What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

I WAS DRIVING ON THE HIGHWAY, SPEED LIMIT WAS 70MPH I WAS GOING THAT SPEED THEN OUT OF NOWHERE I GOT THE CHECK ENGINE LIGHT AND A NOTICE ON MY DASH APPEARED AS 'ENGINE POWER REDUCED' AND MY SPEED DRASTICALLY DECLINED I WAS ALMOST REAR ENDED BY A SEMI TRUCK, I HAD PEOPLE IN THE BACK OF MY CAR AND WITH AN IMPACT FROM A TRAILER WE COULD HAVE BEEN SERIOUSLY HURT OR EVEN KILLED. THIS A REOCCURRING PROBLE WITH MALIBU'S FROM THE YEAR 2016-2019 GM KNOWS ABOUT THE ISSUE BUT HAS DONE NOTHING TO RESOLVE IT. THIS ISSUE NOT ONLY PUTS THE DRIVER OF THE VEHICLE IN HARM BUT OTHERS AROUND AS WELL. THE PROBLEM IS THE THROTTLE BODY RESPONSE SENSOR WHICH IS ABOUT A $300-$500 FIX WHICH IS NOT AN CHEAP FIX. THEY NEED TO BE HELD RESPONSIBLE FOR THIS BECAUSE ONE DAY THIS COULD HAPPEN TO ANYBODY WITH THIS TYPE OF CAR AND IT CAN KILL SOMEONE.

NHTSA ODI 11308024

WHEN DRIVING THE VEHICLE FIRST THE ENGINE LIGHT CAME ON AND I GOT A DIAGNOSTICS IT WAS THE MASS AIR FLOW SENSOR CODE COMING UP. I HAD THE THOTLE CLEANED.... THE ENGINE LIGHT WENT OFF 2 DAYA LATER. THEN I WAS DRIVING ON THE HWY AND THE ENGINE LIGHT CAME ON ALONG WITH THE MESSAGE ENGINE REDUCE POWER. I PULLED OVER SHUT THE CAR OFF FOR 10 SECONDS , START IT AGAIN AND DRIVE IT. IT DOES IT ON A DAILY NOW. AND IM TIRED OF IT THIS IS A BRAND NEW CAR. I GOT IT AT 28,000 MILES IT IS NOW AT 53,000 MILES. CHEVROLET KNOW THAT THIS PROBLEM IS GOING ON WITH MANY OF THE MAILIBUS THEY NEED TO FIX IT. I JUST SPENT 1,100 ON THIS CAR FOR THE REPAIRS

NHTSA ODI 11307941

MY 2016 CHEVY MALIBU COMPLETELY LOST POWER TWICE ON 2/6/2020. THE ENGINE SHUT COMPLETELY DOWN. THE FIRST INCIDENT HAPPENED WHILE WAITING IN THE PICK UP LINE AT MY DAUGHTERS SCHOOL WHICH IS IN A PARKING LOT FULL OF KIDS. THE CAR JUST SHUT COMPLETELY DOWN WHILE IN DRIVE. IT ACTUALLY DIED. NO INSTRUMENT PANEL ON, NO RADIO ON, NO HEAT. I HAD TO PUT THE CAR IN PARK AND THEN PUSH THE PEDAL ALONG WITH THE PUSH TO START BUTTON TO RESTART THE CAR. THE SECOND INCIDENT HAPPENED ABOUT 15 TO 20 MINUTES LATER WHILE I WAS STOPPED AT A TRAFFIC LIGHT. ONCE AGAIN THE CAR WAS IN DRIVE AND JUST COMPLETELY SHUT DOWN. THE SAME THING HAPPENED AS THE FIRST INCIDENT BUT THIS TIME I AM IN HEAVY TRAFFIC DURING THE TIME WHEN KID'S ARE RELEASED FROM SCHOOL AND PEOPLE IN GENERAL ARE MOVING AROUND THE CITY. ALL OF THIS HAPPENED DURING A HEAVY SNOW HERE IN MY STATE. FOR A PERSON DRIVING UP BEHIND ME I'M SITTING THERE WITH NO LIGHTS ON AT A NOW GREEN TRAFFIC LIGHT IN UNSAFE WEATHER CONDITIONS. VEHICLES WERE BLOWING AND GOING AROUND US TO AVOID AN ACCIDENT. I HAD TO ACT FAST FOR OUR SAFETY ALONG WITH THE OTHER DRIVERS ON THE ROAD. MY DAUGHTER AND MYSELF WERE SCARED OF BEING IN AN ACCIDENT. I HAVE AN APPOINTMENT TOMORROW 2/7/2020 AT A GENERAL MOTORS DEALERSHIP TO LOOK INTO THE PROBLEM.

NHTSA ODI 11307600

CAR WOULDN'T COMPLETELY TURN OFF. CAR STAYED IT WASN'T PARKED. IGNITION WENT FROM GREEN TO ORANGE INSTEAD TO NO COLOR/OFF. REPAIR WAS $500

NHTSA ODI 11302997

PASSENGER SIDE HEAD LIGHT WENT OUT WHILE DRIVING THEN CAME BACK ON A COUPLE OF WEEKS LATER. TWO WEEKS LATER DRIVER SIDE LIGHT WENT OUT. TWO WEEKS AFTER THAT BOTH LIGHTS WENT OUT WHILE DRIVING EVEN HIGHBEAMS NOT FUNCTIONAL WHILE DRIVING. ALL LIGHTS NOT FUNCTIONAL AT THE MOMENT.

NHTSA ODI 11301297

WHILE DRIVING, THE CAR SUDDENLY FLASHED THE "REDUCED ENGINE SPEED" MESSAGE, AND THE ENGINE WARNING LIGHT CAME ON. THE VEHICLE WOULD NOT EXCEED 20 MPH AFTER THE MESSAGE CAME ON. THE EARLIEST DEALERSHIP APPOINTMENT WAS FOR 1/20/20 IN A CITY APPROXIMATELY 30 MINUTES AWAY; I CALLED THE CHEVROLET WARRANTY LINE AND WAS ADVISED TO TRY CALLING OTHER DEALERSHIPS AND TAKE MY VEHICLE TO BE SERVICED THERE, DESPITE MY REPEATED EXPLANATIONS OF THE SAFETY RISK DUE TO THE ENGINE FAILURE. I RECEIVED MY CAR BACK TODAY (1/22/20) AND WAS TOLD THE ACCELERATOR WIRING WAS REPLACED UNDER A "SPECIAL" WARRANTY EXTENSION AND THAT THEY ARE NOT PROVIDING THE WARRANTY RENTAL CAR COVERAGE.

NHTSA ODI 11301242

THE ACCELERATION SENSOR IS MAKING THE ENGINE REDUCE POWER ,KNOW AS THE THROTTLE BODY.. IT ONLY COMES ON WHEN IT'S RAINING OUTSIDE OR MY CAR IS DRIVEN IN THE RAIN ,THEN NEXT DAY THIS STARTS HAPPENING.. HAS TO BE SOME TYPE OF RECALLL ON THIS SENSOR ,VERY DANGEROUS REDUCES YOUR SPEED DOWN TO 40 OR SOMETIMES 20 WHEN IT COMES ON

NHTSA ODI 11299167

THE ACCELERATOR PEDAL CENSOR IS FAULTY AND CAUSES THE VEHICLE TO START TO POWER DOWN. THIS COMMON IN MANY CHEVROLET MODELS FROM THE IMPALA, TO THE MALIBU AND CRUZE.

NHTSA ODI 11298034

MY WIFE WAS DRIVING ON THE HIGHWAY WHEN SUDDENLY A MESSAGE COME ON THE DASH STATING REDUCED ENGINE POWER THEN THE CHECK ENGINE LIGHT. OUR 2016 MALIBU CURRENTLY HAS 62510 MILES AND UPON RESEARCHING I HAVE FOUND IT TO BE LINKED TO THE ACCELERATOR PEDAL POSITION SENSOR. I HAVE FOUND MANY COMPLAINTS ONLINE, AND ONE PERSONS LAWSUIT

NHTSA ODI 11297501

PRESS ON THE GAS AND THE CAR SLOWS DOWN TO AN ALMOST STOP POSITION. WHILE DRIVING ON A STREET OR ON THE FREEWAY, THE CAR DECIDES IT WANTS TO SHUT DOWN. ALL ELECTRICAL REGARDING THE FRONT AND BACK CAMERAS HAVE GONE BLACK.

NHTSA ODI 11291709

WHILE DRIVING DOWN THE ROAD VEHICLE SHUTS DOWN WITH A NOTIFICATION SAYING ENGINE POWER REDUCED TO WHERE YOU HAVE TO PULL OFF THE SIDE OF THE ROAD AND SHUT THE CAR OFF THREE OR FOUR TIMES BEFORE IT WILL GET BACK TO WHERE IT'S SUPPOSED TO BE. VERY UNSAFE WHEN IT SHUTS DOWN GOING DOWN THE HIGHWAY AT 55 AND IT SLOWS YOU DOWN TO UNDER 20 YOU HAVE TO PULL OFF WEAVING IN AND OUT OF TRAFFIC VERY DANGEROUS.

NHTSA ODI 11289308

ADAPTIVE CRUISE CONTROL WHICH CONTROLS VEHICLE SPEED TO ENSURE SAFE DISTANCE STOPPED WORKING RENDERING CRUISE CONTROL INOPERABLE. THIS ALSO CAUSED THE FORWARD CRASH AVOIDANCE TO NOT WORK. VEHICLE TROUBLE CODE UO269-00 STORED WHICH RESULTED IN REPLACING LONG RANGE RADAR MODULE TO CORRECT FOR $1055.00

NHTSA ODI 11288521

EVERY TIME I PUSH THE BRAKE PEDAL AND THE AUTO STOP ENGAGES THE ENGINE TURNS OFF, BUT WHEN YOU TAKE YOUR FOOT OFF OF THE BRAKE PEDAL THE WHOLE DASH DISPLAY GOES OUT, INCLUDING THE TURN SIGNALS. IT TAKES ABOUT A MINUTE FOR THE DASH TO COME BACK ON. THIS HAPPENS SEVERAL TIME A DAY, AND IT HAS BEEN GOING ON FOR AT LEAST TWO YEARS. IT SCARES ME WHEN THIS HAPPENS.

NHTSA ODI 11287602

VEHICLE SAYS TO SHIFT TO PARK WHEN ALREADY IN PARK. VEHICLE IS HESITANT TO ACCELERATE SEEMS AS IF IT IS STRUGGLING TO GO AT TIMES. WHEN BLINKERS ARE IN USE , THERE IS NO SOUND AT TIMES THAT IS USUALLY ASSOCIATED WITH TURNING A TURN SIGNAL ON. ALL ISSUES HAPPENED DURING DIFFERENT OPERATIONS OF THE VEHICLE. WHILE STATIONARY , WHILE DRIVING , WHILE IDLED.

NHTSA ODI 11286532

WHEN THE VEHICLE IS IN "PARK", TURNING OFF THE ENGINE A "SHIFT TO PARK" MESSAGE IS DISPLAYED. THE ENGINE TURNS OFF, ALL OTHER ELECTRICAL ITEMS REMAIN ON. REPEATED RESTARTS ARE REQUIRED TO ELIMINATE THE "SHIFT TO PARK" MESSAGE. NOVEMBER 6 2019 THE "DEALER DID NOT HAVE THE PARTS REQUIRED TO CORRECT THE PROBLEM.10

NHTSA ODI 11279093

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL FAILED. WHILE THE VEHICLE WAS AT A COMPLETE STOP, "ACTION REQUIRED STEERING ASSIST REDUCED" APPEARED ON THE INSTRUMENT PANEL AND THE STEERING JERKED. THE ENGINE SHUT OFF, BUT THEN RESTARTED INDEPENDENTLY. THE CONTACT STATED THAT THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO COVINA CHEVROLET (635 SOUTH CITRUS AVENUE, COVINA, CA 91723, (626)-732-1100) WHERE IT WAS DIAGNOSED THAT THERE WAS A SHORT IN THE ELECTRICAL SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 35,000.

NHTSA ODI 11278501

WHEN AT A STP LIGHT, AND PRESS EXCELERATOR THE TOTAL ELECTRICAL SYSTEM H WILL GO OUT & CAR HESITATE TO MOVE. THEN, IT WILL KICK ON. ALSO, THIS THROWS MY SIRUS RADIO OUT COMPLETELY & I HAVE TO CUT THE CAR OFF COMPLETELY TO GET STATION BACK ON OR CALL FOR A REFRESH, BUT LOCAL STATIONS WILL REMAIN. NOW I GET A WARING ABOUT THE STEERING ABILITY-DRIVE CAREFULL.

NHTSA ODI 11270142

FOR THE PAST TWO YEARS MY VEHICLE HAS BEEN TO THE DEALERSHIP 6 TIMES FOR THE SAME ISSUE. ON MULTIPLE OCCASIONS THE CAR WHILE TRAVELING BOTH ON THE HIGHWAY AND IN THE CITY THE CHECK ENGINE LIGHT COMES ONE AND IT GOES INTO REDUCED POWER MODE. ON THE HIGHWAY THIS CAN BE A HUGE ISSUE. AFTER MULTIPLE 'FIXES' IT'S SEEMS TO BE OK. HOWEVER ON 10/3/2019 WHILE SITTING AT A RED LIGHT THE AUTO STOP FEATURE KICKED ON. NOTHING NEW THERE HOWEVER WHEN I TOOK MY FOOT OFF THE BRAKE THE CAR COMPLETELY STALLED AND THE DOORS ALL UNLOCKED. AFTER ABOUT 10 SECONDS IT STARTED BACK UP AGAIN. NOW THE AUTO STOP DOESN'T KICK ON AT ALL AND THE CAR WILL NOT LET ME USE AUXILIARY POWER. THE CAR IS ONLY 3 YEARS OLD AND SHOULDN'T HAVE THIS MANY ISSUES. WHEN I TAKE IT TO THE DEALER THEY PUT IT ON THE COMPUTER AND SAY NOTHING IS WRONG. WHAT IS IT GOING TO TAKE FOR GM TO FIX THIS ISSUE IN THESE MALIBU'S? IS SOMEONE GOING TO HAVE TO BE INJURED?

NHTSA ODI 11265996

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE REDUCE POWER IN THE ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE GRADUALLY BEGAN TO LOSE POWER. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE; HOWEVER, THE VEHICLE WOULD NOT TRAVEL OVER 60 MPH. THE CONTACT ALSO STATED THAT THE BRAKES FAILED WHILE APPROACHING A STOP LIGHT. WHILE DEPRESSING THE BRAKE PEDAL, THE BRAKES FAILED TO RESPOND IN A TIMELY MATTER. THE CONTACT TOOK THE VEHICLE TO ALL AMERICAN CHEVROLET OF KILLEEN (1802 E CENTRAL TEXAS EXPY, KILLEEN, TX 76541, 254-213-5397) WHERE IT WAS DIAGNOSED THAT THE BRAKE BOOSTER AND VACUUM PUMP WERE DEFECTIVE AND THE BATTERY WAS OVERCHARGED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 16V521000 (HYBRID PROPULSION SYSTEM) AND 16V272000 (ELECTRONIC STABILITY CONTROL). THE CONTACT WAS INFORMED BY THE DEALER THAT DUE TO THE BUMPER TO BUMPER WARRANTY, A RECALL REPAIR COULD NOT BE PERFORMED ON THE VEHICLE. THE VEHICLE REMAINED IN THE POSSESSION OF THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,493.

NHTSA ODI 11265632

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE THE CONTACT WAS EXITING THE PARKED VEHICLE, 'ADDITIONAL ACTION REQUIRED, PLACE VEHICLE IN PARK' APPEARED ON THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT WAS UNABLE TO SET THE VEHICLE ALARM AND THE HEADLIGHTS HAD TO BE TURNED OFF MANUALLY. GENESIS CHEVROLET (21800 GRATIOT AVE, EASTPOINTE, MI 48021, (586) 804-7977) WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: [XXX]. THE APPROXIMATE FAILURE MILEAGE WAS 13,000. *JS

NHTSA ODI 11259107

I OWN A 2016 CHEVY MALIBU AND ONE OF ITS FEATURES IS AN AUTO STOP/START FEATURE IN THE CAR. WHEN THIS CAR ENTERS THIS MODE WHEN I TAKE MY FOOT OFF OF THE BREAK IT IS SUPPOSED TO START AGAIN BUT WHEN I TAKE MY FOOT OFF OF THE BREAK IT WILL JUST COMPLETELY SHUT DOWN, WHEN I TRY TO START THE CAR AGAIN IT WILL JUST STALL. I WAS INVOLVED IN AN ACCIDENT ON JUNE 9TH 2019 WHERE THE CAR CUT OFF AND ROLLED BACK INTO ANOTHER VEHICLE. THIS IS JUST ONE OCCASION OF THE CAR CUTTING OFF ON ME AND BECOMING IMMOBILE. I WAS TOLD IT WAS A BATTERY ISSUE AND A WIRING ISSUE I'VE GOTTEN BOTH ADDRESSED BUT IT STILL HAPPENS. I'VE RECEIVED A LETTER FROM CHEVY THAT MAY ADDRESS THE ISSUE BUT I HAVE TO SEE. MY CAR CURRENTLY WON'T START. TODAY IS SEPTEMBER 24,2019

NHTSA ODI 11258818

ON SEPT 6TH 2019, AS I AM TRAVELLING TO WORK IN THE MORNING AROUND 7:15AM AT THE SIGNAL POINT MY CAR SUDDENLY SHUTDOWN OFF AND ALL MY CAR DOORS LOCKED UP AND I TRIED IN PULLING OUT BUT IT TAKES ME SOMETIME TO FIGURE THAT OUT. THIS IS NOT MY FIRST TIME. WHEN I BOUGHT MY CAR I HAD ONE YEAR OF MANUFACTURER WARRANTY BUT WHEN IT IS COMPLETED MY CAR STARTED FAILING OFF THE ENGINE SUDDENLY. I TAKE MY CAR TO DEALER BUT HE TOLD ME THERE IS NOTHING PROBLEM WITH THAT ISSUE. BUT IT IS REPEATING THE SAME ISSUE.

NHTSA ODI 11257280

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH, THE SERVICE ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. ADDITIONALLY, WHILE THE VEHICLE WAS STOPPED AT A TRAFFIC LIGHT, THE AUTOMATIC SHUT OFF FEATURE ACTIVATED. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO RESPOND. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT, BUT WAS MORE FREQUENT IN WARMER TEMPERATURES AND WHEN THE AIR CONDITIONING WAS IN OPERATION. THE VEHICLE WAS TAKEN TO WHITE ALLEN CHEVROLET (442 N MAIN ST, DAYTON, OH 45405, (937) 303-5147) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO REPRODUCE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

NHTSA ODI 11256083

I HAVE HAD MY VEHICLE FOR 2 YEARS SINCE DAY 1 I HAVE HAD ISSUES WITH THE VEHICLE FROM CONTROL ARMS, ELECTRICAL IN DOORS AND CAR SYSTEMS, THROTTLE BODY, STABILITY TRACTION CONTROL. I THINK THE CAR HAS BEEN IN THE SHOP WELL OVER 12 TIMES WITH AT LEAST 5 TIMES BEING THE THROTTLE BODY WHERE THE CAR JUST LOOSES POWER AND YOUR UNABLE TO DRIVE MORE THAN 40 MPH. IT GENERALLY WOULD HAPPEN ON THE FREEWAY. I WOULD PULL OVER AND HAVE TO TURN MY CAR OFF AND SIT AND THEN TURN IT BACK ON. THE ABOVE ISSUES WITH THIS CAR IS JUST TO NAME A FEW. BY THE WAY I PURCHASED THE VEHICLE AT 27,000 MILES SO THERE IS NO REASON WHY THESE ISSUES SHOULD CONTINUOUSLY BE HAPPENING. I HAVE CALLED CHEVY NUMEROUS OF TIMES COMPLAING THAT THIS VEHICLE IS SOMETHING WRONG WITH IT. I BELIEVE THEY HAVE JUST ABOUT REPLACED EVERY PART EXCEPT FOR THE BRAKES, ENGINE AND TRANSMISSION AND I A SURE THOSE ARE GOING TO BE NEXT. I COULD GO ON AND ON ABOUT THIS VEHICLE HOWEVER, IT IS DEFINITELY SOMETHING WRONG. I JUST TOOK IT IN FOR CHECK ENGINE LIGHT AGAIN AND NOISE FROM REAR END SOUNDING LIKE A STRUT. AND THEY FOUND ISSUE WITH KEY THOB CAUSING CHECK ENGINE LIGHT, LEAKING STRUT, AND BAD WHEEL BEARINGS. NOW THAT JUST ADDS MORE TO THE LIST. NOT TO MENTION I GET HOME AND THE CHECK ENGINE LIGHT IS BACK ON AGAIN AND THE NOISE IS SLIGHTLY STILL THERE. I HAVE PLENTY OF RECORDS I JUST HAVE TO MUCH TO UPLOAD HERE, BUT IF SOMEONE COULD PLEASE LOOK INTO MY SITUATION. THIS HAS TRULY BEEN A NIGHTMARE. WE CANNOT EVEN DRIVE THE CAR ON THE FREEWAY TO FAR BECAUSE WE ARE SCARED WE MAY GET STUCK.

NHTSA ODI 11255424

I PARK, PLACE THE SHIFTER INTO PARK AND TURN THE CAR OFF BUT A MESSAGE APPEARS ON THE GAUGE CLUSTER SCREEN SAYING SHIFT INTO PARK. THE ENGINE IS OFF BUT THE LIGHTS AND RADIO STAY ON. THE SHIFTER IS LOCKED AND WILL NOT MOVE. THE SAME SCREEN SHOWS THAT THE CAR IS IN PARK BEFORE I SHUT THE CAR OFF, I CAN FEEL THE TRANSMISSION SHIFTING TOO. I HAVE TO TURN THE CAR BACK ON AND RUN THROUGH THE GEARS AND BACK OFF SEVERAL TIMES TO MAKE IT SHUT OFF. SEEMS TO HAPPEN MORE OFTEN ON SHORTER TRIPS. I WENT TO THE DEALER THEY HAVE A PART ON ORDER SEEMS TO BE A KNOWN ISSUE BUT I'M JUST OUT OF WARRANTY. I HAVE HAD THE CAR FOR 2.5 YEARS JUST OVER 35K MILES AND IT JUST STARTED.

NHTSA ODI 11255096