What 287 owners told NHTSA about the 2016 Ford F-250 Super Crew

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the steering wheel was stiff and made rattling sounds while making a turn. The air bag warning light was illuminated. Additionally, the horn, cruise control, phone, and radio buttons on the steering wheel were inoperable. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that parts were expected to become available in the third quarter of 2023. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

NHTSA ODI 11523219

The contact owns a 2016 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer for a diagnostic test; the diagnostic test showed that the rear knock sensor was defective and needed to be replaced. The contact was informed by the dealer and the manufacturer that the vehicle was not covered under warranty. The contact was referred to NHTSA Hotline for assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 71,000.

NHTSA ODI 11522931

OTHER ELECTRICAL MALFUNCTIONS OCCURING, WINDSHIELD WIPERS WON'T TURN OFF

NHTSA ODI 11520244

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted and notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11518705

The contact owns a 2016 Ford F-250. The contact stated that the check engine warning light illuminated intermittently. The vehicle was taken to several independent mechanics, where the warning light was reset; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed that the reductant heater had failed and needed to be replaced. The contact became aware that the VIN was included in Ford Service Campaign Number: 20M01; however, the dealer informed the contact that the vehicle could not be repaired under the Service Campaign due to the mileage. The dealer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 117,000.

NHTSA ODI 11517876

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V3370000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that an unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11517430

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags); however, the parts to do the recall repair were not yet available. The contact stated that the air bag warning light was illuminated. Additionally, the horn, the fuel gauge, the oil pressure gauge and other instrument cluster functions were inoperable. The vehicle was taken to the dealer, where it was diagnosed that the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. VIN tool confirms parts not available.

NHTSA ODI 11516950

The contact owns a 2016 Ford F-250. The contact received recall notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11515834

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11515571

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11514246

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was contacted. The manufacturer was made aware of the issue and advised the contact to take the vehicle to the dealer for an inspection. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11513229

A notice of recall was received July 2022 by my family with the following numbers: Safety Recall Notice 22S35 / NHTSA Recall 22V337. I called NHTSA today to follow up on this notice, which in July 2022 I was told by Parsons Ford the fix was not available as of yet. [XXX] with NHTSA gave me a number to Ford's customer care hotline. Ford contacted Malloy Ford in Winchester VA which is suppose to call us when an actionable fix is available. They have no clue when that will be so I contacted NHTSA again today which now says there is no recall on my vehicle. So are we driving a vehicle that could potentially kill us or not. Why would the recall disappear within hours of talking to NHTSA & Ford? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11513232

The contact owns a 2016 Ford F-250. The contact stated that while driving at an undisclosed speed, the air bag warning light, the ESC warning light, and the oil change warning light were illuminated. The contact related the failure to NHTSA Campaign Number: 22V337000 (Air Bags). The vehicle was taken to the dealer; however, no cause for the failure was found. The manufacturer was not made aware of the failure. The failure mileage was approximately 48,000.

NHTSA ODI 11513247

Yesterday (3/20/23), as I was driving on the interstate at about 70 miles per hour, I hit a bump in the road and that caused the truck to go into severe shaking which I later learned has been termed as the "death wobble". I had to pull over to the emergency lane and stop the vehicle in order to get the vehicle under control. Luckily, there were not many vehicles on the road at the time so moving from the middle lane to the emergency lane on the right side was easy to do without causing any disruption to other drivers. I called my mechanic about the situation and he was the one to tell me it was the "death wobble" and it is common in Ford trucks and Jeeps. This was my first time experiencing this "death wobble" and it scared the crap out of me. In the past, I've hit bumps before and the truck felt like it might bounce off the road, but it never continuously shook (and shake violently) like it did yesterday. There was no warning or warning lights or anything like that that came on. As I was going to the emergency lane I did turn on the emergency flashers. I have an appointment with my mechanic to get this looked at in a week. That was the soonest I could get in.

NHTSA ODI 11512976

Maintained Truck and did all required maintenance. Truck blew up while driving. All oil leaked out. Ford found hole in upper oil pan. Truck had poor fuel Truck has exhaust issues and ford can’t correct Lost truck and a lot of money , engine needs to be replaced.

NHTSA ODI 11512492

I had the F-250 Death Wobble. I hit a bump at 70mph and the entire truck started shaking violently. It didn’t stop shaking until I slowed down to 30mph on the highway. This had the potential to be a life threatening accident if I would have lost control, especially since this happens at high speeds. Thousands of people have had the death wobble, why won’t the NHTSA mandate Ford to fix this?

NHTSA ODI 11512099

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted but was unable to confirm when parts would become available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11510380

In December 2022, I received a safety recall notice from Ford stating, dust contamination may lead to loss of electrical circuit connection, which may result in failure of airbag to deploy in an accident. Ford stated that when parts become available, they would notify me via email to schedule a service appointment for repairs to be completed free of charge (parts & labor). Parts are anticipated to be available early first quarter 2023. My dealer has no information about availability of parts yet. I am following up, in hope to learn the status of this important safety recall. Thank you, [XXX] sent Feb. 8, 2023 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11506184

DEF heater/sender assembly was replaced under Ford 21M01 recall. However, the damaged caused by these defective items caused the need to repair additional component's that was not paid for by Ford. Ford will not reimburse additional cost, and can not furnish a statement from a Ford engineer that states the defective replaced parts did not cause the additional repairs. (expense).

NHTSA ODI 11503939

When I drove over 50mph and hit any bump the front of the truck shakes wildly. Online says DEATH WOBBLE. This has been going on for 4 months. When taking my children to school 20+ miles away on the highway this has happened several times to and from school on the same day. Other vehicles move out of my line to avoid me while I slow the truck to under 45 mph. They are scared and nervous about getting to school safely. My mother and wife refuse to drive the truck after experiencing this while driving. The fuel injector now also has a problem. The truck is going in to be serviced for the failing fuel injector and death wobble hopefully today if Waldorf MD Ford has openings I am awaiting a call back. It has not been inspected yet only diagnostic at AutoZone showing the fuel injector error code. No warning was given prior to this happening, the truck was riding smoothly, hit a bump in the highway and went crazy. Then it did it again and again and again.

NHTSA ODI 11503106

I was experiencing what is known as the "death wobble" in my 2016 Ford F250 FX4 truck. The truck only has 56,000 miles but is out of warranty. I recently spent $1326.00 to have the problem repaired. Apparently this is a major problem with these trucks. I have the repair bill but didn't include it with this statement.

NHTSA ODI 11502376

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11502110

On a highway, 65-70 mph, drove over a rough patch of road and truck front end began to shake violently(death wobble). Happened three times on same day, same trip. On all occasions we were very lucky to be able to stop or slow down without being involved in an accident. I spent $5000 this past summer that was suppose to have fixed the problem.

NHTSA ODI 11501635

Entered a highway on-ramp, accelerating to 65-70 mph, drove over a rough patch of road and truck front end began to shake violently(death wobble) we were very lucky to be able to slow down without being involved in an accident. I spent $5000 this past summer that was suppose to have fixed this problem.

NHTSA ODI 11501639

I was traveling on the interstate at the posted speed limit of 70 mph. I was crossing an overpass and upon exiting the overpass my vehicle began what is often referred to as ‘death wobble’. My front suspension began shaking so violently that I temporarily lost control of the vehicle and had to reduce my speed dramatically in the travel lane to regain control before I was able to steer into the emergency lane. Had I been hauling or towing a load I am sure this would have resulted in a wreck. Since this happened, I have read that Ford has refused to conduct a recall on this issue. I urge the NHTSA enter this situation and require Ford to address the issue.

NHTSA ODI 11500906