What 435 owners told NHTSA about the 2015 Mercedes-benz C-class Hybrid

GAS LEAK/ SMELL IN CABIN AT IDLE

NHTSA ODI 11402961

THE 7 SPEED TRANSMISSION SHIFTS VERY HARD FROM 1 GEAR TO 2 GEAR TO 3 GEAR. FROM 3 GEAR ALL THE WAY TO 7 GEAR IS VERY SMOOTH. ALSO THE SAME WAY AROUND WHEN YOU DOWNSHIFT FROM 3 GEAR TO 2 GEAR TO 1 GEAR. THE SLOWING DOWN IS VERY HARSH AND IT LOOKS LIKE THE TRANSMISSION DOESN'T UNDERSTAND THAT THE CAR IS GOING TO A FULL STOP. ALL THE POWER AND SPEED CUT DOWN A FEW SECONDS BEFORE FULL STOP. I HAVE PERSONALLY TRIED TO DO THE RESET WITH KEY AND PEDAL TRICK BUT IT ONLY WORKS FOR A DAY OR TWO AND GOES RIGHT BACK TO THE ROUGH SHIFTING.

NHTSA ODI 11399056

TL* THE CONTACT OWNS A 2015 MERCEDES BENZ C300. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE CHECK ENGINE LIGHT REMAINED ILLUMINATED WITH AN ABNORMAL SOUND COMING FROM THE ENGINE. IN ADDITION, WHILE DRIVING THE VEHICLE WOULD NOT PROPERLY ACCELERATE AND UNINTENTIONALLY DECELERATED WHILE SPUTTERING. THE VEHICLE WAS TOWED TO THE LOCAL DEALER MERCEDES BENZ OF WILMINGTON LOCATED AT 3801 LANCASTER PIKE, WILMINGTON, DE 19805 TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 80,000.

NHTSA ODI 11398435

UPON SUBMITTING A CLAIM FOR MY "INOPERATIVE" SENSOR ISSUE AND THE CAR LOSING ALL POWER AT HIGHWAY SPEEDS. I DISCOVERED YOUR CLAIM ABOUT PANORAMIC SUNROOF DETACHMENTS. WELL YOU ARE IN LUCK AS I HAVE A LOVELY MERCEDES WITH A ROOF PANEL THAT I HAD TO GLUE TO THE TRACK AS IT CAME APART. THE HINGE ON RIGHT SIDE IS LOOSE. I CAN NO LONGER OPEN THE SUNROOF OR IT WILL CATCH WIND AS IF IT'S ABOUT TO DETHATCH. DRIVING THE SUNROOF IS SO LOOSE THAT IT WILL NOT CLOSE WITHOUT THE HELP OF HOLDING IT DOWN SO IT LOCKS INTO PLACE. BROUGHT IT INTO THE DEALER LAST SUMMER AND THEY BRUSHED IT OFF AND TRIED TO CHARGE ME OVER $2,000 TO GET IT FIXED. THEY SAID "COMMON ISSUE" I WOULD PRODUCE PICTURES, HOWEVER MY CAR IS CURRENTLY SITTING AT A MERCEDES FACTORY SHOP GETTING ITS OTHER SAFETY ISSUES TAKEN CARE OF.

NHTSA ODI 11397264

ON FEBRUARY 9TH, DURING MY MORNING COMMUTE ON THE INTERSTATE THE CAR LOST POWER TO THE DRIVETRAIN. MESSAGE THAT DISPLAYS WAS "COLLISION ASSIST PLUS INOPERATIVE" ALONG WITH CRUISE CONTROL INOPERATIVE. WITH AN AMBER ESP LIGHT ILLUMINATED, THERE WAS NO ENGINE LIGHT ON. WHEN THIS MESSAGE APPEARED THE CAR WOULD NO LONGER ACCELERATE (LIMP MODE). IN AVOIDANCE TO BEING IN A REAR END COLLISION I QUICKLY PULLED OVER, TURNED OFF THE CAR AND TURNED BACK ON. INOPERATIVE MESSAGE, LIMP MODE AND ESP LIGHT WAS CLEARED. I CALLED DEALER TO NOTIFY. MY THOUGHT WAS THE BATTERY IS A DUD (WAS REPLACED THE DAY PRIOR), THE CAR NEEDS A SOFTWARE REBOOT DUE TO THE NEW BATTERY OR CAR WAS NOT CONNECTED TO THE "MEMORY SAVER" CORRECTLY. OR THE SENSORS WERE DIRTY. SO I DID THE EASIEST. I WASHED THE CAR. THIS PROBLEM CONTINUED TO HAPPEN 5-6 TIMES MORE OVER THE NEXT FEW DAYS STALLING ON THE FREEWAY AT 65-75 MPH. EXTREMELY DANGEROUS & LIFE THREATENING. NO ENGINE PROBLEMS APPARENT. SEEMS TO BE RADAR OR SOFTWARE. THIS IS EXTREMELY DANGEROUS WHILE ON THE HIGHWAY, I FOUND MANY OTHER WITH THIS SAME ISSUE ON NHTSA. I ATTACHED A PICTURE OF CAR SHOWING MESSAGE WITH NO POWER. MY SEATBELT WAS OFF AS I WAS ON SIDE OF ROAD TRYING TO GET TO GAS STATION. THIS ISSUE IS CLEARED BY TURNING CAR ON / OFF. THEN IT HAPPENS AGAIN HOURS OR A DAY LATER, LOSS OF POWER AT HIGHWAY SPEEDS. COAST OVER.

NHTSA ODI 11397252

SUSPENSION PARTS ARE RUSTING OUT FAST I DON'T LIVE IN A SALTED ROAD FOR BLACK ICE TYPE OF ENVIRONMENT CAR ONLY HAS 66K MILES AND AC POURS FUEL ODORS IN THE CABIN INTERIOR MATERIALS ARE BUBBLING UP FAST EVEN AFTER UV TREATMENTS.

NHTSA ODI 11397130

THERE IS A FUEL HOSE (PARTS NUMBER: 274 070 3500) CONNECT TO THE HIGH PRESSURE PUMP IN FRONT ENGINE AREA. THE FUEL HOSE WAS FASTENED BY A CLAMP (NOT SURE THE PARTS NUMBER) . BECAUSE OF THE DESIGN FLAW, THIS CLAMP WILL LOOSE SINCE IT'S A SNAP JOINT ASSEMBLIES NOT TIGHTEN BY SCREWS. UNDER THIS SITUATION, THE FUEL HOSE WILL LOOSE AND AFFECTED BY THERMAL EXPANSION, THIS PROBLEM WILL CAUSE FUEL LEAK/SEEPING. WE CAN SMELL FUEL NEAR THE PUMP BEFORE WE START CAR IN COLD IN THE MORNING AND THIS SMELL CAN BE SMELLED UNTIL THE ENGINE WORKING INTO THE NORMAL OPERATING TEMPERATURE OR WHEN WE TURN ON THE AC OR HEATER . FUEL IS A VERY CRITICAL SAFETY PROBLEM AND USUALLY WE CANNOT TAKE NOTICE OF THIS POTENTIAL PROBLEM.THIS IS BEEN HAPPENING SINCE 11/19/2019 THE DATE WHEN I BOUGHT THE CAR TILL NOW

NHTSA ODI 11390531

CYLINDER ONE CRACKED UNDER NORMAL USE

NHTSA ODI 11390091

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ C300. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER MERCEDES-BENZ OF LOS ANGELES (1801 S FIGUEROA ST, LOS ANGELES, CA 90015, (213)425-3100) AND THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

NHTSA ODI 11390001

THERE IS A MAJOR ISSUE WITH THE 2015 M274 MERCEDES ENGINE REGARDING THE WRIST PINS. MERCEDES HAS ISSUED NUMEROUS INTERNAL SERVICE BULLETINS ABOUT THE ISSUE. THE ENGINES WERE MANUFACTURED WITH WRIST PINS WITH TOO MUCH TOLERANCE THAT SLAP AGAINST THE PISTON WHEN OPERATING THAT COULD LEAD TO PREMATURE ENGINE FAILURES. THERE ARE HUNDREDS OF COMPLAINTS ON ONLINE FORUMS OF PREMATURE ENGINE FAILURES (PRE 100K MILES). I CONTACTED MERCEDES AND THEY REFUSE TO DO ANYTHING TO FIX THIS PROBLEM THE REPAIR IS WELL OVER $8,000 AND THE AVERAGE PERSON JUST CAN NOT AFFORD IT. YOU DIAGNOSE THE PROBLEM BASED ON CHATTER DURING DECELERATION. PLEASE MAKE MERCEDES MAKE THIS RIGHT AND FIX THE AFFECTED CARS THE RIGHT WAY. I JUST BOUGHT THIS CAR AND I AM NOW IN THE HOLE OVER $20,000

NHTSA ODI 11389897

EVERY TIME I START MY CAR IT SMELLS LIKE GAS AND IT'S SO STRONG TO THE POINT WHERE IT GIVES ME HEADACHES. ALSO I WAS ON THE FREEWAY AND THE ROADS WERE WET FROM PREVIOUS RAIN AND I ALMOST DIED AND HYDROPLANED ON THE FREEWAY. EVEN IF IT'S A SMALL BIT OF RAIN MY CAR STARTS SHAKING AS IF I DON'T HAVE CONTROL. I DO NOT FEEL SAFE IN THIS CAR AND I JUST GOT THE CAR A MONTH AGO.

NHTSA ODI 11387746

INTERMITTENT FUEL LEAK. REAL BAD GAS SMELL IN CABIN COMING THROUGH THE VENTS. DRIVER SIDE, IN BACK, DOWN BETWEEN THE ENGINE AND BODY. THE FUEL LINES ARE PRESSURIZED, SO IT MIGHT ONLY LEAK WHEN THE PRESSURE BUILDS UP. I KEPT GETTING A STRONG GAS SMELL THE GARAGE AFTER PARKING FOR LONG PERIODS.

NHTSA ODI 11387131

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ C300. THE CONTACT STATED THAT WHILE ATTEMPTING TO ACCELERATE FROM A STOP LIGHT, A LOUD SOUND CAME FROM THE ENGINE COMPARTMENT AND THE VEHICLE BEGAN TO VIBRATE AND SHAKE BEFORE STALLING. THE VEHICLE WAS TOWED TO THE LOCAL DEALER KEELER MERCEDES BENZ LOCATED AT 1111 TROY SCHENECTADY RD, LATHAM, NY 12110 WHO DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE CAUSE OF THE ENGINE FAILURE WAS NOT PROVIDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000. ## VIN PASSED ## MERCEDES-BENZ 2015 C300 AMG ##

NHTSA ODI 11387214

I HAVE THE SAME PROBLEM ABOUT STEERING HARDER WHEN ON LOWER SPEED, EVERY OIL LEVEL LOOKS TO BE PERFECT.

NHTSA ODI 11384549

WHILE DRIVING ON THE HIGHWAY MY MY MERCEDES BENZ C300 2015 WITH 37000 MILES ,ENGINE BROKE, AND YOU ARE NOT EXPECTING THAT WHEN YOU ARE DRIVING AT 65 MPH. THE MECHANIC IS SAYING IT IS A WRIST PIN AND A CRACKED #1 PISTON AND IT IS A VERY COMMON ISSUE ON THAT CAR AND MERCEDES REFUSES TO RECALL OR FIX THE PROBLEM IM GOING TO LEAVE A LINK WITH ONE OF THE MANY WEBPAGES WITH AL LOT OF PEOPLE COMPLAINING ABOUT THAT PROBLEM. THANK YOU. HTTPS://MBWORLD.ORG/FORUMS/C-CLASS-W205/731642-W205-C300-STAY-AWAY-PISTON-CRACKED-65-K-MILES.HTML

NHTSA ODI 11383859

GAS LEAK IN FUEL LINE, WHILE RECEIVING AN OIL CHANGE FROM A LICENSED MECHANIC, HE BROUGHT TO MY ATTENTION THAT, THERE WAS FUEL LEAKING FROM THE FUEL LINE AND SHOWED (FUEL LINE SOAKED WITH GASOLINE DIRECTLY UNDER THE ENGINE), I ALSO NOTICED THAT WHEN USING THE AC THE STRONG SMELL OF GASOLINE COMES THROUGH THE VENTS.

NHTSA ODI 11375930

THIS CAR LEFT ME STRANDED ON THE SIDE OF THE ROAD. THE CAR WAS ON WORKING FINE DRIVING ALONG THEN ALL OF A SUDDEN PUSHING THE GAS PEDAL DID NOTHING AND THE CAR WOULD NOT MOVE. THE ENGINE SHUT OFF COMPLETELY. THE ENGINE WAS NOT GETTING GAS. THE ELECTRICAL AND EVERYTHING ELSE WAS ON IN THE CAR EXCEPT THE ENGINE. THE SYSTEM IN THIS CAR HAS A DOUBLE FUEL TANK THAT ONLY WORKS ON ONE SIDE. THE ENTIRE FUEL SYSTEM IS FAULTY. THE MANAGER AT MERCEDES TOLD ME HIMSELF THAT THIS IS A DESIGN FLAW IN THIS CAR. THERE IS NO REASON WHY A CAR WITH 24,000 MILES SHOULD HAVE BROKEN DOWN ON THE SIDE OF THE ROAD BECAUSE THE ENTIRE FUEL SYSTEM DOES NOT WORK. FAULTY AND HORRIBLE WORKMANSHIP ON A SUPPOSED LUXURY VEHICLE.

NHTSA ODI 11362900

SUNROOF NO LONGER CLOSED SHAKES AND RATTLES, SEEMS LIKE A SAFETY ISSUE DURING A POSSIBLE ROLLOVER

NHTSA ODI 11354396

WHILE DRIVING MY 2015 C250 COUPE, I HAD TO BRAKE HARD AS I WAS TRYING TO AVERT STOPPED HEAVY TRAFFIC. WHEN I SLAMMED ON THE BREAKS, THE STEERING WHEEL, COLUMN AND ENTIRE VEHICLE LOCKED UP. I WAS UNABLE TO TURN THE WHEEL ENTIRELY. AS A RESULT, MY VEHICLE SLIDE INTO ANOTHER VEHICLE FROM BEHIND. BECAUSE BOTH THE STEERING AND BRAKES LOCKING, I WAS UNABLE TO MANEUVER THE VEHICLE TO AVOID THE STOPPED TRAFFIC. THE AIRBAGS ALSO DID NOT DEPLOY AS THEY SHOULD HAVE.

NHTSA ODI 11353979

I CAN SMELL FUEL NEAR THE PUMP BEFORE WE START CAR IN COLD IN THE MORNING AND THIS SMELL CAN BE SMELLED UNTIL THE ENGINE WORKING INTO THE NORMAL OPERATING TEMPERATURE. FUEL IS A VERY CRITICAL SAFETY PROBLEM AND USUALLY WE CANNOT TAKE NOTICE OF THIS POTENTIAL PROBLEM.

NHTSA ODI 11353226

THERE ARE NO OPEN OR PENDING RECALLS ON THIS VIN. FOR CONSIDERATION OF ANY PART THAT IS OUT OF MANUFACTURER WARRANTY, IT WILL FIRST NEED TO BE ASSESSED AT THE DEALERSHIP LEVEL. IF FURTHER ASSISTANCE MAY BE REQUIRED, YOU CAN THEN CONTACT THE CUSTOMER ASSISTANCE CENTER FOR FURTHER REVIEW BY AN EXECUTIVE REFERRAL MANAGER. THERE ARE MANY FACTORS IN DETERMINING ANY CONSIDERATION WHICH INCLUDE BUT ARE NOT LIMITED TO THE VEHICLE HISTORY, MILES, TIME OUT OF WARRANTY, CUSTOMER PAY, ETC. PLEASE BE ADVISED THAT THERE IS NO GUARANTEE THAT ASSISTANCE WILL BE PROVIDED, BUT YOU WOULD RECEIVE A CALL WITHIN ONE BUSINESS DAY AT THE NUMBER YOU PROVIDE. 2015 C300 4MATIC PANORAMIC SUNROOF FRONT PANEL DETACHMENT WHILE DRIVING. THE GLASS FLEW OFF AND INTO TRAFFIC WHILE I WAS DRIVING ON INTERSTATE HIGHWAY I-25. I LIVE IN COLORADO SPRINGS CO. USA. AND MAINTENANCE AT THE LOCAL MERCEDES BENZ THERE. QUESTION IS IF THERE IS ANY VISIBILITY TO THIS ISSUE VIA MERCEDES BENZ CORPORATE, AND IF ASSISTANCE ON REPAIRS ARE A REALISTIC EXPECTATION. FAILURE DATE: 08/25/2020 THE CONTACT OWNS A 2015 MERCEDES-BENZ C300. THE CONTACT STATED THAT WHILE DRIVING AT THE SPEED LIMIT ON I-25, THE FRONT GLASS PANEL DETACHED FROM THE VEHICLE. THE CONTACT STATED A TRUE REALIZATION OF THE ISSUE WAS NOT FULLY COMPREHENDED WHEN IT HAPPENED OUTSIDE OF THE NOISE IT MADE AT THE TIME OF FAILURE, UNTIL THE CONTACT PULLED OVER ONCE OFF THE HIGHWAY, AND CONFIRMED THAT THE GLASS PANEL HAD DETACHED FROM THE VEHICLE. THE GLASS PANEL WAS NOT RETRIEVED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 19V918000 (VISIBILITY) AS A POSSIBLE SOLUTION FOR THE FAILURE, THE FAILURE MILEAGE WAS APPROXIMATELY 70123. IS ASSISTANCE FOR THE MONETARY COST OF REPAIR AN OPTION. QUESTION REFERENCE # 200826-000024 DATE CREATED: 08/26/2020 09:41 AM DATE LAST UPDATED: 08/27/2020 08:56 AM*DT CONSUMER STATED IN THE LATEST FINDINGS DURING INSPECTION THAT THEY WAS A MANUFACTURER ERROR AND REFUND WOULD BE APPLICABLE.*JB*DT *TR

NHTSA ODI 11352686

WHEN DRIVING ON THE BRIDGE THE PIECE OF MY SUNROOF FLEW OFF I PULLED OVER IT WAS RAINING AND THE INSIDE OF MY CAR GOT WET THE MOTOR ON MY SUNROOF NO LONGER WORKS AS THE WATER LEAKED THROUGH. I PICKED UP AS MUCH OF THE PIECES AS I COULD BUT THE PART WAS RUN OVER.

NHTSA ODI 11351629

2015 MERCEDES BENZ C300. CONSUMER WRITES IN REGARDS TO DELETED SAFETY FEATURES AFTER SAFETY RECALL WAS PERFORMED. *LD THE CONSUMER STATED DURING AN UPDATE THE VOICE RECOGNITION FEATURE WAS UNINSTALLED. THE MANUFACTURER WAS CONTACTED AND STATED THE FEATURE WOULD ONLY OPERATE IF THE VEHICLE HAD AN ACTIVE GPS SYSTEM. THE CONSUMER STATED THE VEHICLE WAS PURCHASE WITH THE USE OF THE VOICE COMMAND AND IT SHOULD REMAIN. *JS

NHTSA ODI 11349482

I STARTED EXPERIENCING LOUD WIND NOISE COMING FROM THE TOP OF MY CAR NEAR MY WINDSHIELD WHEN DRIVING OVER 40MPH. I PULLED OVER AND EXAMINED THE AREA AND FOUND THAT THE TOP LEFT GLASS PANEL IN FRONT OF THE SUNROOF ON MY 2015 MERCEDES BENZ C300 WAS SLIGHTLY PROPPED UP. IT SEEMED TO BE A POSSIBLE SEAL OR GLUE ISSUE CAUSING THE GLASS PANEL TO BE SLIGHTLY LOOSE AND ALLOWING AIR IN. I CALLED MERCEDES AND MADE THE NEXT AVAILABLE APPOINTMENT FOR SERVICE A FEW DAYS OUT. WHILE DRIVING ON THE FREEWAY, I BEGUN TO HEAR THE WIND NOISE AGAIN BUT FOLLOWED BY A LOUD RIP FROM THE ROOF OF MY CAR THIS TIME BUT DID NOT SEE ANYTHING IN SIGHT. WHEN I PULLED OVER, THE GLASS PANEL WAS COMPLETELY MISSING AND WENT FLYING SOMEWHERE ON THE HIGHWAY, CAUSING A ROAD HAZARD. IT WAS TORN OFF THE CAR AND THE ROOF OF THE CAR IS NOW EXPOSED.

NHTSA ODI 11349158

I TOOK MY CAR IN FOR A MULTI POINT INSPECTION AT THE END OF NOVEMBER 2019 TO MERCEDES OF BELLEVUE. I BEGUN SMELLING GASOLINE FROM THE INSIDE CABIN OF MY CAR A FEW DAYS AFTER THE SERVICE AND HAD TO TAKE THE CAR BACK TO THE DEALERSHIP. THEY FOUND THAT FUEL HOSES GOING TO THE HIGH PRESSURE FUEL PUMP TO BE LEAKING FUEL. WITH THIS BEING A POTENTIAL FIRE HAZARD AND A SAFETY ISSUE, I ARGUED WITH THE DEALER THAT IT SHOULD BE COVERED UNDER WARRANTY, WHICH I STILL HAD A CPO WARRANTY FROM PURCHASING THE VEHICLE FROM THIS SPECIFIC DEALERSHIP. I DID SOME RESEARCH ONLINE AND FOUND THAT, THIS IS A VERY COMMON ISSUE WITH MY VEHICLE MODEL, 2015 MERCEDES BENZ C300. I AM UNSURE WHY THIS ISSUE IS NOT YET RECALLED BY THE MANUFACTURER OR WHY THE DEALERSHIP DID NOT HONOR THIS ISSUE TTO BE COVERED UNDER WARRANTY.. AS A CONCERNED CUSTOMER OF THE HAZARDOUS POSSIBILITIES A FUEL LEAK COULD CAUSE, I STILL MOVED FORWARD WITH PAYING FOR THE REPAIR OUT OF POCKET VERSUS CONTINUING TO DEBATE WITH THE FINANCE AND SERVICE PERSONNEL THAT IT SHOULD BE COVERED UNDER WARRANTY THAT I STILL HAD AT THE TIME.

NHTSA ODI 11349160