What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

THROTTLE POSITION SENSOR HAS GONE BAD ON MY 2016 MALIBU IT HAS TO BE A KNOWN PROBLEM BECAUSE THERE ARE THOUSANDS OF VIDEOS OF PEOPLE SHOWING HOW TO FIX THE PROBLEM AND INSTALLING A NEW TPS AND PEDAL.

NHTSA ODI 11172267

AT CRUISING SPEED ON THE FREEWAY, APPROXIMATELY 65 MPH, THE CAR JERKED AND LOST A SIGNIFICANT AMOUNT OF POWER. THE CHECK ENGINE LIGHT ILLUMINATED AND THE WARNING "ENGINE POWER IS REDUCED" DISPLAYED ON THE INFORMATION PANEL. THE CAR CONTINUED TO LOSE A SIGNIFICANT AMOUNT OF POWER UNTIL I WAS ABLE TO GET OUT OF A SEPARATED TOLL LANE AND TO THE BREAKDOWN LANE. AFTER RESTARTING THE CAR, IT WAS ABLE TO AGAIN GAIN POWER. OVER SEVERAL DAYS, THE CAR WOULD GO IN AND OUT OF THIS MODE AND THE CHECK ENGINE LIGHT WENT OFF AND ON MULTIPLE TIMES, IT AGAIN LOST POWER ON THE FREEWAY, LOST SIGNIFICANT POWER WHILE DRIVING UP HILLS (DROPPING FROM A SPEED OF 55 MPH TO BELOW 20 MPH WITHIN A MINUTE). CARS BEHIND MY CAR HAD TO MOVE OUT FROM BEHIND ME AND I HAD TO PULL IN TO THE BREAKDOWN LANE ON SEVERAL OCCASIONS TO LET OTHER CARS PASS ME AS I WAS UNABLE TO MAINTAIN A LEGAL SPEED. THIS PROBLEM WAS ASSESSED BY QUIRK CHEVROLET AND DETERMINED TO BE CAUSED BY THE THROTTLE POSITION SENSOR IN THE GAS PEDAL AND THE ENGINE CONTROL MODULE. QUIRK IDENTIFIED THAT THESE COMPONENTS ARE NOT COVERED UNDER THE POWERTRAIN WARRANTY (DESPITE THE FACT THAT THEY ARE NECESSARY COMPONENTS IN THE POWERTRAIN) AND THAT THE TOTAL COST TO REPLACE THESE WOULD BE APPROXIMATELY $520 PLUS THE COST OF A RENTAL CAR. THEY ALSO WERE NOT ABLE TO LOCATE AN AVAILABLE GAS PEDAL/THROTTLE POSITION SENSOR ASSEMBLY BY THE END OF THE BUSINESS DAY AND WERE UNABLE TO IDENTIFY A TIMEFRAME FOR THE LENGTH OF TIME THIS WOULD TAKE TO COMPLETE BECAUSE OF THIS MISSING PART. THEY ALSO IDENTIFIED THAT THEY WOULD NOT BE ABLE TO RESET THE ECM UNTIL THIS SENSOR ASSEMBLY WAS COMPLETED.

NHTSA ODI 11172152

THE CAR IS STOPPED AND ENGINE TURNED OFF HANDLE DOES NOT ALLOW EXIT FROM CAR EXTERIOR - CANNOT LOCK/UNLOCK THE DOORS FROM THE DOOR SENSOR OR FROM THE FOB INTERIOR - CANNOT LOCK/UNLOCK THE PASSENGER DOORS WITH THE DOOR SENSOR OR FOB UPON ENTERING VEHICLE RANDOM ALARM ' AS IF VEHICLE IS BEING STOLEN CAR WILL DING THAT THE REMOTE IS STILL IN THE CAR WHILE I'M STILL IN THE CAR. ATTACHED IS A LETTER I SENT TO CHEVY TO TELL THEM HOW UNSAFE THIS IS IN EVERY SITUATION. THE CAR HAS BEEN AT THE DEALERSHIP WITH NO ANSWER IN HOW TO FIX THE PROBLEM SINCE 11/20/18. THE CAR HAS BEEN IN THE SHOP 48 OF THE LAST 54 DAYS WITH THE PAST 37 DAYS CONSECUTIVE CHEVY OFFERED ME A REBATE ON A NEW CAR BUT REFUSED TO BUY THE CAR BACK. THE CAR IS A DANGER AND IS NOT ROAD READY FOR ANYONE. I AM HAVING A DIFFICULT TIME UPLOADING DOCUMENTS, PLEASE LET ME KNOW IF I NEED TO SEND SEPARATELY THROUGH EMAIL.

NHTSA ODI 11166708

WATER LEAKED INTO THE BODY OF THE CAR THROUGH THE CENTER MOUNT STOP LAMP AT THE TOP OF THE REAR WINDOW. EITHER THE GASKET WAS DEFECTIVE, OR IT WAS SIMPLY MISSING FROM THE CAR. OVER TIME, WATER SEEPED INTO THE CAR FROM UNDER THE DRIVERS SEAT. THE HEAT FROM THE SUMMER CAUSED MOLD TO GROW ON THE VEHICLE FLOOR BOARDS AND THE DRIVERS SIDE SEAT BLET. MOISTURE IN THE CAR CAUSED DAMAGE TO THE ELECTRONIC COMPONENTS. THE CAR IS TOTALED AND CURRENTLY AWAITING INSPECTION AT THE CHEVROLET DEALERSHIP IN MY AREA. *LN*TP THE CONSUMER STATED HE NO LONGER OWNS THE VEHICLE. *JS

NHTSA ODI 11166377

ON 1/4/2018 I WAS DRIVING ON I-95 AND THE CAR BRAKES SUDENLY STOP WORKING COMPLETLY

NHTSA ODI 11165152

I'LL BE DRIVING APPROXIMATE 40 MILES AND CAR SYSTEM WILL COME UP STATING " ENGINE IS GOING TO REDUCE SPEED" OR SOMETHING LIKE THAT ? IT'S BEEN GOING FOR AT LEAST TWO WEEKS OR MORE NOW .

NHTSA ODI 11164428

DRIVING DOWN MAJOR HIGHWAY, CEL CAME ON, VEHICLE WENT INTO REDUCED ENGINE POWER MODE. SCANNED CEL AND FOUND CODE FOR APP SENSOR FAILURE. BROUGHT TO CHEVY DEALER NEAR WHERE CAR BROKE DOWN AND THEY SAID THEY WOULD CHARGE ME TO DIAGNOSE IT AND THEN CHARGE FOR PARTS AND LABOR. THE ONLY ISSUE BEING IS THAT THE GAS PEDAL AND SENSOR ARE ON A NATIONAL BACKORDER. WHICH MEANS THAT SINCE THIS IS NOT A WARRANTY ISSUE WITH THE THOUSAND OF GM VEHICLES AFFECTED BY THIS ISSUE I WOULD HAVE TO PAY FOR THE REPAIRS AND THE COST OF THE RENTAL CAR THROUGH THE DEALER. THERE IS NO ETA ON WHEN THE PART WILL BE IN (IF EVER) SINCE GM HAS NOT BEEN PRODUCING THESE PARTS FOR AFTERMARKET REPAIRS. THIS ISSUE STARTED ON 12/21/18 AND THE DEALER SAID IT MAY TAKE UP TO TWO WEEKS OR LONGER TO GET THE PART, THE PART HAS STILL NOT BEEN ISSUED TO THE DEALER WHICH HAS SEVERAL CARS WITH THIS ISSUE. I HAVE OWNED SEVERAL GM VEHICLES, MY GRANDFATHER WORKED FOR GM, AND I SERVICE MANY HEAVY DUTY GM ENGINES THROUGH MY JOB, BUT THIS WILL BE THE LAST GM VEHICLE I BELIEVE I WILL BE PURCHASING. THE QUALITY OF GM IS GONE IMMENSELY DOWN AND THEY ARE NOT WORTH THE HEADACHE OF OWNING ONE ANYMORE.

NHTSA ODI 11164672

TAKATA RECALL, WHEN MY VEHICLE STOPS AT A LIGHT AND THE AUTO STOP GOES IN PLACE AS SOON AS I LET OFF THE GAS TO CONTINUE DRIVING MY CHECK ENGINE LIGHT CAME ON AND MY RADIO AND MY DASH LIGHTS ALL WENT OUT AFTER A MINUTE OF DRIVING AGAIN THEY ALL CAME BACK ON

NHTSA ODI 11164396

I WAS DRIVING ON THE HIGHWAY, GOING 74, ALL THE LIGHTS ON THE DASHBOARD WENT ON (REGULAR LIGHTS, WARNING LIGHTS, EVERYTHING) IT LASTED ABOUT 5-10 SECONDS AND THEN WENT BACK TO NORMAL. DROVE ANOTHER TWO MILES REGAINING SPEED TO 74 AND HEADLIGHTS WENTOUT, ALL LIGHTS IN THE INSIDE (DASHBOARD, RADIO, CLIMATE CONTROL), AND I HAD NO POWER AND QUICKLY DROPPED SPEED. THE CAR COMPLETELY SHUT DOWN WHILE I WAS DRIVING ON THE HIGHWAY, IN 5:00 RUSH HOUR TRAFFIC. I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND I TURNED THE KEY OFF. I WAITED A COUPLE MINUTES AND THE CAR DID STARTUP AND I WAS ABLE TO GET OFF THE HIGHWAY. I TOOK THE BACK WAY HOME SO I WOULDN'T BE ON THE HIGHWAY. I CALLED THE CAR DEALERSHIP AND BROUGHT IT IN THE NEXT DAY. THEY SAID THEY HAVE NOT HEARD OF THIS AND HAVE NOT BEEN ABLE TO RECREATE THE ISSUE AND DIAGNOSTICS DIDN'T SHOW ANYTHING. I HAVE SEEN A FEW OTHER POST ON THE INTERNET WITH THIS HAPPENING ON OTHER MALIBU CARS. THE DEALERSHIP IS ALLOWING US TO "EXCHANGE" (FOR A FEE) TO GET A DIFFERENT CAR SINCE WE JUST PURCHASED THIS ONE A MONTH AGO. HOPE IT DOESN'T HAPPEN AGAIN TO SOMEBODY ELSE WITH THIS CAR.

NHTSA ODI 11164122

TAKATA RECALL: I PURCHASE A NEW VEHICLE IN 2016. I START HAVING ISSUES 6MONTHS AFTER PURCHASING. THE FIRST ONE THAT WAS NEVER RESOLVED: CHECK ENGINE, ENGINE POWER REDUCED. I HAVE TAKEN MY CAR TO CHEVY WEBB IN LANSIN, IL. THIS CAR HAS STOP ON ME ON THE EXPRESSWAY AND ON THE STREET. WHEN REDUCE SPEED COME I HAVE TO PULL OVER AND HOPING I AM NOT ON THE EXPRESS AGAIN. NOW, CHEVY STOP ASSISTING ME WITH THESE ISSUES BECAUSE WARRANTY IS OVER BUT, THIS ISSUES WERE NEVER RESOLVED. NOW I FIND OUT THAT 2016 MALIBU HAD A RECALL ON THEM MAY 2016 REGARDING THE SAME ISSUES THAT I AM EXPERIENCING NOW. I PURCHASED OCT 21, 2016. MY CAR HAS BEEN SERVICE OVER 25 AND STILL HAVING THE ISSUES. PLEASE SEE ATTAHED SERVICE REPORT. PLEASE HELP ME

NHTSA ODI 11163713

I WAS TRAVELING ON A HIGHWAY, GOING AROUND 70 MPH, AS I WAS ABOUT TO MERGE ONTO ANOTHER FREEWAY, MY CHECK ENGINE LIGHT CAME ON, AND A NOTIFICATION CAME ON THAT SAID REDUCED ENGINE POWER. MY CAR THEN DROPPED SPEED TO ABOUT 40 MPH. I WAS UNABLE TO ACCELERATE THE REST OF MY ROUTE TO WORK. I TOPPED AT 20 MPH. I CHECKED MY CODE READER AND P2138 CAME UP.

NHTSA ODI 11163602

FOR THE PAST COUPLE OF WEEKS WHEN MY AUTO STOP IS ENGAGE THE CAR TURNS COMPLETELY OFF AND STALLS WHILE STOPPED AT A LIGHT I DON'T KNOW WHAT TO DO ABOUT THIS SITUATION I THINK IT'S A CAR DEFECT IN MULTIPLE PEOPLE HAVE BEEN STATING THEY HAVE BEEN HAVING THE SAME ISSUE WITH THEIR SAME STYLE OF VEHICLE WITH THE SAME ISSUE

NHTSA ODI 11155765

TAKATA RECALL: MY VEICHLE HAVE BEEN HAVING ELECTRICAL ISSUES SINCE MONTHS NOW. I HAVE BEEN PAYING EXTRA MONEY TO REPAIRS AND STILL DOESN'T GET IT FIX. DEALERSHIP DOESN'T KNOW WHAT TO DO ANYMORE. MY CAR TURNS OFF AT THE LIGHT TO SAVE GAS BUT WHENEVER I RELEASE THE BRAKE BACK AGAIN THE WHOLE SCREEN GOES OFF AND BACK ON AGAIN WITH THE ENGINE. SOMETIMES I HAVE TO PUSH IT TO THE SIDE OF THE STREET BECAUSE IT DOESN'T WANT TO TURN BACK ON. MESAAGE ON THE SCREEN SAYS ' POWER STEERLING REDUCED, PLEASE DRIVE WITH CARE' ALSO IT SAYS SOMETIMES ' STABILITITANK ' . I NEED HELP ON THIS SITUATION BECAUSE I DON'T KNOW WHAT TO DO ANYMORE. I SAW A RECALL OF 7,000 CARS SAME TYPE LIKE MINE ON 2016 FOR THE SAME ISSUES. THANK YOU.

NHTSA ODI 11151898

I'VE HAD PROBLEMS WITH THE OFF AND ON IGNITION PUSH BUTTON SINCE LAST YEAR. I HAVE TO PUSH AND START SEVERAL TIME IN ORDER TO CUT OFF TO LOCK MY DOORS AND TURN THE RADIO OFF. MY BRAKES LOCKED ON ME WHILE DRIVING ON THE STREET AND SMELLED LIKE RUBBER WHERE BURNING. I HAD THE VEHICLE TOWED. I WAS TOLD NOTHING IS WRONG AND HAD TO GET MY VEHICLE AND PARK IT.

NHTSA ODI 11150940

2016 CHEVROLET MALIBU. CONSUMER WRITES IN REGARD TO RECEIVING REIMBURSEMENT AND REPAIRS FOR VEHICLE. *AS THE CONSUMER STATED THE A HUMMING NOISE COULD BE HEARD FROM THE HEADLINER MODULE AND ENGINE. THE ENGINE MOUNT COLLAPSED. THE RIGHT FRONT AXLE NEEDED TO BE REPLACED.*JS

NHTSA ODI 11143248

VEHICLE HAS BEEN STOPPED OR DURING TURNING OR DRIVING ON CITY STREET OR HIGHWAY AND SHUT OFF ENGINE, ENGINE LIGHT COME ON AND HAD RESTART IN TRAFFIC ALSO RADIO SCREEN MISSES UP AND ON STAR DOES NOT WORK PROPERLY WHEN IT HAPPENS. CAN'T STEER VEHICLE WHEN IT SHUTS DOWN. ABOUT CAUSED ME TO WRECK 4 TIMES. THIS VEHICLE IS NOT SAFE FOR ME OR MY PASSENGERS IT HAS LOW MILES AND STILL UNDER BUMPER TO BUMPER WARRANTY AND CHEVY DEALERS HAVE NO CLUE THE CAUSE. PLEASE CONTACT ME IF YOU NEED MORE INFO I BE GLAD TO SHOW U ISSUES WITH IT AND I LOVE SOMEONE TO HELP ME FIX THE UNKNOWN ISSUES BEFORE IT GETS ME OR MY CHILD OR SOMEONE ELSE HURT.

NHTSA ODI 11143514

ALTERNATOR BEARING IS GOING BAD. I HAVE NOT REPLACED IT YET THE CAR IS ONLY TWO YEARS OLD ALTERNATOR SHOULD LAST AT LEAST SEVEN YEARS. I ALSO HAD A NEW ENGINE PUT IN A FEW MONTHS AGO BECAUSE OF THE PISTON CRACKED. SO MANY ISSUES WITH THE NEW ENGINE IN THE 2016 CHEVY MALIBU MODEL

NHTSA ODI 11143320

WHEN GOING TO START THE VEHICLE WITH FOOT ON THE BRAKE PEDAL AND PUSH START BUTTON IT MAKES A CLICK SOUND AND SHOWS A CHECK ENGINE LIGHT AS WELL AS STABILITY CONTROL MESSAGE APPEARS IN THE DASH. IT'S NOT AN ISSUE OF A DEAD BATTERY OR FAULTY STARTER. IT HAPPENS ONCE OR TWICE A DAY. WHEN I COME BACK ABOUT A HR LATER I AGAIN APPLY THE BRAKE PEDAL AND PUSH THE START BUTTON AND AFTER A FEW TRIES OF IT READING THE SAME CHECK ENGINE STABILITY CONTROL MESSAGE IT STARTS UP. ALONG WITH THIS HAPPENING WHEN I'M DRIVING AND COME TO A STOP AT A STOP SIGN OR TRAFFIC LIGHT, THE AUTO STOP ENGAGES AS IT SHOULD ONLY THE VEHICLE COMPLETELY DIES. BUT WHEN I LET OFF THE BRAKE IT DOESNT START BACK UP AS NORMAL. ONLY TO HAVE TO PUT IT IN PARK AND APPLY THE BRAKE AND HOPE IT STARTS BACK UP. AFTER READING INTO THIS ON VARIOUS FORUMS THIS SEEMS TO BE A COMMON RECURRING ISSUE. ONLY NO ANSWERS AS TO WHY OR WHAT CAUSES THIS PROBLEM.

NHTSA ODI 11140765

I SEEN THE RECALL ABOUT THE AIR BAG ON THE PASSENGER SIDE OF THE FRONT SEAT I'M HAVING A ISSUE LIKE THAT WHAT CAN BE DONE TO SEE IF IT'S RELATED TO WHAT Y'ALL ARE RECALLING THANKS AND BE SIDE THAT IT COME ON AND OFF ON IT'S OWN EVEN WHEN NO ONE IS SEATING THERE.

NHTSA ODI 11138915

1ST PROBLEM MESSAGE POPS UP WHEN PARKING. MESSAGE READS SHIFT TO PARK EVEN WHEN SHIFTER IS IN PARK. WILL TURN OFF ENGINE BUT WILL NOT TURN OFF THE ACCESSORY. NEED TO SHIFT IN AND OUT OF PARK SEVERAL TIMES UNTIL MESSAGE DISAPPEARS AND ALLOWS TO TURN OFF. 2ND PROBLEM MESSAGE POPS UP NO REMOTE DETECTED PRESS BRAKE TO RESTART

NHTSA ODI 11129088

I TOOK THE CAR TO THE MECHANIC BECAUSE OF CHECK ENGINE LIGHT CAR WASN'T ACTING WEIRD OR ANYTHING. THEY RECOMMENDED REPLACING MULTIFUNCTION POWER SUPPLY CONVERTER, IT HAS INTERNAL ISSUES I APPROVED THEY TOLD ME EVERYTHING IS FINE EVERYTHING CLEARED. THE NEXT DAY THE VEHICLE STARTED TO GO CRAZY I STATED THAT ENGINE LIGHT IS ON AGAIN CAR LOUNGES FORWARD AND THAT THE DOORS LOCK AND UNLOCK ALL WHILE DRIVING AND CAR THEN JUST STOPS I HAD TO RESTART IT. THEY RECOMMENDED REPLACING BATTERY I APPROVED .THE SAME DAY I PICKED UP MY CAR CHECK ENGINE LIGHT SHOWED BUT THE NEXT DAY CAR STARTED TO BE IT SELF AGAIN SO I KEPT IT DIDN'T TAKE IT IN.A WEEK LATER THE SAME SYMPTOMS CAR JOLTS FORWARD,IT LOCKS AND UNLOCKS WHEN DRIVING AND CAR TURNS OFF COMPLETELY THIS TIME THEY RECOMMENDED REPLACING NEGATIVE BATTERY CABLE I APPROVED. 30 MINUTES AFTER LEAVING THE MECHANICS, CAR HAS THE SAME EXACT PREVIOUS SYMPTOMS BUT NOW CAR WENT BEYOND CRAZY, CAR WAS ON DRIVE BUT WON'T ACCELERATE, BREAK, AND STEERING WHEEL LOCKED, DASH SAID (SERVICE STABILITRAK) (ICE POSSIBLE) IT HOT OUTSIDE. IT HAPPENS WHEN I GET OFF FREEWAYS, WHEN I'M DRIVING ON REGULAR STREETS: DOORS LOCKS AND UNLOCKS DASH ALWAYS SAY CHECK REAR DOOR LOCKS THE, CAR LUNGES FORWARD AND THEN CAR JUST STOPS AND WON'T GO I HAVE TO TURN IT OFF THEN ON AGAIN. JUST IMAGINE IF CAR COMPLETELY STOP IN A FREEWAY, I'M LUCKY THAT IT GIVES ME A WARNING WHEN I HEAR THE LOCKS GO CRAZY I PULL OVER I THEN ABLE TO DRIVE IT SLOWLY HOME AND ALL THE WAY HOME CAR JOLTS TOWARDS LOCKS ARE GOING CRAZY AND CAR STOPS FREQUENTLY IN THE MIDDLE OF THE STREETS. THEN I'M ABLE TO TAKE IT TO THE MECHANICS LIKE NOTHING EVER HAPPENS TO IT. GOES BACK TO NORMAL WITH NO CHECK ENGINE LIGHT LIKE NOTHING EVER HAPPENED.

NHTSA ODI 11128340

WHEN I PUT MY CAR IN PARK, ON THE DASH BOARD IT SAY PUT CAR IN PARK TO TURN OFF. WHEN MY CAR IS IN PARK. ALSO WHEN I GO TO START MY CAR IT TAKE A WHILE FOR IT TO START. IT WILL SAY SERIVCE STABLILITY. MY AIR BAG LIGHTS CAME ON. I ALSO HAVE SEEN THAT ALOT OF CUSTOMERS THAT HAS THE SAME CAR IS HAVING THE SAME PROBLEM

NHTSA ODI 11127933

MY CAR WILL BE IN PARK AND THE ENGINE IS SHUT OFF BUT THE DISPLAY WILL INDICATE THAT THE VEHICLE NEEDS TO BE IN PARK. I WILL HAVE TO START MY CAR SEVERAL TIME AND SWITCH THE GEARS SEVERAL TIMES FOR THE INDICATOR TO GO OFF. THIS WILL GO ON SOMETIMES FOR APPROXIMATELY 5 MINUTES. I HAVE ATTEMPTED TO PUT ON THE EMERGENCY BRAKE IN HOPES THAT THIS WILL RECTIFY THE PROBLEM TO NO AVAIL. THIS HAS HAPPENED SEVERAL TIMES AT THE STORE AND IN MY DRIVEWAY.

NHTSA ODI 11122981

WHEN I SHIFT MY CAR INTO PARK & TURN MY CAR OFF, I GET A WARNING LIGHT THAT SAYS 'SHIFT TO PARK' WHICH HAPPENS ALMOST EVERY TIME I GO TO TURN MY CAR OFF. VERY RECENTLY MY CAR IS ALSO TURNING ON THE BACKUP CAMERA WHEN SHIFTING TO DRIVE. THE SHIFT TO PARK ISSUE HAS BEEN GOING ON FOR A MONTH NOW BUT THE BACKUP CAMERA COMING ON HAD JUST STARTED 4 DAYS AGO. THE DAY I BOUGHT MY CAR IT WAS BRAND NEW BUT COULD NOT BRING IT HOME THE DAY I SIGNED THE PAPERWORK BECAUSE THE DEALERSHIP HAD TO REPLACE THE BODY MODULE. NOW, AFTER MY CAR BEING IN THE SHOP 9 TIMES IN 2 YEARS, THE DEALERSHIP IS TELLING ME I'M RESPONSIBLE FOR THE REPAIRS. NOTE: MY CAR IS PUSH STOP NOT KEY

NHTSA ODI 11121223

FALSE INDICATION OF CAR NOT IN PARK AND DOES NOT TURN OFF DASHBOARD DISPLAYS AND CAR BATTERY DISCHARGES FULLY

NHTSA ODI 11119867