What 2,429 owners told NHTSA about the 2016 Ford Explorer

I HAVE OWNED A 2016 FORD EXPLORER XLT FOR APPROXIMATELY 10 MONTHS... DURING THIS TIME EVERY TIME I EXCELERATE THERE IS A VERY STRONG BURNING SMELL. OF COARSE BRINGING IT TO THE DEALER DID NOTHING. THEY TOLD ME MAY BE A STICKER ON ENGINE BURNING.... AFTER 10 MONTHS THE SMELL IS STILL AS STRONG AS THE FIRST WEEK.. I WAS EVEN ASKED BY A POLICE OFFICER WHO HAD PULLED ME OVER FOR A LISENCE PLATE COVER, THAT MY CAR SMELLED OF MARIJUANA! THIS ALL WHILE HAVING CHILDREN AND GRAND PARENTS IN THE CAR!

NHTSA ODI 10926049

WHEN DRIVING AT 65MPH ON INTERSTATE 287 THE CAR DID A SLIGHT JOLT AND THEN LOST ALL POWER. THE ENGINE REMAINED RUNNING, POWER STEERING AND BRAKES STILL WORKED, BUT THERE WAS NO ACCELERATION. WRENCH LIGHT AND CHECK ENGINE LIGHTS CAME ON. LUCKILY I WAS NEAR AN EXIT SO I COASTED TO A HALT OFF THE INTERSTATE. I RESTARTED THE CAR, IT DROVE AT NO MORE THAN 5MPH TO A SAFER SPOT. AFTER SOMETIME WAITING FOR A TOW TRUCK I RESTARTED THE CAR, IT WORKED THIS TIME BUT WITH A CHECK ENGINE LIGHT. I DROVE SLOWLY AND ON COUNTY ROADS, BACK HOME. NOW IN DEALER TO BE FIXED. I HAVE READ MULTIPLE EXAMPLES OF THIS PROBLEM ON THIS WEBSITE AND GENERALLY. THERE IS A CLEARLY A MAJOR SAFETY ISSUE WITH THESE ENGINES AND IT NEEDS ADDRESSING AT A WIDER LEVEL THAN SIMPLY EACH CONSUMER. *TR

NHTSA ODI 10920409

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS ON EXTENDED TRIPS, EXHAUST FUMES ENTERED THE CABIN OF THE VEHICLE. THE FUMES MADE THE CONTACT FEEL NAUSEOUS TO THE POINT OF PASSING OUT. WHEN DEPRESSING ON THE ACCELERATOR PEDAL, THE ABNORMAL FUME ODOR INTENSIFIED. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5,034.

NHTSA ODI 10919185

ON OCT. 18 WHILE OPERATING AT HIGHWAY SPEED OF 40 MPH ON HWY. 301 SOUTH IN WILSON NC AND ATTEMPTING TO SLOW DOWN TO STOP FOR THE TRAFFIC STOPPED AT THE TRAFFIC LIGHT AHEAD THE BRAKE PEDAL AND STEERING BOTH DID NOT FUNCTION, I WAS UNABLE TO STOP OR STEER THE VEHICLE CAUSING A REAR-END COLLISION TO HIT THE VEHICLE IN FRONT OF MINE. MY VEHICLE WAS TOWED TO KENLY FORD LATER THAT DAY FROM THE ACCIDENT SITE WHERE IT WAS PURCHASED, THEY RAN CHECKS AND FOUND NO CODES. ALL I KNOW IS THE BRAKES AND STEERING DID NOT WORK.

NHTSA ODI 10919214

WHILE DRIVING WITH CHILDREN PRESENT THE CAR SUDDENLY LOST POWER AND MY WIFE COULD NOT ACCELERATE. SHE HAD TO DRIFT OVER TO THE SIDE OF THE ROAD. THE "WRENCH" LIGHT AND CHECK ENGINE LIGHT CAME ON THE DASH. AFTER STOPPING THE CAR AND RESTARTING SHE WAS ABLE TO GET HOME BUT THE CAR HAS ALMOST NO ACCELERATION AND KEPT SHUDDERING. FORTUNATELY THE ROADS WERE QUITE AND THERE WAS NO DAMAGE OR INJURY. IF SHE WAS ON A BUSY ROAD OR HIGHWAY IT WOULD HAVE BEEN VERY DANGEROUS. CAR HAS AROUND 7000 MILES ON THE CLOCK. *TR

NHTSA ODI 10918436

I SMELL EXHAUST WHEN PASSING SOMEONE ON OPEN ROAD, OR ENTERING A FREEWAY. I HAVE CALLED FORD MULTIPLE TIMES, AND HAVE AN OPEN CASE. THEY DO NOT RETURN MY CALLS, I HAVE TAKEN MY CAR TO THE DEALER TWICE WHERE THEY TELL ME ITS FIXED IT LASTS ABOUT A WEEK AND THE SMELL RETURNS. I RECENTLY HAD IT IN THE SHOP A SECOND TIME AND I SMELL THE EXHAUST AGAIN. I AM NOW CALLING THEM A THIRD TIME DUE TO THIS SMELL, BUT I AM GETTING NO WHERE. THIS CAN NOT BE SAFE FOR ME TO KEEP SMELLING THIS EXHAUST. THIS VEHICLE WAS PURCHASED BRAND NEW, IT WAS NOT A USED VEHICLE.

NHTSA ODI 10918584

2016 FORD EXPLORER WITH APPROXIMATELY 9100 MILES, I WAS PULLING OUT ONTO A HIGHWAY WHEN THE VEHICLE SUDDENLY STOPPED IN 50MPH TRAFFIC. THE WRENCH LIGHT, ENGINE LIGHT, AIRBAG LIGHT CAME ON AND I HAD TO COAST TO THE SHOULDER. TOWED TO THE DEALER WHERE IT NOW SITS. SAW ALL OF THE COMPLAINTS ON CARCOMPLAINTS.COM AND HERE AND REALIZED I HAVE TO GET RID OF THIS VEHICLE, NO CONFIDENCE IN IT NOW.

NHTSA ODI 10917768

1ST INCIDENT JUNE 2016: DURING A BUSY SCHOOL COMMUTE. ON A VERY BUSY ROAD, THE VEHICLE LOST POWER. WOULD NOT ACCELERATE PAST APPROX. 15 MPH. TOWED TO DEALER AND THROTTLE BODY WAS REPLACED. 2ND INCIDENT OCT. 18,2016: SAME EXACT PROBLEM AS ABOVE, ALSO ON A BUSY STREET. POTENTIAL FOR INJURY OR LOSS OF LIFE WAS GREAT IN BOTH OF THESE CIRCUMSTANCES. TOWED TO DEALER. WAS TOLD THAT ONLY THE COMPUTER NEEDED TO BE RESET AND THE CAR IS FINE??!! I HAVE NO CONFIDENCE IN DRIVING THIS VEHICLE AT ALL! AFRAID FOR MY FAMILY'S SAFETY!! *TR

NHTSA ODI 10917311

PURCHASED THE 2016 FORD EXPLORER AND NOTICED STRONG EXHAUST FUMES IN THE CABIN. CONCERNED ABOUT OUR HEALTH, WENT TO THE DEALERSHIP AND WAS TOLD THAT FORD WOULD NOT DO ANYTHING UNTIL THE VEHICLE HAD 3,000 MILES ON IT. RESEARCHED 'EXHAUST FUMES IN FORD EXPLORERS' AND DISCOVERED THAT 'FORD NAMED IN CLASS ACTION LAWSUIT OVER LEAK OF CARBON MONOXIDE IN PASSENGER COMPARTMENTS OF EXPLORER VEHICLES', ANGELA SANCHEZ-KNUTSON VS. FORD MOTOR COMPANY. THE LAWSUIT INCLUDES 2011-15 FORD EXPLORERS. THEN WENT TO THE MANAGEMENT WITH THIS INFORMATION, WAS TOLD THAT ONLY 'SOME' EXPLORERS WERE AFFECTED SO WE ASKED THEM TO REPLACE THE EXPLORER WITH ONE THAT 'DID NOT' HAVE THE EXHAUST FUMES PROBLEM. WAS TOLD IT WAS NOT POSSIBLE BECAUSE THE VEHICLE HAD BEEN TITLED. DEMANDED THAT THE VEHICLE BE REPAIRED BUT AFTER 6 ATTEMPTS OF WHICH 2 WERE WITH THE FIELD SERVICE ENGINEER, WE WERE TOLD THAT THERE IS "NO FIX". GOOD LUCK TO US. AFTER 6TH ATTEMPT, THE FUMES ARE WORSE THAN EVER.

NHTSA ODI 10917420

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING, THERE WAS A STRONG ODOR FROM THE AIR CONDITIONING UNIT. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000.

NHTSA ODI 10917159

VEHICLE WAS IN CRUISE CONTROL AT ABOUT 60 MPH AND SUDDENLY DECELERATED TO 5-10 MPH AND WOULD NOT ACCELERATE. ENGINE, WRENCH AND AIR BAG LIGHT CAME ON. SHUT ENGINE OFF AND LET SIT AND RESTARTED. VEHICLE DROVE NORMAL BUT STILL HAD ENGINE LIGHT ON. TOOK TO DEALERSHIP AND WAITING ON DIAGNOSTIC. COULD OF BEEN A DANGEROUS SITUATION IF IN HEAVY TRAFFIC.

NHTSA ODI 10916203

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO RESPOND AND DECELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER AN UNKNOWN RECALL RELATED TO THE FAILURE, BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,200.

NHTSA ODI 10915709

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO RESPOND AND DECELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER AN UNKNOWN RECALL RELATED TO THE FAILURE, BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 6,500.

NHTSA ODI 10915710

WHEN ACCELERATING OVER 3500 RPM SMOKE GASES COME INSIDE THE CABIN IT STARTED WHEN I ACQUIRED THE VEHICLE AND HASN'T STOPPED EVER SINCE

NHTSA ODI 10915335

WAS TRAVELING ON I-96 AT 60-65 MPH FAIRLY HEAVY TRAFFIC IN THE LEFT CENTER LANE. THE WRENCH LIGHT AND CHECK IN LIGHT CAME ON AND LOSS OF ACCELERATION. LUCKILY WAS ABLE TO MOVE TO THE LEFT SHOULDER WITHOUT INCIDENT. THE ENGINE WAS RUNNING VERY ROUGH AND I SHUT THE ENGINE OFF. THE WRENCH LIGHT MESSAGE GAVE A MESSAGE TO CHECK MANUAL. I STARTED TO CALL FOR ROADSIDE SERVICE AND WAS ON HOLD FOR A SHORT AMOUNT OF TIME. I HUNG UP AND TRIED TO START THE CAR AS I WAS APPROXIMATELY A MILE FROM THE NEXT EXIT. I WAS ABLE TO START THE CAR. THE WRENCH LIGHT WAS OFF BUT THE CHECK ENGINE LIGHT REMAINED ON. I WAS ABLE TO GET THE CAR TO ACCELERATE NORMALLY AND DECIDED TO TRY AND GET TO THE NEXT EXIT. I WAS ABLE TO CROSS TO THE RIGHT LANES BUT THE SAME THING HAPPENED AND WAS NOT ABLE TO MAKE IT TO THE EXIT BUT AT LEAST I WAS ON THE RIGHT SHOULDER. MY OPINION IS THAT THIS ISSUE COULD BE A BIG HAZARD. I WAS FORTUNATE TO HAVE TRAFFIC THAT WAS LIGHT ENOUGH TO ALLOW ME TO MANEUVER BUT IF THIS WERE TO HAPPEN WHILE MAKING A LEFT HAND TURN ACROSS TRAFFIC, HEAVY TRAFFIC OR CLOSE FOLLOWING TRAFFIC THIS COULD HAVE BEEN A BAD ACCIDENT.

NHTSA ODI 10914500

TRAVELING NORTH ON THE LOOP 101 IN ARIZONA GOING APPROX. 72 MPH WHEN THE ENGINE SUDDENLY STOPPED ACCELERATING AND DECELERATED TO APPROX. 20 MPH. ALMOST CAUSED AN ACCIDENT AS I HAD TO GET OUT OF THE FAST LANES OF TRAFFIC AND INTO THE EMERGENCY LANE. A PICTURE OF A WRENCH APPEARED ON THE DASH AND TOLD ME TO READ THE MANUAL. VEHICLE HAD TO BE TOWED TO THE DEALERSHIP WHERE I BOUGHT IT. VERY DISAPPOINTED IN FORD'S ROADSIDE ASSISTANCE AS I WAITED AN HOUR AND A HALF FOR A TOW TRUCK.

NHTSA ODI 10914225

2016 FORD EXPLORER WITH APPROXIMATELY 8400 MILES. WAS TRAVELING SOUTHBOUND ON US HWY 1 AT APPROXIMATELY 50MPH WHEN VEHICLE SUDDENLY STOPS ACCELERATING AND WRENCH LIGHT COMES ON. CAR WILL ONLY COAST AT LESS THAN 5MPH. WAS ABLE TO PULL INTO A PARKING LOT WITHOUT BEING INVOLVED IN AN ACCIDENT. VEHICLE WAS ON AND SHAKING BUT WOULD NOT ALLOW ME TO ACCELERATE. VEHICLE HAD TO BE TOWED TO FORD DEALERSHIP. FORD MECHANIC STATED IT WAS THE ELECTRONIC THROTTLE BOTTLE AND THEY HAVE ALREADY HAD A FEW OF THEM COME IN TO BE REPLACED. ETB HAS BEEN REPLACED BUT VEHICLE STILL LAGS WHEN ACCELERATING. WENT ON CARSCOMPLAINTS.COM AND 38 COMPLAINTS HAVE ALREADY BEEN FILED FOR THE SAME ISSUE.

NHTSA ODI 10913659

DRIVING DOWN THE ROAD AT 45 MPH WHEN THE ENGINE RPM'S DROPPED BELOW 1,000 AND I LOST ALL THROTTLE CONTROLS. I HAD TO SHIFT INTO N AND COAST INTO THE MEDIAN. ONCE STOPPED, I TURNED THE VEHICLE OFF AND ON AGAIN BUT STILL HAD NO THROTTLE CONTROLS. VEHICLE HAS 6,700 MILES AND THE DEALER SAYS THE PROBLEM WAS A SOFTWARE GLITCH THAT THEY KNEW ABOUT AND WERE GOING TO FIX AT MY 7,000 MILE SERVICE. I WAS LUCKY I WAS NOT ON THE FREEWAY WHEN THIS HAPPENED. IF FORD KNOWS ABOUT THIS GLITCH IT SHOULD BE FIXED RIGHT AWAY!

NHTSA ODI 10911278

ELECTRONIC THROTTLE RECALL (16B32)---WAS DRIVING ON THE 5 NORTH FREEWAY, AND HAD JUST MERGED ONTO THE 55 NORTH WHEN THE CAR LOST POWER. (I PUSHED THE GAS, BUT THE CAR COULD NO LONGER ACCELERATE)--ALL POWER WAS GONE. I WAS, THANKFULLY, ABLE TO MOVE OVER TO THE RIGHT SIDE OF THE FREEWAY. I CALLED AAA, AND WAS EVENTUALLY TOWED OUT OF THERE (TO FORD DEALERSHIP WHERE I ORIGINALLY PURCHASED THE 2016 FORD EXPLORER.) FORD DEALERSHIP TOLD ME THERE WAS "NEW" RECALL REGARDING MY VEHICLE (ELECTRONIC THROTTLE BODY REPAIR)---LEFT CAR ON SATURDAY. (SAID I COULD NOT GET A RENTAL SINCE IT WAS 2:58PM.) WENT TO GET A RENTAL CAR AT DEALERSHIP TODAY (MONDAY AFTER 2:30PM), BUT WAS TOLD THE CAR WAS READY TO GO HOME. I WAS INVOICED AT 3:14PM TODAY. PLEASE LOOK AT PAGE 1 --IT SAYS THAT WORK: "BEGAN:10-1-16 DONE:10-1-16", CAUSE: RECALL CORRECTION: REPROGRAM PCM"-----)*********TECHNICIAN TIME SPENT: 15:23 TO 15:43****** DID NOT REPLACE THE PART ( ELECTRONIC THROTTLE BODY REPAIR********THIS IS VERY DANGEROUS----PEOPLE CAN GET KILLED ON THE FREEWAY BY GETTING HIT BY OTHER CARS (IF THEIR CAR WERE TO SUDDENLY LOSE POWER IN THE PASSING LANE---------OR ON ANY LANE ON THE HIGHWAY FOR THAT MATTER). DEALERSHIP KNOWS ABOUT THE RECALL AND THEY STILL DID NOT REPLACE THE ELECTRONIC THROTTLE.

NHTSA ODI 10913566

( I AM EXPERIENCING WITH MY 2016 FORD) I BEGAN HAVING TROUBLE WITH EXHAUST LEAK IN AIR CONDITION HOWEVER DEALER WAS NOT ABLE TO REPAIR DUE TO FORD HAS NOT ISSUED ANY MANUALS HOW TO FIX THIS PARTICULAR PROBLEM AND DEALER ADVISED THERE IS NOTHING THEY CAN DO. THIS PROBLEM CREATES A SERIOUS SAFETY HAZARD.

NHTSA ODI 10910959

2016 FORD EXPLORER [XXX] LOST POWER AND WOULD NOT MOVE IN MIDDLE OF BUSY HIGHWAY. VEHICLE WAS NOTED TO HAVE A SPUTTERING SOUND AND APPEARED TO BE FIRING ON ONLY A FEW CYLINDERS. TURNED VEHICLE ENGINE OFF AND RESTARTED NO HELP VEHICLE WOULD NOT MOVE WITH ACCELERATOR PEDAL IN FULL OPEN (FLOORED) POSITION. AFTER OPENING HOOD AND DISCONNECTING NEG TERMINAL OF BATTERY VEHICLE OPERATED FINE FOR APPROX 10 MILES AND THEN SAME OCCURENCE. AGAIN FAULT CLEARED AND RAN FINE TO NEAREST FORD DEALER. INITIAL DIAGNOSIS BY DEALER WAS CODES P2111 AND P2112. DEALER STATED FOUND RECALL 16B32 FOLLOWED INSTRUCTIONS AND REPROGRAMMED PCM AND CLEAR CODES. CUSTOMER DEPARTED DEALERSHIP SERVICE BAY AND REPEAT ABOVE MENTIONED MALFUNCTION BEFORE OFF THE DEALER LOT. RETURNED TO SERVICE BAY AND DEALER STATED THAT THROTTLE BODY WAS CHANGED. VEHICLE APPEARS TO BE OPERATING NORMAL AT THIS TIME. THIS IS A SAFETY ISSUE THAT SHOULD BE INVESTIGATED. MY WIFE WAS DRIVING THE VEHICLE WHEN THIS FIRST OCCURRED IN BUSY MOUNTAIN HIGHWAY HERE IN SOUTHERN WV AND WAS NEARLY HIT BY NUMEROUS VEHICLES BEFORE VEHICLE COULD BE DRIFTED BACKWARDS DOWN THE MOUNTAIN WHERE IN ORDER TO GET VEHICLE OFF OF HIGHWAY. SERVICE ADVISER INDICATED THAT HE HAD SEEN SEVERAL SIMILAR PROBLEMS WITH THE 3.5 LITER ENGINE IN FORD EXPLORERS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 10910652

I WAS DRIVING ON 675 IN DAYTON OHIO AT 65-70 MILES AN HOUR WHEN MY FORD EXPLORER XLT LOST ALL ACCELERATION AND I WAS FORCED TO COAST TO A STOP ON THE LEFT SHOULDER OF THE HIGHWAY. I WAS ABLE TO TURN THE CAR OFF AND RESTART IT, AND DRIVE IT HOME WITHOUT INCIDENT. I HAD IT TOWED TO A FORD DEALER AND HOPEFULLY WILL HAVE AN ANSWER TOMORROW. THIS VEHICLE IS A 2016 XLT WITH JUST OVER 8,000 MILES. I NO LONGER TRUST THIS VEHICLE AND WILL BE RESEARCHING MORE RELIABLE VEHICLES.

NHTSA ODI 10910666

DRIVING ON FREEWAY WITH SUDDEN LOSS OF POWER. INSTRUMENT PANEL READ "SEE MANUAL". PULLED VEHICLE OVER, RESTARTED WITH NO PROBLEM AND WENT ON OUR WAY. LUCKILY NO ONE WAS HURT, BUT POTENTIAL FOR INJURY/ACCIDENT IS VERY SIGNIFICANT.

NHTSA ODI 10910061

THE VEHICLE KEEPS LOSING FUEL AND FUEL HAS TO BE REPLACED EVERY OTHER DAY. TOOK VEHICLE INTO FORD DEALERSHIP TO BE CHECKED OUT AND WAS TOLD VEHICLE IS SAFE TO DRIVE. GAS CAN BE SMELT AND VISIBLY GUSHES AFTER FUELING IN STATIONARY POSITION. WHEN VEHICLE IS IN DRIVE MOTION, GAS LEAKS SLOWLY. ALSO, WHILE DRIVING THE VEHICLE JERKS AND WILL SLOW DOWN ACCELERATION.

NHTSA ODI 10908880

WHEN ACCELERATING BEYOND 3000 RPM, EXHAUST GASES ARE ALLOWED INTO VEHICLE CABIN. NO FIX FROM FORD AS OF YET.

NHTSA ODI 10908656