What 1,686 owners told NHTSA about the 2016 Ford F-150 Supercab Diesel

I TURNED ON THE REAR DEFROSTER & THE CABIN STARTED SMOKING. I PULL OVER TO GET OUT TO BREATHE, ONE MINUTE LATER THE BACK WINDSHIELD SHATTERS COMPLETELY.

NHTSA ODI 11242478

MY TRUCK LOST COMPLETE POWER ON 8/3/19. SEVERAL DIFFERENT WANING LIGHTS CAME ON. FORTUNATLEY, I WAS LOST POWER ON A STRAIGHT STRETCH OF ROAD AT ABOUT 30 MPH. I WAS ABLE TO "LIMP" MY TRUCK BACK HOME. I HAVE A CODE READER AND IT SHOWED CODE P2112 "THROTTLE ACTUATOR CONTROL SYSTEM STUCK CLOSED". I SEARCHED ONLINE AND FOUND A FORD CUSTOMER SERVICE LETTER FROM 2016-2017 ADDRESSING THIS ISSUE WITH AN EXPIRATION NOTICE OF SEPTEMBER 2017. I PURCHASED THE VEHICLE USED IN DECEMBER 2016 AND WAS NEVER SENT ANY NOTICE. I FIND IT INCREDIBLE THAT FORD KNOWS ABOUT A DEFECT THAT CAUSES A VEHICLE TO LOSE POWER SUDDENLY, AND ADDRESSES IT WITH THIS BANDAID LEVEL OF SERVICE. IT IS A SIMPLE AND INEXPENSIVE FIX. I FIXED IT MYSELF IN LESS THAN AN HOUR WITH A PART PURCHASED FROM FORD THAT WAS LESS THAN $200. MY CONCERN IS THAT FORD DID NOT NOTIFY ME AND WILL NOT STAND BY THIS DANGEROUS DEFECTIVE ISSUE. THEY HAVE TOLD ME THERE WAS AN EXPIRATION ON THAT LETTER AND THEY WILL NOT HELP ME. PLEASE FORCE THEM TO DO AN ACTUAL RECALL ON THIS ISSUE BEFORE SOMEONE IS KILLED! THANK YOU FOR YOUR TIME.

NHTSA ODI 11242007

ON JULY 18, 2019 VEHICLE (2016 FORD F150 WITH 51,721 MILES) DRIVEN UNDER HIGHWAY CONDITIONS EXPERIENCE A 'LOW BRAKE FLUID' WARNING FOLLOWED AFTERWARDS WITH COMPLETE LOSS OF BRAKES WHEN ATTEMPTING TO SECURE THE VEHICLE TO A SAFE CONDITION. FORTUNATELY THE DRIVING SITUATION ALLOWED THE VEHICLE TO BE SECURED SAFELY. UPON INSPECTING THE VEHICLE THERE WERE NO INDICATION OF BRAKE FLUID LOSS THROUGH BROKEN BRAKE LINES OR SYSTEM LEAKAGE. SUBSEQUENTLY TRANSPORTED THE VEHICLE TO THE VEHICLE OUR ORIGINATING FORD DEALERSHIP, THE SHOP DIAGNOSTIC RESULT WAS THE 'FAILURE OF THE MASTER BRAKE CYLINDER REAR CUP SEAL'. ADDITIONAL DAMAGE INCLUDED THE BOOSTER PUMP DUE TO BRAKE FLUID CONTAMINATION. ISSUES: THIS IS THE SAME FAILURE TO WHICH FORD MOTOR PREVIOUSLY RECALLED 2013 - 2014 F150'S. AT 51K MILES, THE FAILURE OF A MASTER CYLINDER IS PREMATURE. DURING ROUTINE MAINTENANCE, INSPECTION OF THE MASTER CYLINDER DOES NOT READILY LEAD TO INDICATION OF POTENTIAL FAILURE OR NEED FOR REPLACEMENT. THIS FAILURE COULD BE CATASTROPHIC UNDER THE RIGHT CONDITIONS IF PROPER OPERATOR CONTROL IS NOT FOLLOWED - LOWER SPEED BY REDUCING GEARING AND USING THE EMERGENCY BRAKES. THE REPLACEMENTS ARE OEM FACTORY PARTS; POSSIBLY THE SAME MANUFACTURE AS THAT REPLACED WHICH COULD BE POTENTIAL FOR FUTURE FAILURE (THIS COULD NOT BE CLARIFIED BY THE FORD SHOP AT THE TIME OF THE WORK)! THE PRIMARY CONCERN OF COURSE POTENTIAL FOR RELAPSE OF THE SAME EVENT. SECONDARILY IS THE PREMATURE EXPENSE OF MASTER BRAKE CYLINDER AND BOOSTER PUMP REPLACEMENT.

NHTSA ODI 11241755

MY VEHICLE WAS IN MOTION AT APPROXIMATELY 65 MPH WHEN IT SUDDENLY ENTERED A LIMP MODE, INDICATED BY MULTIPLE DASH WARNING LIGHTS AND AN ABRUPT LOSS OF POWER. THE VEHICLE WAS INCREDIBLY UNSAFE TO OPERATE IN SUCH CONDITION. FORD HAS A KNOWN PROBLEM WITH THE ELECTRONIC THROTTLE BODY USED ON THESE MOTORS, BUT HAS FAILED TO ISSUE A RECALL ON A PART THAT COULD CAUSE GREAT BODILY HARM AND INJURY IF IT SHOULD FAIL IN HEAVY TRAFFIC SCENARIOS.

NHTSA ODI 11241766

COMPLETE BRAKE FAILURE WITH LIMITER WARNING. DRIVING AND BRAKE FLUID LEVEL LIGHT CAME ON. STOPPED AT A GAS STATION REFILLED BRAKE FLUID. LOST BRAKE PRESSURE AFTER DRIVING LESS THAN A MILE FROM GAS STATION. REFILLED BRAKE FLUID. NEXT MORNING STARTING SEEING WHITE SMOKE IN EXHAUST. ALL OF THE BRAKE FLUID DRAINED OUT OF BRAKE FLUID OUT AND LEAKING FROM MASTER CYLINDER

NHTSA ODI 11241565

ON THE NEWER FORD F150'S THE MASTER LOCK SITS OUTSIDE OF THE DOOR FRAME. CRIMINALS CAN BREAK THIS LOCK AND GRAIN ACCESS TO THE VEHICLE IN LESS THAN 30 SECONDS. I HAVE HAD MY TRUCK BROKEN INTO 3 TIMES NOW DUE TO THIS SECURITY ISSUE. FORD REFUSES TO ACKNOWLEDGE THE ISSUE THEY ENGINEERED INTO THE F150. I DO NOT FEEL SAFE IN MY TRUCK AND WILL IMEDIETLY BE LOOKING FOR A REPLACEMENT THAT IS NOT A FORD.

NHTSA ODI 11241274

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING ON THE INTERSTATE, THE BRAKE WARNING INDICATOR ILLUMINATED. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO APPLY THE CAMPER BRAKE TO REACH THE NEXT EXIT. THE CONTACT TOOK THE VEHICLE TO MURDO FORD (219 MAIN ST, MURDO, SD 57559, (605) 669-2391) WHERE IT WAS DIAGNOSED THAT THE VACUUM BOOSTER SUCKED THE SEAL OUT OF THE MASTER CYLINDER AND ALL THE FLUID WENT TO THE BOOSTER. THE TECHNICIAN ADDED FLUID TO THE BRAKE MASTER CYLINDER AND DISCONNECTED THE BOOSTER. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AND LATER TOOK IT TO THUNDER BASIN FORD (1100 W 2ND ST, GILLETTE, WY 82716, (307) 682-4735), BUT WAS NOT DIAGNOSED OR REPAIRED DUE TO THE LENGTH OF TIME IT WOULD TAKE FOR THE REPAIR. THE VEHICLE WAS ALSO TAKEN TO JACKSON FORD OF DECATUR (455 E PERSHING RD, DECATUR, IL 62526, (844) 846-7281) WHERE A REPAIR APPOINTMENT WAS SCHEDULED. THE CONTACT ALSO TOOK THE VEHICLE TO RICK RIDINGS FORD (1817 RIDINGS DR, MONTICELLO, IL 61856, (217) 762-2521) AND WAS INFORMED THAT THERE WERE NO RECALLS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. *BF *AS

NHTSA ODI 11241328

STARTED DRIVING AM FOR ABOUT 5-7 MILES AND GETTING ON AN ON RAMP TO FREEWAY VEHICLE SUDDENLY HAD NO POWER AND IDLE VERY ROUGH/ COULD NOT ACCELERATE AND SERVICE ENGINE LIGHT, HILL ASSIST NOT ACTIVE AND ANOTHER SERVICE LIGHT CAME ON. PULLED OVER TO THE SIDE OF ROAD AND SAT FOR ABOUT 30 SECONDS, TURNED VEHICLE OFF AND RE STARTED, NO FAULT WARNING LIGHTS WERE ON AND ALL WAS FINE. DROVE 22 MILES TO DEWEY FORD IN ANKENY, IOWA TOLD THEM WHAT HAPPENED AND THEY ASKED IF ANY FAULT LIGHTS WERE STILL ON AND I SAID NO AND THEY TOLD ME THEY WOULDN'T BE ABLE TO DIAGNOSE THE PROBLEM WITHOUT A FAULT LIGHT BEING ON. THEY SAID IT COULD BE WATER IN THE FUEL AND SUGGESTED A COUPLE CANS OF SEA FOAM AND TO TOP FUEL OFF WITH PREMIUM/NO ALCOHOL. DID THAT, DROVE AN ADDITIONAL 22 MILES WITH OUT ANY PROBLEMS. RESEARCHED SIMILAR PROBLEMS BY OTHERS AND ELECTRONIC THROTTLE BODY CAME UP. WILL UPDATE IF I HAVE ANOTHER INCIDENT.

NHTSA ODI 11241394

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING 30 MPH, THE LOW BRAKE FLUID WARNING INDICATOR ILLUMINATED AND THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD, BUT FAILED TO ADEQUATELY SLOW DOWN THE VEHICLE. THE PARKING BRAKE WAS ACTIVATED AND THE VEHICLE SLOWED TO A STOP. A TOWING SERVICE WAS CONTACTED; HOWEVER, THE VEHICLE WAS STILL WAITING TO BE TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT STATED THAT BRAKE FLUID WAS ADDED TO THE BRAKE RESERVOIR; HOWEVER, AFTER SEVERAL SECONDS, THE BRAKE RESERVOIR WAS EMPTY AGAIN. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.

NHTSA ODI 11240344

UPON PULLING OUT OF PARKING SPACE, LOW BRAKE FLUID LIGHT CAME ON AND BRAKE PEDAL LOST ALL PRESSURE. WENT BACK INTO STORE TO PURCHASE MORE BRAKE FLUID. REFILLED AND LOW FLUID LIGHT CAME BACK ON BEFORE LEAVING PARKING LOT. DROVE TO ANOTHER LOT AND REFILLED RESERVOIR AS IT WAS EMPTY AGAIN. NO SIGNS OF EXTERNAL LEAKS. UPON VIEWING OTHER IDENTICAL COMPLAINTS, I BELIEVE IT IS LEAKING INTO BRAKE BOOSTER, WHICH HAS NOT YET BEEN RECALLED FOR THIS MODEL YEAR. F150 ONLY HAS 61,000 MILES.

NHTSA ODI 11240161

WHILE DRIVING TOTAL LOSS OF BRAKES, PEDAL TO THE FLOOR. NO FLUID IN MASTER CYLINDER. MASTER CYLINDER FAILED AND FLUID LEAKED INTO BOOSTER AND BURNED OFF IN ENGINE

NHTSA ODI 11234577

TL* THE CONTACT OWNS A 2016 FORD F-150. WHEN THE CONTACT ACTIVATED THE REAR DEFROSTER, THE REAR WINDOW EXPLODED AND BEGAN TO PRODUCE SMOKE. THE CONTACT AND OTHER PASSENGERS EXITED THE VEHICLE UNHARMED. THE CONTACT DISCONNECTED THE REAR DEFROSTER THE FOLLOWING DAY. THE VEHICLE WAS DRIVEN TO BONNELL FORD (353 CAMBRIDGE ST, WINCHESTER, MA 01890, (781) 729-9700) AND A DIAGNOSTIC APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS UNKNOWN.

NHTSA ODI 11234558

WHILE DRIVING ON A US HIGHWAY AT 65 MPH, I HAD A NEED TO SUDDENLY APPLY THE BRAKES ON MY 2016 FORD F-150 AND THERE WAS A SUDDEN FAILURE. THE BRAKE PEDAL HAD TO BE DEPRESSED THE ENTIRE DISTANCE TO THE FLOOR TO FINALLY GET THE VEHICLE TO DECELERATE. AFTERWARDS A WARNINGS LIGHT CAME ON INDICATING LOW BRAKE FLUID. DESPITE ADDING FLUID TO THE RESERVOIR THE BRAKES WOULD STILL NOT ENGAGE. THE VEHICLE HAD TO BE BROUGHT FOR SERVICE WHERE IT WAS DETERMINED THAT THERE HAD BEEN A FAILURE IN THE MASTER BRAKE CYLINDER. FORTUNATELY THIS DID NOT RESULT IN AN ACCIDENT OR INJURY.

NHTSA ODI 11234260

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, "SEE SERVICE MANUAL, TRACTION CONTROL NOT AVAILABLE, CHECK ENGINE" ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE LOST POWER AND THE ACCELERATOR PEDAL DID NOT RESPOND. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP AS IT BEGAN TO SHAKE. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, ALL THE WARNING INDICATORS WENT AWAY AND THEN ILLUMINATED AGAIN. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. RICH FORD (8601 LOMAS BLVD, ALBUQUERQUE, NM 87112) WAS CONTACTED VIA PHONE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 49,500.

NHTSA ODI 11233916

WHILE DRIVING TO WORK A RED BRAKE WARNING LIGHT CAME ON THE DISPLAY AND I TRIED THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKES. I PULLED OVER IN A SAFE SPOT CHECKED THE BRAKE RESERVOIR AND IT WAS COMPLETELY EMPTY. I STARTED THE VEHICLE AND SMOKE STARTED POURING OUT OF THE EXHAUST. HAD IT TOWED TO A FORD/LINCOLN DEALER AND THEY SAID THE MASTER CYLINDER AND BRAKE BOOSTER NEEDS TO BE REPLACED $890.00. THERE IS NO FORD RECALL FOR 2016 F150S WHICH IS UNBELIEVABLE SINCE THIS IS A SERIOUS SAFETY ISSUE. DID SOME RESEARCH AND THERE ARE MULTIPLE LAWSUITS FOR THE SAME ISSUE ON 2013-2018 FORD F150S. I CALLED FORD HAD A HARD TIME UNDERSTANDING THE REP AND SHE CREATED A CASE NUMBER. CALLED THEM THE NEXT DAY AFTER SPEAKING WITH FORD DEALER AND THERE WAS NO CASE TO BE FOUND. THE SECOND FORD REP MADE A CASE # CAS22180343, WAS VERY HELPFUL AND THE REP SAID FORD WILL MAKE IT RIGHT. THIS REMAINS TO BE SEEN. MEANWHILE I'M WITHOUT A VEHICLE. I HAD A 2005 TOYOTA TACOMA AND NEVER HAD ANY TYPE OF ISSUES. HOPEFULLY THIS HELPS AND GETS FORD TO RECALL 2016 F150S SO NO ONE GETS HURT. ALSO HAD TO REPLACE ALL BRAKES, ROTORS AND PADS FOR $924.72 ON A 50K MILE VEHICLE IS VERY QUESTIONABLE. THANK YOU

NHTSA ODI 11233557

I HAVE OWNED MY 2016 FORD F-150 SUPER CREW LARIAT FOR ALMOST 3 YEARS. I PURCHASED IT BRAND NEW FROM A DEALER IN PALM BEACH COUNTY FLORIDA. I AM ON TOP OF MY ROUTINE MAINTENANCE AND HAVE JUST HAD MY TRUCK SERVICED 3 WEEKS AGO. ON 7/20/19 MY TRUCK'S BRAKES COMPLETELY FAILED WHILE DRIVING FROM MY HOUSE ON A RESIDENTIAL ROAD. I HAD TO USE MY EMERGENCY BRAKE TO STOP MY VEHICLE FROM GOING THROUGH A STOP SIGN. THANKFULLY, I WAS NOT INVOLVED IN AN ACCIDENT. MY MASTER CYLINDER HAD LOST ALL ITS FLUID BUT THERE WERE NO SIGNS OF LEAKS. I ADDED BRAKE FLUID AND I COULD SEE IT LEAVING THE RESERVOIR. IT APPEARS TO BE LEAKING INTO THE BRAKE BOOSTER. I HAD TO HAVE MY TRUCK TOWED TO THE DEALERSHIP AND I'M WAITING TO HEAR BACK FROM THE SERVICE DEPARTMENT.

NHTSA ODI 11233614

WHILE DRIVING NORMALLY ERROR/MAINTENANCE ALARMS GO OFF AND THE TRUCK WILL DROP TO A ROUGH IDLE (TOTAL LOSS OF POWER), IS NOT RESPONSIVE TO THROTTLE INPUT, AND MULTIPLE ALARM MESSAGES ARE DISPLAYED. IN EVERY CASE, I HAVE HAD TO PULL OVER, SHUT THE ENGINE DOWN, WAIT UNTIL ALL SYSTEMS HAVE POWERED DOWN, AND RESTART THE TRUCK. IN THE PAST AND THE MOST RECENT OCCURRENCE, SOMETIMES THIS ONLY OCCURS ONCE BUT IN A COUPLE OF INSTANCES IT WILL OCCUR A COUPLE OF TIMES IN A ROW BEFORE RESUMING NORMAL OPERATION. THIS IS A VERY DANGEROUS CONDITION- TOTAL LOSS OF POWER WHILE IN TRAFFIC ON BUSY ROADS. FORD HAS DIAGNOSED AS AN ELECTRONIC THROTTLE BODY FAILURE AND REFUSED TO COVER THIS ON WARRANTY (OUT OF WARRANTY 3 MOS) AND IT HAS TAKEN MUCH RESEARCH ON MY PART TO DISCOVER THAT THIS IS A KNOWN ISSUE WITH FORD ETB'S GOING BACK SOME TIME WITH OVER 60K FAILURE REPORTS OVER MANY DIFFERENT VEHICLES.

NHTSA ODI 11232074

VEHICLE OPERATING NORMALLY UNTIL PROBLEM NOTED 7/13/2016. VEHICLE PURCHASED USED FROM CERTIFIED FORD DEALERSHIP ON 5/16/2018. CURRENTLY HAS APPROXIMATELY 44,800 MILES ON ODOMETER. VEHICLE HAS BEEN PARKED OVERNIGHT AND UPON AM STARTUP AND BACKING UP SUFFERED COMPLETE LOSS OF BRAKING ABILITY WHEN BRAKES WERE APPLIED. LOW BRAKE RESERVOIR INDICATOR LIGHT ON. VISUAL CHECK REVEALED RESERVOIR LEVEL WELL BELOW MINIMUM MARK AND LEVEL WITH INLETS FOR THE BRAKE LINES. REFILLED, PUMPED BRAKES AND ABLE TO OBTAIN MODERATELY FIRM PEDAL. STARTED VEHICLE, LET IDLE FEW MOMENTS, TESTED BRAKE PEDAL BUT FOUND SOFT PEDAL AGAIN SINKS IMMEDIATELY TO FLOOR AND RESERVOIR LIGHT ON AGAIN. VISUAL CHECK SHOWS FLUID AGAIN HAS EMPTIED AS DESCRIBED ABOVE. VEHICLE HAD NOT BEEN MOVED. A VISUAL TRACE OF ALL BRAKE LINES SHOWS NO EXTERNAL LEAKAGE ALONG LENGTH OF THE LINES NOR AT ANY BRAKE COMPONENT. FLUID IS OBVIOUSLY BEING DRAWN INTO THE VACUUM BOOST RESERVOIR. VEHICLE HAS NOT BEEN ALTERED IN ANY WAY FROM DATE OF PURCHASE. THIS IS AN EXTREME SAFETY ISSUE WITH A HIGH PROBABILITY OF LOSS OR LIFE AND/OR SEVERE INJURY TO PASSENGERS AND/OR COLLISION WITH OTHER VEHICLES OR OBJECTS DUE TO THIS SUDDEN, TOTAL BRAKE FAILURE. THIS IS A CATASTROPHIC FAILURE OF THE MASTER CYLINDER SYSTEM THAT PRODUCES A FAILURE OF THE REDUNDANT BRAKING ARRANGEMENT (I.E. SEPARATE FRONT AND REAR BRAKE SYSTEMS). THIS APPEARS FROM A QUICK GOOGLE SEARCH OF OTHER COMPLAINTS TO BECOMING A KNOWN PROBLEM. PROMPT ACTION IS URGED BY NHTSA TO INITIATE A RECALL TO CORRECT THESE PROBLEM FOR OBVIOUS SAFETY REASONS.

NHTSA ODI 11231744

THE WRENCH LIGHT FIRST CAME ON AROUND 42,000 MILES, BUT WOULD SHUT OFF WHEN THE VEHICLE WOULD BE TURNED OFF. IT CAME ON A SECOND AND THIRD TIME AROUND THE 50,000 AND 51,750 MILES. SOMETIMES IT WOULD COME BACK ON WHEN DRIVING AGAIN AND SOMETIMES NOT. THEN THE ENGINE LIGHT CAME ON AT ABOUT 52,000 MILES. WHEN THIS CAME ON, IT WOULD STAY ON. THE TRUCK WOULD SEEM TO LOSE A LOT OF POWER AND THE RPM'S WOULD BEGIN REVVING HIGHER WHILE DRIVING. THIS WOULD BE DRIVING ON ALL ROAD CONDITIONS, HIGHWAY OR CITY, UP AND DOWN HILLS. WE HAD THE TRUCK IN TO CHECK AND THE CODE IT PROVIDED WAS 'DTC S-P0741 TORQUE CONVERTOR CLUTCH SOLENOID CIRCUIT PERFORMANCE STUCK OFF. WILL HAVE TO REPLACE TCC AND IF CONDITION STILL EXISTS, REPLACE THE MAIN VALVE BODY.' THE FIRST FORD DEALER (WHILE ON VACATION) MADE THE REPAIR, BUT THIS DID NOT REPAIR THE TRUCK. (THE WRENCH LIGHT CAME BACK ON AGAIN 131 MILES AFTER THE REPAIR AND THE ENGINE LIGHT CAME BACK ON AGAIN 40 MILES LATER OF THE WRENCH LIGHT WARNING.) TOOK THE TRUCK BACK TO THE FORD DEALER WE PURCHASED THE TRUCK AT AND THEY ARE STILL TRYING TO DETERMINE THE CAUSE TO THE ISSUE. THE FIRST TIME THE WRENCH LIGHT CAME ON, WAS UNDER NORMAL DRIVING CONDITIONS AND NOT TOWING A CAMPER. ALL THE REMAINING TIMES THE WRENCH AND ENGINE LIGHT CAME ON WAS WHILE TOWING A CAMPER. (NOT SURE IF THIS IS POSSIBLE CAUSE OF THE ISSUE OR NOT, BUT FEEL IT IS WORTH NOTING.) ACCORDING TO THE OWNER'S MANUAL, THE AUTO START/STOP FEATURE IS TO AUTOMATICALLY DISABLE WHEN A CAMPER IS HOOKED UP TO THE TRUCK. BUT THIS NEVER SEEMED TO AUTOMATICALLY DISABLE WHEN WE WERE HOOKED UP TO THE TRUCK. ANOTHER ISSUE IS WHEN STARTING THE TRUCK UP FROM A COLD START IT WOULD MAKE A RATTLING NOISE. THIS ONLY HAPPENS FROM COLD STARTS. IF THE TRUCK HAD BEEN RUNNER AWHILE, SHUT OFF AND THEN RESTARTED, IT DID NOT MAKE THE NOISE. FORD IS STILL TRYING TO DETERMINE WHAT COULD BE CAUSING THIS.

NHTSA ODI 11231531

IT IDLES ROUGH AT STOP LIGHT SOMETIMES SHUTS DOWN ,RADIO SCREEN IS BLANK SOMETIMES W RADIO OR PHONE CALL. ELECTRICAL BURNING SMELL ENOUGH TO MAKE ME NAUSEOUS. THE COMPUTER READS NO CODES. THIS HAPPENS EVERY COUPLE OF DAYS, IT HAS BEEN AT 2 DIFFERENT SHOPS UP TO WEEKS AT A TIME THEY HAVE CHANGED SEVERAL PARTS BUT NONE HAVE FIXED IT.

NHTSA ODI 11231166

AFTER 71K MILES, THE BRAKE MASTER CYLINDER NEEDS REPLACED DUE TO BRAKE FLUID INTERNAL LEAKING TO THE BRAKE BOOSTERS. LOST ALL CONTROL OF BRAKING POWER. $1100 REPAIR TO REPLACE MASTER CYLINDER AND BRAKE BOOSTERS. THIS HAPPENED ON 7/6/2019 WHILE DRIVING HOME. THE LOW BRAKE FLUID LIGHT CAME ON WHILE DRIVING AND NOTICED SUBSTANTIAL LOSS IN BRAKING POWER AND HAD TO PUSH BRAKE PEDAL ALL THE WAY DOWN TO SLOW THE TRUCK TO A STOP AT STOP SIGN.

NHTSA ODI 11230525

I WAS DRIVING HOME FROM WORK AND VEHICLE WAS FUNCTIONING NORMALLY. UNEXPECTEDLY THE "LOW BRAKE FLUID" WARNING APPEARED. APPROXIMATELY 1 TO 2 MINUTES LATER I STEPPED ON THE BRAKE AND IT WENT TO THE FLOOR. THE FIRST TIME I PRESSED IT SLOWED THE VEHICLE SLIGHTLY. I IPRESSED ON THE BRAKE AGAIN AND IT DID NOT REGISTER. IT WAS TERRIFYING AND I FELT FORTUNATE TO BE ABLE TO MAKE IT TO THE SIDE OF THE ROAD WITHOUT COLLISION. THIS HAPPENED ON A MAJOR CITY STREET MOVING ABOUT 40 MPH.

NHTSA ODI 11230606

TL* THE CONTACT OWNS A 2016 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 17V652000 (LATCHES/ LOCKS/LINKAGES) AND 18V568000 (SEAT BELTS, STRUCTURE). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. LAMARQUE FORD (3101 WILLIAMS BLVD, SUITE F, KENNER, LA 70065, (504) 443-2500) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI 11229542

WHILE SLOWLY PULLING OUT OF A DRIVE WAY THE DRIVER APPLIED THE BRAKES BUT THE PEDAL WENT TO THE FLOOR. A MECHANIC'S INSPECTION DETERMINED THE BOOSTER FAILED CAUSING BRAKE FLUID TO FLOW INTO THE MASTER CYLINDER. WITH NO FLUID IN THE LINES THERE IS NO STOPPING ABILITY.

NHTSA ODI 11229541

IF TRUCK IS NOT DRIVEN IN A FEW WEEKS THE GAS FEED STICKS IN REVERSE, I HAVE NOT HAD IT STICK IN FORWARD. ONLY IN REVERSE, MY WIFE HAD A ACCIDENT WITH THIS TRUCK. I'VE HAD IT STICK ON ME BUT I'M LOOKING FOR IT. FORD AND THE INSURANCE COMPANIES SAY THAT THERE IS NOTHING WRONG. IT HAS OCCURRED SEVERAL TIMES WITH ME AND I DON'T LET MY WIFE DRIVE THE TRUCK.

NHTSA ODI 11229705