has been experiened by other Honda Civic owners.

NHTSA ODI 11537446

Steering intermittently sticks when trying to make small adjustments to stay in lane. It has been doing this for the last couple years.

NHTSA ODI 11537080

The steering sticks around highway speeds which causes me to over correct. The vehicle feels unsafe to drive and I am being told it will cost close to $4,000.00 to replace the electronic steering rack.

NHTSA ODI 11536937

A/C system.- compressor &/or shaft seal leak- As we were driving our BRAND NEW Honda civic to Las Vegas for our daughter’s wedding on July 12, 2019 in the heat of 115 degrees, the AC stopped working & started blowing hot air, we were forced to continue our 5 hour journey in this unsafe driving condition since it was our daughter’s wedding. This was at 36,100 miles, just 100 miles out of warranty. The recall had not happened yet & we were unaware other people were experiencing the same issues with this same AC system Honda used. I Took it to my local Honda dealer upon return of the torturous unsafe trip and they wanted $3000 to fix the problem they took no blame for it. I immediately filed a complaint with safecar.gov #11322455. 4 years later, PARTS of the Ac system were recalled & I was sent a letter from American Honda stating show us the invoices you had to pay before the recall happened. I did exactly what they said and they denied all of my expenses. I am in shock. This was not my problem their defected AC system leaked Freon. That was their system that they put into that brand new car that was worthless. They cut corners used a cheaper outside contractor it’s obvious. I have $552.93, in repairs that American Honda has refused to reimburse me for and I went through the whole process they requested it’s not right. I should be paid for what I had to pay on that AC system before the recall. It was not my fault it was their fault.

NHTSA ODI 11537025

Air conditioner in my 2016 Honda Civic has never worked. Condenser or compressor needs to be replaced continues to leak throughout system and is defective. Emergency Brake malfunction does not work and poses as a safety issue. Left head lamp doesn’t work due to excessive heat exposure in Nevada.

NHTSA ODI 11536240

I recently moved so I am traveling on the interstate more. In doing so, I've noticed after about 15-20 minutes at higher speeds, my steering wheel starts sticking. I have to fight to stay in my lane. It's scary as well as exhausting. I've researched and see other complaints just like mine. Why has this issue not been addressed by Honda? It makes me scared to go visit family or do any traveling at all. I bought this vehicle used in 2019 but this issue really didn't surface until I moved and started driving more on the interstate. I noticed it some before but since most of my driving was in town, it didn't occur often. Please have Honda address this as it definitely is a safety issue. I feel like I'm going to drive off the road the whole time I'm on the interstate.

NHTSA ODI 11535692

While driving on the freeway at 70-80mph the car begins to lose acceleration, stutters and faults all fault codes on the car. Car then begins to brake itself to a stop all while on a freeway at a high rate of speed. I have to pull over to the side of the freeway, crossing up to 5 lanes of high speed traffic all while my car is braking itself to a stop. I have narrowly missed 5 accidents in the 7 times this has occurred. Each time while in the left or carpool lanes of traffic while passing other vehicles at a high rate of speed. I have to bring the car to a complete stop on the side of the road, turn the car off to disengage the braking system, turn the car on, all fault codes remain, car stays in limp mode or safe mode, I limp to the dealer and drop it off. 2 Honda dealers in 2 different states can’t figure out what’s wrong with it. Replaced multiple replays and other components and I am now about $3800 in repairs and the car is not fixed. This has been happening since March when the first occurrence happened. Second and 3rd in Washington while visiting family in June and as of today, the 7th time occurred this morning while taking the car back to the dealer to have it looked at because it faulted on Saturday evening. Codes cleared when I started the car this morning and happened again as I was driving to the dealer. Each time the dealers have the car for a week. Say this fixed it, test drive it have no issues return it to me to have it happen within days of being returned. I’m terrified to drive the car at high speed even when I do get it back as “fix”. I feel like my issues and security is being constantly over looked by Honda. Arrowhead Honda in Arizona currently has the car for yet again more “repairs”.

NHTSA ODI 11535497

Steering- the Steering wheel jerks when I make incremental movements to the left or right. This only occurs when I'm driving on a freeway at or above 55mph. It does not occur on surface streets. I brought it to Autonation Honda in Chandler, AZ. They said it was the Rack Motor or Rack Pinion motor and it needs to be replaced. The advisor said that they have seen many 2016 Civics with this issue. Total out-of-pocket cost $3700.00. Part was not available even if I decided to have it replaced. I feel this should be addressed since this is a major safety issue caused by the manufacturer and should be recalled.

NHTSA ODI 11535084

Air conditioning compressor and condenser leaking which caused the evaporator to fail. Honda refuses to fix evaporator due to faulty A/C system leaking.

NHTSA ODI 11534913

The inside door handle on my car has become unusable two times in the past 2 years. This is a danger because, in case of an emergency, the door would not be able to be opened by the passenger.

NHTSA ODI 11534605

The steering wheel get stuck/ jerks in position and to correct stuck position/ jerks it causes you to correct your lane position. You feel out of control for a second or so. Purchased vehicle in 2019, in 2020/21, this happened and I took it into the dealership where we purchased the car and they did an alignment. After that alignment, steering/jerky/sticky wheel did not happen as much but it still happened and is getting worse. So this weekend I took the vehicle back to the dealership for the same issue again. According to the dealership. their technician(s) test drove the car and they did not feel the sticky and jerky wheel. Generally this happens when the vehicle has been driven for longer than 20-30 mins and when you are going 40-70 mph. The technician(s) stated that they could not reproduce this in their test drive. But it is still happening as I drove home from the dealership. I am not sure how they could not see and feel the constant wheel movement maintain control of the lane. It's sometimes hard to hold lane control especially going at a higher rates of speed. I see 200+ complaints similar to this issue with the 2016 Honda Civic. This dealership states that they see nothing wrong. But there is definitely still something wrong with this year model. I wanted to go on record and voice my concerns about this issue like many others.

NHTSA ODI 11534204

Purchased this vehicle new in 2016. The AC system has never worked properly. A few years ago parts were given the extended warranty. I had it fixed at an authorized Honda dealer, it blew cold air for about 2 weeks and then died agin. I had it fixed again, was told parts were defective in the first repair and it worked for 1 summer. Now this summer it is not blowing cold air once again and again I got another warranty extension in the mail. This time at Honda it’s a different part in the AC and of course it isn’t covered. So for a quick $3000 it can be fixed. This is my 9th Honda/Acura vehicle and I have never had such a unreliable car. Very disappointed with the “new” Honda.

NHTSA ODI 11533925

Steering is getting stuck while driving on highways and/or higher speeds. Appears to be a consistent issue with Honda civics complaints/issues after researching. Requires replacing EPS, approx $2-3k. Not due to wear and tear. Vehicle at less than 30,000 total miles.

NHTSA ODI 11533327

The contact owns a 2016 Honda Civic. The contact stated while driving 40-60 MPH, the steering wheel became firm. There was no warning light illuminated. The contact jerked the steering wheel side to side and the steering wheel started operating normally. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not under recall. No further assistance was provided. The approximate failure mileage was 49,000.

NHTSA ODI 11532945

The inside of the car smells like coolant and the air is making the front dashboard foggy. One area of the Central ac is blowing cooler than the other.

NHTSA ODI 11532691

Steering has become sticky, especially when driving straight on a highway or at higher speeds. Extra force is needed to maintain position in lane and move the wheel. The pressure required to turn the wheel past the stuck position causes the driver to over correct excessively making it difficult to stay in the lane.

NHTSA ODI 11532713

2016 Honda Civic AC system is not working and has not been working for awhile. There are 2 warranty extensions issued for this vehicle's AC system, one for the condenser and one for the compressor. Honda has diagnosed the problem as being the evaporator, which I have been quoted everywhere from $1800 - $3000 to have fixed. The general consensus from mechanics that have dealt with these models (I have seen many different mechanics, 3rd party and dealership), is that the entire AC system is riddled with manufacturing defects, the condenser and compressor issues likely caused the evaporator malfunction, and will likely have to be recalled at some point. That is obviously slowly happening with the existing warranty extensions, however I am still being forced to pay nearly $2k for working AC despite public knowledge of a manufacturing error dealing with these AC systems. Honda refuses to acknowledge the evaporator issue was caused by the other failing components by not extending the warranty to the whole AC system. When I refused service for the evaporator since it was not covered, I was told the compressor shaft seal leak that IS covered under the warranty extension could not be fixed either. The reasoning was that the compressor could not be fixed alone without fixing the evaporator due to "safety concerns". Essentially admitting that the whole system fails if one of those 3 parts is faulty. So even though that is the case, I still have to pay out of pocket for the manufacturers mistake. Unbelievable and clearly an extremely common occurrence as there was an active class action lawsuit for the AC systems of this model (Andre Wong v. American Honda Motor Co. Inc., et al., Case No. 2:19-cv-10537) and Lemon Law documentation of the issue as well. Please hold Honda responsible and force them to issue an all encompassing AC Recall/warranty extension so that myself and many others do not have to choose between a very expensive repair or passing out on the road from the heat

NHTSA ODI 11532826

The steering is sticking - the same as all these other reports I'm seeing below. It is worse in the afternoons (higher temperatures I guess) and definitely more noticeable at highway speeds. Took the car to the dealer and they said that even though my car only has 36k miles it needs a new (electric) rack & pinion system for $4000 !! Ridiculous. I was advised that the dealer is well aware of the issue (I was the 2nd case this week that my service advisor was dealing with) but there's nothing they (the dealer) are doing at the moment other than referring it to corporate Honda U.S. I dont know whats going to happen if the situation gets worse - does the steering stop steering or get continually harder to steer ... is a definite safety issue.

NHTSA ODI 11532300