What 287 owners told NHTSA about the 2016 Ford F-250 Super Crew

The contact owns a 2016 Ford F-250. The contact stated while driving 50 MPH, the front end was shaking violently after driving over a bump in the roadway. There were no warning lights illuminated. The contact called the local dealer, who stated that there were no open recalls on the VIN related to the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 136,000.

NHTSA ODI 11599267

When truck is first driven it will down shift from higher speed to first gear for no reason causing violent lock up of tires. This is an on going problem.

NHTSA ODI 11596824

The problem is commonly called "DEATH WOBBLE". The steering system enters an extremely violent wobble/shake making control of the vehicle nearly impossible. 2 independent service centers have addressed the issue. The first did repairs, including warranty replacement of a faulty part and the truck still has the "DEATH WOBBLE". The 2nd independent service center made note of the 2nd faulty replacement part (TRACK BAR) and reports "TRACK BAR BUSHING IS MOVING EXCESSIVELY. TRACK BAR SHOULD BE REPLACED." No other physical inspections have been performed. There were no vehicle warning lights due to this issue. There were a few incidences of the "DEATH WOBBLE" prior to my first appointment with an independent service center. That first appointment was approx. 2/19/2024, completed on 2/27/2024. Second time completed on 6/21/2024.

NHTSA ODI 11596584

I have had my vehicle inspected and supposedly repaired for the death wobble by two separate ford dealerships (Castle Rock Ford in Castle Rock, CO and Phil Long Ford in Colorado Springs CO). I continue to have safety issues as when I hit pot holes or rough roads, the steering and suspension system shakes the front wheels and steering wheel to the point that I have to come to a full stop. The entire steering system and shocks have been replaced (some parts multiple times) over the past two years. Please assists.

NHTSA ODI 11595308

The contact owns a 2016 Ford F-250. The contact stated while driving approximately 5 MPH and hauling a trailer, the vehicle suddenly lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the fuel pump had failed due to metal shavings in the fuel system. The contact was informed that the fuel system kit needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 237,778.

NHTSA ODI 11594731

The contact owns a 2016 Ford F-250. The contact stated that while driving at approximately 50 MPH, the check engine light illuminated, and the message “Reduced Power Mode” was displayed. The vehicle was taken to a dealer where it was diagnosed that the fuel pump, manifold assembly, fuel injectors, injector terminal seal, gaskets, vacuum pump, and left side fuel rail pressure pump needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 76,880.

NHTSA ODI 11593655

It has been labeled as the death wobble. When driving down the highway at 65-70 mph and I hit a bump, pothole or a washboard effect in the road with the left front wheel. The whole truck will shake violently. So much that I can barely hold on to the steering wheel. The only way to stop the shaking is to slow the truck down to 30-40 mph. In the middle of the highway. I can watch the other vehicles around me scatter and put on their brakes as they try and avoid me. Sometimes it’s to hard to control and I will waver into another lane or on coming traffic. This happens sporadically and without warning. I have taken the truck to the Ford dealership for $3000 in steering component repairs . I have 60,000 miles on it and it is only used for personal use and never abused. This is a design defect that is going to get someone killed. A heavy duty truck should not have the parts wearing out to such a degree that threatens the lives of everyone on the road around me.

NHTSA ODI 11591711

The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the steering wheel was shaking uncontrollably. The contact stated that the steering wheel was shaking, and it was difficult to hold onto the steering wheel. The contact decelerated and the vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired. The contact stated that the failure had previously occurred, and the vehicle was repaired; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

NHTSA ODI 11586621

Driving out of state and twice in a three hour period have experienced the death wobble on the interstate , now trying to continue under 50 mph because it is a very scary shaking .

NHTSA ODI 11584218

After we drove over a bumpy section of road the truck experienced uncontrollable shaking. The road conditions were not severe, but were the cause of the shaking. During the immediate aftermath no input was possible apart from taking my foot off the accelerator. The shaking was severe and uncontrolled causing other vehicles in the vicinity to react. It felt like the truck was going to flip over. This has now happened several times since we purchased the truck. We recently had new brakes installed, but that is not the reason for the shaking.

NHTSA ODI 11583465

The contact owns a 2016 Ford F-250. The contact stated that while driving 20 MPH, the vehicle lost motive power and stalled. The check engine warning light was illuminated, with a message stating to check the engine. The vehicle was towed to an independent mechanic where a diagnostic test was performed. The mechanic stated that the high-pressure pump created metal debris that traveled through the fuel system and the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 110,000.

NHTSA ODI 11581075

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the parts were not yet available. The manufacturer was contacted and referred the contact back to the dealer for assistance. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11571908

-I was driving 65 mph in morning rush traffic when I drove over an overpass. Near the end of the there are some small wrinkles in the concrete. Once I drove over these wrinkles in the pavement, my steering wheel and front end started violently shaking. I removed my foot from the accelerator and once my speed decreased to I'd say 20-30 mph the shaking stopped. My research show that this if referred to as the Ford Death Wobble. -The system that failed were likely the track bar bushing, damper bracket, ball joints, control arms, shocks, and struts. Yes, the truck is available for inspection upon request. -When the front end of the truck started violently shacking I was going 65 mph in lunch rush hour traffic. I'd say that my life and the life of the drivers of the vehicles to my left, right, and rear were at risk. -No, the problem has not been reproduced or confirmed by a dealer or anyone else. -No, the vehicle or components have not been inspected by anyone. -No, there were not any warning lamps, messages or other symptoms of the problem prior to the failure, nor did any warning appear during or after the shaking. -My best assessment of the cause

NHTSA ODI 11570757

Vehicle has 44,000 miles, has never been wrecked in any way. Recently the advance trac system began displaying a fault at random. The light would come and go. At the time the fault light was active the turn signals did not operate normally. A message noted to service advance trac system. ( which is related to the abs) I noticed, once, the abs activate momentarily for no apparent reason. I narrowed the fault down to the steering wheel angle sensor. I had a Ford service center confirm the issue was the steering angle sensor. The sensor was on a backorder. I called around and other dealers confirmed. A week later while entering a cloverleaf and slowing down the system faulted, illuminated the error, and the abs activated. The brake system applied brakes unevenly pulling the vehicle to the left then right and aggressively slowing down without driver brake input. I had to fight to control the vehicle to prevent losing control or get rear ended. The roads were clean, dry, and it was daylight. Upon that i could see the complete loss of steering wheel angle sensor input. The dash can show this readout. Without the steering wheel angle input the system, which is to prevent accidents, nearly caused one. I tried turning off the advance trac via the traction control button, this was ineffective. I had to remove the abs pump fuse to get home safely. This system should not in any way be able to cause this severe loss of vehicle control simply due to the loss of one sensor. This is absolute unsafe software protocall. Attatched are images of the sensor reading then no place holder for it when it does not read.

NHTSA ODI 11570420

I placed my truck in Park, exited the vehicle to assist my daughter to the truck. As we approached the front of the truck - the truck started Rolling forward. I tried to enter the driver side door to stop the vehicle but realized my truck was going to collide with the vehicle next to it and I tried to clear my body of the two vehicles. I was caught between the two vehicles near the rear driver side fender and couldn't free myself. My daughter entered the truck from the passenger side and the truck had went from Park to Drive. My daughter put the truck in Park and somehow I was able to free myself. I received injuries to my hip and pelvic area. The entire incident was recorded on a home surveillance system.

NHTSA ODI 11567093

Def pump or def heater there was a recall on this when I called about the air bag recall they told me that there was one now they say there isn’t one now and something wrong with 4x4 sleeping or might be transmission bought extended warranty 2 times on pickup just need it fixed thank you

NHTSA ODI 11564946

Increase of speed on a rough tar highway road caused a violent Death Wobble.

NHTSA ODI 11563476

The contact owns a 2016 Ford F-250. The contact stated that the body mount on the vehicle was deteriorating. The owner stated that there was a rattling sound coming from the vehicle while driving at various speeds. The contact inspected the vehicle and became aware that the body mount was deteriorating. The vehicle was not repaired. The contact was waiting for an appointment with the local dealer. The manufacture was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 48,194.

NHTSA ODI 11560711

The truck shakes violently after hitting a bump in the road. I have had new Michelin tires installed (by Discount Tires) and balanced twice, and the front end and alignment checked (by Leonard's Truck & Frame Service), both located in Lake City, FL. I think the problem is what is commonly referred to as F250 "Death Wobble".

NHTSA ODI 11559639

While driving on the 215 (Southern California) freeway at approximately 70 miles per hour and without warning I experienced a sever wobble in the front end of the truck. it was so bad I had to pull over on the shoulder of the freeway. I was lucky traffic was light and could do this safely. I took the truck to a mechanic that specializes in ford trucks, and he recommended several components be replaced. He stated this is a common problem with Ford F250 and F350 trucks. He mentioned that this was known as the "Death Wobble." The truck has approximately 60 thousand miles on it.

NHTSA ODI 11557900

Drivers side seat belt will not click in and I believe that is a safety problem

NHTSA ODI 11554503

The contact owns a 2016 Ford F-250. The contact stated that the vehicle failed to start. The vehicle was towed to the dealer. The contact stated that the dealer had not provided any diagnostic information. The contact related the failure to NHTSA Campaign Number: 22V337000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that the parts for the recall repair would not be available for 4 years. Additionally, the manufacturer declined to buy back the vehicle. The vehicle was not repaired. The failure mileage was approximately 100,000. Parts distribution disconnect.

NHTSA ODI 11553190

The bushing on the cable that holds the transmission gear selector cable to to the transmission gear selector bracket on the transmission housing broke and left the truck unable to be shifted in or out of gear using the lever on the steering column. The only way to move the vehicle was to crawl under the vehicle and manually move the gear shift selector to the desired gear. I was able to drive it to a Ford dealer for immediate repair. There were no warning signs and the truck was operating with no problems/issues prior to this incident. The truck is a 2016 model and I am the original owner. The truck had 62982 miles on it when the incident occurred. I feel this is a safety issue because this would prevent the vehicle from being put in park if it broke when being put in drive and could cause the vehicle to roll into something or onto someone

NHTSA ODI 11550681

My truck has developed what is colloquially called a death wobble. The truck shakes wildly and aggressively when hitting a bump. It happens most frequently when crossing the transition from roadway to bridge. But it can occure from a bump in the roadway. When it occurs I have no control. I have paid to replace the steering damper That did not alleviate the problem. My truck is a 2016 Ford F-250 Super Duty. This wobble has occurred several times. To date, except for the initial occurrence, this has only occurred on interstate highways at regular highway sppeds depending on the particular state speed limit. The initial event occurred on a state highway in Colorado while negotiaing a sweeping left curve. Thereafter, it has only occurred on interstate highways. Speeds have alwasy been 60mph or above, depending on speed limits and trafic conditions.

NHTSA ODI 11550227

The contact owns a 2016 Ford F-250. The contact stated that while driving at an unknown speed, the check engine warning light illuminated. The vehicle was parked and restarted when it locked itself into idle mode and would not move. The vehicle was taken to a dealer where it was diagnosed that the reduction heater needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 70,000

NHTSA ODI 11549671