What 188 owners told NHTSA about the 2015 Ford Transit Van - Gas

My 2015 Ford Transit 350 equipped with the 3.2L diesel engine experienced a failure of the high-pressure fuel injection pump at approximately 72,000 miles. The pump generated metallic debris which contaminated the entire fuel system. The vehicle began experiencing drivability problems including loss of power and intermittent stalling. The vehicle was diagnosed by a Ford dealership, where metal contamination was found in the fuel system. The repair required replacement of the high-pressure fuel pump, injectors, high-pressure fuel lines, and fuel rail, along with flushing and cleaning of the fuel tank and fuel system. The total repair cost was approximately 11,500. This failure appears to match the defect described in Ford safety recall 16S32 for certain 2015–2016 Ford Transit vehicles equipped with the same 3.2L diesel engine, where scuffing in the fuel injection pump can create metallic debris that contaminates the fuel system. My vehicle was built July 16, 2015, essentially within the same production period described in the recall, but my VIN was not included in the recall population. Because this failure required replacement of most of the fuel system components and created a sudden loss of power risk while driving, I am reporting this issue so it can be investigated and considered for inclusion with similar failures.

NHTSA ODI 11724153

Initially my van began with a simple engine stall and total electrical failure while driving down the highway. The check engine light came on and the van was taken to the dealer to explore the problem. Multiple codes were found and were fixed which included coils, O2 sensors, fuel pump control module and several other things. Then a few days after picking the van up from the shop it had another engine stall while driving and check engine light. After taking it to the auto shop we informed of additional codes and problems which include catalytic converters, new battery, new alternator, and other things. Picked the vehicle from dealer and a few hours later the engine light came on along with engine stall while driving. I took it back to the dealer and I report problems with poor engine performance vehicle misfiring, rough running, poor fuel performance, check engine light, several engine stalls. Dealer diagnosed the van with needing a new Powertrain Control Module. Repairs were completed and upon picking the van up from the dealer the van wouldn't start, and dealer diagnosed the van with a bad fuel pump. To date we have spent over 30K in repairs, nearly 4 vehicle accidents due to engine failures, over 4 vehicle tow's, 5 battery replacements, and the van is currently awaiting new fuel pump replacement.

NHTSA ODI 11672923

When I was driving, the driveshaft came apart and everything underneath broke including fuel lines, brake lines, and turbo lines. Ford is refusing to pay for the recall repair.

NHTSA ODI 11611496

The car stalled without warning while driving in heavy fast traffic which nearly caused a accident. It turns out that the recall Ford program [XXX] that addressed this issue was not performed by the dealership (even when it was serviced repeatedly at dealer) as they did not have the parts. Now Ford claims they will not fix the issue as the program expired months ago. Former ford stock owner (never again). [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11580052

Vehicle has an open recall for flexible coupling from the transmission to the drive shaft. This broke and damaged the fuel line, broke the brake lines and damage some other components. Took it to the Webb Ford in Highland IN and they informed me they will cover just the flexible connector and not the other damage caused by the failure, stating they send a lot of recall notices to the previous owner. Cost for the repairs are aprox $3,100. Since the failed coupling caused the damage, why i am asked to pay for the repairs caused by the recall component. I am a new owner of the vehicle and never received any notices from Ford. Thank you

NHTSA ODI 11564579

While driving van displayed "engine fault service now" and lost all power in the middle of the road. I was able to pull over turn it off and back on and is running. This is happened to nearly our whole fleet of Ford Transits. I have put in a claim with Ford, as this is an extremely dangerous safety issue. It is causing my employees to feel like we are providing unsafe transportation, it is causing lost revenue due to vehicles being out of service and it is a potential insurance claim/workers comp issue. Ford needs to take action.

NHTSA ODI 11556068

While driving on the highway, acceleration shuts down and I lose the ability to control speed. I had to coast to the side of the road even though the engine was still running and I was rear-ended. After I shut off the vehicle, it turned on and returned to normal operation. This has happened multiple times. The throttle body was replaced in 2021 at 117,444 miles and is having this issue again now. I have a fleet of Transit vehicles and this has happened on 4 transits from 2015-2018 a total of 6 times now. This is an ongoing issue that Ford needs to address.

NHTSA ODI 11555235

The 2015 Ford Transit was designed such that rainwater from the windshield drains into the engine and sometimes floods the air filter system. This issue is documented in this NTSA TSB where it's stated: To resolve this condition, install updated water management hardware and/or a revised air cleaner cover. https://static.nhtsa.gov/odi/tsbs/2019/MC-10156525-0001.pdf We were driving along an interstate and were on a long viaduct while it was raining. The engine stalled and we were lucky enough that the vehicle was able to reach the end of the viaduct. I had my spouse and 7 children in the van. We received a tow but myself and 2 children were forced to walk along the interstate as the tow couldn't hold all of us. As this is a large passenger van, it's my opinion as a licensed professional engineer that it poses an substantial fatality risk to occupants because the likelihood of fatalities on interstates is tremendous due to traveling speed. Ford designed a windshield that puts water into the air system which creates a known safety and 100% preventable condition. This should be a factory safety recall repaired in all Ford Transits. Most of these vans are used by government agencies for employee or prison transport or by church/community service groups and has a high percentage of mass casualty or PDO when the system fails. There are multiple YouTube and Ford Transit auto forums highlighting this safety design flaw so it is a well known and attributable problem created by substandard Ford engineering.

NHTSA ODI 11514273

The contact owns a 2015 Ford Transit. The contact stated that while driving at various speeds, the vehicle stalled while depressing the accelerator pedal. No warning lights were illuminated. The vehicle was towed to a local dealer, where it was diagnosed that the throttle body actuator needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

NHTSA ODI 11510465

On Jan.17th, 2022,the Driveshaft Flexible Coupling separated at Highway speed, taking out my Fuel Lines and severely damaging the Transmission and other under-body components. (Safety Recall Notice 19S38 / NHTSA Recall 19V-767) On May 19th, 2022, I received my 1st phone call from Todd-Judy Ford, Marmet, SC. w/Service Estimate for $5,725.75 of repairs he claimed necessary that would NOT BE COVERED BY FORD. , I know the guy was trying to pad the bill. I told him to talk to Ford Pro. On July,25th, 2022 Todd-Judy Ford called to inform me that my Van was “ready to go,” “completely fixed” I  left Sept. 9th, 2022 driving over 500 miles, to Todd-Judy Ford. Once there they started telling me about all the new parts they put into my Van, saying “You’ve got a “New Transmission,” at which point I interrupted him, saying that I knew it was a New Transmission “Case,” not a “New Transmission.” He then proceeded to explain that when they got the “New Case”, the Trans. Tech. inspects all the parts from my Trans., replacing anything it needs, while re-assembling into the “New Case.” He claims that it’s a “Rebuilt” Transmission! So, I ask, “Is there a Warranty on it, then?” To which he replies “Yes there is!” I looked at the paperwork and saw quite a few parts listed as used, which are obviously Transmission Components. I also see “Rebuilt Transmission” listed twice as Corrections!  My Van had a "Dead Battery" and a "massive exhaust leak". On Nov. 17th, 2022, just 51 days after picking up my Van, the Transmission failed! Towed to Rock-Hill Ford SC. It threw a Code of P0731, which is “Gear 1 Incorrect Ratio.” Multiple teeth from a gear sheared off. Ford Pro (Customer Service) then said “We can’t offer you any “Financial Assistance” on this repair. She said something else, about not having any other “Programs” to offer. I had never asked for Financial Assistance! I asked for the Transmission to be repaired under the Warranty from 51 day previous! Rock Hill Ford wants $9,806.09.

NHTSA ODI 11510273

2015 FORD TRANSIT PRESENTS WITH NO START CONDITION LOSE OF FUEL AND CODE P0230 ON FURTHER DIAGNOSIS FOUND ENGINE COMPARTMENT FUSE BOX TO HAVE MULTIPLE FUSE TERMINALS LOOSE FROM THE BOARD. TO BE CLEAR THESE DO NOT APPEAR AS FUSES LOOSE FROM THE TERMINAL THEY GO IN, THIS IS THE TERMINAL SEEMS LOOSE FROM THE CIRCUIT BOARD. EITHER WAY THE EFFECT IS THE SAME, CAUSING THEM TO LOSE POWER INTERMITTENTLY INCLUDING THE FUEL PUMP CREATING A NO START AND OR DIE WHILE DRIVING CONDITION POTENTIALLY CAUSING LOSS OF STEERING. HAVE VIDEO DOCUMENTING THE CONDITION AS WELL AS TWO PICTURES INCLUDED SHOWING VOLTAGE FLUCTUATING..

NHTSA ODI 11402602

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS DIAGNOSED AS A FUEL MODULE AND FUEL PUMP THAT NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE CONTACT STATED HE RECEIVED AN UNKNOWN MANUFACTURER RECALL NOTICE SEVERAL DAYS LATER AND WAS UPSET THAT HE WAS NOT NOTIFIED THAT RECALLS WERE REPAIRED FREE OF CHARGE. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS NOT PROVIDED AN EXPLANATION ABOUT THE REIMBURSEMENT POLICY. THE APPROXIMATE FAILURE MILEAGE WAS 112,760.

NHTSA ODI 11397440

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITH THE FUEL FILTER CLOGGED MESSAGE DISPLAYED. THE CHECK ENGINE WARNING LIGHT ALSO ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 15V005000 (FUEL SYSTEM, GASOLINE) AND REFERRED THE CONTACT TO THE DEALER. THE VEHICLE WAS TOWED TO PHIL LONG FORD OF MOTOR CITY (1212 MOTOR CITY DR, COLORADO SPRINGS, CO 80905, (844) 237-2169) AND DIAGNOSED WITH SHARDS OF FUEL PUMP IN THE FUEL LINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V005000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 77,000.

NHTSA ODI 11362444

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED WHILE DRIVING 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PUSHED THE VEHICLE TO A NEARBY PARKING LOT. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL RAIL ASSEMBLY, FILTER AND RETURN LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED AFTER 600 MILES WITH THE REDUCED POWER WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO GARY CROSSLEY FORD LOCATED AT (8050 N CHURCH RD, KANSAS CITY, MO 64158), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP, FUEL PUMP AND LOW PRESSURE FUEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT RESTARTED THE VEHICLE AND DROVE THE VEHICLE BACK TO THE DEALER. THE CONTACT WAS INFORMED BY THE MECHANIC THAT THERE WAS METAL BITS INSIDE THE FUEL SYSTEM AND THE FUEL INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 16V618000 (FUEL SYSTEM, DIESEL, ENGINE AND ENGINE COOLING) AS A POSSIBLE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 56,826.*DT*JB

NHTSA ODI 11319068

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP LEAKED INSIDE THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP WAS REPLACED AT ASHE COUNTY FORD DEALER, (409 E 2ND ST, WEST JEFFERSON, NC 28694) HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.*BF*JB

NHTSA ODI 11310509

THE VEHICLE STALLED UPON BACKING OUT OF A STEEP DRIVEWAY & TURNING TO THE LEFT. IT WOULD NOT RESTART. THE VAN HAD BEEN PARKED, AT A CUSTOMERS' HOME ALL DAY. HEAVY SNOW BEGAN FALLING A COUPLE OF HOURS BEFORE THE VAN WAS STARTED & WARMED UP TO MELT THE SNOW FROM THE WINDSHIELD. WHEN THE VAN STALLED, IT WAS BROADSIDE TO THE STREET, BLOCKING BOTH OPPOSING LANES OF TRAVEL AS THE HEAVY SNOW INCREASED IN INTENSITY. THE VAN WAS VIRTUALLY IMPOSSIBLE TO PUSH OFF TO THE SIDE OF THE ROAD, DUE TO THE QUICKLY ACCUMULATING SNOW, INITIALLY PREVENTING A PLOW & POLICE CRUISER FROM PASSING. AAA TOWING WAS CALLED BUT, DID NOT ARRIVE UNTIL 2 HOURS AFTER BEING SUMMONSED AS THE SNOW CONTINUED TO ACCUMMULATE. I HAD THE VAN TOWED TO OUR BUSINESS LOCATION AND DECIDED TO CHECK THE ENGINE AIR FILTER. WHEN I OPENED THE FILTER HOUSING, IT AND THE AIR FITER WERE WATER-SOAKED. I OBSERVED WATER RUNNING DOWN THE WINDSHIELD, DOWN ALONG THE FIREWALL AND ONTO/INTO THE AIR FILTER BOX. I CONTACTED MY LOCAL FORD DEALER (FORD OF WILBRAHAM, MA, TEL.: 413-543-2800) TO REPORT MY FINDINGS & TO MAKE AN APPOINTMENT TO REMEDY THE PROBLEM. THE SOLUTION WAS PERFORMED AS PER TSB (TECHNICAL SERVICE BULLETIN) #19-2091 AND AT A COST OF $488.45 (INVOICE #659506), WHICH I RELUCTANTLY PAID TO THE DEALER. I EXPLAINED THAT THIS A POOR DESIGN ALLOWING WATER TO RUN DIRECTLY INTO THE AIR FILTER BOX, WHICH, IN TURN, SHUTS DOWN THE ENGINE & RENDERS THE VEHICLE MOTIONLESS & CAN BE DANGEROUS, DEPENDING UPON WHERE & WHEN THE VEHICLES' ENGINE STALLS & THEN FAILS TO RESTART. THE SERVICE WRITER SAID THAT THERE WAS NOTHING SHE COULD DO TO HELP ME & THAT I AM STILL RESPONSIBLE FOR THE COST OF THE TSB. IN ADDITION, MY INVOICE INDICATES THAT RECALL #19S38 WAS PERFORMED, YET IT IS STILL OUTSTANDING ON THE RECALL WEBSITE UNDER MY VEHICLES' VIN. FOR THE RECORD, THIS VAN HAD ONLY 31,853 MILES ON IT, WHEN I BROUGHT IT IN FOR THIS PROBLEM.

NHTSA ODI 11302511

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTING TO DRIVE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MURRAY MOTOR (85 GRIFFITH RD, MUNCY, PA 17756, (570) 546-2222) WHERE IT WAS DIAGNOSED THAT A METAL FLAKE WAS FOUND IN THE FUEL AND THE HIGH PRESSURE FUEL INJECTION SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.

NHTSA ODI 11258278

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WHILE DRIVING ON AN INCLINE OR ON A NORMAL ROAD SURFACE, AND WHEN THE CRUISE CONTROL WAS ENGAGED. THE CONTACT HAD TO PLACE THE VEHICLE IN NEUTRAL AND TURN OFF AND RESTART THE ENGINE IN ORDER FOR THE VEHICLE TO REGAIN NORMAL FUNCTION. ALSO, WHILE DRIVING 30 TO 70 MPH, THE REDUCE ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LOGANSVILLE FORD FIRST (3460 HIGHWAY 78, LOGANSVILLE, GA 30052, 770-554-9994) DIAGNOSED THAT THE FUEL TANK FAILED. THE FUEL TANK CONTAINED METAL FRAGMENTS. THE VEHICLE WAS ALSO TAKEN TO AKINS FORD (220 WEST MAY STREET, WINDER GA, 30680, 770-867-9136) FOR A SECOND OPINION. AKINS FORD ALSO STATED THAT THE FUEL TANK HAD METAL FRAGMENTS. THE DEALER STATED THAT THE FUEL SYSTEM MUST BE CLEANED AND FLUSHED. THE DEALER FLUSHED THE FUEL SYSTEM, REPLACED THE RAILING FIVE INJECTOR, THE FUEL TANK WAS FLUSHED AND CLEANED, AND THE FUEL LINES WERE CLEANED. IN ADDITION, THE FUEL FILTER HOUSING WAS REPLACED. THE CONTACT ALSO STATED THAT THE FUEL INJECTOR PUMP CAUSED THE METAL FLAKES TO ENTER THE FUEL TANK; HOWEVER, THE FUEL INJECTOR PUMP WAS NOT REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE ENTERED LIMP MODE AND THE CONTACT HAD TO TURN THE ENGINE OFF TO REGAIN NORMAL FUNCTION. THE FAILURE OCCURRED WHEN DRIVING 70 TO 80 MPH AND WHEN DRIVING UP AN INCLINE AT ANY SPEED. THE MANUFACTURER WAS CONTACTED, THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN AN UNKNOWN RECALL REGARDING THE FUEL INJECTION PUMP RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

NHTSA ODI 11232751

WATER LEAKS INTO AIR FILTER, CAUSING STALLING AND EXTENSIVE ENGINE DAMAGE HAD THE STALLING OCCURRED IN HEAVY TRAFFIC AN ACCIDENT COULD EASILY HAPPENED

NHTSA ODI 11222254

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING APPROXIMATELY 50 MPH, THE POOR FUEL FILTER INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO SCAFFIDI AUTO STEVENS POINT (888-718-5340, LOCATED AT 3733 STANLEY ST, STEVENS POINT, WI 54481) WHERE METAL FILINGS WERE FOUND IN THE FUEL FILTER. THE TECHNICIAN REPLACED THE FUEL FILTER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 61,495.

NHTSA ODI 11183466

THE VEHICLE RANDOMLY DEVELOPED HESITATION TO START ONE DAY AS IF IT WASN'T GETTING ENOUGH FUEL OR AIR. IT DID START AND I DROVE HOME FROM WORK. I PLANNED TO TAKE IT TO A DEALERSHIP TO GET IT CHECKED OUT BUT THE NEXT DAY BUT THE VEHICLE WOULD NOT START. I ATTEMPTED TO JUMP-START BUT THE BATTERY WAS AT FULL VOLTAGE. I HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY DIAGNOSED THE CAR. I WAS INFORMED THE NEXT DAY BY THE TECHNICIAN THAT THERE WAS A TSB ABOUT THIS ISSUE AND THAT FORD MOTOR COMPANY WAS WELL AWARE OF THE PROBLEM AND THAT IT WOULD COST ME $850 PLUS TAX. APPARENTLY THE CABIN AIR FILTER IS NOT PROPERLY WEATHER SEALED AND UNDER NORMAL USE WATER WILL MAKE ITS WAY INTO THE FILTER, AND INTO THE MASS AIR SENSOR. FORD HAS MADE NEW REPLACEMENT PARTS FOR THIS ISSUE BUT BECAUSE I AM OUT OF WARRANTY BY A FEW MONTHS, I WILL HAVE TO PAY FOR THE ENTIRETY OF THE BILL. HAD THE PART GIVEN OUT WHILE DRIVING (ESPECIALLY AT HIGH SPEEDS) THE ENGINE WOULD SEIZE AND COULD HAVE LIKELY CAUSED A CRASH.

NHTSA ODI 11166133

VEHICLE WAS BEING DRIVEN ON A TWO-LANE ROAD AT 45 MPH WHEN SUDDENLY THE ENGINE JUST STOPPED WITHOUT BEING ABLE TO EVEN PULL TO THE SIDE OF THE ROAD. I TRADED CARS WITH MY WIFE SO SHE COULD TAKE OUR 6 KIDS HOME. TOWED THE VEHICLE TO A FORD DEALERSHIP WHO DIAGNOSED A FAULTY FUEL PUMP CONTROL MODULE. SAID THIS HAPPENS A LOT. SEVERAL OTHER FORD VEHICLES HAVE BEEN RECALLED FOR THIS REASON BUT NOT THE 2015 TRANSIT.

NHTSA ODI 11141820

SLIDING DOOR ALERT KEEPS GOING OFF. POSSIBLE SENSOR OR LATCH DEFECT. HAPPENS WHILE DRIVING OVER DIPS, BUMPS AND WHILE BRAKING. UNABLE TO READ DASH SYSTEM PANEL WHILE ALERT IS ON. POSSIBLE SAFETY ISSUE, AS CANNOT SEE OTHER ALERTS WHILE THIS ONE IS ON, AS IT REMAINS ON THE ENTIRE TIME I'M DRIVING AND IS A DISTRACTION. POSSIBLE SAFETY ISSUE. CHECK ENGINE LIGHT ON FUEL SYSTEM SENSOR ISSUES. AFTER PUTTING FUEL IN VEHICLE IT HAS TROUBLE RESTARTING, CAUSING ME TO FUEL VEHICLE WHILE STARTED TO REMEDY THIS. POSSIBLE FIRE HAZARD, COULD CAUSE VEHICLE TO CATCH FIRE RESULTING IN EXPLOSION/DEATH.

NHTSA ODI 11053687

EGR COOLER LEAK CHANGING SECOND TIME IN ONE YEAR AND ALSO I HAVE TO CHANGE OIL COOLER. THIS JOBS IS VERY EXPENSIVE.

NHTSA ODI 11023632

TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 70 MPH, THE ENGINE STALLED AND THE VEHICLE WENT INTO LIMP MODE. THE VEHICLE WAS TAKEN TO FOX FORD MAZDA (3560 28TH STREET GRAND RAPIDS MI, 49512 PHONE: (616-956-5511)) WHERE IT WAS DIAGNOSED THAT THERE WERE METAL SHAVINGS IN THE FUEL INJECTOR AND FUEL TANK. THE FUEL INJECTOR, FUEL PUMP, AND FUEL FILTER WERE REPLACED AND THE FUEL TANK WAS CLEANED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V618000 (FUEL SYSTEM, DIESEL, ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 15,000.

NHTSA ODI 11005294