What 1,000 owners told NHTSA about the 2015 Kia Optima Phev

The contact owns a 2015 Kia Optima. The contact stated that while attempting to start the vehicle or while driving at undisclosed speeds, there was an abnormal fuel odor inside the vehicle after the vehicle was serviced by the dealer. The contact stated that the vehicle received an undisclosed engine repair. The vehicle was not taken to an independent mechanic or the dealer to be diagnosed. The manufacturer was not notified of the failure. The failure mileage was 123,323.

NHTSA ODI 11717265

12-01-2025 driving to work in the morning approx 7:00A.M. and turned on the heater and had a very strong smell like fuel so immediately turned it off. Cracked my windows to air it out and then was super cold again and had turned on the heater to try again. Immediately had to turn it off and rolled windows down to air it out because the smell was intense and had started to feel nauseas. Later in the day, about to head to lunch and had started the vehicle and smelt a lot like gas and turned it off and had someone come out to double check the smell. Co worker had strong smell from the hood area and looked underneath the car and can see a little drop puddle. Opened the hood and lifted the cover to engine where you can see the leakage coming from the center hose and spill puddle. Service tech came to take a look and advised its the fuel feed to the high pressure pump. This is a safety concern because fuel is extremely flammable and can put myself in dangerous situation of firing igniting in the car or hurt others around. No check engine light and prior the vehicle incident car has been consuming oil putting in about 1- quart a week or so with commute miles about 270 weekly.

NHTSA ODI 11702454

While driving my 2015 Kia Optima (VIN: [XXX] ) at highway speed, the engine suddenly shut off without any warning lights, alerts, noises, or check-engine indicators. This created a dangerous situation for me and surrounding drivers. The vehicle had passed state inspection only 3 months earlier with no issues. The sudden shutdown is consistent with the known Theta II engine defect investigated by NHTSA. The car is now completely undrivable. Two Kia dealerships refused to assist, claiming that they cannot perform KSDS because the engine is already dead. These reasons directly contradict the Kia Theta II engine settlement terms. This sudden stall is a safety hazard and could have caused a severe crash. I am requesting that NHTSA review this incident as a potential recurrence of the engine-stall defect already documented in Hyundai/Kia vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11701029

While driving my 2015 Kia optima I was getting ready to turn in to my residence.My car completely shut off but my lights had got dimmed.So I had it towed to the Kia dealership then proceeded to tell me it has three recalls on it.Then a customer service representative said that I would have to pay $200,and something dollars to have my car diagnostic done.Whoever I replied even with these recalls I have to pay for diagnostic test to be done she replies yes,but I’m thinking they are just trying to make money off customers.

NHTSA ODI 11691385

The car makes a raddled noise when turn on and the car turns off when I press the brakes

NHTSA ODI 11671879

The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. However, several days later the failure reoccurred, and the contact heard an abnormal sound coming from the engine compartment, prompting the contact to discontinue driving the vehicle. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a nondescript failure with the engine. The contact was informed that the engine needed to be replaced. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 96,000.

NHTSA ODI 11655502

My 2015 Kia Optima Hybrid poses a serious safety risk. While driving at highway speeds, the car has randomly shut off multiple times. A "Check Hybrid System" or hybrid battery warning appears on the dashboard, and the vehicle either loses power entirely or switches to electric-only mode and coasts to a stop. This happens without warning, putting my life and the lives of others at risk. I already had the relevant hybrid system recall work completed by a Kia dealer, but the issue persists and the car remains unreliable and unsafe. This appears to be a known issue affecting many 2011–2016 Optima Hybrid vehicles. Kia needs to be held accountable for continuing hybrid system failures that occur post-recall and outside of warranty. This is a dangerous, recurring defect.

NHTSA ODI 11653852

The contact owns a 2015 Kia Optima. The contact stated that while driving 70 MPH, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. After a visual inspection, the contact observed an excessive amount of oil leaking from underneath the engine compartment. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with engine failure, observing a hole on the side of the engine block. The vehicle was not repaired. The vehicle was then towed to the dealer however, the diagnosis was not yet confirmed. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 112,000.

NHTSA ODI 11651080

DURING COVID 19 PANDEMIC GRIEVIANCE DEPRESION HOMELESSNESS RACISM CRITICISM HATE CYBERBULLY ATTACK I LIVE IN MY 2015 KIA OPTIMA I HAD [XXX] I HAD TBONE ACCIDENT IAM NOT FAULT FOR I HAVE ALL STATE INSURANCE I NEVER GET HELPED COMPENSATED THEY CLOSED MY CLAIMS I HAD MULTPLE CITATIONS 13 IN EL CAJON 4 IN SAN DIEGO 4 3 HOLLYWOOD 1 RIVERSIDE THAT I WASNT AWARE OF AS I WENT TO DMV TO RENEW MY CAR REGISTRATION I WAS BILLED FOR $1522 PAID $2200 FOR RENEWAL THERES PEOPLE WHO CROSSED MY LIFE WHO DAMAGED MY VEHICLE IT WASNT DRIVEABLE FOR ONE YEAR PARKED AT [XXX] THEN APRIL 2022 THIEVES INTENDED TO STEAL MY PERSONAL BELONGINGS THEY BROKE MY WINDOW ALL MY PERSONAL ITEMS WAS GONE IT WAS TOWED BY AGENCY HAD TO PAY $1000 WITH BUSTED WINDOWS MISSING PERSONAL ITEMS DENT TBONE ACCIDENT I SUFFERED BURDEN PAIN DEPRESSION EMOTIONAL DISTRESS WHILE I WAS BEING MOCKED CRITICIZED UNLAWFULLY I HAD TRAUMA THERE IS NO RELIEF RECOVERY IT DIDNT STOP THERE AFTER I PICKED UP FROM ROAD ONE TOWING AGENCY I HAVE IT TOWED MOVED PARKED IN [XXX] THEN MY ENGINE SEIZED UP WONT START IGNITION THEN BROUGHT KIA KEARNY MESA SERVICE DEALERSHIP JAN 1, 2023 THEN IT GOTTEN WORST MORE REPAIRS REPLACEMENT PARTS WHEN I HAVE LIFETIME WARRANTY ON MY ENGINE THEY INSTALLED BAD ENGINE REPLACED DEFECTS ON IT I WAS [XXX] MULTPLE TIMES NO PEACE OF MIND UNTIL PRESENT DEC 09, 2024 ALL THE REPAIR ORDERS WASNT BEING DONE PROPERLY. THEY PUT DAMAGES ON ME I GOT STRANDED MULTIPLE TIMES IN HIGHWAY FREEWAY INTERSTATE SIDE STREETS FOR ALL ISSUES ENGINE PROBLEMS THAT HAPPENED TO ME I COULDNT GET RECOVERY JUSTICE THEN [XXX] I HAD TRAFFIC COLLISION ACCIDENT IAM NOTAT FAULT I WAS BEING INTEROGATED BY KEMPER INSURANCE INVESTIGATORS TRYING TO ACCESS MY VEHICLE IMFORMATION DATA WHEN THEIR CLIENT HIT MY CAR FROM BEHIND I WAS WITH MOTHER WE BOUGHT HAD WHIPLASHED BACKPAIN WENT STRAIGHT TO E.R UNTIL NOW THEY WONT GIVE ME PEACE OF MIND I SUFFERED THE WORST PAIN INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11629788

For the past month or two my vehicle hesitates to start on the first try. I can smell an odor at times when this occurs. Most recently it seems to occur more frequently when the outside temperature is warmer.

NHTSA ODI 11611272

The contact owns a 2015 Kia Optima. The contact stated while driving 65 MPH, the vehicle shut off without warning. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed. The vehicle was diagnosed with engine failure and the vehicle was repaired by the dealer under Warranty. The contact stated that several months after the repair was performed, the contact noticed a fuel odor coming from the vehicle after a visit to the gas station. The next day upon inspection of the vehicle, the contact's husband discovered a puddle of fuel underneath the vehicle. The dealer was notified of the failure and requested that the vehicle be towed to the dealer for an inspection. Upon investigation, the contact discovered NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline; Engine) which the contact linked to the failure. The manufacturer was not notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 178,000.

NHTSA ODI 11606753

Drove this 15 Kia Optima on the highway when all of a sudden it lost power and died. There was no lights or symptoms prior to this happening. The vehicle ran as it should up until the other day, the Engine had no codes or lights on in the vehicle.. Then without any signs at all the vehicle stalled and almost caused an accident on the highway and the would not start. Barely made it to the breakdown lane. We had it towed to a shop and We spent some time checking the Kia over to find out the starter had melted. We installed a new starter and now the engine has a very loud knocking sound that was never there before. Based on reading the safety recalls and bulletins on this Kia and issues surrounding this vehicle online, we should meet the criteria for a claim. Can you help me please!!!!

NHTSA ODI 11593134

The contact owns a 2015 Kia Optima. The contact stated that the check engine and battery warning lights were illuminated. The contact stated that the engine had been replaced two weeks prior to the failure. The vehicle was taken to a local dealer for routine maintenance; however, the cause of the failure could not be determined. In addition, during a battery replacement, there were several unknown warning lights illuminated and smoke was coming from the vents. The vehicle was towed to a local dealer where it was diagnosed that there was an EVAP leak, the canister purge valve had cracked, and the battery needed to be replaced. The vehicle was not repaired. The contact referenced Kia Campaign Number: SC135. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

NHTSA ODI 11592841

My car has been consuming lots of oil. I took it in for an oil change and while test driving two of the mechanics stated the oil light came on and it ran out of oil on the test drive. Instead of saying anything about a possible issue with the engine, they went ahead and put oil in it and sent me on my way. Since, my car is still consuming loads of oil. I've taken it into the dealership several times for the same issue and each time they told me they can't do anything about it until it runs out of oil. One person advised to not put oil in it. Now the engine light came on, so I took it in again and this time I was told the cylinders have gone bad and one person that worked there said to let it run out of oil, but you didn't hear that from me, and they will replace the engine for free. I said, so I'm supposed to let the car die while I'm driving it, what happens if the car quits running in the middle of a turn and I get hit, the guy looked at me and said nothing. In addition, he asked if I had an extended warranty as its covered under an extended warranty. I'm pretty sure I did buy one, but I couldn't remember, so I called up the dealership I purchased it from and they said they couldn't tell me either since, they don't keep any paperwork after 7 years, and its been 8 years.They also said it wouldn't matter as it wouldn't be covered because of mileage. I have been complaining about the oil way before my mileage was over and I'm pretty sure I read something about mileage ext on Kia for this same issue.The last time I drove it, I was sitting idle in my car and the oil light came on, so I called the dealership, they asked if it started back up and I wasn't sure, so I tried and it started back up and the oil light went back off again, so I didn't have it towed down there. Now my understanding there is a new recall on the car with the fuel and it could catch fire and was stated to park it, so its been sitting for three months with nothing fixed.The car needs a new engine.

NHTSA ODI 11559552

Engine failure & fuel leak. Also oil was burning extremely fast . I had taking it to the dealership while back ago for a recall and said it was fixed. Few months later gas started running out fast. A check light engine came on saying there was an evaporation leak. I did call the dealership to see what exactly they fixed, emailed them. They kept telling me they would call me back and never did. Wouldn’t get any emails back. I took it upon headquarters to let them know about the oil burning fast and emailed. And called them. Apparently there was nothing they can do and told me I have to call the dealership. I took the car to my mechanic because I trust him more than the actual dealership at this point. And I brought up concerns about my safety being in that car. No one heard me out or seemed to care. And now forward months later after check light engines on and the pcv valve getting changed, purge valve. The light stopped coming on after changing the purge valve got change which linked to the code that showed up. I started seeing online that Kia optima’s have so many engine problems , misfires etc. and now my Kia has an engine failure. I tried to contact Kia again by entering the info for a settlement and I was told there is nothing they can do about it. So now I’m left with $5,500 to finish paying off my loan for the car and can’t even drive the car anymore. I havnt felt safe In my car for months and no one would hear me out.

NHTSA ODI 11554030

The contact owns a 2015 Kia Optima. The contact stated that the engine was previously replaced due to abnormal knocking sound. Additionally, the contact stated while driving 60-65 MPH, there was a strong gasoline odor coming through the A/C vents. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the low-pressure fuel hose was leaking and needed to be replaced; however, the part was not available. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V093000 (Fuel System, Gasoline). The manufacturer was not notified of the failure. The failure mileage was approximately 142,000.

NHTSA ODI 11553075

Engine lost power and when restart was attempted, it could torn turn over. Tried restarting 3 times with no success. After this, smoke started coming from the hood. I opened the hood and noticed a small flame at the driver side bottom of the engine compartment. Flame intensified and grew and eventually I extinguished with a fire extinguisher. I had just replaced the starter that same week and replaced some wiring at a local car repair facility.

NHTSA ODI 11552409

1st problem happened when I was at a complete stop, at a traffic light, in rush hour traffic. All the sudden steam started coming out from underneath my hood. I instantly looked at my temperature gauge and it did not show anything however I knew something was wrong when the light turned green I immediately pulled over, out of the street as far as I can get without being hit by other cars. I put on my hazard lights. Pop the hood. I had a gallon jug in my trunk. And I walked to a store to fill it up with water. Came back, poured the entire gallon into the radiator. Waited for at least 30 minutes. Started the car and made it home. After that incident, the problems with this 2015 Kia Optima has snowballed. It just amazes me that it has started happening 2000 miles after my extended warranty expired. I had to purchase and replace spark plugs, the coil packs, two other sensor things, which I do have the receipts for and now the car reeks a gasoline and it automatically kicks into overdrive and I lose my reading on my tachometer, this puts it into a disabled mode, I'm on the freeway in Russia traffic, trying to pull over without getting into an accident. Do I believe this is a safety concern? You're damn right I do am I mad yes. I am taking my k i a into the dealership. After doing my research on this make and model, is the dealership doesn't honor what the claims department and the media response to this problem. Will then I will leave the car with Kia because I cannot afford a new engine. I will have to call to finance company and let them know that I voluntary I'm letting them come repo this car, good luck selling it

NHTSA ODI 11548919

Excessive shaking of engine, stalled out while driving on highway, knocking in the engine.

NHTSA ODI 11545569

I HAVE 2015 KIA OPTIMA GREY OR PLATINUM GRAPHITE EXTERIOR COLOR SINCE AUG 2019 I HAD AN TBONE ACCIDENT LAST DEC 26 2021 WHICH IAM NOT AT FAULT FOR NEVER RECEIVED ANY TYPE OF COMFORT CARE CLAIM IT WAS DURING COVID PANDEMIC I WAS IN THE PROCESS OF GRIEVIANCE BEING HATE LEFT IN DESPAIR ALSO JOB LOSS WITH NO INCOME UNSTABLE LIVING SITUATION WHICH I WAS LIVING ON MY PERSONAL VEHICLE BEEN GOING THROUGH FINANCIAL HARDSHIP UNTIL PRESENT I HAVENT BEEN DRIVEN UNTIL I BROUGHT TO KIA DEALERSHIP JAN 1ST OF 2023 DUE TO MY PERSONAL INJURY AND CAR ACCIDENT IT WAS LEFT PARKED GOT TOWED WITH BUSTED WINDOWS HAD MY PERSONAL BELONGINGS BEING GONE MISSING.... I HAVE ROUGH YEARS... IT WAS DIFFICULT FOR ME TO GET BACK UP IN MY FEET MY CAR HAS RECALLS ARENT BEING REPAIRED FAIRLY. THIS WILL BE MY FIRST TIME TO ADHERE MY CONCERNS I WOULD LIKE TO GET SOME ASSISTANCE IF POSSIBLE...I THANK YOU IN ADVANCE

NHTSA ODI 11543067

I WAS DRIVING NORTH ON THE 57 FREEWAY AND MY CAR STOP RUNNING AND I PULLED ON THE SIDE OF THE FREEWAY AND MY CAR CATCH ON FIRE. EVERYTHING STARTED IN THE ENGINE. I CALLED KIA AND MADE A COMPLAINT AND THEY TOLD ME IT WAS NOT UNDER WARRANTY AND THEY COULD NOT HELP ME.

NHTSA ODI 11541660

I driving my vehicle is just started powering down and didn’t want to turn on again. We jumped started it thinking it was the battery but it checked out fine. The vehicle doesn’t want to start anymore and the mobile mechanic said the engine had ti be replaced since it was off the timing loop. No engine or vehicle lights were in and no prior issues were appearing.

NHTSA ODI 11533417

My 2015 Kia is burning 1. a lot of oil and 2. The second is the car smells of gas scared it is one that will catch fire

NHTSA ODI 11519490

The fuel rail seals keep leaking and spraying fuel all over . Fuel rail needs replaced

NHTSA ODI 11511637

I purchased a kia turbo optima from bob's lamphere's beaverton oregon kia dealership 9 days later I felt the acceleration awkwardly bi wanted to return it or exchange but was told no contract was only within 5 days. I took it to kia dealership for diagnostic 3 times I had it for 9 months the last 6 weeks was the 3rd time until Feb 28th It was totaled by a uninsured motorist memes william benton penny lll Or. Driver lic# 1289466 Of 1633 n.e. 76th portland oregon 97213 he was speeding illegally bypassing on a bridge into on coming traffic which was me he ending totally the back end of my kia. No air bags deployed I had no airbag warning light on I suffer injuries whiplash in my neck shoulder and back to this day Wild willy seemed to have injured his leg to the point of amputation ... Portland police report# 21-54465 which is the report that wild willy gave a false identity. Later the officer text giving his real identity. To this day I haven't been compensated for bodily or auto damageby wild willy or Geico my insurance. And lost my kia in a junk yard with a remaining of a bill of 12,000 of 25,500.

NHTSA ODI 11501694