What 258 owners told NHTSA about the 2015 Hyundai Elantra Hev

THERE'S A KNOCKING ,TAPPING COMING FROM MOTOR, I WAS CROSSING INTERSECTION ACROSS A HIGHWAY MY VEHICLE STALLED A BIT THOUGHT IT WAS GOING TO DIE. I RECENTLY FOUND OUT THERE WAS A CLAIM OUT THAT THE MOTORS WERE DEFECTIVE AS FAR AS PISTONS TAPPING , LOSING POWER. I HAVE CONTACTED ALL I COULD ALL SAME SAME THING , SORRY YOUR WARRANTY IS EXPIRED.I HAVE KEPT UP WITH OIL CHANGES AND MAINTENANCE CAR ONLY HAD ROUGHLY 4,000 MILES ON IT. THE EXTENDED WARRANTY DOES NOT COVER MILES OVER 10000 (IF YOUR A SECOND OWNER )OR 140000 IF YOUR ORIGINAL OWNER. I BOUGHT MY CAR FROM ENTERPRISE CAR DEALERSHIPS THEY BOUGHT IT FROM HYUNDAI. MY ISSUE IS I WAS NOT TOLD ABOUT A FAULTY ENGINE UNTIL IT WAS TO LATE. AND THAT WASN'T EVEN FROM HYUNDAI OR DEALERSHIP. IT WAS FROM THE CLASS ACTION LAWSUIT PAPER. THE REPAIRS OR REPLACEMENT OF MOTOR HYUNDAI IS OFFERING EXCLUDES PEOPLE LIKE ME THAT HAD NO IDEA AND HAVE EXCEEDED MILES OF THEIR ORIGINAL 100000 MILE WARRANTY. PEOPLE LIKE ME THAT HAD AND HAVE NO CLUE ABOUT THE ISSUES WITH MOTOR ARE AT RISK FOR STALLING OR WHATEVER ELSE BECAUSE WE WERE NOT NOTIFIED ABOUT PROBLEMS. I'M THANKFUL MY CAR DIDN'T DIE ON CROSSING HIGHWAY/ INTERSTATE WITH TRAFFIC . MY PROBLEMS WITH MOTOR THAT THEY KNEW WAS FAULTY JUST STARTED AT 127,000 MILES OR SO. PEOPLE NEED TO BE AWARE OF THESE ISSUES, HYUNDAI I FEEL ARE TRYING TO COVER UP OR REFUSE A RECALL TO SAVE THEM MONEY.

NHTSA ODI 11397741

CAR STALLS WHEN STOPPING OR IDLING IF YOU DO NOT KEEP YOUR FEET ON THE GAS. IT DOES NOT HAPPEN IN THE FIRST 10 MINS OF WARMING UP THE CAR BUT THEN HAPPENS FOR THE REMAINING TIME. I HAVE HAD A TUNE UP, THROTTLE BODY SERVICED, CRANKSHAFT SENSOR REPLACED, AND FUEL PUMP REPLACED. I HAVE BEEN TRYING TO GET THIS FIXED FOR THE LAST 3 YEARS AND NOTHING HAS HELPED.

NHTSA ODI 11395125

WHILE DRIVING MY 2015 HYUNDAI ELANTRA IT STARTED MAKING A RATTLING NOISE FROM THE AREA AROUND THE ENGINE. THIS NOISE EVENTUALLY GREW TO A LOUD KNOCKING NOISE. THE KNOCKING NOISE CONTINUED AND I BEGAN TO FEEL IT VIBRATING IN MY STEERING WHEEL. I TOOK MY CAR TO MY LOCAL HYUNDAI DEALERSHIP IN GRAND JUNCTION, CO TO HAVE IT LOOKED AT. THE SERVICE TECHNICIAN CAME OUT AND AS SOON AS I DESCRIBED IT HE SAID HE KNEW EXACTLY WHAT THE PROBLEM WAS BECAUSE THEY HAVE BEEN RECEIVING A LOT OF COMPLAINTS ABOUT IT. AFTER TURNING THE VEHICLE ON AND INSPECTING IT HE ASSURED ME THAT THE CONNECTION RODS AND BEARINGS WERE GOING OUT AND THAT I NEEDED TO REPLACE MY ENGINE THAT HAD 50,000 MILES ON IT. I WAS ALSO GIVEN THE OPTION TO ONLY REPLACE THE LOWER HALF OF MY ENGINE FOR HALF THE PRICE BUT THAT PRICE WOULD POSSIBLY EVEN OUT TO AN ENTIRE ENGINE REPLACEMENT BECAUSE THE COST OF LABOR WOULD GO UP. I DECIDED TO RESEARCH THIS ISSUE FURTHER AND HAVE FOUND THAT RECALLS HAVE BEEN ISSUED FOR SEVERAL OTHER VEHICLES WITH THE SAME ENGINE AND ISSUE BUT MY VEHICLE HAS YET TO BE PART OF THE RECALL. THIS HAS BEEN A MAJOR INCONVENIENCE FOR MY FAMILY AND I AS I HAVE NOT USED THIS VEHICLE SINCE MAY 2020 AND HAVE BEEN TOLD BY HYUNDAI THAT EVEN THOUGH THIS IS A COMMON ISSUE THERE IS NOTHING THAT CAN OR WILL DO TO HELP ME BECAUSE IT HAS NOT BEEN RECALLED FOR MY VEHICLE.

NHTSA ODI 11389015

I HAVE A 2015 ELANTRA THAT DEVELOPED AN ENGINE NOISE AT 135,000 MILES. AS I WAS DRIVING ON THE HIGHWAY, AT A SPEED OF 65, THE ENGINE BECAME EXTREMELY LOUD. I PULLED OVER TO CHECK MY VEHICLE. I PULLED OUT THE DIPSTICK AND IT HAD METAL SHAVINGS IN THE OIL. THE CAR LOST ALL ABILITY TO MOVE. THE GAS PEDAL DID NOT WORK AND THE VEHICLE WOULD REV ON ITS OWN. I HAD IT TOWED TO A HYAUNDAI DEALERSHIP. THEY SAID THE VEHICLE ONLY HAD 1 QUART OF OIL. THE ISSUE WITH THAT, IS MY LOW OIL LIGHT NEVER CAME ON IN THE VEHICLE. THE DEALERSHIP RAN THE CODES, AND IT SHOWED NOTHING ON THE SCANNER.

NHTSA ODI 11388504

THE VEHICLE ENGINE STARTED KNOCKING AROUND 80,000 MILES. AT 101000 MILES THE ENGINE HAD A CATASTROPHIC FAILURE. THE VEHICLE HAD TERRIBLE LOUD KNOCKING AND CRUNCHING NOISES WITH VERY LITTLE POWER. THIS HAPPENED ON THE INTERSTATE GOING 70MPH. THE KNOCKING ISSUE HAD BEEN BROUGHT UP SEVERAL TIMES TO ALLEN TURNER HYUNDAI IN PENSACOLA, FL AND IGNORES. THE SERVICE STAFF TOLD ME IT WAS BECAUSE I WAS NOT GETTING THE OIL CHANGED (I STOPPED GOING TO THEM BECAUSE OF THEIR TERRIBLE CUSTOMER SERVICE). ONCE I PRODUCED RECEIPTS PROVING THEM WRONG THEY SAID THAT I WASN'T GETTING IT CHANGED OFTEN ENOUGH EVEN THOUGH I GOT IT CHANGED ACCORDING TO THE TIME FRAME THEY TOLD AND WHAT WAS STATED IN THE OWNERS MANUAL. THEY EVENTUALLY AGREED TO FIX IT FOR $500 AFTER HAVING TO GET LOUD AND OBNOXIOUS WITH EVERYONE UP TO THE GENERAL MANAGER. IT WAS ONE OF THE MOST STRESSFUL SITUATIONS I'VE EVER HAD. THE VEHICLE STILL HAD $10,000 OWED ON THE LOAN. EVEN AFTER THE ISSUE WAS CORRECTED THE CAR NEVER GOT BACK TO WORKING WELL AT ALL. TO GET RID OF IT I HAD TO LEASE A VEHICLE FOR NEARLY $600 A MONTH TO RID MYSELF OF THE NEGATIVE EQUITY. BUYER BEWARE

NHTSA ODI 11378012

ENGINE HAD A CLICKING NOISE, CAR DIED WHILE DRIVING. BRAKES AND STEERING WHEEL DID NOT OPERATE. CAR ROLLED UNTIL IT GOT SLOW ENOUGH TO PULL THE EMERGENCY BRAKE. *TR

NHTSA ODI 11327195

WHEN I TRY TO ACCELERATE QUICKLY, ESPECIALLY IF THE ENGINE IS STILL COLD, I WILL SUDDENLY NOT BE ABLE TO ACCELERATE EVEN THOUGH THE ENGINE AND VEHICLE IS STILL RUNNING. THEN WHEN I SLOW DOWN THE VEHICLE BEGINS TO SHAKE LIKE IT'S ALMOST GOING TO DIE ALTOGETHER. THEN IF I TRY TO ACCELERATE AGAIN, IT'S ALMOST LIKE THERE IS NO POWER TO DRIVE,OR THE ENGINE COMPLETELY STALLS, AND THE CHECK ENGINE LIGHT BEGINS TO FLASH AND THE OIL PRESSURE LIGHT COMES ON. THE ONLY WAY THEN TO BE ABLE TO KEEP DRIVING IS IF I COMPLETELY STOP THE VEHICLE AND TURN THE IGNITION COMPLETELY OFF AND WAIT A FEW MINUTES AND THEN IT WILL USUALLY TAKE 3-5 TRIES TO GET THE CAR TO START AGAIN. THIS HAPPENS NEARLY 1-3 TIMES A WEEK, AND THE DEALERSHIP SAYS THAT IT'S NOT RELATED TO THE ENGINE RECALL THAT THEY ISSUED, EVEN THOUGH IT APPEARS TO BE THE SAME EXACT ISSUES THAT IS AFFECTING THE OTHER VEHICLES. THERE HAVE BEEN AT LEAST 20 OCCASIONS WHERE I WAS TRYING TO MERGE ONTO A HIGHWAY AND THEN MY VEHICLE DIES OR LOSES POWER AND THIS IS A HUGE SAFETY CONCERN OF MINE.

NHTSA ODI 11322738

2015 ELANTRA-ENGINE KNOCK/TICKING ON STARTUP. CURRENTLY WITH EVERY START. VEHICLE HAS 53000 MILES. QUIETS DOWN SLIGHTLY WHEN NORMAL OPERATING TEMP IS REACHED. MORE PRONOUNCED UPON ACCELERATION AND LESS WHEN COASTING.

NHTSA ODI 11315429

THE ENGINE ON MY CAR STALLED WHILE DRIVING ON THE HIGHWAY. I WAS ABLE TO PULL OVER AND GET IT STARTED AGAIN. I TURNED AROUND TO GO BACK HOME AND IT STARTED KNOCKING AND STALLED AGAIN. AFTER THAT, IT WOULD NOT START AGAIN. I HAD IT TOWED TO A REPAIR SHOP WHO SAID THE ENGINE WAS SEIZED. THEY WERE ABLE TO GET IT STARTED AGAIN BUT IT WAS KNOCKING LOUDLY. I ENDED UP HAVING TO REPLACE THE ENGINE WHICH COST CLOSE TO $6000 FOR A USED ENGINE. I HAD CLOSE TO 127,000 MILES ON THE CAR (I DRIVE 100 MILES PER DAY FOR WORK) AND HYUNDAI WOULD NOT HELP SINCE I AM OUT OF THE WARRANTY MILEAGE.

NHTSA ODI 11267226

TL* THE CONTACT OWNS A 2015 HYUNDAI ELANTRA. WHILE DRIVING 60 MPH, THE CHECK ENGINE WARNING INDICATOR STARTED TO FLICKER AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE SPARK PLUGS WERE REPLACED AND THE ENGINE OIL AND FILTER WERE CHANGED; HOWEVER, THE FAILURE RECURRED. SOUTH BAY HYUNDAI (20433 HAWTHORNE BLVD, TORRANCE, CA 90503, (310) 974-8180) WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,659.

NHTSA ODI 11257411

WE JUST BOUGHT THE CAR TWO MONTHS AGO FROM A USED CAR DEALERSHIP. MY SON WAS DRIVING WHEN ALL OF A SUDDEN ALL OF THE DASH LIGHTS FLASHED ON THE CAR AND THE CAR STOPPED IN THE MIDDLE OF THE ROAD. WE HAD IT TOWED TO A CAR DEALERSHIP NEARBY AND THEY LOOKED AT THE ENGINE AND SAID THAT THE ENGINE LOCKED. ALSO, WHEN YOU OPEN UP THE HOOD OF THE CAR THERE'S ALSO OIL ON THE INSIDE OF THE HOOD OF THE CAR.

NHTSA ODI 11256694

TL* THE CONTACT OWNS A 2015 HYUNDAI ELANTRA. WHILE DRIVING 70 MPH, THE VEHICLE BEGAN TO HESITATE AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE AND NOTICED AN OIL LEAK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER AND THE MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 55,103.

NHTSA ODI 11251848

CAR BURNS OIL WHICH HAS NOW DESTROYED CATALYTIC CONVERTER. DEALER REFUSES TO CORRECT

NHTSA ODI 11233785

CAR USED TO RUN WELL , BUT LAST WEEK STARTED TO MAKE A VERY LOUSY NOISE FROM THE ENGINE , I DONT FEEL SAFE TO USE IT ANYMORE ,ALSO THE CAR DONT HAVE THE SAME PUSH TO MAKE IT RUN I HAVE TO PUSH THE PEDAL ALMOST COMPLETELY BUT STILL IT DONT .IT DONT WORK AS IT USED TO BE

NHTSA ODI 11230910

ENGINE BEGAN KNOCKING AT VERY LOW MILEAGE. KNOCK WAS APPARENT WHILE STATIONARY, DRIVING, ACCELERATING. ENGINE REPLACED UNDER WARRANTY, NO QUESTIONS ASKED. IF ENGINE HAD FAILED DURING OPERATION IT WOULD HAVE CREATED A DANGEROUS DRIVING SITUATION.

NHTSA ODI 11220310

SEEKING TO ACCELERATE AS I MERGED ONTO A HIGHWAY, VEHICLE RPM EXCEEDED 6,000 WITHOUT ACCELERATION. DEPRESSED ACCELERATOR, TRIED AGAIN AND THE ENGINE BACKFIRED. RESULT: BLOWN HEAD GASKET ON VEHICLE WITH ONLY 62,000 KM. I CHANGED THE OIL EVERY 8,500 KM AND HYUNDAI IS DEBATING THE WARRANTY.

NHTSA ODI 11220030

I WAS IN MOTION ON NUMEROUS OCCASIONS DRIVING ON HIGHWAY AND CITY STREETS AND THE VEHICLE WOULD MAKE AN AWFUL TICKING AND GRINDING NOISE AND THEN STALL. I LOSE STEERING AND BRAKES AND HAVE BEEN IN TOO MANY CLOSE ACCIDENTS DUE TO THIS. I HAVE KIDS AND THIS IS NOT SAFE. I TOOK IT TO THE DEALERSHIP WHERE I BOUGHT THE CAR AND THEY COULD NOT FIND ANYTHING WRONG WITH IT. THERE ARE NO DASH INDICATORS ON NOR ANY CODES COMING UP WHEN SCANNED. I READ ABOUT THIS FROM OTHER PEOPLE. SOMETHING NEEDS TO BE DONE. THE SCARIEST TIME WAS WHEN I WAS GOING DOWN A STEEP HILL, CARS IN FRONT AND BACK OF ME. MY CAR STALLED AND WITH NO POWER STEERING AND NO BRAKES I BARELY MANAGED TO SWERVE AROUND THE CAR IN FRONT, DODGE THE ONCOMING CAR IN OTHER LANE, I THEN HAD TO GO INTO AN INTERSECTION PRAYING TO GOD THAT NO OTHER CARS WERE COMING THRU AT THE SAME TIME AND THEN MANAGED TO PULL OVER. DID I MENTION MY KIDS WERE IN THE CAR!!!! PLEASE RECALL THESE CARS FOR STALLING BEFORE SOMEONE GETS KILLED! IT IS VERY DANGEROUS.

NHTSA ODI 11219672

ITS A LOUD CRACKLING TICKING NOISE THAT COMES FROM MY 2015 HYUNDAI ELANTRAS ENGINE. WHEN I DRIVE THE THE TICKING TURNS INTO KNOCKING AND THE CAR SHUTS OFF COMPLETELY IN MOTION. I HAVE LOOKED ONLINE TO SEE WHAT THIS ISSUE COULD BE. I'VE READ COUNTLESS STATEMENTS ABOUT THIS ISSUE. HYUNDAI NEEDS TO STEP UP TO THE PLATE AND ACKNOWLEDGE THIS IS A URGENT MANUFACTURING ISSUE THAT NEEDS TO FIXED IMMEDIATELY.

NHTSA ODI 11217477

CAR IS STALLING AND ENGINE TURNS OFF WHEN DRIVING AT LOW SPEEDS HEAVY TRAFFIC. HAVE TO PUT CAR IN PARK AND RESTART. ALL INDICATORS ON DASH TURN ON SUDDENLY AND ENGINE SHUTS OFF. THIS HAS OCCURRED REPEATIDLY WHENEVER I AM IN TRAFFIC ON THE FREEWAY

NHTSA ODI 11208093

I BOUGHT MY 2015 HYUNDAI ELANTRA FROM THE CARMAX IN OAK LAWN ILLINOIS IN SEPTEMBER OF 2018 AND SINCE THEN I'VE EXPERIENCED A FEW PROBLEMS WITH THE VEHICLE AND CARMAX IS ONLY TELLING ME THAT IT WAS A PLASTIC BAG ON THE EXHAUST PIPE AND THAT IT WILL BURN OFF ON ITS OWN. I TOOK THE CAR INTO THEM ON APRIL 17, 2019 AND TODAY IS MAY 14, 2019 AND I'M ALMOST POSITIVE THAT IT DOESN'T TAKE A WHOLE MONTH FOR A BAG TO BURN OFF AN EXHAUST PIPE. ALSO I HAVE A COMPLAINT ABOUT MY BRAKE SYSTEM, WHEN I BRAKE THE CAR ACTS LIKE IT'S STALLING AND IT MAKES A CLICKING NOISE AS IF THE CAR IS ON ICE AND THE EXTRA BRAKE IS HELPING THE VEHICLE TO STOP. I KNOW THIS ISN'T SUPPOSED TO HAPPEN THIS WAY. I HAVE 3 CHILDREN THAT TRAVEL IN THIS VEHICLE EVERYDAY AND I CAN'T DRIVE A FAULTY VEHICLE AND SOMETHING HAPPENS TO THEM WHILE DRIVING IT.

NHTSA ODI 11207435

TL* THE CONTACT OWNS A 2015 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY AND WOULD STALL. THE FAILURE LEFT THE CONTACT STRANDED ON NUMEROUS OCCASIONS. WALSER HYUNDAI (8100 LAKELAND AVE N, BROOKLYN PARK, MN 55445, (651) 705-0151) WAS NOTIFIED AND REPLACED THE ENGINE ASSEMBLY, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION AND ENGINE ASSEMBLIES NEEDED TO BE REPLACED. THE CONTACT ASKED FOR THE MANUFACTURER TO BUY BACK THE VEHICLE. THE MANUFACTURER REFUSED AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

NHTSA ODI 11196922

VERY LOUD TICKING NOISE FROM ENGINE. WOULD NOT STOP WHEN CAR WAS WARMED UP AS I WAS ORIGINALLY TOLD BY THE DEALER IN THE FALL OR 2018. CONTINUALLY GOT LOUDER AND LOUDER AND I KNEW IT WAS NOT RIGHT. TOOK TO DEALER HAVE BEEN TOLD NEEDS A BRAND NEW ENGINE. FAULTY PISTONS.

NHTSA ODI 11193115

TL* THE CONTACT OWNS A 2015 HYUNDAI ELANTRA. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD ABNORMAL NOISES COMING FROM THE ENGINE COMPARTMENT. THERE WERE NO WARNING INDICATORS ILLUMINATED. BILLION AUTO HYUNDAI (3401 W 41ST ST, SIOUX FALLS, SD 57106) DIAGNOSED THAT THE ENGINE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 11192410

VEHICLE WAS MAKING A "TICKING" SOUND. GETS LOUDER AS YOU ACCELERATE. TOOK VEHICLE TO MECHANIC - ADVISED PISTONS/ENGINE ARE CAUSING SOUND TO CONTACT HYUNDAI DEALER AS THERE HAS BEEN MANY ISSUES WITH THE CARS ENGINES. CAN DRIVE THE CAR AT THIS TIME, WAITING ON DEALER TO RESPOND AND HOPE ENGINE DOESN'T BLOW UP ON ME. CAR ONLY HAS 55,000 MILES.

NHTSA ODI 11184269

MY ENGINE BEGAN MAKING A CLICKING NOISE IN JANUARY 2019. I DIDN'T THINK MUCH OF IT. THEN THE CHECK ENGINE LIGHT, THE OIL PRESSURE LIGHT AND THE BATTERY LIGHT ALL WOULD START FLASHING WHEN I WAS DRIVING AND MY ENGINE WOULD DIE. I TOOK IT TO MY CAR DEALERSHIP, WHO SAID THEY COULDN'T TELL ME WHAT WAS WRONG WITH IT, BUT THAT IT WAS COVERED UNDER MY WARRANTY SO THEY ARE REPLACING IT. I HAVE LOOKED ONLINE AND NOTICED MANY OTHER PEOPLE WITH THE SAME PROBLEM. I DON'T KNOW MUCH ABOUT CARS BUT I DO KNOW THAT AN ENGINE TOTALLY DYING AT 58,000 IS NOT GOOD. THEY DID MENTION THAT THEY WOULD CHECK THE OIL FOR METAL SHAVINGS. I LOOKED THAT UP ONLINE, WHICH HAPPENS WHEN AN ENGINE IS POORLY MADE AND THE MOTORS ARE SCRAPING AGAINST EACH OTHER, PRODUCING METAL SHAVINGS, WHICH THEN GO THROUGH THE ENTIRE ENGINE THROUGH THE OIL. EVERY TIME THE ENGINE DIED I WAS DRIVING ON A SIDE STREET, GOING ABOUT 30 MPH.

NHTSA ODI 11183348